GMC SAVANA 2003 Owner's Manual

Service Parts Identification Label
You’llfind this label on the front passenger door frame.
It’s very helpful if you ever need to order parts. On this
label is:
•your VIN,
•the model designation,
•paint information and
•a list of all production options and special equipment.
Be sure that this label is not removed from the vehicle.
Electrical System
Add-On Electrical Equipment
Notice:Don’t add anything electrical to your
vehicle unless you check with your dealerfirst.
Some electrical equipment can damage your vehicle
and the damage wouldn’t be covered by your
warranty. Some add-on electrical equipment can
keep other components from working as they
should.Your vehicle has an air bag system. Before attempting to
add anything electrical to your vehicle, seeServicing
Your Air Bag-Equipped Vehicle on page 1-74.
Headlamp Wiring
The headlamp wiring is protected by a circuit breaker in
the lamp switch. An electrical overload will cause the
lamps toflicker on and off, or in some cases to remain off.
If this happens, have your headlamp wiring checked
right away.
Windshield Wiper Fuses
The windshield wiper motor is protected by a circuit
breaker and a fuse. If the motor overheats due to heavy
snow, etc., the wiper will stop until the motor cools.
Although the circuit is protected from electrical overload,
overload due to heavy snow, etc., may cause wiper
linkage damage. Always clear ice and heavy snow
from the windshield before using the windshield wipers.
If the overload is caused by some electrical problem
and not snow, etc., be sure to get itfixed.
5-91
2003 - Savana OM

Fuses and Circuit Breakers
Floor Console Fuse Block
Thefloor console fuse block is located under the driver’s seat.
Front of Vehicle
5-92
2003 - Savana OM

Fuse Usage
1 Spare
2 Outside Rear View Mirror
3 Courtesy Lamp/SEO
4 Left Rear Stop/Turn Signal
5 Cargo Locks
6 Right Rear Stop/Turn Signal
7 Driver Locks
8Stop/Center High Mounted
Stop Lamp
9 Climate Control 1
10 Climate Control
11 Brakes
12 Heated Mirror/Defogger
13 Right Rear Blower
14 Driver Turn Mirror
15 Door Locks
16 Upfitter Park
17 Not Available
18 Left Rear Park LampFuse Usage
19 Pass Turn Mirror
20 Right Rear Park Lamp
21 Trailer Park Lamp
22 Front Park Lamp
32 Auxilary1
33 Auxilary2
Relays Usage
23 Window Residual Accessory Power
24 Auxiliary
25 Right Rear Defogger
26 Courtesy Lamp
27 Cargo Unlock
28 Driver Unlock
29 Park Lamp
30 Door Locks
31 Pass Unlock
Circuit Breaker Usage
34 Power Window
5-93
2003 - Savana OM

Engine Compartment Fuse Block
The fuse block is in the engine compartment on the driver’s side of the vehicle.
Front of Vehicle
5-94
2003 - Savana OM

Fuse Usage
1 Radio Battery
2 Powertrain Control Module Battery
3 Left Rear Turn Lamp
4 Right Rear Turn Lamp
5 Backup Lamps Trailer Wiring
6 Ignition 0
7 Stop Lamp
8 Right Rear Defogger/Heated Mirror
9Right Daytime Running Lamp/
Turn Signal
10Left Daytime Running Lamp/
Turn Signal
11 Truck Body Control Module 4
12 Fuel Pump
13 Trailer
14 Flasher
15 Horn
16 Truck Body Control Module 3
17 Trailer Stop/Turn Signal
18 Truck Body Control Module 2
19 Truck Body Control ModuleFuse Usage
20 Remote Function Actuator
21 Engine 2
22 Ignition E
23 Engine 1
24Truck Body Control Module
Ignition 1
25 Spare
26 RPA/Inside Rearview Mirror
27 Crankcase
28Brake Transmission Shift
Interlock System
29 Auxiliary Power Outlets
30 Cigarette Lighter
31 Instrument Panel Cluster
32 Air Conditioning
36 Vehicle Back Up
37Supplemental Inflatable
Restraint System
38 Powertrain Control Module Ignition 1
39 Oxygen Sensor B
40 Oxygen Sensor A
5-95
2003 - Savana OM

Fuse Usage
41 Windshield Wipers
42 Right Headlamp—Low Beam
43 Left Headlamp—Low Beam
44 Left Headlamp—High Beam
45 Right Headlamp—High Beam
46Truck Body Control
Module-Accessory
47 Front Windshield Wiper
48 Anti-Lock Brakes
49 Ignition A
50 Trailer
51 Climate Control Blower
52 Ignition B
63 Spare
64 SpareFuse Usage
Relay Usage
53 Windshield Wiper
54 Air Conditioning
55 Spare
56 Headlamp—High Beam
57 Fuel Pump
58 Headlamp—Low Beam
59 Horn
61 Starter
62 Spare
Circuit Breaker Usage
60 Power Seat
5-96
2003 - Savana OM

Capacities and Specifications
All capacities are approximate. When adding, be sure tofill to the appropriate level or as recommended in this manual.
See refrigerant charge label under the hood for charge capacity information and requirements.
Engine Specifications
Engine VIN Code Transmission Spark Plug Gap Firing OrderWheel Nut
Torque
VORTEC™4300
V6 MFI
1WM300.060 inches
(1.52 mm)1–6–5–4–3–2140 lb ft
190Y
VORTEC™4800
V8 MFI
1VMT10.060 inches
(1.52 mm)1–8–7–2–6–5–4–3140 lb ft
190Y
VORTEC™5300
V8 MFI
1TM300.060 Inches
(1.52 mm)1–8–7–2–6–5–4–3140 lb ft
190Y
VORTEC™6000
V8 MFI
1UMT10.060 inches
(1.52 mm)1–8–7–2–6–5–4–3140 lb ft
190Y
1Sequential Fuel Injection
5-97
2003 - Savana OM

Capacities
ApplicationCapacities
QTY Without
Rear HeaterQTY With
Rear Heater
Cooling System
After refill, the level must be rechecked. See“Cooling System”in the Index.
VORTEC™4300 V6 11.0 quarts (10.4 L) 14.0 quarts (13.2 L)
VORTEC™4800 V8 13.4 quarts (12.7 L) 16.4 quarts (15.5 L)
VORTEC™5300 V8 13.4 quarts (12.7 L) 16.4 quarts (15.5 L)
VORTEC™6000 V8 14.8 quarts (14.0 L) 17.8 quarts (17.0 L)
ApplicationCapacities
English Metric
Engine Oil With Filter
After refill, the level must be rechecked. Add enough engine oil so that thefluid is within the proper operating
range. SeeEngine Oil on page 5-13
VORTEC™4300 V6 (Vin W) 4.5 quarts 4.3 L
VORTEC™4800 V8 ( Vin V) 6.0 quarts 5.7 L
VORTEC™5300 V8 (Vin T) 6.0 quarts 5.7 L
VORTEC™6000 V8 (Vin U) 6.0 quarts 5.7 L
5-98
2003 - Savana OM

ApplicationCapacities
QTY Without
Rear HeaterQTY With
Rear Heater
Fuel Tank
Standard Tank (Passenger and Cargo) 31.0 gallons 117.3 L
Standard Tank (Cab and Chassis) 35.0 gallons 132.5 L
Optional Tank* (Cab and Chassis) 55.0 gallons 208.1 L
* 159 inch wheelbase or 177 inch wheel base only
Air Conditioning Refrigerant Capacity
Air Conditioning Refrigerant R-134a (Front) 1.8 lbs (0.81 kg)
Air Conditioning Refrigerant R-134a (Front and Rear) 3.1 lbs (1.41 kg)
5-99
2003 - Savana OM

Normal Maintenance Replacement Parts
Replacement part numbers listed in this section are based on the latest information available at the time of printing,
and are subject to change. If a part listed in this manual is not the same as the part used in your vehicle when it was
built, or if you have any questions, please contact your GM dealer.
These specifications are for information only. If you have any questions, see the service manual for the chassis or
refer to the body manufacturer’s publications.
VIN Code W V T U
Oil Filter* PF47 PF44 PF44 PF44
Engine Air Cleaner /Filter* A1621C A1621C A1621C A1621C
Passenger Compartment
Air Filter Kit**52485513 52485513 52485513 52485513
PCV Valve* CV 769–C CV 2001–C CV 2001–C CV 2001–C
Spark Plugs 41–932 41–974 41–974 41–974
Fuel Filter* 6F6Z6 GF626 GF626 GF626
Wiper Blades** 15153642 15153642 15153642 15153642
Wiper Blade Type ITTA ITTA ITTA ITTA
Wiper Blade Length22 inches
(56.0 cm)22 inches
(56.0 cm)22 inches
(56.0 cm)22 inches
(56.0 cm)
* ACDelco
®part number
** GM part number
5-100
2003 - Savana OM