brake fluid GMC SIERRA 1998 Owner's Manual

Short TripKity Maintenance Schedu’? -- Gasoline Engines
84,000 Miles (140 000 km) (Continued)
0 Check rear/front axle fluid level and add fluid as needed. Check constant
e3 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
velocity
joints and axle seals for leaking. (See footnote
*:*.)
rotation pattern and additional information. (See footnote +.)
87,000 Miles (145 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components (or every 3 months, whichever occurs first).
(See footnote
#.)
Check readfront axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote
**.)
90,000 Miles (I50 000 km)
Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
17 Check rear/front axle fluid level and add fluid as needed. Check constant
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
An. Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
bearings (or at each brake relining, whichever occurs first).
DATE I
MILEAGE
DATE I
MILEAGE
ACTUAL SERVICED BY
7-24
ProCarManuals.com

Long TripMighway Maintenance Schedule =- Gasoline Engines
The services shown in this schedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals. The services shown
at 150,000 miles (240 000
km) should be performed at
the same interval after 150,000 miles (240 000 km).
See “Owner Checks and Services” and “Periodic Maintenance Inspections” following.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure
to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspension, kingpin bushings,
steering linkage, transmission
shift linkage, transfer case
shift linkage, parking brake cable guides, rear driveline
center splines, front axle propshaft spline and brake
pedal springs. Ball joints and kingpin bushings should
not be lubricated unless their temperature is 10°F
(- 12°C) or higher, or they could be damaged.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspections”
in Part C of this schedule.
‘+‘K Drive axle service (see “Recommended Fluids and
Lubricants”
in the Index for proper lubricant to use):
Locking Differential -- Drain fluid and refill at first
engine oil change.
At subsequent oil changes, check
fluid level and add fluid as needed.
0 Standard Differential -- Check fluid level and add
fluid
as needed at every engine oil change.
3500 HD Models with applications requiring
high-speed (above 45 mph or 70 kndh) operation
for
extended periods of time must have the drive axle
fluid changed every 30,000 miles
(50 000 km).
7-28
ProCarManuals.com

Long Trip/Highway Maintenance Schedule -- Gasoline Engines I
22,500 Miles (37 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
(3 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
MILEAGE An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
rotation pattern and additional information. (See footnote +.)
30,000 Miles (50 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
0 Replace fuel filter.
An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote *‘k.)
bearings (or at each brake relining, whichever occurs first).
rotation pat.tern and additional information. (See footnote
+.)
An Emission Control Service. (See footnote?.)
DATE I
7-30
ProCarManuals.com

Long Tripmighway Maintenance Schedule -- Gasoline Engines I
52,500 Miles (87 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
An Emissimz Control Service. MILEAGE
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
rotation pattern and additional information. (See footnote +.)
60,000 Miles (100 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
AH Emission Contmi Service.
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
(See footnote
#.)
velocity
joints and axle seals for leaking. (See footnote :$*.)
bearings (or at each brake relining, whichever occurs first).
rotation pattern and additional information. (See footnote
+.)
(Continued)
I DATE I
SERVICED BY
7-33
ProCarManuals.com

Long Tripmighway Maintenance Schedule -- Gasoline Engines I
82,500 Miles (I37 500 km) DATE I
Change engine oil and filter (or evl_-,r I2 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components (or every 12 months, whichever occurs first).
(See footnote
#.)
Check rear/front axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote
*4‘.)
Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
90,000 Miles (150 000 km)
0
0
0
Change engine oil and filter (or every 12 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components (or every 12 months, whichever occurs first).
(See footnote
#.)
Check redfront axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote
**.)
For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
bearings (or at each brake relining, whichever occurs first).
Replace fuel filter.
AI? Emissiorz Cnrztrol &r\Vice. (See footnote?.)
I MILEAGE ACTUAL I SERVICEDBY I
DATE I
7-36
ProCarManuals.com

Drive Axle Service
Check readfront axle fluid level and add as needed.
Check constant velocity joints and axle seals for leaking.
Transfer Case (Four-wheel Drive)
Inspection
Every 12 months or at oil change intervals, check front
axle and transfer case and add lubricant when necessary.
On ~nanual shift transfer case,
oil the control lever pivot
point and
all exposed control linkage. Check vent hose
at transfer case for kinks and proper installation. More
frequent lubrication may be required on off-road use.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads
for wear and rotors
for surface condition. For vehicles
with rear drum
brakes, also inspect drum brake linings for wear and
cracks. Inspect other brake parts, including drums,
wheel cylinders. calipers, parking brake, etc. Check
parking brake adjustment.
You may need to have your
brakes inspected more often
if your driving habits or
conditions result
in frequent braking.
7-45
ProCarManuals.com

Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from
your dealer.
USAGE
Engine Oil
(Gasoline
Engine)
Engine Coolant
~~
Hydraulic Brake
System
FLUIDLUBRICANT
Engine Oil with the American
Petroleum Institute Certified For
Gasoline Engines “Starburst”
symbol of the proper viscosity. To
determine the preferred viscosity
for your vehicle’s engine, see
“Engine Oil” in the Index.
50/50 mixture of clean water
(preferably distilled) and use only
GM Goodwrench@ DEX-COOL@
or Havoline@ DEX-COOL@
Coolant. See “Engine Coolant” in
the Index.
Delco Supreme
11 @ Brake Fluid
(GM Part
No. 12377967 or
equivalent
DOT-3 Brake Fluid).
USAGE
Hydraulic Clutch
System
Parking Brake
Cable Guides
~
Power Steering System
Manual
Transmission (5-Speed with
Low Gear, RPO
MW3)
Manual
Transmission (5-Speed without
Low Gear,
RPO
MG5)
FLUID/LUBRICANT
Hydraulic Clutch Fluid (GM Part
No. 12345347 or equivalent
DOT-3 Brake Fluid).
Chassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of
NLGI # 2, Category LB or
GC-LB.
GM Power Steering Fluid (GM
Part
No. 1052884 - 1 pint,
1050017
- 1 quart, or equivalent).
GM Goodwrench Synthetic
Manual Transmission Gear Oil
(GM Part No. 12346190
- 1 st.) or
equivalent
SAE 75W-90 GL-4
Gear Oil.
Synchromesh Transmission Fluid (GM Part
No. 12345349 or
equivalent).
7-46
ProCarManuals.com

Section 9 Index
Accessory Power Outlet ......................... 2-59
AirBag ....................................... 1-23
Adding Equipment
............................ 1-3 1
How Does it Restrain .......................... 1-28
How it Works ................................ 1 -26
Location .................................... 1-26
Readiness Light ......................... 1.25, 2.65
What Makes it Inflate .......................... 1-27
What Will You See After
it Inflates ............... 1-28
When Should it Inflate ......................... 1-27
Air Bag
Off Light .......................... 1.58. 2.65
Air Cleaner
.................................... 6- 18
Air Cleaner Filter Restriction Indicator Check ........ 7-41
Air Conditioning ............................ 3.3. 3.4
Air Conditionillg Refrigerants ..................... 6-79
Alignment and Balance. Tire
...................... 6-59
Antenna
...................................... 3-26
Antifreeze
........................... 6-28.6-79.7-46
Anti-Lock Brake System Warning Light
................ 2.68. 4.7
Brakes ...................................... 4-7
Appearance Care
............................... 6-6 I
Adding Equipment to the Outside of Your Vehicle ...... 6-3
Servicing
................................... 1-30
Aluminum Wheels. Cleaning ...................... 6-67
Appearance Care and Materials .................... 6-69
Arbitration Program .............................. 8-9
Armrest Storage Compartment
.................... 2-56
Audio Equipment. Adding
........................ 3-24
Audio System
.................................. 3-7
Automatic Transmission
Check
...................................... 7-41
Fluid
.................................. 6-21. 7-47
Operation ................................... 2-15
Park Mechanism Check
........................ 7-43
Starting Your Engine
.......................... 2-12
Axle. Front
............................... 6-27. 7-47
Axle. Locking Rear
............................. 2-32
Axle. Rear
............................... 6-26. 7-47
Ashtrays ...................................... 2-58
Battery
...................................... 6-39
Jump Starting
................................. 5-3
Warnings ................................ 5-3. 5-5
BBB Auto Line ................................. 8-9
Better Business Bureau Mediation ................... 8-9
Blizzard. Driving
In ............................. 4-38
Replacement.
Keyless Entry ..................... 2-8
9-1
ProCarManuals.com

Brake Adjustment
.................................. 6-38
Fluid .................................. 6-35, 7-46 Master Cylinder .............................. 6-35
PedalTravel ................................. 6-38 Replacing System Parts ........................ 6-38
System Warning Light ......................... 2-67
Transmission Shift Interlock Check ............... 7-42
Brakes, Anti-Lock ............................... 4-7
Braking ........................................ 4-6 Braking in Emergencies ........................... 4-8
Break-In, New Vehicle .......................... 2-10
Bulb Replacement .............................. 6-39
Parking ..................................... 2-25
Trailer ...................................... 4-56
Wear ....................................... 6-37
BTSICheck ..................................... 42
Camper vpe Mirror ........................... 2-48
Camper Wiring Harness .......................... 4-48
Canadian Roadside Assistance ...................... 8-7
Capacities and Specifications ...................... 6-77
Carbon Monoxide .................... 2.30.2.31. 4.40
Care of Your Cassette Tape Player .................. 3-25
Cassette Deck Service ........................... 7-40
Cassette Tape Player ........................ 3-9, 3- 12
Cassette Tape Player Care ........................ 3-25
CassetteKompact Disc Storage ............... 2-55, 2-56
Center Overhead Console ........................ 2-51
Center Passenger Position ........................ 1-32
Certification Label .............................. 4-43
CargoLamp ................................... 2-45
.
ProCarManuals.com

Tachometer .................................. 2-63
Voltmeter
................................... 2-67
Garage Door Opener
............................ 2-5 1
GAWR ....................................... 4-43
Gear Positions. Automatic Transmission
............. 2- 15
Gear Positions. Manual Transmission .......... 2- I8 . 2- 19
GloveBox .................................... 2-51
Gross Axle Weight Rating ........................ 4-43
Gross Vehicle Weight Rating
...................... 4-43
Guide en Franpis
11
GVWR ....................................... 4-43
.. .................................
Halogen Bulbs ................................ 6-39
Hazard Warning Flashers
.......................... 5-2
Head Restraints ................................. 1-5
Headlamps .................................... 2-41
Bulb Replacement
....................... 6-40. 6.4 I
High/Low Beam Changer ...................... 2-36
On Reminder
................................ 2-42
Wiring
..................................... 6-71
Heating
........................................ 3-5
High-Beam Headlamps
.......................... 2-36
Hill and Mountain Roads
......................... 4-34
Hitches. Trailer
................................. 4-55
Hood
Checking Things Under ......................... 6-9
Release
..................................... 6-10
Horn ......................................... 2-34
Hydraulic Clutch Fluid
...................... 6-25 . 7-46
Hydraulic Clutch System Check
................... 7-41
Hydroplaning
.................................. 4-30
Hearing Ilnpaired
. Customer Assistance .............. 8-4
Highway Hypnosis
.............................. 4-33 Ignition
Positions
..............................
Brakesystem ................................ 7-45
Drive Axle
.................................. 7-45
Engine Cooling System
........................ 7-44
Exhaust
Systems ............................. 7-44
Steering
.................................... 7-44
Suspension
.................................. 7-44
Throttle Linkage
.............................. 7-44
Transfer Case (Four-Wheel Drive)
............... 7-45
Instrument Panel
............................... 2-60
Cleaning
.................................... 6-64
Cluster
..................................... 2-62
FuseBlock
.................................. 6-72
Intensity Control
............................. 2-43
Interior Lamps
................................. 2-43
.................................... J ack. Tire 5-25
Jump Starting
................................... 5-3
Key Lock Cylinders Service
..................... 7-41
Key Release Button
............................. 2-12
Keyless Entry System ............................ 2-6
Keys
.......................................... 2-2
9-5
ProCarManuals.com