coolant HONDA CIVIC HATCHBACK 2003 7.G Owner's Manual

If you see steam and/or spray
coming f rom under the hood, turn
of f the engine.
If you do not see steam or spray,
leave the engine running and
watch the temperature gauge. If
the high heat is due to overloading
(climbing a long, steep hill on a
hot day with the A/C running, f or
example), the engine should start
to cool down almost immediately.
If it does, wait until the tempera-
ture gauge comes down to the mid-
point then continue driving.
Saf ely pull to the side of the road.
Put the transmission in Neutral or
Park, and set the parking brake.
Turn of f the heating and cooling
system and all other accessories.
Turn on the hazard warning
indicators.
The pointer of your car’s tempera-
ture gauge should stay in the mid-
range under most conditions. It may
go higher if you are driving up a long
steep hill on a very hot day. If it
climbs to the red mark, you should
determine the reason. Your car can overheat f or several
reasons, such as lack of coolant or a
mechanical problem. The only
indication may be the temperature
gauge climbing to or above the red
mark. Or you may see steam or
spray coming f rom under the hood.
In either case, you should take
immediate action.1. 2. 3.
If Your Engine Overheats
T aking Care of t he Unexpect ed
232 Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.
Driving with the temperature gauge
pointer at the red mark can cause
serious damage to your engine.

If the temperature gauge stays at
the red mark, turn of f the engine.
Wait until you see no more signs
of steam or spray, then open thehood.
If you don’t f ind an obvious leak,
check the coolant level in the
radiator reserve tank (see page). If the level is below the
MIN mark, add coolant to halfway
between the MIN and MAX marks. If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly.
If there was no coolant in the
reserve tank, you may also have to
add coolant to the radiator. Let the
engine cool down until the pointer reaches the middle of the tempera-
ture gauge, or lower, bef ore check-
ing the radiator.
Using gloves or a large heavy
cloth, turn the radiator cap
counterclockwise, without pushing
down, to the f irst stop. This
releases any remaining pressure in
the cooling system. After the
pressure releases, push down on
the cap and turn it until it comes
off.
Start the engine and set the
temperature control dial to
maximum. Add coolant to the
radiator up to the base of the f iller
neck. If you do not have the
proper coolant mixture available,
you can add plain water.
Remember to have the cooling
system drained and ref illed with
the proper mixture as soon as you
can.
Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (see
on page ). Put the radiator cap back on
tightly. Run the engine and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair. (See
on page .)
4. 5.
6. 7. 8. 9.10.
11.
12.
133 245
245
Emergency
Towing
Emergency
Towing
If Your Engine Overheats
T aking Care of t he Unexpect ed 233
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

ÎÎ Î
Î Î Î
Specif ications
T echnical Inf ormation
250 Dimensions
Weights
Engine
Capacities
67.1 in (1,705 mm)
54.1 in (1,375 mm)
101.2 in (2,570 mm)
57.8 in (1,468 mm)
57.8 in (1,468 mm)
3.39 x 3.39 in (86.0 x 86.0 mm) 121.9 cu-in (1,998 cm
)
9.8 : 1 13.2 US gal (50
)
1.32 US gal (5.0
)
164.2 in (4,170 mm)
Length
Width
Height
Wheelbase
Track
Gross vehicle weight ratingType
BorexStroke
Displacement
Compression ratio
Spark plugs See the certification label attached
to the driver’s doorjamb. Fuel tank
Engine
coolant
Engine oil Manual
transmission
fluid
Windshield
washer reservoir1.77 US gal (6.7
)
4.4 US qt (4.2
)
4.2 US qt (4.0)
5.6 US qt (5.3)
1.6 US qt (1.5)
1.8 US qt (1.7)
2.6 US qt (2.5
)
0.13 US gal (0.5
)
Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity:
Water cooled 4-stroke DOHC
i-VTEC 4-cylinder gasoline engine 5.8 US qt (5.5
)
See spark plug maintenance
section page 183 .
FrontRear
Approx.
Change Manual
Total Manual
Change
Without filter
Total
ChangeTotal
1: 2: 3: On the U.S. model
On Canadian model 1
23
Including filter

CONT INUED
BatteryCharging System ...........................
Indicator . 58, 235
............................
Jump Starting . 230
..............................
Maintenance . 184
............................
Specif ications . 251
..............................
Bef ore Driving . 127
....................................
Belts,Seat .8,43
...........................
Beverage Holders . 90
.................................
Body Repairs . 220
Brakes
.............
Break-in, New Linings . 128
...........................................
Fluid . 177
.....................
Light, Burned-out . 207
.........................................
Parking . 89
.................
System Indicator . 59, 238
........................
Wear Indicators . 147
.............................
Braking System . 147
........................
Break-in, New Car . 128
..
Brightness Control, Instruments . 67
........................
Brights, Headlights . 66
...
Accessories and Modif ications . 135
................................
Accessories . 135
.
Additional Safety Precautions . 136
............................
Modif ications . 136
ACCESSORY (Ignition Key .......................................
Position) . 73
...............
Accessory Power Socket . 92
Adding
................................
Brake Fluid . 178
...............................
Clutch Fluid . 178
..........................
Engine Coolant . 171
..................................
Engine Oil . 167
....
Manual Transmission Fluid . 177
........
Windshield Washer Fluid . 176
Additional Inf ormation About .......................
Your Seat Belts . 43
......................
Lap/Shoulder Belt . 43
...............
Seat Belt Maintenance . 45
..
Seat Belt System Components . 43
Additional Inf ormation About ...........................
Your Airbags . 46
...
Additional Safety Precautions . 51
How the Passenger Airbag
..........
Cutoff Indicator Works . 49 How Your Front Airbags
.........................................
Work . 46
....................
Airbag Components . 46
....................
Additives, Engine Oil . 168
Adjustments
..........................
Head Restraints . 82
.........................................
Mirrors . 88
.............................................
Seats . 81
...........................
Steering Wheel . 71
...............................
Airbag (SRS) . 9, 46
.....................
Air Cleaner Element . 179
................
Air Conditioning System . 96
..............................
Maintenance . 189
............................................
Usage . 96
.........................
Air Outlets (Vents) . 98
.......................
Air Pressure, Tires . 193
..................
High Speed Driving . 194
.........................
Normal Driving . 194
.......................
Alcohol in Gasoline . 254
......................................
Antif reeze . 171
Anti-thef t Steering Column
..............................................
Lock . 73
..........................
Appearance Care . 213
................................
Audio System . 104
Index
A B
I

Bulb Replacement..........................
Back-up Lights . 206
..................................
Stop Light . 206
......................
Cargo Area Light . 211
................
Front Parking Lights . 205
........
Front Side Marker Lights . 204
.................................
Headlights . 202
.........
High-mount Brake Light . 207
...........................
Interior Lights . 210
.................
License Plate Lights . 209
..................
Side Marker Lights . 204
...........
Side Turn Signal Lights . 208
............................
Specif ications . 251
....................
Turn Signal Lights . 203
..............................
Bulbs, Halogen . 202
.........
Cables, Jump Starting With . 230
............................
Capacities Chart . 250
.............
Carbon Monoxide Hazard . 52
...........................
Cargo Area Cover . 84
.............................
Carrying Cargo . 137
Cassette Player
............................................
Care . 122
...................................
Operation . 119 ..............
CAUTION, Explanation of . ii
...................................
CD Changer . 115
.......................................
CD Player . 113
........................
Certif ication Label . 248
............................................
Chains . 199
Change Oil
........................................
How to . 169
......................................
When to . 158
....................
Changing a Flat Tire . 223
............
Changing Engine Coolant . 173
...
Charging System Indicator . 58, 235
Checking
.....................
Battery Condition . 184
................................
Brake Fluid . 178
...............................
Clutch Fluid . 178
.................................
Drive Belts . 192
..........................
Engine Coolant . 133
..................................
Engine Oil . 132
..........................................
Fuses . 241
....
Manual Transmission Fluid . 177
............
Checklist, Bef ore Driving . 142
.....................................
Child Saf ety . 20
....................
Cleaner Element, Air . 179
Cleaning
....................
Aluminum Wheels . 216
...................................
Carpeting . 216 ......................................
Exterior . 214
.........................................
Fabric . 217
.......................................
Interior . 216
...................................
Seat Belts . 218
...........................................
Vinyl . 217
....................................
Windows . 218
.........................
Clock, Setting the . 109
...................................
Clutch Fluid . 178
........................
CO in the Exhaust . 256
............
Cold Weather, Starting in . 143
..............................
Compact Spare . 222
.............
Controls, Instruments and . 55
Coolant
........................................
Adding . 171
....................................
Checking . 133
.........................
Proper Solution . 171
...................................
Replacing . 173
...................
Temperature Gauge . 64
....................
Corrosion Protection . 219
Crankcase Emissions Control
........................................
System . 256
...............................
Cruise Control . 124
Index
C
II

CONT INUED
................
DANGER, Explanation of . ii
...................................
Dashboard . 2, 56
................
Daytime Running Lights . 67
...........
Dead Battery, What to Do . 230
............
Def ects, Reporting Saf ety . 264
........................
Def og and Def rost . 101
................
Def ogger, Rear Window . 70
..............
Def rosting the Windows . 101
....................................
Dimensions . 250
...............
Dimming the Headlights . 66
Dipstick
..................................
Engine Oil . 132
..........................
Directional Signals . 68
.....
Disabled, Towing Your Car If . 245
........
Disc Brake Wear Indicators . 147
.....................
Disposal of Used Oil . 170
Doors
..............
Locking and Unlocking . 75
..........
DOT Tire Quality Grading . 252
Downshif ting, 5-speed Manual
.............................
Transmission . 144
.....................................
Drive Belts . 192
...........
Driver and Passenger Safety . 5 ...........................................
Driving . 141
....................................
Economy . 134
.........................
In Bad Weather . 151
................
In Foreign Countries . 255
..............................
Economy, Fuel . 134
............
Emergencies on the Road . 221
.............
Battery, Jump Starting . 230
...........
Brake System Indicator . 238
................
Changing a Flat Tire . 223
.....
Charging System Indicator . 235
..................
Checking the Fuses . 241
.....
Low Oil Pressure Indicator . 234
...
Malf unction Indicator Lamp . 236
..................
Overheated Engine . 232
...........................
Emergency Brake . 89
......................
Emergency Flashers . 70
......................
Emergency Towing . 245
.......................
Emissions Controls . 256Engine
............................................
Belts . 192
....
Coolant Temperature Gauge . 64
Malf unction Indicator
................................
Lamp . 59, 236 ........
Oil Pressure Indicator . 58, 234
..............
Oil, What Kind to Use . 167
...............................
Overheating . 232
............................
Specif ications . 250
...................
Engine Speed Limiter . 145
......................
Ethanol in Gasoline . 254
.
Evaporative Emissions Controls . 256
...............................
Exhaust Fumes . 52
Expectant Mothers, Use of Seat
........................................
Belts by . 18
..................
Exterior,Cleaningthe .214
............................
Fabric, Cleaning . 217
.....................................
Fan, Interior . 96
Features, Comfort and
................................
Convenience . 95
....................
Filling the Fuel Tank . 129
Filter
................................
Air Cleaner . 179
...............................................
Oil . 169
Index
E
F
D
III

...
Identif ication Number, Vehicle . 248
......
If Your Car Has to be Towed . 245
Ignition
..............................................
Keys . 72
...........................................
Switch . 72
5-speed Manual Transmission
...............
Checking Fluid Level . 177
................................
Shif ting the . 144
.............
Flashers, Hazard Warning . 70
...................
Flat Tire, Changing a . 223
Fluids
..........................................
Brake . 177
.........................................
Clutch . 177
..............
Manual Transmission . 177
..................
Windshield Washer . 176
FM Stereo Radio ...................................
Reception . 111
...........................
Folding Rear Seat . 83
.....
Foreign Countries, Driving in . 255
..........................
Four-way Flashers . 70
Front End, Towing by
................
Emergency Wrecker . 245
.................................................
Fuel . 128
......................
Fill Door and Cap . 129
...........................................
Gauge . 63
................
Octane Requirement . 128
...............................
Oxygenated . 254
........................
Reserve Indicator . 60
........................
Tank, Filling the . 129
.....................
Fuses, Checking the . 241 ...............
Gas Mileage, Improving . 134
..........................................
Gasohol . 254
.........................................
Gasoline . 128
...............
Fuel Reserve Indicator . 60
...........................................
Gauge . 63
................
Octane Requirement . 128
........................
Tank, Filling the . 129
................
Gas Station Procedures . 129
Gauges
Engine Coolant
...........................
Temperature . 64
...............................................
Fuel . 63
Gearshif t Lever Positions 5-speed Manual
.........................
Transmission . 144
..............................
Glass Cleaning . 218
........................................
Glove Box . 90
.............
Halogen Headlight Bulbs . 202
Hatch
.................................
Opening the . 80
..............
Hazard Warning Flashers . 70 Headlights
............
Daytime Running Lights . 67
..................
High Beam Indicator . 59
...........
High Beams, Turning on . 66
............
Low Beams, Turning on . 66
........................
Reminder Beeper . 66
........
Replacing Halogen Bulbs . 202
...................................
Turning on . 66
..............................
Head Restraints . 82
.......................
Heating and Cooling . 96
.............
High Altitude, Starting at . 143
.................
High-Low Beam Switch . 66
....................................
Hood Latch . 181
.......................
Hood, Opening the . 130
..............................................
Horn .3,65
.......
Hot Coolant, Warning about . 171
...........................
Hydraulic Clutch . 178
.................................
Hydroplaning . 152
Index
G H I
IV

CONT INUED
..................................................
Keys . 72 ........................
Jacking up the Car . 224
.......................................
Jack, Tire . 223
................................
Jump Starting . 230 ..................................
Maintenance . 153
...
Owner Maintenance Checks . 165
................................
Record . 163, 164
..........................................
Saf ety . 154
.............................
Schedule . 158-162
.
Malf unction Indicator Lamp . 59, 236
...................
Manual Transmission . 144
........
Manual Transmission Fluid . 177
...............................
Meters, Gauges . 63
...................
Methanol in Gasoline . 254
..........................
Mirrors, Adjusting . 88
..................
New Vehicle Break-in . 128
.....................
Normal Shif t Speeds . 145
..................
NOTICE, Explanation of . ii
...............
Numbers, Identif ication . 248
............
Timing Control System . 257
.........
Important Safety Precautions . 6
Indicator Lights, Instrument
.............................................
Panel . 57
...............................
Inf ant Restraint . 28
...................
Inf lation, Proper Tire . 193
..................
High Speed Driving . 194
.........................
Normal Driving . 194
...................................
Inside Mirror . 88
.............................
Inspection, Tire . 195
............................
Instrument Panel . 57
........
Instrument Panel Brightness . 67
...........................
Interior Cleaning . 216
.................................
Interior Lights . 93
........................................
Introduction . i .......................
Label, Certif ication . 248
.................
Lane Change, Signaling . 68
..........................
Lap/Shoulder Belt . 43
.........
Leaking of Exhaust into Car . 52
Lights
....................
Bulb Replacement . 202
.......................................
Indicator . 57
.........................................
Parking . 89
..................................
Turn Signal . 68
.....................................
Load Limit . 138
......
LOCK (Ignition Key Position) . 73
Locks
.......
Anti-thef t Steering Column . 73
............................
Fuel Fill Door . 129
............................................
Hatch . 80
........................
Low Coolant Level . 133
.........................
Low Fuel Indicator . 60
...
Lower Gear, Downshif ting to a . 145
...
Low Oil Pressure Indicator . 58, 234
...
Lubricant Specif ications Chart . 250
.........................................
Luggage . 137
Index
J K LM
NV

...
Octane Requirement, Gasoline . 128
.........................................
Odometer . 63
...............................
Odometer, Trip . 63
Oil
........................
Change, How to . 169
......................
Change, When to . 158
......................
Checking Engine . 132
..............
Pressure Indicator . 58, 234
...........
ON (Ignition Key Position) . 73
Onboard Ref ueling Vapor
....................................
Recovery . 256
.........................
Opening the Hatch . 80
........................
Opening the Hood . 130
..
Operation in Foreign Countries . 255
..............................
Outside Mirrors . 88
....................
Overheating, Engine . 232
.......
Owner Maintenance Checks . 165
.........................
Oxygenated Fuels . 254
..............................
Paint Touch-up . 216
..............
Panel Brightness Control . 67
...........................................
Parking . 146 .................................
Parking Brake . 89
Parking Brake and Brake
.................
System Indicator . 59, 238
.................................
Parking Lights . 66
..
Parking Over Things that Burn . 258
.............................
PGM-FI System . 257
..................
Polishing and Waxing . 215
..............................
Power Windows . 85
............
Pre-Drive Saf ety Checklist . 11
.........
Pregnancy, Using Seat Belts . 18
............................
Protecting Adults . 12
...
Additional Safety Precautions . 18
.....
Advice f or Pregnant Women . 18
........................
Protecting Children . 20
.......................
Protecting Inf ants . 29
.......
Protecting Larger Children . 35
.........
Protecting Small Children . 32
Using Child Seats with
.....................................
Tethers . 39
...................
Radiator Overheating . 232
...
Radio/Cassette Sound System . 104
..........................
Rear End Towing . 245
..
Rear Lights, Bulb Replacement . 206 ............................
Rear Seat Access . 82
..........................
Rear Seat, Folding . 83
............................
Rear View Mirror . 88
.................
Rear Window Def ogger . 70
....................
Rear Window Washer . 69
.......................
Rear Window Wiper . 69
...............
Reclining the Seat Backs . 81
.......
Recommended Shif t Speeds . 145
.............................
Reminder Lights . 57
Replacement Inf ormation
.................
Air Cleaner Element . 179
..........................
Engine Coolant . 173
................
Engine Oil and Filter . 169
..........................................
Fuses . 241
................................
Light Bulbs . 202
....................................
Schedule . 156
................................
Spark Plugs . 181
...........................................
Tires . 197
.............................
Wiper Blades . 186
Replacing Seat Belts Af ter a ............................................
Crash . 45
Reserve Tank, Engine
...............................
Coolant . 133, 171
...............................
Restraint, Child . 20
................................
Rotation, Tire . 196
Index
P R
O
VI