tailgate GMC SIERRA 1996 Owners Manual

Your vehicle has one
double-sided key for the
ignition and all door locks.
If you ever lose your keys, your dealer will be able to
assist
you with obtaining new ones.
NOTICE:
Your vehicle has a number of new features that
can help prevent theft. But you can have a lot of
.
trouble getting into your vehicle if you ever lock
your key inside. You may even have to damage
your vehicle to get in.
So be sure you have an
extra key.
Tailgate
You can open the tailgate by lifting up on its handle
while
pulling t.he tailgate toward you.
To shut the tailgate, firmly push it away from you into
the latch.
When
you put the tailgate back up, pull it back towara
you, to be sure that it latches securely.
Tailgate Removal
The tailgate on your vehicle can be removed to allow
for different loading situations. Although the tailgate
can be removed without assistance,
you may want
someone to assist you
with the removal to avoid
possible finish damage.
2-2
ProCarManuals.com

To remove the tailgate:
1. Raise the tailgate
slightly and release both
retaining cable clips.
To
release the cable clips,
lift the cable
so it points
straight
out and push the
cable clips forward.
2. With the tailgate at a
slight upward angle,
pull back on the tailgate
at the right edge and
then move the tailgate
to the right to release the
left edge.
Reverse the above procedure
to re-install. Make sure the
tailgate is secure.
Third Door (Option)
Your vehicle may be equipped with a third door that
allows easier access
to the rear area of an extended cab.
To open the door, first open the passenger side front
door. Then, use
the handle located on the front edge of
the rear door.
You must close and latch the third door before you can
close the front passenger
door.
2-3
ProCarManuals.com

Roof Marker Lamps
I. Remove the screws and lift off the lens.
2. Pull the bulb straight out of the socket.
3. Put a new bulb into the socket and push it in until
it is tight.
4. Replace the lens and tighten the screws.
Tailgate Marker Lamps
1. Use a screwdriver to gently pry the lens/buIb
assembly
from the lens holder.
2. Unplug the lens/bulb assembly at the connector wire.
3. Plug in a new lendbulb assembly and push the
connector wire into
the hole in the tailgate.
4. Snap the lens/buIb assembly into the lens holder.
Taillamps (Pickup Models)
I. Open the tailgate.
cp
I
2. Remove the two
rear lamp assembly
screws near the tailgate
latch and pull out the
lamp assembly.
3. Remove the screws
from the
bulb retainer
and take
it off the
lamp assembly.
ProCarManuals.com

4. Pull the old bulb straight
out of the socket..
5.
6.
7.
8.
Put in a new bulb and push it in until it is tight.
Replace the bulb retainer.
Replace the rear lamp assembly and tighten
the screws.
Close the tailgate.
Taillamps (Chassis Cab Models)
1. Using your hands, peel the rubber seal away from
the lens.
2. Lift the lens off the
lamp assembly.
3. Slide the socket out of the lamp assembly.
6-46
ProCarManuals.com

014
020
03
09
0 l5
0.
04
0
0
l6
0 22
Fuse Usage
1
2
Stop/TCC Switch, Buzzer, CHMSL, Hazard
Lamps, Stoplamps
Transfer Case
3 Courtesy Lamps, Cargo Lamp, Glove
Box
Lamp, Dome/Reading Lamps, Vanity Mirrors,
Power Mirrors
Fuse
4
10
11
12
13
14
Usage
Instrument Cluster, DRL Relay, Lamp
Switch, Keyless
Entry, Low Coolant
Module, Illuminated Entry Module, DRAC
(Diesel Engine)
Not Used
Cruise Control
Auxiliary Power Outlet
Air Bag System
License Lamp, Parking Lamps, Taillamps, Roof Marker Lamps, Tailgate Lamps, Front
Sidemarkers, Fog Lamp Relay, Door Switch
Illumination, Fender Lamps, Headlamp
Switch Illumination
Air Bag System
Wiper Motor, Washer Pump
A/C, A/C Blower, High Blower Relay
Power Amp, Cigarette Lighter, Door Lock
Relay, Power Lumbar Seat
'
4WD Indicator, Cluster, Comfort Controls,
Instrument Switches, Radio Illumination,
Chime Module
6-70
ProCarManuals.com

Automatic Transmission Check
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly. Look
for any other loose or damaged
safety belt system parts.
If you see anything that might
keep a safety belt system from doing its job, have
it
repaired. Have any torn or frayed safety belts replaced.
Also
look for any opened or broken air bag covers, and
have them repaired or replaced. (The air bag
system
does not need regular maintenance.)
Air Cleaner Filter Restriction Indicator Check
Your vehicle has an indicator on the engine that lets you
know when the air cleaner filter is dirty and needs to be
changed. Check indicator at least twice
a year or when
your
oil is changed. See “Air Cleaner” in the Index for
more information.
Manual Transmission Check
Check the transmission fluid level; add if needed. See
“Manual Transmission” in
the Index. A fluid loss may
indicate
a problem. Check the system and repair if needed. Check the transmission
fluid level; add if needed. See
“Automatic Transmission”
in the Index. A fluid loss
may indicate a problem. Check the system and repair
if needed.
Hydraulic Clutch System Check
Check the fluid level in the clutch reservoir. See
“Hydraulic Clutch Fluid”
in the Index. A fluid loss in
this system could indicate a problem. Have the system
inspected and repaired
at once.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified
in Part D.
Body Lubrication Service
Lubricate all fuel doors, body hood and body door
hinges, tailgate and tailgate handle pivot points, latches,
locks and folding seat hardware. Part
D tells you what to
use. More frequent lubrication may be required when
exposed to a corrosive environment.
ProCarManuals.com

USAGE
Windshield
Washer Solvent
Propeller Shaft
SplineRJniversal
Joint and
Propeller Shaft
Hood Latch
Assembly,
Pivots, Spring
Anchor
and
Release Pawl ~~
Hood and Door
Hinges
FLUIDLUBRICANT ~~
GM Optikleen@ Washer Solvent
(GM Part No. 105 15 15) or
equivalent.
Chassis lubricant (GM Part
No. 1052497 or equivalent) or
lubricant meeting requirements
of
NLGI Grade 2, Category LB or
GC-LB.
Lubriplate lubricant aerosol (GM
Part No. 12346293 or equivalent)
or lubricant meeting requirements
of NLGI Grade 2, Category LB or
GC-LB.
Multi-pu ose lubricant,
Superlube
% (CM Part
No. 1234624 1 or equivalent).
USAGE
Body Door
Hinge Pins,
Tailgate Hinge
and Linkage,
Folding Seat,
Fuel Door Hinge
Tailgate Handle
Pivot Points,
Hinges, Latch
Bolt and Linkage
Weatherstrip Conditioning
Weatherstrip Squeaks
Gas Line
FLUIDLUBRICANT
~~ ~~ ~
Multi-pu ose lubricant,
Superlube
(GM Part
No. 1234624 1 or equivalent). I%
Multi-pu ose lubricant,
Superlube (GM Part
No. 12346241 or equivalent).
~~
%
Dielectric Silicone Grease (GM
Part No. 12345579 or equivalent).
Multi-pu ose lubricant,
Superlube (GM Part
No. 12346241 or equivalent).
%
Gas Line De-Icer (GM Part
No. 105 1516).
See “Replacement Parts”
in the Index for recommended
replacement filters, valves and spark plugs.
I
7-50 ..
ProCarManuals.com

Seatback. Latches ................................ 1-5
Seatbacks. Reclining
............................. 1-3
Seats EasyEntry
................................... 1-6
ManualFront ................................. 1-1
Power Driver’s
................................ 1-2
Power Lumbar Control
.......................... 1-2
Rear
.................................... 1-7. 1-8
Seatcontrols
................................. 1-1
Securing a Child Restraint
. ..... 1-39. 1-41 1-44. 1-46
Service
......................................... 6-1
Bulletips, Ordering .............................. 8-9
EngineSoonLight
............................ 2-63
Manuals, Ordering
............................. 8-9
Parts Identification Label
....................... 6-67
Publications, Ordering
.......................... 8-9
Work, Doing Your Own
......................... 6- 1
Service and Appearance Care
...................... 6-1
Service and Owner Publications
.................... 8-9
Service Publications
.............................. 8-9
Servicing Your Air Bag-Equipped Vehicle
........... 1-26
Sheet Metal Damage
............................ 6-64
Shift Lever
.......................... 2-13,2-17, 2-18
Shift Light
............................... 2-20, 2-66
Shift Speeds
.................................... 2-19
Shifting Into Park
(P) ............................ 2-26
Shifting, Manual Transmission
............... 2- 17, 2- 18
Shoulder Belt Height Adjuster
..................... 1-15
Sidemarker Lamp Bulb Replacement
............... 6-43
Signaling Turns
................................ 2-34
Restraint Systems
.............................. 1 . 1 .
SIR .......................................... 1-21 Skidding
....................................... 4-12
Sound Equipment. Adding
........................ 3-23
Specifications and Capacities
...................... 6-74
Specifications. Engine
........................... 6-74
Speedometer
................................... 2-57
Stains. Cleaning
................................ 6-60
Starter Switch Check
............................ 7-44
Starting Your Engine
............................ 2-11
Steam
........................................ 5-10
Steering
....................................... 4-8
Column Lock Check
.......................... 7-45
In Emergencies
................................. 4-9
Power
....................................... 4-8
Tips
......................................... 4-8
Wheel. Tilt
.................................. 2-33
Step-Bumper Pad
............................... 4-62
StorageAreas
.................................. 2-46
Storage. Overhead
.............................. 2-48
Storage. Underhood
............................. 2-51
Storage. Vehicle
................................ 6-37
Stuck: In Sand. Mud. Ice or Snow
.................. 5-32
Sunglasses Storage
.............................. 2-48
Sunvisors
.................................... 2-53
Supplemental Inflatable Restraint
.................. 1-21
Symbols. Vehicle
.................................. v
Tachometer .................................. 2-57
Tailgate Marker Lamp Bulb Replacement
. .. .......... 6-45
Tailgate Removal
................................ 2-2
Taillamp Bulb Replacement
.................. 6-45. 6-46
Speech Impaired. Customer Assistance ............... 8-3
9-9
ProCarManuals.com