light HONDA CIVIC 2000 6.G Workshop Manual

Cruise Control
(
UNDER.DASHFUSE/RELAYBOXI t FUSE i4| (CBUISE CO{TAOL)
i f tlfl*t., s"" P *",a H DistribulDn,
L--g----r9101_
".,."11[ftT:{.
! i,*f+*l
f:L[
SeeDash andConsoleLights
"-T[_
CRUISECONTROLMAINswtTcH
\fa
SeeDash andConsoleLights
I
'r
Lr cRN I I
I """I
I
*"1
rt
,. L----- ---3-l
i--- r#e
-ffi$r------(
llL------- --------J
"oN"
It{otcAToR
depressed. f--
Open withbrake pedal
34

Cruise Control (conrd)
""t===j
= G401
Cruise controlactuator qontol
4BBT{
4
Se€ Ground Oistribution,page 1+4.
BRt{lv}tT
3
RED/BLU
10('96197 models 9)
'Cruige control'indlcator light codrol
wEw 56 Ss€ po$/er
-r+ Distribution,page 10-6.
CRUI6E I
c411PHOTO 60
GAUGEASSEMBLY
a
;lG;-
- - -
J,T"r"r,E;oAitr-usE z5 tusEi RELAY
IiF" 3g;g;; f,%,,-------' page.tG6. IL:4---:---JSee Dashand Console
;I
CONTROLrNrxcaTonUGHT
t-ffiII c0f 0r IIJ
I
I
E3BL|(
Se€ Ground Distribution,pag61+7.
I
IGro{nd
('96198 models 8)o
6nNAVST
""r1
I
11
ENN/ELX
aFt/Bu(
2aLu
c202PHOfO 23VIEW 1
c203PHOTO 18
CRUISECONTROLACTUATOR
\1----*-E2Y
34-2
l' G202

Gruise Control (cont'd)
- How the Circuit Works
The cruise control system uses mechanical and
electrical devices to maintain the car's sDeed at a
setting selected by the driver.
System Description
The cruise control unit receives command signals
from the crurse control main switch and the cruise
control SeVResume switch. With the ignition switch
in ON (ll) or START (lll), voltage is provided to the
cruise control main switch through fuse 14. When
you push the switch to ON, power is provided to the
cruise control unit and the brake switch.
The cruise control unit receives information about
operating conditions from the brake switch, the
vehicle speed sensor (VSS), and the clutch switch
(manual transmission) or the A,/T gear position
switch (automatic transmission). The cruise control
unit then sends signals to the cruise control actuator
which regulates the throttle position to maintain the
selected speed. The conlrol unit compares the
actual speed of the car to the selected speed. The
control unit then uses the result of that comoarison
to open or close the throttle.
The brake switch releases the system's control of
the throttle at the instant you press on the brake
pedal. The switch sends a signal to the control unit
by removing power from the normally closed brake
input (GRY wire), and providing power at the
normally open brake input (GRN/vVHT wire). The
control unit responds by allowing the throttle to
close. The clutch switch or the A,/T gear position
switch sends a "disengage" signal to the control unit
that also allows the throttle to close.
The cruise control system will set and automatically
maintain any speed above 25 mph (40 km/h). To set
it, make sure the main switch is on and the switch
indicator is on. Then, after reaching the desired
speed, press the SET switch. This sends a "set"
signal to the cruise control unit which, in turn,
controls the cruise control actuator to maintain the
set speed.
When you push the SET switch and the cruise
control system is on, the "cruise control" ON
indicator lights up.
34-4
(
You can cancel the cruise control system by
turning the main switch off . This removes power to
the control unit and erases the set speed from
memory. lf the system is disengaged temporarily
by the brake switch, or clutch switch, and the car's
speed is still above 25 mph, press the resume
switch: the car will automatically return to the
previously set speed.
For gradual acceleration without pressing the
accelerator pedal, push the RESUME switch and
hold it there. This will send an "acceleration" signal
to the control unit. When you release the switch, the
system will be reprogrammed for the new speed. To
slow the car down. oush the SET switch in and hold
it there. This sends a "deceleration" signal to the
control unit, causing the car to coast. When the
desired speed is reached, release the SET switch.
This reprograms the system tor the new speed.
Refer to the Service Manual (Section 23, Electrical)
tor specific tests or troubleshooting procedures.
(
a

A/T Gontrols ('96-'98 CVT) (conrd)
sfr
Dl0
YEUALU
@
I J
-'u-.'-.i - - -
I 3X3'5"
L]Sffiflulilir:
lLlftT:l,', "*,
3=:. fierminalslT-20)
*l
v56
r+
r andLights
"," I
;I
-JI!.
br
iee Dash
vtEw 56
IISs€ PowerDisfibution,page 10.6.Se€ PGIV-FI,page 23-12.See Dash arConsole Ligl
I FEo/ELK
lazIMANIFOLDABSOLUTEPRESSURE(MAP}
il'-
4o
(
REO/ELK-{ i["r.r,
RED/BLK
cl't5fferminals8n4)
wEw 3a
#.1 !3"" r,
c'l31PHOfO 85vtEw 59
1lc410
vtEw 35
Se€ GroundDistribution,page 1+7.
ORN/BLK
Dl1D12
a
-----1 ENGINE
I l-c_qllFgL
I l8l,:',T* lffiff" iF!&i:'
L_"S.f___ __y,' _j,ii!,J?"*
a
i
--r3 - -.
:F.
- - -.-o ,'i6i I rRANsMrssroN
I TP MAP
i iln'o, ;;;' iiaicato, i[f[!!! ftcM)
I input input conkol IVie-Jo:e'-L - - -- - - - - - - - - - - J
39-6
ir=l*--:*"ii*lF.?}t?''------JvtEwTa
\

A/T Controls ('98 GX and All '99-'00 Models except CW) (cont'd)
(
\la
t
\
\
\
I
t
I
\
I
I
t
I
t
\
POWERTRAIN
! t*,*" ffi,v i"lll i[?Hl,1P.
L _gA _ _ _ _ _g'L _ _ _ _ yy _ j ii?i%'"
*:ll--
",."
-1
"-TX
YEL
.[-Qhuit"I
miftu.*
.Li--,1
""":l
iii
F=lm+';I ii,r-;.'_
I tiJ.l______
i 1",,'"'."."-*{
TfleolTla's8.14)
I
"""'"'.
f
""r.:
I
",,1 ;il
UNDER-DASHFUSE/RELAYBOXiT-*-.'-;---l
LJ5Effi$iJ
lL[9*?:{. csoT
See PowerDistribution,page 10-6.
===a oerm|nars 17-20)
lJ'lll"-+
See Dash and Console Lights
l*'r
L__l+: G40t
See GroundDistribution,c€lge 14-7.
J:I
I
c410
vlEW 35
c136
vtEw 20
r--,"";---- -----^-_=--r powERTRAtN
I s"""iy n'i'^- lcoNTRoL
i ;a; iiii"rto, i MoDULE (PcM)
L------- ----:Slgrol- -j ur-iic,
SeePGM-FI
39-10

Anti-Lock Brake System (ABS) (cont'd)
(
FUSE 16iA DEFlEtsY See Power:ar Distribution,page 10-8.
c421 10
vlEW 50
'96- 97 Dl
mooels
.I UNDER-
page 1G6. I pHoro 5d
c501
vlEW 55
See Power Distribution,page 1S6.
AAS INDICATORLIG}IT
!'-r;us?;---l H5BE"
ilrryilrfi#ftilHriL-g------JL-g------J'tr F,1%'wHr/GRN I v/El.V 2Z
I t"r,o"" se€ Power
YELD5GAUGEASSEMBLY
usA
CarsdaI
(
D3
', ',i:,tr?""" ! P"g" t+-z".r',
*
! see cround Distributiofl,
".., I i"., I ".-l I;nl
iffit L------J
' n : G401
mI iot
T1*l ^*ry*l:-------l 8Bi"o.' used) ; 4ts5lnolcalor i UH|Tr----j. light conlrol r. iicib ett,"LTfflo",Input
1lo2)lgnition 2
Speed sensor anputsvlEw 63
(
{FLo) {FL1) (FBo) {FF1) (Rr"o) Sg____gT]-__g,l-j
Blo lf B23Y B8Y B21lf B6Y BlsY B4X B17f
i i I i o""l .,",-ul u.,"..1 o"",'.. I
rrttl
| | | I ,l ,l .I of"on"
ll ll I ti
't---'+----"[ --f !'?'%,'
""n*",lo"no""l *"1 *"*-l *"1 .'"."1 *,*.[ "**.I
I r L___t"" " t__t"." 1___!".""
"r.f_ "4::3' ;FJ,;::; ":f3:::1'' "lf-*i":''
t' ,.,Jtri"?r. ll;l]flffi lFli.ft. lU]flqtfl
l l"#tgl I lt5T8?l I lt"F"Ti?l I lt;Tt?f
O--t Distribution,
'n"r,o^n
I
Page 10-13'
.trr -N- .I BRAKE
| | swrrcH
igr:*
o"ntr"r
!
a'KBLU
It
""*[:-l
ftff^"n"o''''ot
I
", I
m;r""#,usi:",
".1
44-2

- How the Circuit Works
Battery voltage is supplied through tuse 56 to the
A,/C compressor clutch r€lay contacts at all times.
With the ignition switch in ON (ll), vollage is applied
to the coil of the A,/C compressor clutch relay
through fuse 17. When you push the A,/C switch
ON, and the heater fan switch is in position | , 2, 3,
or 4, a "ground" input is provided to the engine
control module (ECM) or powertrain control module
(PCM) through the l'lC thermostat and the l'lC
pressure switch.
The A,/C compressor clutch relay is grounded by the
engine control module (ECM) or powertrain control
module (PCM). When energized, the A'lC
compressor clutch relay allows battery voltage to
turn on the A,/C comDressor clutch.
The A,/C ON indicator light comes on when the A,/C
system is requested.
A,/C Thermostat
The A'lC thermostat is located on the evaoorator
housing. The A,/C thermostat turns off the A,/C
compressor clutch if the temperature at the
evaporator goes below 3'C (37'F). This prevents
condensation from freezing on the evaporator fins
and blocking the air delivery into the passenger
compartment. The blower motor will keep running
when the sensor turns off the comDressor.
A,/C Pressure Switch
The fuC oressure switch is located in the condenser
outlet line where refrigerant is in a high
temperature/high pressure liquid state. The switch
will sense abnormally high or low pressure, and
open the circuit. This removes ground, and the
compressor will stop running.
Thermal Protectot
The thermal protector, located on the A,/C
compressor, opens and turns the compressor off if it
senses high temperature. Once the compressor
cools, the switch will close and the compressor will
begin running again.
Refer to the Service Manual (Section 22,
Air Conditioning) for specific tests or
troubleshooting procedures.
62-3

Rear Window Defogger
l
- '96-'98 Models
See Dash andConsole Lights
rf
See Dash andConsole Lights
S€e GroundDistribution,page 14-7.
L--------
c501
vtEw 55
il
l1c
FUSE 16FR DEF R€LAY7_54
I FUSE/RELAY
ff":;;1il, l"'3|""
3"C3jgl-i
REARwtNDowDEFOGGERSWITCH
.I UNDER-DASH
@
r-F----1
i-f:"'*rul
!._L:___J
UNDER-HOODFUSE/RELAYBOX
FEO/BL| vtEw 34
ll-,---:L::
NEAHwtNDowDEFOGGERRELAYP|1oTO 59
UNOER-DASHFUSE/RELAYBOX
co,pe ano seoanu
'1"[ FzT;4-
-------J
Hatchback
See GroundDistribution,page 14-7.
Y
I
I
t___
"._,".trf
t*''
T^
fl[lfEex,"
"'-f
t
seecrounda rr( Distnbutron,
"r- |
Pase 14-10
I
* coorPHA|O 1A2
".^,"i'uI g"x%,0,
' * 9,g%,,,eu,eul
I
|.Tl neanI .5 | WTNDOW
IiIDEFoGGER
I"
I*-l
II ^--.
PHOra 1AA: G401
64

Integrated Control Unit
NOTE: Fuse 31 is hot with lgnition Switch in START (lll) and clutch pedal depressed or A,/T Gear Selector in
PARK (P) or NEUTRAL (N), see Starting System, page 21,21-1, ot 21-2.
See BrakeSystemlndicatorli^hl
FUSE 3IstaaTEaSIGI{AT7AAI
I
I
I
I
I
\
\
\
\
\
\
I
I
I
I
I
I
/
S€s SiarlingSyslsm, pago 21,21-1. or 21'2.
SEs BrakeSystemlndicetorLight A6
SsaClharSrrESystom
Eog GoundDistlbution,page l,l-7.
L------3c420PHO|O 63vtEw 53
--r-r..r'
FED/BLU
SeeCeilingLightSee Seat Beltand lgnitionKey Remind€rs
t@
i'l-;;,-lH8B'r*| rrmn1gn I FUSEI
i f t*" ig8f"LJr____J PHOTO 7
u'lf tf,%,
S vtEw 3a
wHr/FED
| 3fl3,n'"n
wHr,FED I sYsteh
<--=- !t
,r"r,".0 | ,n"r,".u I
| .l B*?r:"" ,.!,.*,

Brake System Indicator Light
- '96-'98 Models
NOTE: Fuse 31 is hot with lgnition Switch in START (lll) and clutch pedal depressed or A,/T gear selector in
PARK (P) or NEUTRAL (N), see Starting System, page 21 , 21-1, or 21-2.
a
FUS€ 31atAirEn8Gl{tt7.all
UNDER-DASHFUSE/RELAYBOXS€o Starling Sysl6m,pag6 21, 2l-1, or el-2,
FUSE 25
ffR s." Ponr"tDistribulion,page 10-6.
rry
I
;?l
r
I
I
I
I
I
I
I
c501PHOTO 60vtEw 55
Ss€ Pow6rDlstribution,page 1G6.
---.I GAUGE$os IndicatorsI ASSEMBLY
i',i!i,I2'
I
I
(slt--95.:l-_i
l8s: GRN/FEDr--- CW ----.
! 3 A cso3 :..^.,"..,"",^.;i "lir%?u' ' rRANsMls-sloN :! ll virw ro : CONTROL ;
99€ grqn'd | ! s I iiiiir^ , vtLw 6s
i o"^r"'o |
'i'jri
| "lw;t,b---4---- 31i3*:'. --l:ffiffi--i
i
---- -.L- J- -:g,tgLesr.l - ---- J--:- J--i : ! 3113'"0* | :-9tF":--T-tY-E;"41i'",
: : lsrss9l;-;?--q1Al" :L:W-J i
-----.1- J- -tlb$Lsr'{.i------ J--:- J--i : ! 31ffi "o* | i-trfr; - -
i
-TFr,lifu:i-|l - - .Tf"*;',r;,f'.F?f;l', i LTS-: :
i I ii
-""'"L--i:t--i3trFlr*n'"i
i mooule ficlrt) iI PHO|O 121 '
:! :i ffitre"ninas;: ll ti n"",".0 ll :---. [: i,119i9."' ''tl
: I :i asi: '.I i eri: -----':::---:
i",",1 iiiffi_il$.t'ii: i"-,s*
vlEw 54
-- vtEot 66 , Ffl anlxe rLUto
i*l
' ".","1;l,"p;a;
illJff*ttt**
u.-u.*il ii [JFHi:"'l*iTfit*,".
I Y i frpanxrxc :' r#"Al[';u3*'""i
I I
U il4.lFfffff'UJ:"" ii EJi,fii,i,"-" i r-j
3"ilj*il
ii
"."""J[ft*,,tl-
i lilt:','x;l
71
i Cior I tE^- phoroTs ,l - : pHoro 7s * C+6tF6r6sz r- usA. - - - - - . t - - - - - canada Froiit sz