engine HONDA CIVIC COUPE 2003 7.G Manual Online

The three way catalytic converter
contains precious metals that serve
as catalysts, promoting chemical
reactions to convert the exhaust
gasses without af f ecting the metals.
The catalytic converter is ref erred to
as a three-way catalyst, since it acts
on HC, CO, and NOx. A replacement
unit must be an original Honda part
or its equivalent.Always use unleaded gasoline.
Even a small amount of leaded
gasoline can contaminate the
catalyst metals, making the three
way catalytic converter inef f ective.
The three way catalytic converter
must operate at a high temperature
for the chemical reactions to take
place. It can set on f ire any com-
bustible materials that come near it.
Park your car away f rom high grass,
dry leaves, or other f lammables.
A defective three way catalytic
converter contributes to air pollution,
and can impair your engine’s per-
f ormance. Follow these guidelines to
protect your car’s three way catalytic
converter. Keep the engine tuned-up.
Have your car diagnosed and
repaired if it is misf iring, back-
f iring, stalling, or otherwise not
running properly.
(DX, LX and U.S. HX models)
(U.S. EX and Canadian Si models)
Three Way Catalytic Converter
T echnical Inf ormation296
THREE WAY CATALYTIC CONVERTER THREE WAY CATALYTIC CONVERTER
——y
y
(%yy

CONT INUED
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle re-tested within the
next two or three days, you can
condition the vehicle for re-testing
by doing the f ollowing.Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the vehicle has been
parked with the engine of f f or 8
hours or more.
Make sure the ambient
temperature is between 20° and
95°F. Without touching the accelerator
pedal, start the engine and let it
idle f or 20 seconds.
Keep the vehicle in Park
(automatic transmission) or
Neutral (manual transmission).
Increase the engine speed to 2,000
rpm and hold it there until the
temperature gauge rises to at least
1/4of thescale(approximately3
minutes).
If you take your car for a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.
T echnical Inf ormation
St at e Emissions T est ing
T esting of Readiness Codes
297
——y

y
(%yy

µµ
µ
( % ) $
%."#)
This manual describes the procedures involved in the
replacement of damaged body parts.
This manual covers maintenance and recommended
procedures f or repair to engine and chassis components.
It is written f or the Journeyman mechanic, but is simple
enough f or most mechanically-inclined owners to under-
stand.
This manual complements the Service Manual by
providing in-depth troubleshooting inf ormation f or each
electrical circuit in your vehicle.
Authorized Manuals
Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
304 NOTE: Dealers and Companies please provide dealer or company name,
and also the name of the person to whose attention the shipment should
be sent. For purchases outside U.S.A. please write to the address shown
below for a quotation.
P.O. BOX 07280·DETROIT, MICHIGAN 48207·1-800-782-4356
Customer Name Attention
Apartment Number
State & Zip Code
City
Daytime Telephone Number
Check or money order enclosed payable to Helm Inc U.S. funds only.
Do not send cash
Master
Card VISA Check here if your billing address is different
from the shipping address shown above.
Account Number Expiration: Mo. Yr.
CUSTOMER SIGNATURE DATE
Street Address No P.O. Box Number
()
These Publications cannot be returned for credit without receiving advance authorization within 14
days of delivery. On returns, a restocking fee may be applied against the original order.
——y

y
(%yy

CONT INUED
...
Accessories and Modif ications . 163
................................
Accessories . 163
.
Additional Safety Precautions . 164
............................
Modif ications . 164
ACCESSORY (Ignition Key .......................................
Position) . 83
.............
Accessory Power Socket . 104
....................
Additives, Engine Oil . 203
.............................
Airbag (SRS) . 10, 49
.....................
Air Cleaner Element . 219
..............
Air Conditioning System . 110
..............................
Maintenance . 228
.........................................
Usage . 110
.......................
Air Outlets (Vents) . 112
.......................
Air Pressure, Tires . 232
.........................
Normal Driving . 233
.......................
Alcohol in Gasoline . 292
......................................
Antif reeze . 207
Anti-lock Brakes (ABS)
....................
Indicator Light . 65, 186
...................................
Operation . 184
Anti-thef t Steering Column ..............................................
Lock . 82
..........................
Appearance Care . 249 ........................
Audio System . 118, 130
.............
Automatic Speed Control . 151
..............
Automatic Transmission . 174
..........................
Capacity, Fluid . 288
...............
Checking Fluid Level . 214
.......................................
Shif ting . 175
.
Shif t Lever Position Indicator . 174
................
Shif t Lever Positions . 175
....................
Shif t Lock Release . 178
Battery Charging System ...........................
Indicator . 64, 273
............................
Jump Starting . 267
..............................
Maintenance . 224
............................
Specif ications . 289
..............................
Bef ore Driving . 155
....................................
Belts,Seat .8,45
.........................
Beverage Holders . 102
.................................
Body Repairs . 256
Brakes
...........
Anti-lock System (ABS) . 184
.............
Break-in, New Linings . 156
....................
Bulb Replacement . 244 ...........................................
Fluid . 217
.......................................
Parking . 100
.................
System Indicator . 65, 275
........................
Wear Indicators . 183
.............................
Braking System . 183
........................
Break-in, New Car . 156
..
Brightness Control, Instruments . 74
........................
Brights, Headlights . 73
Bulb Replacement
..........................
Back-up Lights . 244
..............................
Brake Lights . 244
..............................
Ceiling Light . 247
................
Front Parking Lights . 242
........
Front Side Marker Lights . 242
.................................
Headlights . 241
.........
High-mount Brake Light . 245
.................
License Plate Lights . 245
.........
Rear Side Marker Lights . 244
............................
Specif ications . 289
...................................
Spotlights . 247
...............................
Trunk Light . 246
....................
Turn Signal Lights . 242
..............................
Bulbs, Halogen . 241
Index
A
B
I
——y

y
(%yy

Î
................
DANGER, Explanation of . ii
...................................
Dashboard . 2, 60
................
Daytime Running Lights . 74
............
Def ects, Reporting Saf ety . 302
........................
Def og and Def rost . 115
................
Def ogger, Rear Window . 78
..............
Def rosting the Windows . 115
....................................
Dimensions . 288
...............
Dimming the Headlights . 73
Dipstick
..........
Automatic Transmission . 214
..................................
Engine Oil . 160
..........................
Directional Signals . 75
........
Disc Brake Wear Indicators . 183
.....................
Disposal of Used Oil . 206
Doors
..............
Locking and Unlocking . 84
......................
Power Door Locks . 84
..........
DOT Tire Quality Grading . 290
Downshif ting, 5-speed Manual
.............................
Transmission . 172
.....................................
Drive Belts . 231
...........
Driver and Passenger Safety . 5
............................
Capacities Chart . 288
.............
Carbon Monoxide Hazard . 55
.................................
Cargo Hooks . 168
.............................
Carrying Cargo . 165
Cassette Player
............................................
Care . 148
...........................
Operation . 124, 145
..............
CAUTION, Explanation of . ii
..........................
CD Changer . 127, 141
..............................
CD Player . 127, 139
..................................
Ceiling Light . 105
........................
Certif ication Label . 286
............................................
Chains . 238
....................
Changing a Flat Tire . 259
............
Changing Engine Coolant . 209
Changing Oil
........................................
How to . 205
......................................
When to . 192
...
Charging System Indicator . 64, 273
............
Checklist, Bef ore Driving . 170
.....................................
Child Saf ety . 21
Child Seats
...........................
Lower Anchors . 42
..........
Tether Anchorage Points . 41 ....................
Cleaner Element, Air . 219
Cleaning
......................................
Exterior . 250
.......................................
Interior . 252
...................................
Seat Belts . 253
...........................................
Vinyl . 253
....................................
Windows . 254
.................
Clock, Setting the . 123, 135
...................................
Clutch Fluid . 217
........................
CO in the Exhaust . 294
......................................
Coat Hook . 105
............
Cold Weather, Starting in . 171
..............................
Compact Spare . 258
...............
Consumer Inf ormation . 300
.............
Controls, Instruments and . 59
Coolant
........................................
Adding . 207
....................................
Checking . 161
.........................
Proper Solution . 207
...................................
Replacing . 209
...................
Temperature Gauge . 71
....................
Corrosion Protection . 255
Crankcase Emissions Control
........................................
System . 294
............
Cruise Control Operation . 151
..........
Customer Relations Of f ice . 300
Index
C D
II
——y
y
(%yy

CONT INUED
...........................................
Driving . 169
....................................
Economy . 162
.........................
In Bad Weather . 187
................
In Foreign Countries . 293
............................
Fabric, Cleaning . 253
...................................
Fan, Interior . 110
Features, Comfort and
..............................
Convenience . 109
....................
Filling the Fuel Tank . 157
Filters
................................
Air Cleaner . 219
.........................
Dust and Pollen . 229
...............................................
Oil . 205 5-speed Manual Transmission
...............
Checking Fluid Level . 216
................................
Shif ting the . 172
.............
Flashers, Hazard Warning . 78
...................
Flat Tire, Changing a . 259
Fluids
..........
Automatic Transmission . 214
..........................................
Brake . 217
.........................................
Clutch . 217
..............
Manual Transmission . 216
..........................
Power Steering . 218
..................
Windshield Washer . 213
FM Stereo Radio ...................................
Reception . 137
...........................
Folding Rear Seat . 94
.....
Foreign Countries, Driving in . 293
..........................
Four-way Flashers . 78
.................................................
Fuel . 156
....................................
Economy . 162
......................
Fill Door and Cap . 157
...........................................
Gauge . 70
................
Octane Requirement . 156
...............................
Oxygenated . 292
........................
Reserve Indicator . 66
........................
Tank, Filling the . 157
..............................
Economy, Fuel . 162
............
Emergencies on the Road . 283
.............
Battery, Jump Starting . 267
...........
Brake System Indicator . 275
................
Changing a Flat Tire . 259
.....
Charging System Indicator . 273
..................
Checking the Fuses . 279
.....
Low Oil Pressure Indicator . 272
...
Malf unction Indicator Lamp . 274
...
Manually Closing Moonroof . 277
..................
Overheated Engine . 269
.........................
Emergency Brake . 100
......................
Emergency Flashers . 78
......................
Emergency Towing . 283
............
Emergency Trunk Opener . 89
.......................
Emissions Controls . 294Engine
....
Coolant Temperature Gauge . 71
.................................
Drive Belts . 231 Malf unction Indicator
................................
Lamp . 66, 274
........
Oil Pressure Indicator . 64, 272
..............
Oil, What Kind to Use . 203
...............................
Overheating . 269
............................
Specif ications . 288
.......................................
Starting . 171
......
Engine Speed Limiter . 173, 177
......................
Ethanol in Gasoline . 292
.
Evaporative Emissions Controls . 294
...............................
Exhaust Fumes . 55
Expectant Mothers, Use of Seat
........................................
Belts by . 19
..................
Exterior, Cleaning the . 250
Index
E
F
III
——y

y
(%y
y

.....................
Fuses, Checking the . 279
........................
Jacking up the Car . 259
.......................................
Jack, Tire . 259
................................
Jump Starting . 267
...............
Gas Mileage, Improving . 162
..........................................
Gasohol . 292
.........................................
Gasoline . 156
...............
Fuel Reserve Indicator . 66
...........................................
Gauge . 70
................
Octane Requirement . 156
........................
Tank, Filling the . 157
................
Gas Station Procedures . 157
Gauges
...
Engine Coolant Temperature . 71
...............................................
Fuel . 70
...............................
Speedometer . 69
.................................
Tachometer . 69
Gearshif t Lever Positions ..........
Automatic Transmission . 174
5-speed Manual
.........................
Transmission . 172
..............................
Glass Cleaning . 254
......................................
Glove Box . 101 .............
Halogen Headlight Bulbs . 241
..............
Hazard Warning Flashers . 78
Headlights
............
Daytime Running Lights . 74
..................
High Beam Indicator . 66
........................
Reminder Beeper . 73
........
Replacing Halogen Bulbs . 241
...................................
Turning on . 73
..............................
Head Restraints . 92
.....................
Heating and Cooling . 110
.............
High Altitude, Starting at . 171
.................
High-Low Beam Switch . 73
..............
High-mount Brake Light . 245
....................................
Hood Latch . 220
.......................
Hood, Opening the . 158
..................................................
Horn . 72
...........................
Hydraulic Clutch . 217
.................................
Hydroplaning . 188
...
Identif ication Number, Vehicle . 286
Ignition
..............................................
Keys . 80 ...........................................
Switch . 82
............
Timing Control System . 295
.........
Important Safety Precautions . 6
Indicators, Instrument
.............................................
Panel . 61
...............................
Inf ant Restraint . 30
Inf ant Seats
...........................
Lower Anchors . 42
..........
Tether Anchorage Points . 41
...................
Inf lation, Proper Tire . 232
.........................
Normal Driving . 233
...................................
Inside Mirror . 99
.............................
Inspection, Tire . 234
........................
Instrument Panel . 2, 58
........
Instrument Panel Brightness . 74
...........................
Interior Cleaning . 252
...............................
Interior Lights . 105
........................................
Introduction . i
Index
G H I J
IV
——y
y
(%y

y

CONT INUED
..................................................
Keys . 80
...................
Neutral Gear Position . 176
..................
New Vehicle Break-in . 156
.....................
Normal Shif t Speeds . 173 ...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 286
..................................
Maintenance . 189
...
Owner Maintenance Checks . 201
.................................
Record . 199-200
......................
Required Indicator . 67
..........................................
Saf ety . 190
.............................
Schedule . 192-198
.
Malf unction Indicator Lamp . 66, 274
...................
Manual Transmission . 172
........
Manual Transmission Fluid . 216
...............................
Meters, Gauges . 69
...................
Methanol in Gasoline . 292
..........................
Mirrors, Adjusting . 99
.........................................
Moonroof . 98
......................
Closing Manually . 277
.....................................
Operation . 98 ...
Octane Requirement, Gasoline . 156
.........................................
Odometer . 69
...............................
Odometer, Trip . 70
Oil
........................
Change, How to . 205
......................
Change, When to . 192
......................
Checking Engine . 160
..............
Pressure Indicator . 64, 272
Selecting Proper Viscosity
......................................
Chart . 204
...........
ON (Ignition Key Position) . 83
Onboard Ref ueling Vapor
....................................
Recovery . 295
..
Operation in Foreign Countries . 293
..............................
Outside Mirrors . 99
....................
Overheating, Engine . 269
.......
Owner Maintenance Checks . 201
.........................
Oxygenated Fuels . 292
.......................
Label, Certif ication . 286
.................
Lane Change, Signaling . 75
........................
Lap/Shoulder Belts . 45
Lights
....................
Bulb Replacement . 241
.......................................
Indicator . 61
.........................................
Parking . 73
..................................
Turn Signal . 75
.....................................
Load Limit . 166
......
LOCK (Ignition Key Position) . 82
Locks
.......
Anti-thef t Steering Column . 82
............................
Fuel Fill Door . 157
.................................
Power Door . 84
...........................................
Trunk . 88
........................
Low Coolant Level . 161
.........................
Low Fuel Indicator . 66
................................
Lower Anchors . 42
...
Lower Gear, Downshif ting to a . 173
...
Low Oil Pressure Indicator . 64, 272 ...
Lubricant Specif ications Chart . 288
.........................................
Luggage . 165
Index
L M N O
K
V
——y
y
(%y
y

Î..................................
Saf ety Belts . 8, 45
.........
Safety Defects, Reporting . 302
.................................
Saf ety Features . 7
.........................................
Airbags . 10
..................................
Door Locks . 11
..........................
Head Restraints . 11
.......................................
Seat Belts . 8
..................
Seats and Seat-Backs . 11
.............
Saf ety Labels, Location of . 56
...............................
Saf ety Messages . ii
.....................................
Seat Belts . 8, 45
...............
Additional Information . 45
Automatic Seat Belt
...............................
Tensioners . 46
.....................................
Cleaning . 253
......................
Lap/Shoulder Belt . 45
...................
Radiator Overheating . 269
Radio/CD/Cassette
....................
Sound System . 118, 130
...................
Readiness Codes . 275, 297
Rear Lights, Bulb
......................
Replacement . 244, 245
..........................
Rear Seat, Folding . 94
............................
Rear View Mirror . 99
.................
Rear Window Def ogger . 78
...............
Reclining the Seat Backs . 90
.......
Recommended Shif t Speeds . 173
.............................
Reminder Lights . 61
.......................
Remote Transmitter . 85
Replacement Inf ormation
.................
Air Cleaner Element . 219
..........................
Engine Coolant . 209
................
Engine Oil and Filter . 205
..........................................
Fuses . 279
................................
Light Bulbs . 241
....................................
Schedule . 192
................................
Spark Plugs . 221
................................
Timing Belt . 231
...........................................
Tires . 236
.............................
Wiper Blades . 226 Replacing Seat Belts Af ter a
............................................
Crash . 48
Reserve Tank, Engine ...............................
Coolant . 161, 207
...............................
Restraint, Child . 21
..................
Reverse Gear Position . 176
................................
Rotation, Tire . 235
..............................
Paint Touch-up . 251
..............
Panel Brightness Control . 74
........................
Park Gear Position . 176
...........................................
Parking . 182
...............................
Parking Brake . 100
.................................
Parking Lights . 73
..
Parking Over Things that Burn . 296
.............................
PGM-FI System . 295
..................
Polishing and Waxing . 251
............
Pre-Drive Saf ety Checklist . 12
.........
Pregnancy, Using Seat Belts . 19
............................
Protecting Adults . 13
...
Additional Safety Precautions . 19
.....
Advice f or Pregnant Women . 19
........................
Protecting Children . 21
.......................
Protecting Inf ants . 30
.......
Protecting Larger Children . 37
.........
Protecting Small Children . 34
Using Child Seats with
.....................................
Tethers . 41
................
Using Lower Anchors . 42
Index
PR
S
VI
——y
y
(%y
y

Î
CONT INUED
................................
Maintenance . 47
......
Reminder Light and Beeper . 64
...................
System Components . 45
...............
Use During Pregnancy . 19
...
Wearing a Lap/Shoulder Belt . 16
........................
Seats, Adjusting the . 90
...............................
Serial Number . 286
...........................
Service Intervals . 192
...........................
Service Manual . 309
.........
Service Station Procedures . 157
..................
Setting the Clock . 123, 135
.....
Shif t Lever Position Indicator . 174
........................
Shif t Lock Release . 178
..............................
Side Airbags . 10, 51
....................
Cutof f Indicator . 53, 64
Side Marker Lights, Bulb .................
Replacement in . 242, 244
...............................
Signaling Turns . 75
.....................................
Snow Tires . 237
...................
Solvent-type Cleaners . 250
........................
Sound System . 118, 130
Spare Tire
......................................
Inf lating . 258
............................
Specif ications . 289
................
Spark Plugs, Replacing . 221
....................
Specif ications Charts . 288 ................................
Speed Control . 151
...................................
Speedometer . 69
.......................................
Spotlights . 106
..........
SRS, Additional Inf ormation . 49
...
Additional Safety Precautions . 54
.............................
Airbag Service . 54
How the Passenger Airbag
CutoffIndicator Light ...................................
Works . 53
How the SRS Indicator .......................................
Works . 52
How Your Front Airbags .........................................
Work . 49
...
How Your Side Airbags Work . 51
........................
SRS Components . 49
.............................
SRS Indicator . 52, 64
....
START (Ignition Key Position) . 83
........
Testing of Readiness Codes . 297
.......................
Starting the Engine . 171
In Cold Weather at High ..................................
Altitude . 171
................
With a Dead Battery . 267
..............
State Emissions Testing . 297
........
Steam Coming f rom Engine . 269
Steering Wheel
..................................
Adjustment . 79 .............
Anti-theft Column Lock . 82
...........
Stereo Sound System . 118, 130
...........................
Storing Your Car . 248
Supplemental Restraint
................................
System . 10, 49
......................................
Servicing . 54
.........................
SRS Indicator . 52, 64
...................
System Components . 49
..................................
Synthetic Oil . 204
.....................................
Tachometer . 69
Taillights, Changing
......................................
Bulbs in . 242
.
Taking Care of the Unexpected . 257
...........................
Tape Player . 124, 145
Technical Descriptions
......
DOT Tire Quality Grading . 290
.....
Emissions Control Systems . 294
.....................
Oxygenated Fuels . 292
Three Way Catalytic
...............................
Converter . 296
.......................
Temperature Gauge . 71
Index
T
VII
——y
y
(%y
y