maintenance schedule HONDA CIVIC 2002 7.G Owner's Manual

The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If the level is at or
below the MIN mark, your brake
system needs attention. Have the
brake system inspected f or leaks or
worn brake pads.
Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement. However, the use of
any non-Honda brake fluid can cause
corrosion and decrease the lif e of the
system. Have the brake system
f lushed and ref illed with Honda
Heavy Duty Brake Fluid DOT 3 as
soon as possible.
Check the f luid level in the reser-
voirs monthly. There are up to two
reservoirs, depending on the model.
They are:
Brake f luid reservoir (all models)
Clutch f luid reservoir
(manual transmission only)
Brake f luid marked DOT 5 is not
compatible with your car’s braking
system and can cause extensive
damage.
The brake f luid should be replaced
according to the time recommenda-
tion in the maintenance schedule.
Brake and Clutch Fluid
Maint enance
Brake System
222
MMAAXX
MMIINN

Caref ully clean the inside of the
air cleaner housing with a damp
rag.
Place the new air cleaner element
in the air cleaner housing.
The air cleaner element is inside the
air cleaner housing in the engine
compartment.
To replace it:Loosen the seven bolts and
remove the air cleaner housing
cover.
Remove the old air cleaner
element. Reinstall the air cleaner housing cover, tighten the seven bolts.
The air cleaner element should be
replaced according to the distance
recommendation in the maintenance
schedule.
1.3.
2. 4. 5.
Replacement
Maint enance
A ir Cleaner Element
225
AAIIRRCCLLEEAANNEERREELLEEMMEENNTT
BBOOLLTTSS
BBOOLLTTSS

Clean the hood latch assembly with a
mild cleaner, then lubricate it with a
multipurpose grease. Lubricate all
the moving parts (as shown),
including the pivot. Follow the time
and distance recommendations in
the Maintenance Schedule. If you
are not sure how to clean and grease
the latch, contact your Honda dealer.
Maint enance
Hood L at ch
226
PPIIVVOOTTSS
LLAATTCCHHAASSSSEEMMBBLLYY

Disconnect the wire connector
f rom the ignition coil by pushing
on the lock tab and pulling on the
connector. Pull on the plastic
connector, not the wires.
Loosen the two holding clips by
turning the heads one-quarter turn
counterclockwise with a f lat-tipped
screwdriver. Remove the cover by
pulling it straight up.
The spark plugs in your car are a
special platinum-tipped design f or
longer lif e. The spark plugs should
be replaced according to the
distance recommendation in the
maintenance schedule.
Clean up any dirt and oil that have
collected around the ignition coils.
1.
2. 3.
CONT INUED
Maint enance
Spark Plugs
Replacement
227
CCOONNNNEECCTTOORRLLOOCCKKTTAABBHHOOLLDDIINNGGCCLLIIPPSS
IIGGNNIITTIIOONNCCOOIILL

µµ
µµ
µµ
The belts should have the f ollowing
‘‘play’’ or def lection. The timing belt should normally be
replaced at the intervals shown in
the maintenance schedule.
In very high temperatures
(over 110°F, 43°C).
In very low temperatures
(under 20°F, 29°C).
Replace this belt at 60,000 miles (U.S.)
or 100,000 km (Canada) if you
regularly drive your car in one or
more of these conditions:
Power steering belt:
Alternator belt:
Check the condition of the two drive
belts. Examine the edges of each
belt f or cracks or f raying. If you see signs of wear or looseness,
have your dealer adjust or replace
the belts.
Check the tension of each belt by
pushingonitwithyourthumb
midway between the pulleys.
Drive Belts
T iming Belt
Drive Belts, T iming Belt
Maint enance237
AALLTTEERRNNAATTOORRBBEELLTT
PPOOWWEERRSSTTEEEERRIINNGGBBEELLTT
0.51 0.65 in (13.0 16.5 mm)
0.33 0.43 in (8.5 11.0 mm)

Block the rear wheels.
Fill the f uel tank.
Change the engine oil and f ilter
(see page ).
Wash and dry the exterior
completely.
Cleantheinterior.Makesurethe
carpeting, floor mats, etc. are
completely dry.
Leave the parking brake off. Put
the transmission in Reverse
(5-speed manual) or Park
(automatic).
If you need to park your car f or an
extended period (more than one
month), there are several things you
should do to prepare it f or storage.
Proper preparation helps prevent
deterioration and makes it easier to
get your car back on the road. If
possible, store your car indoors.
If the car is to be stored for a
longer period, it should be
supported on jackstands so the
tires are of f the ground.
Leave one window open slightly (if
the car is being stored indoors).
Disconnect the battery.
Support the f ront wiper blade
arms with a f olded towel or rag so
they do not touch the windshield.
To minimize sticking, apply a
silicone spray lubricant to all door
and trunk seals. Also, apply a
vehiclebodywaxtothepainted
surfaces that mate with the door
and trunk seals.Coverthecarwitha‘‘breathable’’
cover, one made f rom a porous
material such as cotton.
Nonporous materials, such as
plastic sheeting, trap moisture,
which can damage the paint.
If possible, run the engine f or a
while periodically (pref erably once
amonth).
If you store your car f or 12 months
or longer, have your Honda dealer
perf orm the inspections called f or in
the 24 months maintenance schedule
(Normal Conditions) as soon as you
take it out of storage (see page ).
The replacements called f or in the
maintenance schedule are not
needed unless the car has actually
reached that time or mileage.
211
200
St oring Your Car
Maint enance256

ÎÎIn Canada, Honda vehicles comply
with the Canadian Motor Vehicle
Saf ety Standards (CMVSS) f or
Emissions valid at the time they are
manuf actured.
The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page
.
The burning of gasoline in your car’s
engine produces several byproducts.
Some of these are carbon monoxide
(CO), oxides of nitrogen (NOx) and
hydrocarbons (HC). Gasoline
evaporating from the tank also
produces hydrocarbons. Controlling
the production of NOx, CO, and HC
is important to the environment.
Under certain conditions of sunlight
and climate, NOx and HC react to
f orm photochemical ‘‘smog.’’ Carbon
monoxide does not contribute to
smog creation, but it is a poisonous
gas.
Your car has a Positive Crankcase
Ventilation System. This keeps
gasses that build up in the engine’s
crankcase from going into the
atmosphere. The Positive Crankcase
Ventilation valve routes them fromthe crankcase back to the intake
manif old. They are then drawn into
the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The Onboard Ref ueling Vapor
Recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
200
The Clean Air Act
Crankcase Emissions Control
System Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
T echnical Inf ormation
Emissions Cont rols
302

CONT INUED
..................................................
Keys . 77 ........................
Jacking up the Car . 268
.......................................
Jack, Tire . 267
................................
Jump Starting . 274
..................................
Maintenance . 195
...
Owner Maintenance Checks . 207
.................................
Record . 205-206
......................
Required Indicator . 64
..........................................
Saf ety . 196
.............................
Schedule . 198-204
.
Malf unction Indicator Lamp . 63, 281
...................
Manual Transmission . 180
........
Manual Transmission Fluid . 221
...............................
Meters, Gauges . 66
...................
Methanol in Gasoline . 300
..........................
Mirrors, Adjusting . 96
.........................................
Moonroof . 95
......................
Closing Manually . 284 .....................................
Operation . 95
...
Octane Requirement, Gasoline . 164
.........................................
Odometer . 66
...............................
Odometer, Trip . 67
Oil
........................
Change, How to . 211
......................
Change, When to . 200
......................
Checking Engine . 168
..............
Pressure Indicator . 62, 279
Selecting Proper Viscosity
......................................
Chart . 210
...........
ON (Ignition Key Position) . 81
Onboard Ref ueling Vapor
....................................
Recovery . 302 ...................
Neutral Gear Position . 184
..................
New Vehicle Break-in . 164
.....................
Normal Shif t Speeds . 181
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 294
.......................
Label, Certif ication . 294
.................
Lane Change, Signaling . 72
..................
Lap/Shoulder Belts . 16, 45
...........
LATCH Anchorage System . 43
Lights
....................
Bulb Replacement . 247
.......................................
Indicator . 59
.........................................
Parking . 70
..................................
Turn Signal . 72
.....................................
Load Limit . 174
......
LOCK (Ignition Key Position) . 80
Locks
.......
Anti-thef t Steering Column . 80
............................
Fuel Fill Door . 165 .................................
Power Door . 82
...........................................
Trunk . 86
........................
Low Coolant Level . 169
.........................
Low Fuel Indicator . 63
................................
Lower Anchors . 43
...
Lower Gear, Downshif ting to a . 181
...
Low Oil Pressure Indicator . 62, 279
...
Lubricant Specif ications Chart . 296
.........................................
Luggage . 173
Index
LM N O
J K
V

Î
..
Operation in Foreign Countries . 301
..............................
Outside Mirrors . 96
....................
Overheating, Engine . 276
.......
Owner Maintenance Checks . 207
.........................
Oxygenated Fuels . 300
...................
Radiator Overheating . 276
Radio/CD/Cassette
...........
Sound System . 114, 126, 138
...................
Readiness Codes . 282, 305
Rear Lights, Bulb
......................
Replacement . 250, 251
..........................
Rear Seat, Folding . 91
............................
Rear View Mirror . 96
.................
Rear Window Def ogger . 75
...............
Reclining the Seat Backs . 88
.......
Recommended Shif t Speeds . 181
.............................
Reminder Lights . 59
.......................
Remote Transmitter . 83
Replacement Inf ormation
.................
Air Cleaner Element . 225
..............
Dust and Pollen Filter . 235
..........................
Engine Coolant . 215
................
Engine Oil and Filter . 211 ..........................................
Fuses . 286
................................
Light Bulbs . 247
....................................
Schedule . 198
................................
Spark Plugs . 227
................................
Timing Belt . 237
...........................................
Tires . 242
.............................
Wiper Blades . 232
Replacing Seat Belts Af ter a ............................................
Crash . 47
Reserve Tank, Engine ...............................
Coolant . 169, 213
...............................
Restraint, Child . 22
..................
Reverse Gear Position . 184
................................
Rotation, Tire . 241
..................................
Saf ety Belts . 8, 45
.........
Safety Defects, Reporting . 310
.................................
Saf ety Features . 7
.........................................
Airbags . 10
..................................
Door Locks . 11
..........................
Head Restraints . 11
.......................................
Seat Belts . 8
.....................
Seats & Seat-Backs . 11
.............
Saf ety Labels, Location of . 55
..............................
Paint Touch-up . 259
..............
Panel Brightness Control . 71
........................
Park Gear Position . 183
...........................................
Parking . 187
.................................
Parking Brake . 97
Parking Brake and Brake System
.......................................
Indicator . 62
.................................
Parking Lights . 70
..
Parking Over Things that Burn . 304
.............................
PGM-FI System . 303
..................
Polishing and Waxing . 259
............
Pre-Drive Saf ety Checklist . 12
.........
Pregnancy, Using Seat Belts . 20
............................
Protecting Adults . 13
...
Additional Safety Precautions . 20
.....
Advice f or Pregnant Women . 20
........................
Protecting Children . 22
.......................
Protecting Inf ants . 31 .......
Protecting Larger Children . 38
.........
Protecting Small Children . 35
Using Child Seats with
.....................................
Tethers . 42
.............................
Using LATCH . 43
Index
PR
S
VI