brake GMC SIERRA 1998 Manual Online

I Short Trip/City Maintenance Schedule -- Gasoline Engines I
The services shown in this schedule up to 100,000 miles
(I 66 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals. The services shown
at 150,000 miles (240 000 km) should be performed at
the same interval after
150,000 miles (240 000 km).
See “Owner Checks and Services” and ”Periodic
Maintenance Inspections” following.
Footnotes
p The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not
nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed
at the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspension, kingpin bushings,
steering linkage. transmission shift linkage, transfer case
shift linkage, parking brake cable guides, rear driveline
center splines, front axle propshaft spline and brake
pedal springs. Ball joints and kingpin bushings should
not be lubricated unless their temperature is 10°F
(- 12°C) or higher, or they could be damaged.
+ A good time to check your brakes is during tire
rotation. See ”Brake System Inspection’’ under “Periodic
Maintenance Inspections”
in Part C of this schedule.
7-8
ProCarManuals.com

I Short Trip/City Maintenance Schedule -- Gasoline Engines I
15,000 Miles (25 000 km) (Continued)
0 Check rear/front axle fluid level and add fluid as needed. Check constant
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
velocity
joints and axle seals for leaking. (See footnote
**.)
bearings (or at each brake relining, whichever occurs first).
insulation for darnage or looseness. Adjust or replace as required.
This is cl Noise Emission Cmztrol Service. Applicable ody fo vei~icles
sold in the United States.
18,000 Miles (30 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check rear/front axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation’? in the Index for proper
An Emissiorl Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote ‘i”i’.)
rotation pattern and additional information. (See footnote +.)
21,000 Miles (35 000 km)
I DATE I
MILEAGE
DATE
0 Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Cmtrol Service. MI1,EAGE SERVICED BY
7-12
ProCarManuals.com

I Short TripKity Maintenance Schedule -- Gasoline Engines I
30,000 Miles (50 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Replace fuel filter.
0 Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
(See
footnote
#.)
velocity joints and axle seals for leaking. (See footnote *‘$.)
bearings (or at each brake relining, whichever occurs first).
An Emission Control Service. (See footnote?.)
insulation for damage
or looseness. Adjust or replace as required.
This is a Noise Emission Control Service. Applicable only to vehicles
sold in the United States.
0 Rotate tires. See “Tire Inspection and Rotation’’ in the Index for proper
rotation pattern and additional information. (See footnote
+.)
33,000 Miles (55 000 km)
Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
ITE
MILEAGE SERVICED BY:
MILEAGE SERVICED BY
7-14
ProCarManuals.com

I Short TripKity Maintenance Schedule -- Gasoline Engines I
42,000 Miles (70 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote *‘i’.)
rotation pattern and additional information. (See footnote +.)
DATE I
I DATE I
MILEAGE I SERVICED BY
45,000 Miles (75 000 km)
Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
bearings (or at each brake relining, whichever occurs first).
insulation for damage or looseness. Adsjust or replace
as required.
This is cr Noise Emission Corztr-ol Service. Applictrhle only to vehicles
sold in the United States.
7-16
ProCarManuals.com

I Short Trip/City Maintenance Schedule -- Gasoline Engines I
Lubricate chassis components (or every 3 monms, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
(See
footnote
#.)
velocity joints and axle seals for leaking. (See footnote **.)
60,000 Miles (100 000 km)
Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
(See footnote
#.)
velocity
joints and axle seals for leaking. (See footnote **.)
bearings (or at each brake relining, whichever occurs first).
insulation for damage or looseness. Adjust or replace
as required.
This is a Noise Emission Control Service. Applicable only to vehicles
sold in the United States.
An Emission Control Service.
0 Inspect engine accessory drive belt.
DATE I
MILEAGE
(Continued)
ProCarManuals.com

Short Trip/City Maintenance Schedule -- Gasoline Engines
72,000 Miles (120 000 km) (Continued)
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
velocity
joints and axle seals for leaking. (See footnote
**.)
rotation pattern and additional information. (See footnote +.)
75,000 Miles (125 000 km)
0
0
0
0
Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components (or every 3 months, whichever occurs first).
(See footnote
#.)
For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
bearings (or at each brake relining, whichever occurs first).
Check readfront axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote
**.)
Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
insulation for damage or looseness. Adjust or replace as required.
This is a Noise Emission Control Senrice. Applicable only to vehiclus sold in
the United States.
78,000 Miles (130 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
DATE
SERVICED
BY
I DATE I
7-22
ProCarManuals.com

Short TripKity Maintenance Schedu’? -- Gasoline Engines
84,000 Miles (140 000 km) (Continued)
0 Check rear/front axle fluid level and add fluid as needed. Check constant
e3 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
velocity
joints and axle seals for leaking. (See footnote
*:*.)
rotation pattern and additional information. (See footnote +.)
87,000 Miles (145 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components (or every 3 months, whichever occurs first).
(See footnote
#.)
Check readfront axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote
**.)
90,000 Miles (I50 000 km)
Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
17 Check rear/front axle fluid level and add fluid as needed. Check constant
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
An. Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
bearings (or at each brake relining, whichever occurs first).
DATE I
MILEAGE
DATE I
MILEAGE
ACTUAL SERVICED BY
7-24
ProCarManuals.com

Long TripMighway Maintenance Schedule =- Gasoline Engines
The services shown in this schedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals. The services shown
at 150,000 miles (240 000
km) should be performed at
the same interval after 150,000 miles (240 000 km).
See “Owner Checks and Services” and “Periodic Maintenance Inspections” following.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure
to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspension, kingpin bushings,
steering linkage, transmission
shift linkage, transfer case
shift linkage, parking brake cable guides, rear driveline
center splines, front axle propshaft spline and brake
pedal springs. Ball joints and kingpin bushings should
not be lubricated unless their temperature is 10°F
(- 12°C) or higher, or they could be damaged.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspections”
in Part C of this schedule.
‘+‘K Drive axle service (see “Recommended Fluids and
Lubricants”
in the Index for proper lubricant to use):
Locking Differential -- Drain fluid and refill at first
engine oil change.
At subsequent oil changes, check
fluid level and add fluid as needed.
0 Standard Differential -- Check fluid level and add
fluid
as needed at every engine oil change.
3500 HD Models with applications requiring
high-speed (above 45 mph or 70 kndh) operation
for
extended periods of time must have the drive axle
fluid changed every 30,000 miles
(50 000 km).
7-28
ProCarManuals.com

Long Trip/Highway Maintenance Schedule -- Gasoline Engines I
22,500 Miles (37 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
(3 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
MILEAGE An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
rotation pattern and additional information. (See footnote +.)
30,000 Miles (50 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
0 Replace fuel filter.
An Emission Control Service.
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote *‘k.)
bearings (or at each brake relining, whichever occurs first).
rotation pat.tern and additional information. (See footnote
+.)
An Emission Control Service. (See footnote?.)
DATE I
7-30
ProCarManuals.com

Long Tripmighway Maintenance Schedule -- Gasoline Engines I
52,500 Miles (87 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
An Emissimz Control Service. MILEAGE
(See footnote #.)
velocity joints and axle seals for leaking. (See footnote **.)
rotation pattern and additional information. (See footnote +.)
60,000 Miles (100 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
AH Emission Contmi Service.
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
(See footnote
#.)
velocity
joints and axle seals for leaking. (See footnote :$*.)
bearings (or at each brake relining, whichever occurs first).
rotation pattern and additional information. (See footnote
+.)
(Continued)
I DATE I
SERVICED BY
7-33
ProCarManuals.com