air condition HONDA CIVIC COUPE 2002 7.G Owner's Manual

Every time you check inf lation, you
should also examine the tires f or
damage, f oreign objects, and wear.
Youshouldlookfor:Bumps or bulges in the tread or
side of the tire. Replace the tire if
youfindeitherof theseconditions.
Excessive tread wear. In addition to proper inf lation,
correct wheel alignment helps to
decrease tire wear. If you f ind a tire
is worn unevenly, have your dealer
check the wheel alignment.
Cuts, splits, or cracks in the side
of the tire. Replace the tire if you
can see f abric or cord. The tires were properly balanced by
the factory. They may need to be
rebalanced at some time bef ore they
are worn out. Have your dealer
check the tires if you f eel a consis-
tent vibration while driving. A tire
should always be rebalanced if it is
removed f rom the wheel f or repair.
Your car’s tires have wear indicators
molded into the tread. When the
tread wears down to that point, you
will see a 1/2 inch (12.7 mm) wide
band running across the tread. This
shows there is less than 1/16 inch
(1.6 mm) of tread lef t on the tire. A
tire that is this worn gives very little
traction on wet roads. You should
replace the tire if you can see the
tread wear indicator in three or more
places around the tire.
Inspection
Maintenance
Tires
Maint enance240
IINNDDIICCAATTOORRLLOOCCAATTIIOONNMMAARRKKSS
TTRREEAADDWWEEAARRIINNDDIICCAATTOORR

ÎÎ
ÎÎSlow down by shif ting to a lower
gear, and pull to the side of the road
when it is saf e. Because of the
longer distance needed to stop, it is
hazardous to drive the car. You
should have it towed, and repaired as
soon as possible. (Seeon page .)
If you must drive the car a short
distance in this condition, drive
slowly and cautiously.
If it comes on at any other time, it
indicates a problem with the car’s
brake system. In most cases, the
problem is a low f luid level in the
brake f luid reservoir. Press lightly on
the brake pedal to see if it f eels
normal. If it does, check the brake
f luid level the next time you stop at a
service station (see page ). If the
fluid level is low, take the car to your
dealer and have the brake system
inspected f or leaks or worn brake
pads.
However, if the brake pedal does not
f eel normal, you should take
immediate action. Because of the
brake system’s dual-circuit design, a
problem in one part of the system
will still give you braking at two
wheels. You will f eel the brake pedal
go down much f arther bef ore the car
begins to slow down, and you will
have to press harder on the pedal.
The distance needed to stop will be
much longer.
The Brake System Indicator
normallycomesonwhenyouturn
the ignition switch ON (II). It is a
reminder to check the parking brake.
It comes on and stays lit if you do not
f ully release the parking brake.
223
289Emergency
Towing
Brake System Indicator
T aking Care of t he Unexpect ed282
UU..SS..iinnddiiccaattoorrsshhoowwnn
BBRRAAKKEESSYYSSTTEEMMIINNDDIICCAATTOORR

µµµ
µµ
Î Î µµ µ µµ µ µµµµµµµµ µ
Î ÎÎ
Î
Î Î ÎÎ
ÎÎ
Specif ications
T echnical Inf ormation295
Battery Fuses
Tires
Alignment
Air Conditioning
Lights
HFC-134a (R-134a)
17.6 19.4 oz (500 550 g)
SP-10
12 V
12 V 60/55 W (HB2)
21/5 W
60 psi (420 kPa , 4.2 kgf/cm
)
12 V 5 W
12 V 8 W
12 V 5 W
12 V 5 W
12 V 8 W
12 V 5 W
12 V 21 W
12 V 3 CP
12 V 21 W
12 V 21/5 W
12 V 21 W
12 V 3 CP
12 V 36 AH/5 HR
Capacity Interior
Under-hood Size
Pressure
Toe-in
Camber
Caster
1°33’45’
0°
0.00 in (0.0 mm)
30 psi (210 kPa , 2.1 kgf/cm)
T115/70D14 88M
P185/65R15 86HP185/70R14 87S
Refrigerant type
Charge quantity
Lubricant oil type
See page 285 or the fuse label
attached to the inside of the fuse
box door under the steering
column.
See page 284 or the fuse box
cover.
0.08 in ( 2.0 mm)
T125/70D15 95M
Headlights (HI/LO)
Front turn signal/side marker
lights
Front parking light
Rear turn signal lights
Stop/Taillights/Rear side
marker lights
Back-up lights
Taillights
High-mount stop light
License plate lights
Ceiling light
Front ceiling light
Spotlights
Trunk light
Front Rear
FrontRear
Front
1: EX
2: LX Front/Rear
Spare
Front/Rear
Spare
1: 2:3: U.S.: DX, HX and LX
Canada: DX
U.S.: EX
Canada: LX, Si
U.S.: EX
Canada: Si
1
12 12
13

ÎÎIn Canada, Honda vehicles comply
with the Canadian Motor Vehicle
Saf ety Standards (CMVSS) f or
Emissions valid at the time they are
manuf actured.
The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page
.
The burning of gasoline in your car’s
engine produces several byproducts.
Some of these are carbon monoxide
(CO), oxides of nitrogen (NOx) and
hydrocarbons (HC). Gasoline
evaporating from the tank also
produces hydrocarbons. Controlling
the production of NOx, CO, and HC
is important to the environment.
Under certain conditions of sunlight
and climate, NOx and HC react to
f orm photochemical ‘‘smog.’’ Carbon
monoxide does not contribute to
smog creation, but it is a poisonous
gas.
Your car has a Positive Crankcase
Ventilation System. This keeps
gasses that build up in the engine’s
crankcase from going into the
atmosphere. The Positive Crankcase
Ventilation valve routes them fromthe crankcase back to the intake
manif old. They are then drawn into
the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
194
The Clean Air Act
Crankcase Emissions Control
System Evaporative Emissions Control
System
Emissions Cont rols
T echnical Inf ormation300

The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), dinitrogen
(N ), and water vapor.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO and NOx produced.
The PGM-FI System uses sequential
multiport f uel injection.
It has three subsystems: Air Intake,
Engine Control, and Fuel Control.
The Engine Control Module (ECM)
or the Powertrain Control Module
(PCM) uses various sensors to
determine how much air is going
into the engine. It then controls how
much f uel to inject under all operat-
ing conditions.
The emissions control systems are
covered by warranties separate f rom
the rest of your car. Read your
warranty manual f or more inf orma-
tion.
The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Genuine Honda replacement parts or
their equivalent f or repairs. Using
lowerqualitypartsmayincreasethe
emissions f rom your car.
The Onboard Ref ueling Vapor
Recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
The exhaust emissions controls
include three systems: PGM-FI,
Ignition Timing Control and Three
Way Catalytic Converter. These
three systems work together to
control the engine’s combustion and
minimize the amount of HC, CO, and
NOx that comes out the tailpipe. The
exhaust emissions control systems
are separate from the crankcase and
evaporative emissions control
systems.
2
2
Replacement Parts
Onboard Ref ueling Vapor
Recovery
Exhaust Emissions ControlsPGM-FI Syst em
Three Way Catalytic Converter
Ignit ion T iming Cont rol Syst em
Emissions Cont rols
T echnical Inf ormation301

CONT INUED
...
Accessories and Modif ications . 169
................................
Accessories . 169
...
Additional Safety Precaution . 170
............................
Modif ications . 170
ACCESSORY (Ignition Key .......................................
Position) . 79
...............
Accessory Power Socket . 99
....................
Additives, Engine Oil . 209
.............................
Airbag (SRS) . 10, 48
.....................
Air Cleaner Element . 225
..............
Air Conditioning System . 104
......................
Maintenance . 234, 235
.........................................
Usage . 104
.......................
Air Outlets (Vents) . 106
.......................
Air Pressure, Tires . 238
.........................
Normal Driving . 239
.......................
Alcohol in Gasoline . 298
......................................
Antif reeze . 213
Anti-lock Brakes (ABS)
....................
Indicator Light . 62, 192
...................................
Operation . 190
Anti-thef t Steering Column ..............................................
Lock . 79
..........................
Appearance Care . 255 ................
Audio System . 112, 124, 136
.............
Automatic Speed Control . 156
..............
Automatic Transmission . 180
..........................
Capacity, Fluid . 294
...............
Checking Fluid Level . 220
.......................................
Shif ting . 181
.
Shif t Lever Position Indicator . 180
................
Shif t Lever Positions . 181
....................
Shif t Lock Release . 184
Battery Charging System ...........................
Indicator . 62, 278
............................
Jump Starting . 273
..............................
Maintenance . 230
............................
Specif ications . 294
..............................
Bef ore Driving . 161
....................................
Belts,Seat .8,44
.............................
Beverage Holder . 98
.................................
Body Repairs . 262
Brakes
...........
Anti-lock System (ABS) . 190
.............
Break-in, New Linings . 162
............
Bulb Replacement . 250, 251 ...........................................
Fluid . 223
.........................................
Parking . 96
.................
System Indicator . 62, 282
........................
Wear Indicators . 189
.............................
Braking System . 189
........................
Break-in, New Car . 162
..
Brightness Control, Instruments . 71
........................
Brights, Headlights . 70
Bulb Replacement
..........................
Back-up Lights . 251
..............................
Brake Lights . 250
..............................
Ceiling Light . 253
................
Front Parking Lights . 248
........
Front Side Marker Lights . 248
.................................
Headlights . 247
.........
High-mount Brake Light . 251
.................
License Plate Lights . 251
.........
Rear Side Marker Lights . 250
............................
Specif ications . 294
...................................
Spotlights . 253
...............................
Trunk Light . 252
....................
Turn Signal Lights . 248
..............................
Bulbs, Halogen . 247
Index
A
B
I

CONT INUED
...........................................
Driving . 175
....................................
Economy . 168
.........................
In Bad Weather . 193
................
In Foreign Countries . 299
..............................
Economy, Fuel . 168
............
Emergencies on the Road . 289
.............
Battery, Jump Starting . 273
...........
Brake System Indicator . 282
................
Changing a Flat Tire . 265
.....
Charging System Indicator . 279
..................
Checking the Fuses . 285
.....
Low Oil Pressure Indicator . 278
...
Malf unction Indicator Lamp . 280
...
Manually Closing Moonroof . 282
..................
Overheated Engine . 275
...........................
Emergency Brake . 96
......................
Emergency Flashers . 74
......................
Emergency Towing . 289
............
Emergency Trunk Opener . 88
.......................
Emissions Controls . 300 Engine
....
Coolant Temperature Gauge . 68
.................................
Drive Belts . 237 Malf unction Indicator
................................
Lamp . 63, 280
........
Oil Pressure Indicator . 62, 278
..............
Oil, What Kind to Use . 209
...............................
Overheating . 275
............................
Specif ications . 294
.......................................
Starting . 177
......
Engine Speed Limiter . 179, 183
......................
Ethanol in Gasoline . 298
.
Evaporative Emissions Controls . 300
...............................
Exhaust Fumes . 54
Expectant Mothers, Use of Seat
........................................
Belts by . 19
..................
Exterior, Cleaning the . 256
............................
Fabric, Cleaning . 259
...................................
Fan, Interior . 108
Features, Comfort and
..............................
Convenience . 103
....................
Filling the Fuel Tank . 163
Filters
................................
Air Cleaner . 225
.......................
Air Conditioning . 235
...............................................
Oil . 211 5-speed Manual Transmission
...............
Checking Fluid Level . 222
................................
Shif ting the . 178
.............
Flashers, Hazard Warning . 74
...................
Flat Tire, Changing a . 265
Fluids
..........
Automatic Transmission . 220
..........................................
Brake . 223
.........................................
Clutch . 223
..............
Manual Transmission . 222
..........................
Power Steering . 224
..................
Windshield Washer . 219
FM Stereo Radio ...................................
Reception . 143
...........................
Folding Rear Seat . 90
.....
Foreign Countries, Driving in . 299
..........................
Four-way Flashers . 74
.................................................
Fuel . 162
....................................
Economy . 168
......................
Fill Door and Cap . 163
...........................................
Gauge . 67
................
Octane Requirement . 162
...............................
Oxygenated . 298
........................
Reserve Indicator . 63
........................
Tank, Filling the . 163
Index
E
F
III