maintenance HONDA CIVIC 2005 7.G Owner's Manual

Check the brake f luid level in the
reservoirs monthly.
Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement.
Using any non-Honda brake f luid can
cause corrosion and decrease the lif e
of the system. Have the brake
system f lushed and ref illed with
Honda Heavy Duty Brake Fluid
DOT 3 as soon as possible.The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If the level is at or
below the MIN mark, your brake
system needs attention. Have the
brake system inspected f or leaks or
worn brake pads.The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If it is not, add
brake f luid to bring it up to that level.
Use the same fluid specified for the
brake system.
Low f luid level can indicate a leak in
the clutch system. Have this system
inspected as soon as possible.
Brake f luid marked DOT 5 is not
compatible with your vehicle’s
braking system and can cause
extensive damage.
Replace the brake f luid according to
the time recommendation in the
maintenance schedule.
Manual Transmission only
Brake and Clutch Fluid
Brake System Clutch System
Maint enance
161
MAX
MIN
MAX
MIN
——y
y
(y
y

Check the level on the side of the
reservoir when the engine is cold.
The f luid should be between the
UPPER LEVEL and LOWER LEVEL.
If not add power steering f luid to the
UPPER LEVEL mark.Clean the hood latch assembly with a
mild cleaner, then lubricate it with a
multipurpose grease. Lubricate all
the moving parts (as shown),
including the pivot. Follow the time
and distance recommendations in
the Maintenance Schedule. If you
are not sure how to clean and grease
the latch, contact your dealer.
Always use Honda Power Steering
Fluid. You may use another power
steering f luid as an emergency
replacement, but have the power
steering system f lushed and ref illed
with Honda PSF as soon as possible.
Pour the f luid slowly and caref ully so
you do not spill any. Clean up any
spills immediately; it could damage
components in the engine
compartment. A low power steering f luid level can
indicate a leak in the system. Check
the f luid level f requently, and have
the system inspected as soon as
possible.
Power Steering Fluid, Hood L atch
Power Steering Fluid
Hood L atch
162
UPPER LEVEL
LOWER LEVEL PIVOTS
LATCH
ASSEMBLY
T urning the steering wheel to f ull lef t
or right lock and holding it there can
damage the power steering pump.
——y
y
(y
y

Examine the new wiper blades. If
they have no plastic or metal
reinf orcement along the back
edge, remove the metal
reinf orcement strips f rom the old
wiper blade, and install them in
the slots along the edge of the new
blade.Slide the new wiper blade into the
holder until the tabs lock.
Slide the wiper blade assembly
onto the wiper arm. Make sure it
locks in place.
Lower the wiper arm down against
the windshield.
To saf ely operate your vehicle, your
tires must be the proper type and
size, in good condition with adequate
tread, and correctly inf lated.
The f ollowing pages give more
detailed inf ormation on how to take
care of your tires and what to do
when they need to be replaced.
4. 5. 6. 7.
Wiper Blades, Tires
Tires
Maint enance
171
BLADE
REINFORCEMENT
Using tires that are excessively
worn or improperly inflated can
cause a crash in which you can
be seriously hurt or killed.
Follow all instructions in this
owner’s manual regarding tire
inflation and maintenance.
——y
y
(y
y

Every time you check inf lation, you
should also examine the tires f or
damage, f oreign objects, and wear.
Youshouldlookfor:Bumps or bulges in the tread or
side of the tire. Replace the tire if
youfindeitherof theseconditions.
Cuts, splits, or cracks in the side
of the tire. Replace the tire if you
can see f abric or cord.
Excessive tread wear. Your tires have wear indicators
molded into the tread. When the
tread wears down. You will see a
band 1/2 inch (12.7 mm) wide across
the tread. This shows there is less
than 1/16 inch (1.6 mm) of tread lef t
on the tire. A tire that is this worn
gives very little traction on wet roads.
Youshouldreplacethetireif youcan
see the tread wear indicator in three
or more tread wear indicators. In addition to proper inf lation,
correct wheel alignment helps to
decrease tire wear. If you f ind a tire
is worn unevenly, have your dealer
check the wheel alignment.
Have your dealer check the tires if
you f eel a consistent vibration while
driving. A tire should always be
rebalanced if it is removed f rom the
wheel. When you have new tires
installed, make sure they are
balanced. This increases riding
comf ort and tire lif e. For best results,
have the installer perform a dynamic
balance.
For Vehicles with aluminum wheels:
Tire Inspection
Tire Maintenance
Tires
174
TREAD WEAR INDICATOR
IINNDDIICCAATTOORRLLOOCCAATTIIOONNMMAARRKKSS
Improper wheel weights can damage
your vehicle’s aluminum wheels. Use
only genuine Honda wheel weights f or
balancing.
——y
y
(y
y

µ
Check the condition of the battery
monthlybylookingatthetest
indicator window. The label on the
battery explains the test indicator’s
colors. If additional battery maintenance is
needed, see your dealer or a
qualif ied technician.
Battery posts,
terminals, and related accessories
contain lead and lead compounds.
Check the terminals f or corrosion (a
white or yellowish powder). To
remove it, cover the terminals with a
solution of baking soda and water. It
will bubble up and turn brown. When
this stops, wash it of f with plain
water. Dry off the battery with a
cloth or paper towel. Coat the
terminals with grease to help prevent
f urther corrosion.
If you need to connect the battery to
a charger, disconnect both cables to
prevent damaging your vehicle’s
electrical system. Always disconnect
the negative ( ) cable first, and
reconnect it last.
WARNING:
Wash your hands af ter handling.
Checking the Battery
178
The battery gives off explosive
hydrogen gas during normaloperation.
A spark or flame can cause the
battery to explode with enough
force to kill or seriously hurt you.
Wear protective clothing and a
face shield, or have a skilled
mechanic do the batterymaintenance.
——y

y
(y

y

Fill the f uel tank.
Change the engine oil and f ilter.Block the rear wheels.
If the vehicle is to be stored f or a
longer period, it should be
supported on jackstands so the
tires are of f the ground.
Wash and dry the exterior
completely.
Cleantheinterior.Makesurethe
carpeting, floor mats, etc., are
completely dry.
Leave the parking brake off. Put
the transmission in Reverse
(5-speed manual) or Park
(automatic).
If you need to park your vehicle f or
an extended period (more than one
month), there are several things you
should do to prepare it f or storage.
Proper preparation helps prevent
deterioration and makes it easier to
get your vehicle back on the road. If
possible, store your vehicle indoors. Leave one window open slightly (if
the vehicle is being stored
indoors).Cover the vehicle with a
‘‘breathable’’ cover, one made
f rom a porous material such as
cotton. Non-porous materials, such
as plastic sheeting, trap moisture,
which can damage the paint.
To minimize sticking, apply a
silicone spray lubricant to all door
and trunk seals. Also, apply a
vehiclebodywaxtothepainted
surfaces that mate with the door
and trunk seals.
Support the f ront wiper blade
arms with a f olded towel or rag so
they do not touch the windshield.
Disconnect the battery.
If you store your vehicle f or 12
months or longer, have your dealer
perf orm the inspections called f or in
the 24 months/30,000 miles
(48,000 km) maintenance schedule
(Normal Conditions) as soon as you
take it out of storage (see page ).
The replacements called f or in the
maintenance schedule are not
needed unless the vehicle has
actually reached that time or mileage.If possible, periodically run the
engine until it reaches f ull
operating temperature (the
cooling f an cycles twice).
Pref erably, do this once a month.
149
Vehicle Storage
Maint enance
179
——y
y
(y
y

Î
Î
The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page
. As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The onboard ref ueling vapor
recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
In Canada, Honda vehicles comply
with the Canadian Motor Vehicle
Saf ety Standards (CMVSS) f or
Emissions valid at the time they are
manuf actured.
The burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx) and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons. Con-
trolling the production of NOx, CO,
and HC is important to the environ-
ment. Under certain conditions of
sunlight and climate, NOx and HC
react to f orm photochemical ‘‘smog.’’
Carbon monoxide does not contri-
bute to smog creation, but it is a
poisonous gas.
Your vehicle has a positive
crankcase ventilation system. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The positive
crankcase ventilation valve routesthem from the crankcase back to the
intake manif old. They are then
drawn into the engine and burned.
147
Crankcase Emissions Control
System Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
The Clean Air Act
Emissions Cont rols
T echnical Inf ormation
215
——y
y
(y
y

µµ
µ
( % ) $
%."#)
This manual covers maintenance and recommended
procedures f or repair to engine and chassis components.
It is written f or the journeyman mechanic, but is simple
enough f or most mechanically-inclined owners to under-
stand.
This manual describes the procedures involved in the
replacement of damaged body parts.
This manual complements the service manual by
providing in-depth troubleshooting inf ormation f or each
electrical circuit in your vehicle.
Authorized Manuals
Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
226 NOTE: Dealers and Companies please provide dealer or company name,
and also the name of the person to whose attention the shipment should
be sent. For purchases outside U.S.A. please write to the address shown
below for a quotation.
P.O. BOX 07280·DETROIT, MICHIGAN 48207·1-800-782-4356
Customer Name Attention
Apartment Number
State & Zip Code
City
Daytime Telephone Number
Check or money order enclosed payable to Helm Inc U.S. funds only.
Do not send cash
Master
Card VISA Check here if your billing address is different
from the shipping address shown above.
Account Number Expiration: Mo. Yr.
CUSTOMER SIGNATURE DATE
Street Address No P.O. Box Number
()
These Publications cannot be returned for credit without receiving advance authorization within 14
days of delivery. On returns, a restocking fee may be applied against the original order.
——y
y
(yy

CONT INUED
....................................
Accessories . 127
ACCESSORY (Ignition Key
.......................................
Position) . 71
...............
Accessory Power Socket . 86
....................
Additives, Engine Oil . 155
.............................
Airbag (SRS) . 11, 23
...
Airbags, Additional Information . 23
...
Additional Safety Precautions . 29
.............................
Airbag Service . 28
How the Side Airbag Cutof f
......................
Indicator Works . 28
..
How the SRS Indicator Works . 27
How Your Front Airbags
.........................................
Work . 24
...
How Your Side Airbags Work . 26
........................
SRS Components . 23
................
Air Conditioning System . 88
.......................
Air Pressure, Tires . 173
..................
High Speed Driving . 173
.........................
Normal Driving . 173
.......................
Alcohol in Gasoline . 213
......................................
Antif reeze . 157
Anti-lock Brakes (ABS)
...............................
Indicator . 57, 143 ...................................
Operation . 143
..............
Anti-thef t, Audio System . 114
Anti-thef t Steering Column
..............................................
Lock . 71
..................................
Audio System . 92
...
Automatic Seat Belt Tensioners . 21
.............
Automatic Speed Control . 117
..............
Automatic Transmission . 138
..........................
Capacity, Fluid . 208
...............
Checking Fluid Level . 159
.......................................
Shif ting . 138
.
Shif t Lever Position Indicator . 138
................
Shif t Lever Positions . 138
....................
Shif t Lock Release . 140
Battery Charging System ...........................
Indicator . 56, 194
............................
Jump Starting . 190
..............................
Maintenance . 178
............................
Specif ications . 209
..............................
Bef ore Driving . 121
..................................
Belts, Seat . 10, 20
.............................
Beverage Holder . 86 Brakes
...........
Anti-lock System (ABS) . 143
.............
Break-in, New Linings . 122
....................
Bulb Replacement . 166
...........................................
Fluid . 161
.......................................
Parking . 141
.................
System Indicator . 57, 196
........................
Wear Indicators . 142
.............................
Braking System . 142
.................
Break-in, New Vehicle . 122
..
Brightness Control, Instruments . 66
........................
Brights, Headlights . 65
Bulb Replacement
..........................
Back-up Lights . 167
..............................
Brake Lights . 166
................
Front Parking Lights . 165
........
Front Side Marker Lights . 165
.................................
Headlights . 163
.........
High-mount Brake Light . 168
.........
Rear Side Marker Lights . 166
............................
Specif ications . 209
Bulb Replacement ....................
Turn Signal Lights . 165
..............................
Bulbs, Halogen . 163
Index
A
B
INDEX
I
——y
y
(yy

CONT INUED
Locks.......
Anti-thef t Steering Column . 71
............................
Fuel Fill Door . 123
.................................
Power Door . 72
...........................................
Trunk . 73
........................
Low Coolant Level . 125
.........................
Low Fuel Indicator . 58
................................
Lower Anchors . 38
...
Lower Gear, Downshif ting to a . 136
...
Low Oil Pressure Indicator . 56, 194
...
Lubricant Specif ications Chart . 208
..................................
Maintenance . 145
...
Owner Maintenance Checks . 148
.................................
Record . 151-152
......................
Required Indicator . 60
..........................................
Saf ety . 146
.............................
Schedule . 147-150
.
Malf unction Indicator Lamp . 56, 195
...................
Manual Transmission . 136
........
Manual Transmission Fluid . 160
...............................
Meters, Gauges . 61
...................
Methanol in Gasoline . 213
..........................
Mirrors, Adjusting . 81 .........................................
Moonroof . 81
......................
Closing Manually . 196
.....................................
Operation . 81
...................
Neutral Gear Position . 139
..................
New Vehicle Break-in . 122
.....................
Normal Shif t Speeds . 137
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 206
...
Octane Requirement, Gasoline . 122
.........................................
Odometer . 61
...............................
Odometer, Trip . 61
Oil
........................
Change, How to . 155
......................
Change, When to . 149
......................
Checking Engine . 125
..............
Pressure Indicator . 56, 194
Selecting Proper Viscosity
......................................
Chart . 154
...........
ON (Ignition Key Position) . 71 Onboard Ref ueling Vapor
....................................
Recovery . 215
..
Operation in Foreign Countries . 214
..............................
Outside Mirrors . 82
....................
Overheating, Engine . 191
.......
Owner Maintenance Checks . 148
.........................
Oxygenated Fuels . 213
..............
Panel Brightness Control . 66
........................
Park Gear Position . 139
...........................................
Parking . 141
.................................
Parking Brake . 83
Parking Brake and Brake
.................
System Indicator . 57, 196
.................................
Parking Lights . 65
..
Parking Over Things that Burn . 217
............................
Playing the Radio . 92
..................................
Playing a Disc . 99
.............................
PGM-FI System . 216
.........
Pregnancy, Using Seat Belts . 18
Index
M N O
P
INDEX
V
——y

y
(yy