Tps HONDA CIVIC 1998 6.G User Guide

Road Test
NOTE: Warm up the engine to normal operating temperature (the radiator fan com6s on).
1. Apply the parking brake and block the wheels. Start the engine, then shift to the E position while depressing the
brake pedal. Depress the accelerator pedal and release it suddenly. The engine should not stall.
2. Test in E position
Park the vehicle in a slope (approx. 16'). apply the parking brake, and shift into E position. Release the brake; the
vehicle should not move.
3. Test-drive the vehicle on a flat road in the position shown in the table. Check that the engine speeds meet the approx-imate vehicle speeds shown in the table.
NOTE: Throttle position sensor voltage represents the throttle opening. To monitor the throttle position sensor volt-age, use one of the following methods:
A. Connect the Honda PGM Tester, and go to the PGM-FI Data List.
A1For road testing on '96 - 98 models, remove the drive/s side kick panel to expose the TCM; on '99 - OO models,remove the passenger's side kick panel to expose the PCM (see page l,[-236),
Set the digital multimeter to check throttle position sensor voltage between terminals:. '96 - 98 modols: TCM 84 {+} and Aa (-) or A17 (-1.. '99 - 0O models: FCM C27 {+l and 820 (-l ot 822 l-1.
DIGITAL MULTIMETER(Commerci.lly rvrilabl.lKS-AHM-32-003or oquivalant
BACKPROBE ADAPTER
BRN/BLK
A {26P1
TPS {BED/BLK}
'96 - 98 Models:
BRN/BLK
14-296
OBD ll SCAN TOOL orHONOA PGM TESTER
D{16Pt
Ware side ot female terminals
Wire side of female terminals

Dashboard
Gomponent Removal/lnstallation
(cont'd)
Center panel removal:
1. Remove:
. Center dashboard lower cover (see page 20-69)
. Radio {see section 23)
2. Remove the rear window defogger switch and haz-
ard warning switch, then disconnect the connectors.
>: Screw locations, 5 >: Clip locationsA>,4 B>,3
fii*-)
CENTERPANEI.
rt-xR.
W
IHAZARDWARNINGswlTcH
r44 "
F.IZvl
IIREARwtNoowOEFOGGERswtrcH
MtxCONTNOLCABLE
3. Disconnect the air mix control cable, and remove the
screws, then pull out the center panel.
4. Disconnect the connectors from the heater control
u nit.
5. Installation is the reverse of the removal procedure.
NOTE:
. Make sure the connectors are connected properly.
. Adjust the air mix control cable (see section 21).
20-70
Removal
SRS components are located in this area. Review the
SRS component locations, precautions, and procedures
in the SRS section (24) before preforming repairs or ser-
vice.
NOTE:
. An assistant is helpful when removing and installing
the dashboard.
. Take care not to scratch the dashboard, body and
related parts.
1. Remove:
o Front and rear consoles (see page 20-67)
. Console panel (see page 2O 67),
. Driver's dashboard lower cover and knee bolster(see page 20-68)
. Glove box (see page 20-69)
. Center dashboard lower cover (see page 20-69i
2. Lower the steering column (see section 17).
@ To avoid accidental deplovment and
possible injury, always disconnect the driver's
airbag connector belore lowering the steering col-
umn lsee section 241.
NOTE: To prevent damage to the steering column,
wrap it with a shop towel.
3. Disconnect the dashboard wire harness connectors,
remove the nuts, then move the under-dash fuse/
relay box. Disconnect the antenna lead and moon-
roof relay connectors.
DASHBOARD cltPs
CONNECTORS(for some models)
MOONROOFRELAY
ANTENNALEAO
FRAME
SRS MAINHARNESS
9.8 N.m (1.0 kgf m,7.2lbt.ltl
DATACONNECTOR WIRE HARNESSDetach. CONNECTORS

rt
'99-00 models:
(5i%ease)E>4 BRNiBLK
i.,.,].',,-
ERNi BtK
BRIVBLK
BFN/BLK
BRN/BLK
BRN]BLK
BRIl/8LK
BFN/BLK
r * s r;l ao^r,qt r
CKF s€nsor 1t -1ll ELU/FEU
Knoq( sonsor (r15J '-l !l r{EUl6LU
P maryHo2s*?H wHT
Mainshafl speeo ssnsor -1ll fiEU
Coutershall sp€ed sensor -+F ] BLU) ..",r.u,.0n
016Y7, Dl6Y5 (CW) ongines
;;=-"r,i,-l
Ly"::::::::
I Secondary Ho2s :{ WHT/RED-;'4:v-..1
RED/BLU - I
wHT - f rau,rru (an )
pgTpse- J
*1i016Y5, Dl6Y8engines *4:016Y7, Bl6AzerEines lcont'd)*2: Excepl DI6YSengino ([VT) *5: D16Y5, D16Y7, D16Y8Bngines* 3:Dl6Y5 sngine ([VT) *6:B16M, D16Y8,016Y5 (CW)engines
015Y5 (LVT) sngine
41-.1
Dfiv6 prirEy speeo sonsot -1l l hEL,bLU
Driven gr ley sp€ed sensor -- F I WHT
Secondary gea sian sp€ed sensor .-ll WHT/RED
E : Engine w re harness E : Rear h€al6d orygen sensor sLlb harness
IIJ : Main wire harnsss ------ shielding
816A2, Dl6Ygengiftes
23-77

\
Connector C
- Blue- On engine wire harness
\
1 BLU/RED (CKF P)
2 BLU (CKP P)
3 GRN [rDC P)
4 YEL (CYP P)
5 BLU/REO (ACS)
6 BLU/ORN (STS)
7 BRN (SCS)
8 LT BLU (K.LINE)
I CVT: GRY [rMA)10 WHT/BLU (VBU)
11 WHT/RED (CKF M)
12 WHT (CKP M)
13 RED [rDC M)
14 BLK (CYP M)
1s Dl6Ys/D16Y8iBLU/BLK (VTM)
16 USA: GRN (PSPSW)
17 WHT/RED {ALTF)
18 BLUA/VHT (VSS)
19 -,.
20
21
22
23 016Y5 with l\.4/T:BLK (lP +)
24 D 16Y5 with M/T:RED (rP -, VS -)
25 D16Y5 with M/T:wHT (VS +)
26_
27_
28
29 CW: LT GRN (ATP NP)D16Y5 with l\4/T:RED (CLSW
30 CW: PNK OMB)
t
'I48910
11121314't5't6171819202122
23242526272a293031
L
124
789101112
13141516
Connector D
- Gray- On engine wire harness
1 RED/BLK [TPS)2 REDMHT (ECI)
3 RED/GRN (MAP)
4 YEURED (vCC1)
5 GRN,A/VHT (BKSW)
6 CWD16Y8:RED/BLU (KS)
7 WHT (All except D16Y5M/'T - PHO2S)(D16Y5 M/T - LABEL)
8 RED/YEL (IAT)
I D16Y5i WHT/BLK(EGRr)
10 YEUBLU (VCC2)
11 GRN/BLK (SG2)
12 GRN,ryVHT (SG1)
13 016Y5/D16Y8:GRN/BLKD16Y7: RED//EL(sHo2sG)
14 WHT/REO (SHO2S)
15 '2: LT GRN (PTANI9
16 USA: GRN/RED (EL)
*2 = '96 D16Y8 enoine: All Coupes97 D16Y7 enoine. Calitornia Couoe and CaliforniaSedan LX'97 D16Yg engine: All Coupes and California Sedan'98-99:All
202-27

\I
Connector C
- Blue- On engine wire harness
1 BLK/WHT (PO2SHTC)
2 WHT/GRN (ALTC)
3 al: RED/BLU (KS)
5 WHT/RED (ALTP)
6 12 WHT/BLK (EGR2)
7 GRNAVHT (SGl)
8 BLU (CKPP)
9 WHT (CKPM)
10 *3: BLU/BLK (VTM)
13 D1685: GRN/RED OF2)14 01685: BLU/RED (PF2)
16 WHT (PHO2S)
17 RED/GRN (MAP)
18 GRN/BLK (SG2)
1s YEURED (VCC1)
20 GRN (TDCP)
21 RED fiDcl\4)22 BLU/RED (CKFP)
23 BLU,ryVHT (VSS)
24
25 RED/yEL (lAT)
26 REDAVHT (ECT)
27 RED/BLK (TPS)
28 YEUBLU (VCC2)
29 YEL (CYPP)
30 BLK (CYPr,,t)
31 WHTiRED (CKFrVr)
cw D16Y8,816A2cw D1685Except D l6Y7
t
1sl't0234678
111213141516171819202122
23242526272A293031
Connector D
- Gray- On engine wire harness
D1685, '99100 except CW:
1 YEL (LCA)
2 GRN,ryVHT (SHB)
3 GRN/BLK (LCB)
5 .1 : BLIVYEL (VBSOL)
6 WHT (ATPR)
7 BLU/YEL {SHA)8 PNK (ATPD3)
*1= Except D1685
'99100 cw:
1 WHT/RED (VEL)
2 GRN/BLK (rNH SOL)
3 GRN/vEL (SHLS l\4)
4 BLUAVHT (SHLS P)
5 BLK^fEL (VBSOL)
6 WHT (ATPR)
7 BLKWHT (VEL SG)
8
9 YEL (ATP D4)
10 BLU (NC)
11 RED (Ntvl)
12 WHT (NMSG)
13 LT GRN (ATPNP)
14 8LU {ATP P2)
16 GRN (NCS G)
I
1O WHT (NDN)
11 RED/BLU (NDR)
12 GRN (NDR SG)
13 LT GRN/RED (ATP S)
14 GRN/BLK (DIND)
16 REDMHT (NDNSG)
IJ
14
6o10rr ll rz
13141516
202-29