HONDA CIVIC COUPE 2002 7.G Owners Manual

The three way catalytic converter
contains precious metals that serve
as catalysts, promoting chemical
reactions to convert the exhaust
gasses without af f ecting the metals.
The catalytic converter is ref erred to
as a three-way catalyst, since it acts
on HC, CO, and NOx. A replacement
unit must be an original Honda part
or its equivalent.Always use unleaded gasoline.
Even a small amount of leaded
gasoline can contaminate the
catalyst metals, making the three
way catalytic converter inef f ective.
The three way catalytic converter
must operate at a high temperature
for the chemical reactions to take
place. It can set on f ire any com-
bustible materials that come near it.
Park your car away f rom high grass,
dry leaves, or other f lammables.
A defective three way catalytic
converter contributes to air pollution,
and can impair your engine’s per-
f ormance. Follow these guidelines to
protect your car’s three way catalytic
converter. Keep the engine tuned-up.
Have your car diagnosed and
repaired if it is misf iring, back-
f iring, stalling, or otherwise not
running properly.
(EX) (DX, LX, HX)
Three Way Catalytic Converter
T echnical Inf ormation302
TTHHRREEEEWWAAYYCCAATTAALLYYTTIICCCCOONNVVEERRTTEERRTTHHRREEEEWWAAYYCCAATTAALLYYTTIICCCCOONNVVEERRTTEERR

CONT INUED
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle re-tested within the
next two or three days, you can
condition the vehicle for re-testing
by doing the f ollowing.Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the vehicle has been
parked with the engine of f f or 8
hours or more.
Make sure the ambient
temperature is between 20° and
95°F. Without touching the accelerator
pedal, start the engine and let it
idle f or 20 seconds.
Keep the vehicle in Park
(automatic transmission) or
Neutral (manual transmission).
Increase the engine speed to 2,000
rpm and hold it there until the
temperature gauge rises to at least
1/4of thescale(approximately3
minutes).
If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.
T echnical Inf ormation
St at e Emissions T est ing
T esting of Readiness Codes
303

Then drive in city/suburban
traffic for at least 10 minutes.
When traf f ic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
If the testing f acility determines the
readiness codes are still not set, see
your Honda dealer.
Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D (A/T) or 5th (M/T). Do not use
thecruisecontrol.Whentraffic
allows, drive f or 90 seconds
without moving the accelerator
pedal. (Vehicle speed may vary
slightly; this is okay.) If you cannot
do this f or a continuous 90
seconds because of traf f ic
conditions, drive f or at least 30
seconds, then repeat it two more
times (for a total of 90 seconds).
T echnical Inf ormation
St at e Emissions T est ing
304

Customer Relations................................
Inf ormation . 306
....................
Warranty Coverages . 309
Reporting Saf ety Def ects
..........................
(U.S. Vehicles) . 310
.....................
Authorized Manuals . 311
Warranty and Customer Relations
Warrant y and Cust omer Relat ions305

Honda dealership personnel are
trained prof essionals. They should
be able to answer all your questions.
If you encounter a problem that your
dealership does not solve to your
satisf action, please discuss it with
the dealership’s management. The
Service Manager or General
Manager can help. Almost all
problems are solved in this way.
If you are dissatisf ied with the
decision made by the dealership’s
management, contact your Honda
Customer Relations Of f ice.U.S. Owners:
Canadian Owners:
In Puerto Rico and the U.S. Virgin
Islands:
When you call or write, please give
us this inf ormation:
Vehicle Identif ication Number
(see page )
Name and address of the dealer
who services your car
Date of purchase
Mileage on your car
Your name, address, and tele-
phone number
A detailed description of the
problem
Name of the dealer who sold the
car to you 292
Cust omer Relat ions Inf ormat ion
Warrant y and Cust omer Relat ions306
CUSTOMER RELATIONS
RELATIONS AVEC LA CLIENTÉLE
Acura Client Services
Department
1919 Torrance Blvd
Torrance, CA 90501-2746
or telephone: ( 800) 382-2238
Honda Canada Inc.
715 Milner Avenue
Toronto, ON
M1B 2K8
Tel: 1-888-9-HONDA-9
Fax: Toll-free 1-877-939-0909 Toronto (416) 287-4776 Bella International
P.O. Box 190816
San Juan, Puerto Rico 00919-0816
(787) 250-4318

µ
µ
µ
µµ
µ
µ µ
µ
Your new Honda is covered by these
warranties:
provides prorated
coverage f or a replacement battery
purchased f rom a Honda dealer.
a seat
belt that f ails to f unction properly is
coveredfortheusefullifeof the
vehicle.
covers all genuine
Honda replacement parts against
defects in materials and workman-
ship. all exterior body panels are
covered f or rust-through f rom the
inside f or the specif ied time period
with no mileage limit. provides
coverageforaslongasthepur-
chaser of the muf f ler owns the car.
covers your new vehicle, except f or
the battery, emissions control
systems and accessories, against
def ects in materials and
workmanship.
this warranty gives up
to 100 percent credit toward a
replacement battery. these two
warranties cover your vehicle’s emis-
sions control systems. Time, mileage,
and coverage are conditional. Please
read the warranty manual for exact
inf ormation. Restrictions and exclusions apply to
all these warranties. Please read the
2002 Honda Warranty Inf ormation
booklet that came with your car f or
precise inf ormation on warranty
coverages. Your Honda’s original
tires are covered by their
manuf acturer. Tire warranty inf or-
mation is in a separate booklet.
Please ref er to the 2002 Warranty
Manual that came with your car.
Honda Accessories are covered
under this warranty. Time and
mileage limits depend on the type of
accessory and other f actors. Please
read your warranty manual f or
details.
Replacement Bat t ery L imit ed
Warranty
Seat Belt Limited Warranty
Replacement Part s L imit edWarranty
Rust Perf orat ion L imit ed Warrant y Replacement Muf f ler L if et ime
Limited Warranty
New Vehicle L imit ed Warrant y
Original Equipment Bat t ery L imit edWarranty
Emissions Cont rol Syst ems Def ect s
Warrant y and Emissions
Perf ormance Warranty Accessory Limited WarrantyU.S. Owners
Canadian Owners
Warranty Coverages
Warrant y and Cust omer Relat ions307

To contact NHTSA, you may either
call the Auto Saf ety Hotline toll-f ree
at 1-800-424-9393 (or 366-0123 in
Washington D.C. area) or write to:
NHTSA, U.S. Department of
Transportation, Washington,
D.C. 20590. You can also obtain
other inf ormation about motor
vehicle safety from the Hotline.
If you believe that your vehicle has a
def ect which could cause a crash or
could cause injury or death, you
should immediately inf orm the
National Highway Traf f ic Saf ety
Administration (NHTSA) in addition
to notifying American Honda Motor
Co., Inc.
If NHTSA receives similar com-
plaints, it may open an investigation,
and if it f inds that a saf ety def ect
exists in a group of vehicles, it may
order a recall and remedy campaign.
However, NHTSA cannot become
involved in individual problems
between you, your dealer, or
American Honda Motor Co., Inc.
Reporting Saf ety Def ects (U.S. Vehicles)
Warrant y and Cust omer Relat ions308

µ
Î
Î Î
Î   $#
The f ollowing publications covering the operation and
servicing of your vehicle can be obtained f rom Helm
Incorporated, either by f illing out the attached f orm or,
f or credit card holders, calling the toll-f ree phone number
on the f orm. For manuals prior to the year shown below,
contact Helm Incorporated, P.O. Box 07280, Detroit,
Michigan 48207, or call 1-800-782-4356.
Valid only f or sales within the U.S. Canadian owners should
contact their authorized Honda dealer.
Authorized Manuals
Purchasing Factory Authorized Manuals
(U.S. only)
309
ORDER TOLL FREE: 1-800-782-4356
OR
(NOTE: For Credit Card Holder Orders Only)
MINIMUM CREDIT CARD PURCHASE $10.00
Publication
Form Number 61S5A03 61S5A05
61S5A03EL
61S5A30
31S5P610 HON-R Price
Each
$68.00$33.00$48.00$42.00$32.00
FREE
Form Description
2001-2002 Honda Civic 4 Door Service Manual Base Book
2001-2002 Honda Civic 2 Door Service Manual Supplement
2001-2002 Honda Civic 2/4 Door
Electrical Troubleshooting Manual 2001-2002 Honda Civic 2/4 Door Body Repair Manual
2002 Honda Civic 2 Door Owner’s Manual
Order Form for Previous Years-
Indicate Year and Model Desired
PUBLICATION NUMBER VEHICLE MODEL
Name Year Qty
Price
Each Total
Price
GRAND TOTAL
HANDLING CHARGE
Mich. Purchases
Add 6% Sales Tax
TOTAL MATERIAL
$6.00
Monday-Friday 8:00 A.M. 6:00 P.M. EST
By completing this form you can order the materials desired. You can
pay by check or money order, or charge to your credit card. Mail to
Helm Incorporated at the address shown on the back of the order form.
Prices are subject to change without
notice and without incurring obligation.
Orders are mailed within 10 days. Please
allow adequate time for delivery.
Prices are subject to change without notice and without incurring
obligation.

µµ
µ
( % ) $
%."#)
This manual describes the procedures involved in the
replacement of damaged body parts.
This manual covers maintenance and recommended
procedures f or repair to engine and chassis components.
It is written f or the Journeyman mechanic, but is simple
enough f or most mechanically-inclined owners to under-
stand.
This manual complements the Service Manual by
providing in-depth troubleshooting inf ormation f or each
electrical circuit in your vehicle.
Authorized Manuals
Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
310 NOTE: Dealers and Companies please provide dealer or company name,
and also the name of the person to whose attention the shipment should
be sent. For purchases outside U.S.A. please write to the address shown
below for a quotation.
P.O. BOX 07280·DETROIT, MICHIGAN 48207·1-800-782-4356
Customer Name Attention
Apartment Number
State & Zip Code
City
Daytime Telephone Number
Check or money order enclosed payable to Helm Inc U.S. funds only.
Do not send cash
Master
Card VISA Check here if your billing address is different
from the shipping address shown above.
Account Number Expiration: Mo. Yr.
CUSTOMER SIGNATURE DATE
Street Address No P.O. Box Number
()
These Publications cannot be returned for credit without receiving advance authorization within 14
days of delivery. On returns, a restocking fee may be applied against the original order.

CONT INUED
...
Accessories and Modif ications . 169
................................
Accessories . 169
...
Additional Safety Precaution . 170
............................
Modif ications . 170
ACCESSORY (Ignition Key .......................................
Position) . 79
...............
Accessory Power Socket . 99
....................
Additives, Engine Oil . 209
.............................
Airbag (SRS) . 10, 48
.....................
Air Cleaner Element . 225
..............
Air Conditioning System . 104
......................
Maintenance . 234, 235
.........................................
Usage . 104
.......................
Air Outlets (Vents) . 106
.......................
Air Pressure, Tires . 238
.........................
Normal Driving . 239
.......................
Alcohol in Gasoline . 298
......................................
Antif reeze . 213
Anti-lock Brakes (ABS)
....................
Indicator Light . 62, 192
...................................
Operation . 190
Anti-thef t Steering Column ..............................................
Lock . 79
..........................
Appearance Care . 255 ................
Audio System . 112, 124, 136
.............
Automatic Speed Control . 156
..............
Automatic Transmission . 180
..........................
Capacity, Fluid . 294
...............
Checking Fluid Level . 220
.......................................
Shif ting . 181
.
Shif t Lever Position Indicator . 180
................
Shif t Lever Positions . 181
....................
Shif t Lock Release . 184
Battery Charging System ...........................
Indicator . 62, 278
............................
Jump Starting . 273
..............................
Maintenance . 230
............................
Specif ications . 294
..............................
Bef ore Driving . 161
....................................
Belts,Seat .8,44
.............................
Beverage Holder . 98
.................................
Body Repairs . 262
Brakes
...........
Anti-lock System (ABS) . 190
.............
Break-in, New Linings . 162
............
Bulb Replacement . 250, 251 ...........................................
Fluid . 223
.........................................
Parking . 96
.................
System Indicator . 62, 282
........................
Wear Indicators . 189
.............................
Braking System . 189
........................
Break-in, New Car . 162
..
Brightness Control, Instruments . 71
........................
Brights, Headlights . 70
Bulb Replacement
..........................
Back-up Lights . 251
..............................
Brake Lights . 250
..............................
Ceiling Light . 253
................
Front Parking Lights . 248
........
Front Side Marker Lights . 248
.................................
Headlights . 247
.........
High-mount Brake Light . 251
.................
License Plate Lights . 251
.........
Rear Side Marker Lights . 250
............................
Specif ications . 294
...................................
Spotlights . 253
...............................
Trunk Light . 252
....................
Turn Signal Lights . 248
..............................
Bulbs, Halogen . 247
Index
A
B
I