check engine light GMC SIERRA 1994 User Guide

If the light comes on at any other time, use this chart.
“Water in Fuel” Light Chart
Problem
Light comes on intermittently.
Light stays on:
1. At temperatures above
freezing.
2. At temperatures below
freezing.
Recommended Action
Drain water from fuel filter.
Drain fuel filter immediately. If no
water
can be drained and light stays
on, see your dealer for assistance.
Drain fuel filter immediately. If no
water can be drained
- water may
be frozen. Open the air bleed valve
to check
for fuel pressure. If no fuel
pressure is present, replace the
fuel
filter.
3. Immediately after refueling - Fuel tank purging required. See
large amount of water possibly your dealer for assistance.
pumped into fuel tank.
Hesitation or “flat” performance at high speed or during hard acceleration
may be an indication of premature fuel filter plugging due
to dirty or
contaminated fuel, The filter element may need to be changed
if this
happens. See your dealer for assistance.
NOTICE:
If you drive when this warning light is on, you can damage y\
our
fuel injection system and your engine. If the light comes on right
after you refuel,
it means water was pumped into your fuel tank.
Turn off your engine immediately. Then, have the water drained \
at once.
To drain water:
1. Stop and park the vehicle in a safe place. Turn off the engine and apply
the parking brake.
2. Remove the fuel tank cap.
3. Place a fuel-resistant container under the filter drain hose.
6-8
ProCarManuals.com

To Check Coolant
When your engine is cold, the coolant level should be at the COLD mark,
or a little higher. When your engine is warm, the level should be above the
COLD mark.
If this light comes on,
it means you’re low
on engine coolant.
To Add Coolant
If you need more coolant, add the proper mix at the surge tnnk, but only
when the engine is cool.
Open the air bleed valve on the thermostat housing to allow trapped air
out
of the system. Close the bleed valve when coolant begins to flow out.
I A CAUTION:
nrning the surge tank pressure cap when the engine and
radiator are hot can allow steam and scalding liquids to blow
out:
and burn you badly. Never turn the surge tank pressure cap -
even a little - when the engine and radiator are hot.
A CAUTION:
You can be burned if you spill coolant on hot engine parts.
Coolant contains ethylene glycol, and it will burn if the engine
parts are hot enough. Don’t spill coolant on
a hot engine.
6-41
ProCarManuals.com

Wheel Nut Torque
For vehicle with dual wheels, wnen the vehicle, wheel or Tasteners are new,
have the torque set at
the first 100, 1,000 and 6,000 miles (1 60, 1600 and
9600 km). Use the torque specified
in the appropriate Specification Chart
later
in this section.
Single Belt Accessory Drive
If your new vehicle uses a serpentine belt, it is lighter and more durable than
systems with several belts.
The belt runs over or around the pulleys on the engine.
A tensioner may be
used
to keep the belt tight at all times. The tensioner also makes replacing
the belt easier.
If you need to replace the belt, be sure to get the correct
replacement belt. Your dealership or parts supplier can help you with this.
The Accessory Drive belt Routing label on your vehicle will show
you how
to route
the belt your vehicle uses.
Windshield Wiper Blade Inserts
To replace the
windshield wiper
blade insert, lift the
wiper arm and rotate
the blade until
it is
facing away from the
windshield.
Unlatch
the end of the insert from the holding clips. Remove the insert and
slide a new
one in place. Make sure the blade is secured in the clips.
Air Conditioning
Every now and then have your dealership check your air conditioning
system
to be sure it has not lost any cooling ability. If you think the system
is not working properly, have your dealership check it out as soon as
possible.
The air conditioning
will not work when the temperature is below 40°F
(4°C).
6-50
ProCarManuals.com

Heater or A/C Control Lamp
Four Wheel Drive Indicator
rour Wheel Drive Shift Lever
Instrument Panel Compartment Lamp
Ashtray Lamp
Sunshade Vanity Mirror
"Crew Cab Only
LAMP OR BULB
INSTRUMENT PANEL
Transmission Indicator (PRNDL)
Daytime Running Lights Indicatory
Charging System Indicator Lamp
Instrument Cluster Illumination
--Gage Cluster
Instrument Cluster Illumination
-Tachometer Cluster
Headlamp Beam Indicator
Directional Signal Indicator
Brake Warning Indicator
Safety Belt Warning
Check Gages Indicator
Malfunction Indicator ("Service
Engine Soon") Lamp
Upshift Indicator
Glow Plugs Lamp*:$:
Low Coolant
Water
in Fuel Lamp*'$
Service Throttle Soon Lamp*"
194
161
194
194
I94 74
TRADE NO.
161
74
74
I94
I94 74 74
74
74 74
74
74
74
74
74
74
6
6-98
ProCarManuals.com

Scheduled Maintenance Services
Section
This section covers the maintenance required for your General Motors
vehicle
. Your vehicle needs these services to retain it’s safety. dep\
endability.
and emission control performance
.
A Word About Maintenance .................................. 7-3
Your Vehicle and the Environment
............................. 7-3
Recording Maintenance Services
............................... 7-3
Scheduled Maintenance Services
............................... 7-4
Selecting Your Vehicle’s Maintenance Services
................. 7-4
Gasoline Engines with Light Duty Emissions
-
MaintenanceScheduleI ................................ 7-6
MaintenanceScheduleII
................................ 7-8
Maintenance Schedule I
............................... 7-10
Maintenance Schedule I1
............................. 7-12
Maintenance Schedule I
............................... 7-14
Maintenance Schedule
11 ............................... 7-16
Explanation of Scheduled Maintenance Services
............... 7-18
Owner Checks and Services
.................................. 7-22
Recommended Fluids
& Lubricants ........................... 7-25
Maintenance Record
....................................... 7-27
Service Station Checks
.... ., ................................ 7-28
Gasoline Engines with Heavy Duty Emissions
-
Diesel Engines .
Have you purchased the GM Protection Plan? The Plan supplements
the new vehicle warranties
. See your GM dealer for details .
7-1
ProCarManuals.com

F
FanNoise ...................................................... 5-25
Filter Replacement Chart
.......................................... 6-94
Finish Care
........................................................ 6-85
Damage
..................................................... 6-86
Automatic Transmission
........................................ 6-30
Brake
....................................................... 647
Coolant
..................................................... 5-17
Capacities .............................................. 6-92, 6-93
FrontAxle
................................................... 6-37
Hydraulicclutch
.............................................. 6-35
LeakCheck
............................................. 6-47. 6-51
ManualTransmission .......................................... 6-33
Power Steering
............................................... 6-43
Radiator
..................................................... 5-17
Rear Axle ................................................... 6-39
Recommended Fluids
.......................................... 7-25
Transfer Case
................................................ 6-36
Windshield Washer
............................................ 6-45
Four-WheelDrive ............................................... 244
Transfer Case
........................................... 2-35, 6-36
Front Axle ................................................... 6-37
Fuel (Diesel Engines)
............................................. 6-11
Cold Weather Operation ......................................... 6-6
Filter Replacement ............................................ 6-11
Fuel Requirements ............................................. 6-4
Gage
....................................................... 2-78
RunningOutOf
.............................................. 6-10
Tankcapacity ................................................ 6-93
WaterinFuel
................................................. 2-71
Fuel (Gasoline Engines)
............................................ 6-4
FillingYourTank
............................................. 6-13
Foreign Countries
............................................. 6-12
Gage
....................................................... 2-78
Gasolines for Cleaner Air
........................................ 6-5
Tankcapacity
................................................ 6-93
Fuses and Circuit Breakers
................................... 6-64. 6-96
FuseBlock ............................................. 6-63, 6-95
Headlights
.............................................. 6-62-6-97
Trailer Wiring Harness
......................................... 6-62
Windshield Wipers
....................................... 6-45, 6-96
Fluid
Power Windows and Other
Power Options ......................... 6-62
Gages ......................................................... 2-78
Coolant Temperature Gage
...................................... 2-79
FuelGage
................................................... 2-78
Odometer
................................................... 2-68
Oil Pressure Gage ............................................. 2-80
Speedometer
................................................. 2-68
4
ProCarManuals.com

L
Labels Certificatioflire
.............................................. 6-65
Truck-Camper
............................................... 6-68
Lights
......................................................... 2-70
BrakeSystemWarning
......................................... 2-70
Bulb Replacement
................................... 2-52.6-53. 6-98
Cargo Lamp
............................................ 2.58. 6.60
Charging System Light
......................................... 2-73
Check Gages Light
............................................ 2-75
CHMSL
..................................................... 2-82
DomeLights
................................................. 2-51
Fender
...................................................... 6-58
Front Parking/Turn Signal
....................................... 6-55
GlowPlugsLight
............................................. 2-72
Headlights (See “Headlights”)
Indicator
.................................................... 2-77
Low Coolant Warning
.......................................... 2-73
Malfunction Indicator
..................................... 2.74. 6.66
Reading
..................................................... 2-51
Service Engine
Soon ........................................... 2-74
Service Throttle Soon
.......................................... 2-72
SideMarker
.................................................. 6-58
Rear .................................................... 6-60. 6-61
Replacementchart
............................................ 6-98
RoofMarker
................................................. 6-59
TailgateMarker
................................................ 6-59
Underhood Reel Lamp
......................................... 2-53
WaterInFuel
................................................. 2-71
LoadingYourVehicle
............................................ 6-65
Lubrication
..................................................... 6-51
Accelerator Control System
..................................... 6-51
Body
....................................................... 6-51
Constant Velocity Joints
........................................ 6-51
FrontAxle
................................................... 6-37
Front Shock Absorbers
......................................... 6-49
Front Suspension and Steering Linkage
............................ 6-49
FrontWheelBearings
.......................................... 6-49
TailgateHandle
............................................... 6-52
Hood Latches and Hinge ........................................ 6-51
Hydraulic Clutch Grease Fitting
.................................. 6-35
Lockcylinders
............................................... 6-52
Propeller Shaft Slip Splines
..................................... 6-51
RearAxle ................................................... 6-35
Recommended Lubricants
...................................... 7-25
Transfer Case
................................................ 6-36
Operation
................................................... 249
6
ProCarManuals.com

I
Service Do-It-Yourself
.......
Parts Identification Label
Publications
..........
Replacement Parts and Fj
Service Engine Soon Light
Service Station Checks
....
11
........................................ 6-3
....................................... 6-90
.................................... 8.6, 8.8
ter Recommendations
..................... 6-94
.................................. 2.74. 6-65
....................................... 7-28
Shift Indicator Light
......................................... 2.26, 2.76
ShiftingIntoPark
................................................ 2-30
Sliding Rear Window
............................................. 2-38
SpareTire
...................................................... 5-29
Pickup Bed Mounting
..................................... 5.31. 5-40
Specification Charts .............................................. 6-91
Speedometer
.................................................... 2-68
Starting your Diesel Engine
........................................ 2-16
Starting your Gasoline Engine
...................................... 2-12
Removal
.................................................... 5-29
Storage
..................................................... 5-39
Steering
........................................................ 4-8
Column Shift Lever
............................................ 2-30
InEmergencies
................................................ 4-9
Console
................................................ 2-59. 2-61
GarageDoorOpener
........................................... 2-61
GloveBox
................................................... 2-58
Other
....................................................... 2-65
SunVisors
..................................................... 2-55
Swing-Outwindows
............................................. 2-38
Storage Compartments
............................................ 2-58
T
Tachometer ..................................................... 2-69
Tailgate
......................................................... 2-8
Theft
........................................................... 2-9
Tiltwheel
...................................................... 2-39
Tires
.......................................................... 6-71
Chains
...................................................... 6-79
Flat
........................................................ 5-26
Balancing
................................................... 6-78
Changing a Flat
.......................................... 5.25, 5.32
Hub CapsNVheel Nut Caps
...................................... 5-32
InspectionRotation
....................................... 6-73. 6-75
Loading
..................................................... 2-39
New
........................................................ 6-76
Pressure
..................................................... 6-71
Spare (See “Spare Tire”)
Underbodycarrier
............................................ 5-29
Uniform Tire Quality Grading
................................... 6-77
TorqueLock
............................................... 2.29. 2.31
Towing
ATrailer
............................................... 4-38. 6.67
Maintenance
................................................. 4-44
Recommendations
............................................. 6-70
Turnsignals
................................................. 4-42
Following Distance
............................................ 4-42
9
ProCarManuals.com