engine HONDA CIVIC COUPE 2009 8.G Manual Online

The engine number is stamped into
the engine block. It is on the f ront.
The transmission number is on a
label on top of the transmission.
Identif ication Numbers
Technical Inf ormation
375
MANUAL TRANSMISSION
NUMBER
Si
ENGINE NUMBER
ENGINE NUMBER
AUTOMATIC/MANUAL
TRANSMISSION NUMBER
DX, Canadian DX-G, LX, EX, and EX-L
\f—\f—\fy

y
(+\fy\f\fy
2009 Civic Coupe

Î
ÎÎÎ
Î
Î Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Specif ications
376
Dimensions Engine
Weights
Seating Capacities 174.8 in (4,440 mm)
68.9 in (1,751 mm)
53.5 in (1,358 mm)
104.3 in (2,650 mm)
59.0 in (1,499 mm)
59.9 in (1,522 mm)
Length
Width
Height
Wheelbase
Track
Type
BorexStroke
Displacement
Compression ratio
Spark plugs
Spark plugsWater cooled 4-stroke
SOHC VTEC , DOHC i-VTEC 4-cylinder gasoline engine
3.19 x 3.44 in (81.0 x 87.3 mm) 3.39x3.39in(86x86mm) 110 cu-in (1,799 cm
)
122 cu-in (1,998 cm)
10.5
11.0
NGK:
DENSO: IZFR6K-11S
SKJ20DR-M11S
IFR7G-11KS
SK22PR-M11S
Gross vehicle weight rating See the certification label attached to the driver’s doorjamb.
Total
Front
Rear 3
2
5
60.2 in (1,528 mm)
Front
Rear
NGK:
DENSO:
1:
2: DX, Canadian DX-G, LX, EX, EX-L
Si
1:
2:
LX, Canadian DX-G (M/T), EX, EX-L
DX, Canadian DX-G (A/T)
1
2 12
1
2 1
2
1
2
1
2
\f—\f—\fy

\fy
(+\fy\f
y
2009 Civic Coupe

µµ
Î
Î µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Specif ications
Technical Inf ormation
377
Air Conditioning
Capacities
Lights
Refrigerant type
Charge quantity
Lubricant oil typeHFC-134a (R-134a)
14.1 15.9 oz (400 450 g) SP-10
60 W
12 V
12 V
12 V 51 W
28/8 W
Including the coolant in the reserve tank and that remaining in
the engine
Reserve tank capacity:
Excluding the oil remaining in the engine 13.2 US gal (50)
1.45 US gal (5.5)
1.37 US gal (5.2)
1.19 US gal (4.5)
1.88 US gal (7.1)
1.72 US gal (6.5)
1.80 US gal (6.8)
3.9 US qt (3.7
)
4.6 US qt (4.4)
3.7 US qt (3.5)
4.4 US qt (4.2)
4.8 US qt (4.5)
5.8 US qt (5.5)
1.5 US qt (1.4)
1.6 US qt (1.5)
1.7 US qt (1.6)
1.8 US qt (1.7)
2.5 US qt (2.4)
6.2 US qt (5.9)
2.6 US qt (2.5
)
4.8 US qt (4.5)
0.11 US gal (0.4
)
Fuel tank
Engine
coolant
Engine oil
Manual
transmission
fluid
Automatic
transmission
fluid
Windshield
washer
reservoir
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V
5W
8W
8W
3CP
21 W
18 W
3CP
21/5 W
21 W
12 V 55 W
Headlights (HI)
Headlights (LO)
Front turn signal/Side marker/
Parking light
Fog lights
Rear turn signal lights
Stop/Taillights
Rear side marker lights
Back-up lights
High-mount brake light
License plate lights
Ceiling light
Spotlights
Trunk light
Change
Total
Change
Including
filter
Without filter
Total
Change
Total
Change
Total
U.S. Vehicles
Canada
Vehicles Approx.
Si A/T
M/T
A/T
M/T
(HB3)
(HB4)
EX, EX-L, Si:
U.S.: DX, LX, EX, EX-L U.S. DX and LX
Canada: DX, DX-G, LX
1:
Replacement of the light should be done by your
dealer.
2 : If equipped (H11)
1:
2:
3:
4: Canada: DX, DX-G, LX, EX-L (Amber)
(Amber)
2
1
1
2
3
3
4
3
3
4
3
4
3
4
3
4
3
4
3
4
\f—\f—\fy

y
(+\fy\fy
2009 Civic Coupe

Î
ÎThe burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx), and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons. Con-
trolling the production of NOx, CO,
and HC is important to the environ-
ment. Under certain conditions of
sunlight and climate, NOx and HC
react to f orm photochemical ‘‘smog.’’
Carbon monoxide does not contri-
bute to smog creation, but it is a
poisonous gas. The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
In Canada, Honda vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured.
Your vehicle has a positive
crankcase ventilation system. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The positive
crankcase ventilation valve routes
them from the crankcase back to the intake manif old. They are then
drawn into the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The onboard ref ueling vapor
recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
The Clean Air Act
Crankcase Emissions Control
System
Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
Emissions Cont rols
Technical Inf ormation
385
\f—\f—\fy

y
(+\fy\f\fy
2009 Civic Coupe

The PGM-FI system uses sequential
multiport f uel injection. It has three
subsystems: air intake, engine
control, and f uel control. The
powertrain control module (PCM) in
automatic transmission vehicles or
the engine control module (ECM) in
manual transmission vehicles uses
various sensors to determine howmuch air is going into the engine. It
then controls how much f uel to inject
under all operating conditions.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more informa-
tion.
The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Honda replacement parts or their
equivalent f or repairs. Using lower
qualitypartsmayincreasethe
emissions f rom your vehicle.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor.
The exhaust gas recirculation (EGR)
system takes some of the exhaust
gas and routes it back into the intake
manif old. Adding exhaust gas to the
air/f uel mixture reduces the amount
of NOx produced when the f uel is
burned.
The exhaust emissions controls
include three or f our systems:
PGM-FI, ignition timing control,
exhaust gas recirculation (DX,
Canadian DX-G, LX, EX and EX-L),
and three way catalytic converter.
These systems work together to
control the engine’s combustion and
minimize the amount of HC, CO, and
NOx that comes out the tailpipe. The
exhaust emissions control systems
are separate from the crankcase and
evaporative emissions control
systems.
2
2
On DX, Canadian DX-G, LX, EX and EX-L models
Exhaust Emissions Controls
Replacement Parts
Emissions Cont rols
PGM-FI SystemIgnit ion T iming Cont rol Syst em
Exhaust Gas Recirculat ion (EGR)Syst em Three Way Catalytic Converter
386
\f—\f—\fy

y
(+\fy\f
y
2009 Civic Coupe

The three way catalytic converter
contains precious metals that serve
as catalysts, promoting chemical
reactions to convert the exhaust
gasses without af f ecting the metals.
The catalytic converter is ref erred to
as a three-way catalyst, since it acts
on HC, CO, and NOx. A replacement
unit must be an original Honda part
or its equivalent.
The three way catalytic converter
must operate at a high temperaturefor the chemical reactions to take
place. It can set on f ire any
combustible materials that come
near it. Park your vehicle away from
high grass, dry leaves, or other
f lammables.
A defective three way catalytic
converter contributes to air pollution,
and can impair your engine’s per-
f ormance. Follow these guidelines to
protect your vehicle’s three way
catalytic converter. Always use unleaded gasoline.
Even a small amount of leaded
gasoline can contaminate the
catalyst metals, making the three
way catalytic converter inef f ective.
Keep the engine well maintained.
Have your vehicle diagnosed and
repaired if it is misf iring, back-
f iring, stalling, or otherwise not
running properly.
Three Way Catalytic Converter
Technical Inf ormation
387
THREE WAY CATALYTIC CONVERTER
THREE WAY CATALYTIC CONVERTER
DX, Canadian DX-G, LX, EX, EX-L Si model
\f—\f—\fy

\fy
(+\fy\fy
2009 Civic Coupe

If you take your vehicle f or an
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
Make sure the ambient
temperature is between 40° and
95°F (4° and 35°C).
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle retested within the
next two or three days, you can
condition the vehicle f or retesting by
doing the f ollowing.
Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the vehicle has been
parked with the engine of f f or 6
hours or more. Keep the vehicle in Park
(automatic transmission) or
neutral (manual transmission).
Increase the engine speed to 2,000
rpm,andholditthereuntilthe
temperature gauge rises to at least
1/4of thescale(about3minutes).
Without touching the accelerator
pedal, let the engine idle f or 20
seconds.
1.
2.
3. 4.
5.
6.
T esting of Readiness Codes
Emissions T esting
388
\f—\f—\fy


\fy
(+\fy\fy
2009 Civic Coupe

Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D (automatic) or 5th (manual). Do
notusethecruisecontrol.When
traffic allows, drive for 90 seconds
without moving the accelerator
pedal. (Vehicle speed may vary
slightly; this is okay.) If you cannot
do this f or a continuous 90
seconds because of traf f ic
conditions, drive f or at least 30
seconds, then repeat it two more
times (for a total of 90 seconds).Then drive in city/suburban
traffic for at least 10 minutes.
When traf f ic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
Make sure the vehicle has been
parked with the engine of f f or 30
minutes.
If the testing f acility determines the
readiness codes are still not set, see
your dealer.
7. 8.
9.
Emissions T esting
Technical Inf ormation
389
\f—\f—\fy


y
(+\fy\fy
2009 Civic Coupe

T he publications shown below can be purchased f rom Helm
Incorporated. You can order by phone or online:Call Helm Inc. at 1-800-782-4356 (credit card orders only)
Go online at
If you are interested in other years or models, contact Helm Inc.
at 1-800-782-4356.Covers maintenance and recommended procedures f or
repair to engine and chassis components. It is written
f or the journeyman mechanic, but it is simple enough
f or most mechanically inclined owners to understand.
Complements the Service Manual by providing in-depth
troubleshooting inf ormation f or each electrical circuit
in your vehicle.
Describes the procedures involved in the replacement
of damaged body parts.
Purchasing Factory Authorized Manuals (U.S. only) Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
Authorized Manuals
Authorized Manuals
395
Form Description
2009 Honda Civic 2/4 door Service Manual 2006-2009 Honda Civic 2/4 door
Electrical Troubleshooting Manual
2006-2009 Model Series Honda Civic 2/4 door Body Repair Manual
2009 Honda Civic 2-door Owner’s Manual
2009 Honda Civic Navigation System Manual 2009 Honda Civic Honda Service History
2009 Honda Civic 2-door Quick Start Guide Order Form for Previous Years
Indicate Year and Model Desired
Publication
Form Number 61SNA08
61SNA08EL
61SNA30
31SVA630
31SNA820
31SNAM30 31SVAQ30 HON-R
www. helminc. com
\f—\f—\fy

y
(+\fy\f\f\fy
2009 Civic Coupe

CONT INUED
........................................
AAC .151,206
...
Accessories and Modif ications .273
ACCESSORY (Ignition Key
.......................................
Position) .79
............
Accessory Power Sockets .110
..................
Active Head Restraints .98
................
Adding Engine Coolant .316
....................
Additives, Engine Oil .313
...............................
Airbag (SRS) .9,21
..........
Airbag System Components .21
..............
Air Conditioning System .116
.........................................
Usage .119
.......
Air Pressure, Tires .335,337,378
......................................
Antif reeze .316
Anti-lock Brakes (ABS)
...............................
Indicator .59,292
...................................
Operation .292
..............
Anti-thef t, Audio System .221
Anti-thef t Steering Column
..............................................
Lock .79
................................
Audio System .121
.....
Auto Door Locking/Unlocking .82
...
Automatic Seat Belt Tensioners .19
.............
Automatic Speed Control .224 ..............
Automatic Transmission .286
..........................
Capacity, Fluid .377
...............
Checking Fluid Level .320
.......................................
Shif ting .286
Shif t Lever Position
...............................
Indicators .286
................
Shif t Lever Positions .287
....................
Shif t Lock Release .289
............................
Capacities Chart .377
Battery
Charging System ...........................
Indicator .57,361
............................
Jump Starting .357
..............................
Maintenance .345
............................
Specif ications .378
..............................
Bef ore Driving .263
....................................
Belts,Seat .8,18
.........................
Beverage Holders .109
.......
Bluetooth
HandsFreeLink.227
..................................
Booster Seats .47
Brakes
...........
Anti-lock System (ABS) .292
.............
Break-in, New Linings .264
....................
Bulb Replacement .328 ...........................................
Fluid .322
.......................................
Parking .107
..........................
System Design .291
.................
System Indicator .58,363
........................
Wear Indicators .291
.............................
Braking System .291
.................
Break-in, New Vehicle .264
..
Brightness Control, Instruments .74
Bulb Replacement
..........................
Back-up Lights .328
..............................
Brake Lights .328
.................................
Fog Lights .329
................
Front Parking Lights .327
........
Front Side Marker Lights .327
.................................
Headlights .324
.........
High-mount Brake Light .331
................................
Rear Lights .328
............................
Specif ications .377
....................
Turn Signal Lights .327
..............................
Bulbs, Halogen .324
Index
A
B
C
INDEX
I
——y

y
(+yy
2009 Civic Coupe