maintenance GMC SIERRA 1993 Owner's Manual

Other Maintenance Items
Front Suspension and Steering Linkage
Your maintenance schedule will tell you how often to lubricate the fittings. See
“Recommended Fluids and Lubricants’’ in the Index for the proper lubricant to
use.
Front Wheel Bearings
Your vehicle has front wheel bearings that must be cleaned and repa\
cked.
Your maintenance schedule will tell you how often this must be done.
Front Shock Absorbers
The front shock absorbers of your vehicle do many things. They help the
vehicle ride smoothly and also control the travel
of the suspension system.
When the shock absorbers are serviced, any replacement shock absorber\
s
must be the same as the original equipment shock absorbers in both
extended length and strength.
1 NOTICE
If you use shock absomers that are nor me same as the original shock
I absorbers, the shock absorbers or suspension system could be da\
maged.
Wheel Nut Torque
For vehicles with dual wheels, when the vehicle, wheel or fast\
eners are new,
have the torque set at the first
100, 1,000 and 6,000 miles (160, 1600 and
9600 km). Use the torque specified in the appropriate Specification \
Chart later
in this section.
Single Belt Accessory Drive
If your new vehicle uses a serpentine belt, it is lighter, and more durable
than systems with several belts.
The belt runs over or around the pulleys
on the engine. A tensioner is used
to keep the belt tight at all times. The tensioner also makes replacing the
belt easier.
If you need to replace the belt, be sure to get the correct
replacement belt. Your dealership
or parts supplier can help you with this.
The Accessory Drive Belt Routing label on your vehicle will sh\
ow you how to
route the belt your vehicle uses.
6-5 1
ProCarManuals.com

Service & Appearance Care
Windshield Wiper Blade Inserts
I -
r
PO232
To replace the windshield wiper blade insert, lift the wiper arm and rotate the
blade until it is facing away from the windshield. Unlatch the\
end of the insert
from the holding clips. Remove the insert and slide a new one\
in place.
Make sure the blade is secured in the clips.
Air Conditioning
Every now and then have your dealership check your air conditi\
oning system
to be sure it has not lost any cooling ability.
If you think the system is not
working properly, have your dealership check it out as soon as\
possible.
The air conditioning will not work when the temperature is bel\
ow 40°F
(4°C).
Fluid Leak Check
After the vehicle has been parked for a while, inspect the su\
rface under the
vehicle
for water, oil, fuel or other fluids. Water dripping from the air
conditioning system after it has been used is normal, If you notice fuel leaks
or fumes, the causes should be found and corrected at once.
Lubrication
Accelerator Control System
Your maintenance schedule will tell you how often the accelerator linkage
pivot points must be lubricated. See “Recommended Fluids and \
Lubricants” in
the Index for the proper lubricant to use.
6-52
ProCarManuals.com

Accelerator cables and cruise control cables should not be lubr\
icated. Any
cables that are worn or are hard to pull should be replaced. \
Remove external deposits from injector pump face cam on 6.2L d\
iesel
engines, when the engine is cold.
Hood Latches and Hood Hinge
Your maintenance schedule will tell you how often to lubricate the \
hood latch
and hood hinge assembly. See “Recommended Fluids and Lubrican\
ts” in the
Index for the proper lubricant to use.
Propeller Shaft Slip Splines
See your maintenance. schedule to find out how often the slip \
splines must
be lubricated. See “Recommended Fluids and Lubricants” in \
the Index for the
proper lubricant to use.
Constant Velocity Joints
See your maintenance schedule to find out how often the consta\
nt velocity
joints must be lubricated. See “Recommended Fluids and .Lubri\
cants” in the
Index for the proper lubricant to use.
80dy
Normal use of your vehicle will cause metal to metal wear at some points on
the cab and body
if they are not lubricated.
For exposed surfaces, such as door checks, door lock bolts, lo\
ck striker
plates, dovetail bumper wedges, etc., a thin film of engine oil should be
applied.
The seat adjusters and seat track should be lubricated with chassis grease.
Door weather strips and rubber hood bumpers should be lightly coated with a
rubber lubricant.
Never use too much of any lubricant and be sure to wipe up any extra
lubricant when you are finished.
Your maintenance schedule
will tell you how often to lubricate these Ilems.
See “Recommended Fluids and Lubricants” in the Index for \
the proper
lubricant to use.
Lock Cylinders
To be sure your locks operate properly, they must be lubricated. \
Your vehicle’s
maintenance schedule
will tell you how often to lubricate them. See
“Recommended Fluids and Lubricants” in the Index for the proper lubricant to
use.
6-53
ProCarManuals.com

Service & Appearance Care
You should not use penetrating oils because they could wash out the factory
installed lubricant and cause the lock to bind. De-icers which contain alcohol
could also wash away the lubricant,
so be sure to lubricate the lock after
using a de-icer of this type.
Tailgate Handle
The tailgate handle pivot points on your vehicle should be lub\
ricated to keep
it working smoothly.
Your maintenance schedule will tell you how often to lubricate the handle.
See “Recommended Fluids and Lubricants” in the Index for the proper
lubricant to use.
Electrical System
Battery
Every new GM vehicle has a Delco Freedom@ battery. You never have to
add water to one of these. When it’s time for a new battery, we recomme\
nd
a Delco Freedom@ battery. Get one that has the catalog number \
shown on
the original battery’s label.
Vehicle Storage
If you’re not going to drive your vehicle for 25 days or more, take off the
black, negative
(-) cable from the battery. This will help keep your battery
from running down.
I - Batteries have acid that can burn you and gas that can explod\
e. You I
1 can be badly hurt if you aren’t careful. See “Jump Starting” in the
Index for tips on working around a battery without getting hur\
t.
Contact your dealer to learn how to prepare your vehicle for longer periods.
Bulb Replacement
Before you replace any bulbs, be sure that all the lights are off and the
engine isn’t running.
6-54
ProCarManuals.com

Service & Appearance Cam
Tire lnspecfion and Rotation
To make your tires last longer, have them inspected and rotated at the
mileages recommended in the Maintenance Schedule. See “Scheduled
Maintenance Services” in the Index.
Q
-
-
K2655
Use this rotation pattern.
If your vehicle has front tires with different load ratings or tread designs (such
as all season
vs. onloff road) than the rear tires, don’t rotate your tires \
front
to rear.
After the tires have been rotated, adjust the front and rear \
inflation pressure
as shown on the CertificationRire label. Make certain that all wheel nuts are
properly tightened. See “Wheel Nut Torque”
in the Index.
A Rust or dirt on a wheel, or on the parts to which -it is fastened, can
make the wheel nuts become loose after a time. The wh.eel could
come
off and cause an accident. When you change- a- :wheel, remove
’ any -rust or dirt from places where the wheel attaches to the vehicle:
,: In an emergency, you can use a cloth or paper towel to do this; but
3 be sure to use a scraper or wire brush later, if you need- to, to get
-T all the rust or dirf off. See “Changing a Flat Tire” in the Index.
6-78
ProCarManuals.com

Service & Appearance Care
Finish Damage
Any stone chips, fractures or deep scratches in the finish should be repaired
right away. Bare metal will corrode quickly and may develop into a major
repair expense.
Minor chips and scratches can be repaired with touch-up materia\
ls available
from your dealer or other service outlets. Larger areas of finish damage can
be corrected
in your dealer’s body and paint shop.
Underbody Maintenance
Chemicals used for ice and snow removal and dust control can \
collect on the
underbody.
If these are not removed, accelerated corrosion (rust) can occur \
on the underbody parts such as fuel lines, frame, floor pan, \
and exhaust
system even though they have corrosion protection.
At least every spring, flush these materials from the underbody wi\
th plain
water. Clean any areas where mud and other debris can collect.\
Dirt packed
in closed areas of the frame should be loosened before being flushed. Your
dealer or an underbody washing system can do this for you.
Chemical Paint Spotting
Some weather and atmospheric conditions can create a chemical fallout.
Airborne pollutants fall upon and attack painted surfaces on yo\
ur vehicle. This
damage
can take two forms: blotchy, ringiet-shaped discolorations, and small\

irregular dark spots etched into the paint surface.
Although no defect in the paint job causes this, General Motors will repair, at
no charge to the owner, the surfaces of new vehicles damaged by this fallout
condition within
12 months or 12,000 miles (20 000 km) of purchase,
whichever comes first. This applies only to materials manufactured and
sold
by General Motors. Bodies, body conversions or equipment not made or sold
by General Motors are not covered.
6-90
ProCarManuals.com

Scheduled Maintenance Services
’
-1 I
This section covers the maintenance required for your General M\
otors vehicle.
Your vehicle needs these services to retain it’s safety, dependabi\
lity, and
emission control performance.
A Word About Maintenance
........................................................................\
......... 7-3
Your Vehicle and the Environment
...................................................................... 7-3
Recording Maintenance Services
........................................................................\
. 7-3
Scheduled Maintenance Services
........................................................................\
7-4
Selecting Your Vehicle’s Maintenance Services
.......................................... 7-4
Gasoline Engines with Light Duty Emissions- Maintenance Schedule
I ........................................................................\
.... 7-6
Gasoline Engines with Light Duty Emissions-
Maintenance Schedule
II ........................................................................\
... 7-8
Gasoline Engines with Heavy Duty Emissions- Maintenance Schedule
I ........................................................................\
.. 7-1 0
Gasoline Engines with Heavy Duty Emissions- Maintenance Schedule
II ........................................................................\
. 7-1 2
6.2L and 6.5L Diesel Engines- Maintenance Schedule
I ........................................................................\
.. 7-1 4
6.2L and 6.5L Diesel Engines- Maintenance Schedule
II ........................................................................\
. 7-1 6
7-1
ProCarManuals.com

Scheduled Maintenance Services
Explanation of Scheduled Maintenance Services ...................................... 7-18
Owner Checks and Services
........................................................................\
...... 7-22
Recommended Fluids
& Lubricants ................................................................... 7-25
Maintenance Record
........................................................................\
................... 7-27
Service Station Checks
........................................................................\
............... 7-28
7-2
ProCarManuals.com

A Word About Maintenance
We at General Motors want to help you keep your vehicle in good working
condition. But we don’t know exactly how you’ll drive it. You may drive very
short distances only a few times a week. Or you may drive long distances all
the time in very hot, dusty weather. You may use your vehicle in making
deliveries. Or you may drive it
to work, to do errands, or in many other ways.
Because of all the different ways people use their GM vehicles, maintenance
needs vary. You may even need more frequent checks and replacements than
you will find in the schedules in this section.
So please read this section and
note how you drive.
If you have any questions on how to keep your vehicle
in good condition, see your GM dealer, the place many GM owners choose
to have their maintenance work done. Your dealer can be relied upon to use
proper parts and practices.
Your Vehicle and the Environment
Proper vehicle maintenance not only helps keep your vehicle in good working
condition, but also helps the environment. All recommended maintenance
procedures are important. Improper vehicle maintenance or the removal of
important components can significantly affect the quality of the air we breathe.
Improper fluid levels or even the wrong tire inflation can inc\
rease the level of
emissions from your vehicle. To help protect our environment, and to help
keep your vehicle in
good condition, please maintain your vehicle properly.
Recording Maintenance Services
The Maintenance Record near the end of this section provides a place for
you
to record the maintenance performed on your vehicle. Whenever any
maintenance is performed, be sure
to write it down in the Maintenance
Record. This will help you determine when your next maintenance should be
done, In addition, it is a good idea to keep your maintenance receipts. They
may be needed to qualify your vehicle for warranty repairs.
CAUTION
+ CAUTION: Performing maintenance work on a vehicle can be
dangerous. In trying
to do some jobs, you can be seriously injured.
Do your own maintenance work only if you have the required
know-how and the proper tools and equipment for the job.
If you
have any doubt. have
a aualified technician do the work.
If you are skilled enough to do some work on your vehicle, you will probably
want to get the service information GM publishes. You will
find a list of
publications and how to get them in the back of Section
8, “Customer
Assistance Information.” See “Service Publications’’ in the Index.
7-3
ProCarManuals.com

Scheduled Maintenance Services
Scheduled Maintenance Services
This part tells you the maintenance services that you should h\
ave done and
the times you should schedule them. Your GM dealer knows your vehicle best
and wants you
to be happy with it. If you go to your dealer for your service
needs, you’ll know that GM-trained and supported service peop\
le will perform
the work using genuine GM parts.
These schedules are for vehicles that:
carry passengers and cargo within the recommended limits. You will find
these limits on your vehicle’s Certification Label. See “L\
oading Your
Vehicle” in the Index.
are driven on regular road surfaces, and within legal driving \
limits.
are driven off-road in the recommended manner. See the Index U\
nder
use the recommended fuel. See “Fuel” in the Index.
“Off Road Driving With Your Four Wheel Drive Vehicle.”
selecting The Proper Maintenance Services
To find the proper maintenance schedule for your vehicle, you must\
know two
things. What engine your vehicle has, and how you use your ve\
hicle. Your
engine type will tell you which chart to use, and your drivin\
g conditions will
tell you which schedule to use. The charts are found later in\
this section.
Selecting the Proper Maintenance Chart
Your engine type (Gasoline or Diesel) and its emissions classificat\
ion (Light
Duty 3r Heavy Duty Emissions) will tell you which maintenance \
chart
to use.
Find your Vehicle Identification Number (VIN), and look at th\
e eighth character
to see what your engine code is. Then use the following Engine E\
missions
Classifications table
to find your emissions classification.
Your VIN is on the plate on the top left corner of your instrument panel,
the Certification Label and on the Service Parts Identification \
Label. See “Vehicle Identification Number” in the Index.
If your engine has more than one emissions classification, look at\
your
Certification Label to see what your Gross Vehicle Weight Ratin\
g
(GVWR)
is. See “Loading Your Vehicle” in the Index.
7-4
ProCarManuals.com