transmission fluid HONDA CIVIC 1991 Owners Manual

Fluid Locations
AUTOMATIC TRANSMISSION
FLUID DIPSTICK ENGINE OILFILLER CAP
POWER STEERING
FLUID RESERVOIR
RADIATOR
CAP WASHER FLUID
RESERVOIR CAP
RADIATOR RESERVE
TANK CAP BRAKE FLUID
RESERVOIR
ENGINE OIL
DIPSTICKProCarManuals.comMain Menu s t

Transmission Oil/Fluid Check
Transmission oil/fluid must be checked with the engine off and the
car on level ground.
If the engine has been running, some engine components may be
hot enough to burn you.

CAUTION:

If the oil/fluid level is low, check for possible leaks before adding
oil. Do not overfill.
Since the transmission and differential are in the same housing, you
are actually checking both oil/fluid levels in one procedure. Change
transmission oil/fluid according to the Maintenance Schedule on
page 70.

Manual
Remove the oil filler bolt (beside the right axle). Feel inside the bolt
hole with your finger. If the oil is up to the bottom edge of the hole,
the oil level is correct. If it is not, slowly add oil until it runs out of
the hole, then reinstall the bolt and tighten it securely with a wrench.
MANUAL TRANSMISSION OIL CHANGE CAPACITY: 1.8 (1.9 US qt, 1.6 Imp qt)
Use only SF or SG grade motor oil when adding or changing transmis-
sion oil. OIL CHECK/
FILLER BOLT
CORRECT LEVELProCarManuals.comMain Menu s t

Use the proper viscosity oil

for the climate in which
you drive:

Ambient Temperature

Automatic
The automatic transmission fluid level is checked (with the engine off and the car on level ground) using the dipstick on the passenger
side of the transmission housing. Remove the dipstick and wipe it

DIPSTICK
UPPER

LOWER

Insert the dipstick and remove it. The fluid level should be between
the upper and lower marks. If necessary, add fluid and recheck. Use only DEXRON
Automatic Transmission Fluid (A.T.F.) when adding or changing fluid.
After checking the fluid level, push the dipstick in securely
AUTOMATIC TRANSMISSION FLUID CHANGE CAPACITY: 2.4 (2.5
US qt, 2.1 Imp qt)ProCarManuals.comMain Menu s t

Power Steering
The Sedan (except DX with manual transmission) and DX Hatch- back with automatic transmission are equipped with power steering.
The power steering on your car provides easy handling while parking and maneuvering in traffic, without loss of road "feel" at
highway speeds. An engine-driven hydraulic pump provides full
power assist at low speeds and decreasing assist as the car goes

faster.

CAUTION:

If the power steering system should fail, or if the engine should
stall, the car can still be steered. However, much greater effort
will be required, particularly in sharp turns at low speed.

NOTE:

You may feel a slight clunk or knock when turning the wheel with
the engine off. This is a normal condition due to the design of the

system.

RESERVOIR CAP

UPPER
LOWER

Power Steering Fluid
Check the power steering fluid level
with the engine cold and the car
parked on level ground. Make sure
the fluid level is between the upper and lower marks on the reservoir. If
the level has dropped close to or below the lower mark, check for
leaks before adding fluid to theupper mark. Do not overfill.

CAUTION:

Use only genuine Honda power steering fluid. The use of other
fluids such as A.T.F. or other manufacturer's power steering fluid will damage the system.ProCarManuals.comMain Menu s t

Jump Starting

To start a car with a dead battery, use another battery of the samevoltage, and the proper jumper cables.
Procedures other than those below could cause injury or
damage from battery acid spray, explosion or charging system

overload.

Never connect the jumper cable directly to the negative post of
the "dead" battery.
Never allow the two cars to touch each other. Never allow the jumper cable clamps to touch each other.
Never lean over the battery when making connections.
Never attempt to jump start a vehicle with a frozen battery. The
battery could rupture and explode. If you suspect a frozenbattery, remove the vent caps and check the fluid. If there
seems to be no fluid, or if you see ice, do not attempt a jump
start until the fluid thaws.

CAUTION:

If jumper cables are connected backwards, the car's main fuse
may blow.
1.Turn off all lights, heater and other electrical loads, set parking brake, and shift the transmission to Neutral or Park.
2. Use one cable to connect the positive terminal of the booster
battery to the positive terminal of the "dead" battery.

3. Use the other cable to connect
the negative terminal of the

booster battery to the engine at
the ground cable as shown.
4. To remove the cables, reverse the above procedures exactly.
DO NOT push or tow a car to start
it. The forward surge when the en- gine starts could cause a collision.
Also, under some conditions, the catalytic converter could be dam- aged. A car equipped with an auto-matic transmission cannot be
started by pushing or towing.
DEAD

BATTERY
Negative to the
engine at the

ground cable, not

to the battery

Do not attach

cable here
Positive to

positive
BOOSTER

BATTERYProCarManuals.comMain Menu s t

If towing is necessary, contact a professional towing service. Your
authorized Honda dealer can assist you with detailed towing

instructions.

Never use tow chains or rope to tow a car; your ability to safely
control the car may be adversely affected.
We recommend the following: Flat Bed Equipment —Entire car is winched on a flat bed vehicle.
This is the best way of transporting your Honda.
Wheel Lift Type—Tow with the front wheels off the ground.

If the car can only be towed with the front wheels on the ground:

make sure the transmission is full of fluid (see pages 78 — 79) and
tow with the transmission in neutral (N) and the ignition key in the 1
position.

CAUTION:

To avoid serious damage on automatic transmission cars, first
start the engine and shift to D4, then to N and shut the engine off. If the engine does not run or the transmission cannot be shifted
while the engine is running, the car must be transported on flat
bed equipment.
Check local regulations for towing.

CAUTION:
Do not exceed 35 mph (55 km/h) or tow for distances of more
than 50 miles (80 km).
If a sling type tow is used, the tow truck driver should position
wood spacer blocks between your car's frame and the chains
and lift straps to avoid damaging the bumper and the body. Do not use the bumpers to lift the car or to support the car's
weight while towing. TowingProCarManuals.comMain Menu s t

Index

Battery
Charging System Warning Light.............................................. 30
Jump Starting ........................ 110
Maintenance............................. 89
Specification (Hatchback).... 116
Specification (Sedan)............ 119
Beeper System Fasten Seat Belt Beeper(Sedan).................................. 11

(Hatcback)............................ 15

Belts, Seat............. See "Seat Belts"
Body Repair.................................. 102
Brake Warning Light...................... 31 Brakes
Brake Failure Warning Light.... 31

Brake Fluid................................ 84

Brake System Design.............. 83
Brake Wear Indicators............. 84
Parking Brake........................... 42
Parking Brake Warning Light.. 31
Break-in Period................................. 2

Bulb
Replacement............................
92

Specification (Hatchback)....
117
Specification (Sedan)............

120
Buzzer........... See
"Beeper System"
Capacities (Hatchback)............... 115 Capacities (Sedan)....................... 118
Care and Cleaning.......................... 99
Catalytic Converter..................... 126 Certification Label....................... 121
Chains, Tires...................................

95
Check Engine
Warning Light......... 31
Child Proof Door Locks...................

5

Child Restraint
System................. 21
Cigarette Lighter............................ 44

Clock............................................... 42
Clutch Pedal Adjustment.............. 61
Compact Spare Tire.................... 104
Coolant Temperature Gauge ........

28
Cooling (with
A/C).........................

49

Cooling System..............................

80

Crankcase Emission Control
System................................... 124
Cruise Control Operation.................................. 39
Indicator.................................... 31

Defogger........................................ 34
Defroster........................................ 51

Doors
Child Proof Door Locks............. 5

Locks........................................... 3

Power Locks.............................. 4

Emergency
Changing a Flat Tire............... 105
Hazard Warning System ......... 37If Your Car Gets Stuck.......... 112
Jump Starting........................ 110

Shoulder Belt Buckle............. 113

Towing.................................... 111
Warning and Indicator Lights.. 29
Emission Controls........................ 124

Engine
Coolant...................................... 80

Coolant Temperature Gauge... 28
Exhaust Controls................... 125Identification Number............ 12

1
Oil and
Filter.............................. 76
OH Pressure Warning Light..... 30
Specification (Hatchback).... 116
Air Conditioner
Operation.................................. 47

Service...................................... 98

Air Filter.......................................... 86

Air Pressure, Tires......................... 94
Antifreeze.. See "Radiator Coolant" Anti-theft Steering Column Lock System ..................................... 57
Appearance Care........................ 100

Ashtrays......................................... 44

Automatic Seat Belt...................... 10

Automatic Transmission
Driving Technique.................... 66

Fluid........................................... 79

Operation.................................. 64

(cont'd)ProCarManuals.comMain Menu s t

Maintenance
Non-Scheduled MaintenanceRecord................................... 72
Scheduled Maintenance Record................................... 71

Schedule................................... 68

Severe Driving Conditions...... 72
Manual Transmission Clutch Pedal Adjustment........ 61
Maximum Allowable Speeds.. 63
Oil...............................................
78

Recommended Shift
Speeds.. 62

Shifting......................................

61

Meters, Gauges..........
See "Gauges"
Mirrors Power Mirrors.......................... 35

Rearview Mirrors..................... 35

Octane Rating, Gasoline. See "Fuel"
Odometer........................................ 28
Oil
Engine Oil.................................. 75

Fluid Locations......................... 74
Oil Pressure Warning Light..... 30
Power Steering Fluid................ 85
Transmission Oil/Fluid.............. 78
Operation In Foreign Countries..... 55
Panel Brightness Control............... 37
Parking Brake................................. 42
Passive Belt.................................... 10
PGM-FI
System.................................... 125
Power Door Locks................................. 4
Mirrors...................................... 35
Steering..................................... 85

Windows.................................. 43

Pregnant Women........................... 25
Pressures, Tire Inflation................ 94
Preventive Service...................... 102 Radiator Coolant............................ 80

Rear Seat.......................................... 8

Rearview Mirrors........................... 35
Rear Window Defogger................ 34Rear Window Wiper...................... 34Reminder Lights .................. See "Warning Lights"
Replacement
Air Filter.................................... 86

Bulb............................................ 92
Engine Oil.................................. 76

Fuel Filter.................................. 86

Fuse...........................................90
Oil Filter..................................... 76
Radiator Coolant...................... 82
Spark Plugs............................... 87

Tire............................................ 94
Wiper Blades............................. 88
Rust Prevention........................... 101
Safety Defects, Reporting.......... 128

Safety Items................................... 59

Seats
Adjustment................................. 6
Head Restraints.......................... 7
Seat Belt Reminder Light
and Beeper (Sedan).................. 14

Seat Belt Reminder Light and Beeper (Hatchback).......... 17
Seat Belts Anchor Points (Hatchback)..... 22
Anchor Points (Sedan)............ 24

Automatic Belt......................... 10

Buckling the Front Seat Belts (Sedan)............... 11
Buckling the Front Seat Belts (Hatchback)....... 15
Buckling the Rear Seat Belts .. 19
Child Restraint.......................... 21
Cleaning..................................... 25

Fasten Seat Belt Reminder Light and Beeper (Sedan).............. 14
Fasten Seat Belt Reminder Light and Beeper (Hatchback)...... 17

(cont'd)

Numbers, Identification............... 121ProCarManuals.comMain Menu s t

Index (cont'd)

Inspection................................. 25

Passive Belt.............................. 10
Pregnant Women..................... 25
Rear Center Seat Belt.............. 20
Replacement............................. 25 Shoulder Belt Buckle............. 113

Seats
Front Seat................................... 6
Head Restraints.......................... 7

Rear Seat.................................... 8

Shifting
Automatic................................ 64

Manual....................................... 61

Spare Tire Changing a Flat Tire............... 106
COMPACT Spara Tire........... 104
Spark Plugs Replacement............................. 87
Specifications (Hatchback) ..116Specifications (Sedan).......... 119
Speedometer.................................. 28
Starting the Engine......................... 58
Steering Anti-theft Column Lock .......... 57Power Steering......................... 85

Tilt Steering.............................. 32

Stuck Car..................................... 112

Sunroof........................................... 52
If the Sunroof Won't Close..... 53
Maintenance............................. 53
Operation.................................. 52

Sunshade.................................. 52

Tachometer.................................... 28
Temperature Gauge, Coolant....... 28 Tilt Steering.................................... 32
Tire Air Pressure............................. 94
Balancing................................... 97

Chains....................................... 95

Changing a Flat Tire............... 106COMPACT Spare.................. 104
DOT Tire Quality Grades....... 122
Inflation Pressures................... 94 Requirement............................. 96
Rotation.................................... 97
Snow Tire................................. 95
Spare Tire............................... 104
Specification (Hatchback).... 116 Specification (Sedan)............ 119
Tools............................................. 105
Towing.......................................... 111

Transmission
Capacity.................................... 79
Identification Number............ 121

Oil/Fluid..................................... 78

Shifting the Automatic............ 64

Shifting the Manual.................. 61
Transmission............................ 78
Treadwear.................................... 122

Trip Meter....................................... 28
Trunk Access From Rear Seat....... 8

Trunk Lid........................................... 5

Turn Signals.................................... 36
Warning Lights............................... 29
Warranty Service........................ 127Washer Rear Window Washer............. 34Reservoir Capacity.................. 33
Windshield Washer.................. 33
Washing........................................ 100

Waxing......................................... 101

Windows
Appearance Care................... 100
Power Windows...................... 43

Windshield Defogger..................... 51 Windshield Washer....................... 33
Windshield Wipers........................ 33
Wiper Blades ..................................
88
Wipers Rear Windo
w Wiper................ 34
Windshield Wipers................... 33
Vehicle Identification Number.... 121
Ventilation...................................... 45ProCarManuals.comMain Menu s t

AMERICAN HONDA MOTOR CO., INC.
1919 Torrance Blvd., Torrance California 90501 1991 Honda Motor Co., Ltd. - All Rights Reserved

31SH3630 CRES 10009805

00X31-SH3-6302 PRINTED IN U.S.A.
Gas Station Information

Gasoline: UNLEADED only
Pump octane of 86 or higher.
Gas Tank-Capacity: 45 l (11.9 US gal, 9.9 Imp gal)
Tire Pressure (measured cold) front/rear STD Hatchback: 240 kPa (35 psi) /220 kPa (32 psi)DX Hatchback: 220 kPa (32 psi) / 220 kPa (32 psi)
Si Hatchback: 195 kPa (28 psi) /195 kPa (28 psi)DX Sedan: 220 kPa (32 psi) / 220 kPa (32 psi)
LX Sedan: 180 kPa (26 psi) /180 kPa (26 psi)
EX Sedan: 180 kPa (26 psi) /180 kPa (26 psi)
Compact Spare: 415 kPa (60 psi)
Other Tire Information See "Tires" pages 94-97.
Hood Release Pull handle under left side of dash.
Engine Oil: Use "Energy Conserving II" SG grade oil. 5W -30 preferred (see page 75 for complete viscosityrecommendations).
Capacity (including filter):
3.5 l (3.7 US qt, 3.1 Imp qt)
Manual Transmission Oil: Use SF or SG grade oil.
10W-30 or 10W-40 preferred (see page 78 for complete
viscosity recommendations). Capacity (including differential): 1.8 l (1.9 US qt, 1.6 Imp qt)
(Oil should be up to filler bolt hole in housing beside
right axle)
Automatic Transmission Fluid:
Us
e
DEXRON® II type Automatic Transmission Fluid

(ATF). Remove
dipstick from right end of transmission,
wipe off, reinsert, remove and read fluid level - do not
force the rubber plug in when reading fluid level or replacing dipstick.
Capacity (including differential):
2.4 l (2.5 US qt, 2.1 Imp qt)
Power Steering Fluid Use only Honda power steering fluid: do not use ATF or
any other brand of power steering fluid because it will
damage the system.ProCarManuals.comMain Menu s t