maintenance GMC SIERRA 1998 Owner's Guide

I Short Trip/City Maintenance Schedule -- Gasoline Engines I
The services shown in this schedule up to 100,000 miles
(I 66 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals. The services shown
at 150,000 miles (240 000 km) should be performed at
the same interval after
150,000 miles (240 000 km).
See “Owner Checks and Services” and ”Periodic
Maintenance Inspections” following.
Footnotes
p The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not
nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed
at the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspension, kingpin bushings,
steering linkage. transmission shift linkage, transfer case
shift linkage, parking brake cable guides, rear driveline
center splines, front axle propshaft spline and brake
pedal springs. Ball joints and kingpin bushings should
not be lubricated unless their temperature is 10°F
(- 12°C) or higher, or they could be damaged.
+ A good time to check your brakes is during tire
rotation. See ”Brake System Inspection’’ under “Periodic
Maintenance Inspections”
in Part C of this schedule.
7-8
ProCarManuals.com

1 Short Trip/City Maintenance Schedule -- Gasoline Engines I
4:::: Drive axle service (see "Recommended Fluids and
Lubricants"
in the Index for proper lubricant to use):
0 Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent oil changes, check
fluid level and add fluid as needed.
If driving in
dusty areas or towing a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
Standard Differential -- Check fluid level and add
fluid as needed at every oil change.
If driving in
dusty areas or towing a trailer. drain fluid and refill
every 15,000 miles (25
000 km).
More frequent lubrication may be required for
0 3500 HD Models with applications requiring
heavy-duty
or off-road use.
extreme overload/trailer towing conditions and
high-speed (above
45 mph or 70 km/h) conditions
for extended periods of time must have the drive axle
fluid changed every
30,000 miles (50 000 km).
See "Recommended Fluids and Lubricants" in
this section.
7-9
ProCarManuals.com

I Short TripKity Maintenance Schedule -- Gasoline Engines I
3,000 Miles (5 000 km)
Ci Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
An Etnission Comd Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote $'*.)
6,000 Miles (10 000 km)
Cl Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See "Tire Inspection and Rotation" in the Index for proper
An Emission Colztr-ol Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
rotation pattern and additional information. (See footnote +.)
9,000 Miles (15 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
An EInisston Control Service.
I DATE I
I MILEAGE ACT I SERVICEDBY I
DATE
MILEAGE
DATE I
SERVICED BY
7-10
ProCarManuals.com

I Short TripKity Maintenance Schedule -- Gasoline Engines I
Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
(See footnote
#.)
velocity
joints and axle seals for leaking. (See footnote **.)
12,000 Miles (20 000 km)
Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every 3 months, whichever occurs first).
17 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
(See
footnote
#.)
velocity joints and axle seals for leaking. (See footnote **.)
rotation pattern and additional information. (See footnote +.)
15,000 Miles (25 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
17 Lubricate chassis components (or every 3 months, whichever occurs first).
An Emission Control Service.
(See footnote #.)
(Continued)
DATE 1
DATE 1
ACTUAL
7-11
ProCarManuals.com

I Short Trip/City Maintenance Schedule -- Gasoline Engines I
15,000 Miles (25 000 km) (Continued)
0 Check rear/front axle fluid level and add fluid as needed. Check constant
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
velocity
joints and axle seals for leaking. (See footnote
**.)
bearings (or at each brake relining, whichever occurs first).
insulation for darnage or looseness. Adjust or replace as required.
This is cl Noise Emission Cmztrol Service. Applicable ody fo vei~icles
sold in the United States.
18,000 Miles (30 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check rear/front axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation’? in the Index for proper
An Emissiorl Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote ‘i”i’.)
rotation pattern and additional information. (See footnote +.)
21,000 Miles (35 000 km)
I DATE I
MILEAGE
DATE
0 Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Cmtrol Service. MI1,EAGE SERVICED BY
7-12
ProCarManuals.com

I Short Trip/City Maintenance Schedule -- Gasoline Engines I
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check rearlfront axle fluid level and add fluid as needed. Check constant
(See footnote
#.)
velocity
joints and axle seals for leaking. (See footnote **.)
24,000 Miles (40 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
Check readfront axle fluid level and add fluid as needed. Check constant
Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
Arz Emissiorl Control Service.
(See footnote #. j
velocity joints and axle seals for leaking. (See footnote :!’*:.)
rotation pattern and additional information. (See footnote +.)
27,000 Miles (45 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first’).
Check readfront axle fluid level and add fluid as needed. Check constant
An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote *:I:.)
DATE
MILEAGE
ACTUAL SERVICED BY
7-13
ProCarManuals.com

I Short TripKity Maintenance Schedule -- Gasoline Engines I
30,000 Miles (50 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Replace fuel filter.
0 Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
(See
footnote
#.)
velocity joints and axle seals for leaking. (See footnote *‘$.)
bearings (or at each brake relining, whichever occurs first).
An Emission Control Service. (See footnote?.)
insulation for damage
or looseness. Adjust or replace as required.
This is a Noise Emission Control Service. Applicable only to vehicles
sold in the United States.
0 Rotate tires. See “Tire Inspection and Rotation’’ in the Index for proper
rotation pattern and additional information. (See footnote
+.)
33,000 Miles (55 000 km)
Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
ITE
MILEAGE SERVICED BY:
MILEAGE SERVICED BY
7-14
ProCarManuals.com

I Short TripKity Maintenance Schedule -- Gasoline Engines I
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check redfront axle fluid level and add fluid as needed. Check constant
(See footnote
#.)
velocity
joints and axle seals for leaking. (See footnote **.)
36,000 Miles (60 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and Rotation’’ in the Index for proper
An Emission Control Service.
(See footnote #.)
rotation pattern and additional information. (See footnote +.)
0 Check readfront axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote
#:*.)
39,000 Miles (65 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
An E1niission Control Service.
0 Lubricate chassis components (or every 3 months, whichever occurs first).
(See footnote
#.)
I7 Check readfront axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote
**.)
I DATE I
MILEAGE ACTUAL I SERVICED BY:
I DATE I
I MILEAGE ACTUAL I SERVICEDBY: I
7-15
ProCarManuals.com

I Short TripKity Maintenance Schedule -- Gasoline Engines I
42,000 Miles (70 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote *‘i’.)
rotation pattern and additional information. (See footnote +.)
DATE I
I DATE I
MILEAGE I SERVICED BY
45,000 Miles (75 000 km)
Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
bearings (or at each brake relining, whichever occurs first).
insulation for damage or looseness. Adsjust or replace
as required.
This is cr Noise Emission Corztr-ol Service. Applictrhle only to vehicles
sold in the United States.
7-16
ProCarManuals.com

I Short TripKity Maintenance Schedule -- Gasoline Engines I
48,000 Miles (80 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote *$:.)
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
50,000 Miles (83 000 km)
DATE
I MILEAGE ACTUAL 1 SERVICEDBY I
DATE I
0 Change automatic transmission fluid and filter if the vehicle’s GVWR is over
MILEAGE
ACTUAL SERVICED BY 8600 lbs. or if the vehicle is mainly driven under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
IJ’pou do nut ~se your vehicle under NIIY of these cmditions, c.llcmge the.flLric1
und filter at IOO, 000 miles (I 66 000 kn;).
Manual transmission fluid doesn’t require change.
90°F (32°C) or higher.
7-17
ProCarManuals.com