light HONDA CIVIC HATCHBACK 2003 7.G Manual Online

ÎÎ
If you must drive the car a short
distance in this condition, drive
slowly and cautiously.
Slow down by shif ting to a lower
gear, and pull to the side of the road
when it is saf e. Because of the
longer distance needed to stop, it is
hazardous to drive the car. You
should have it towed, and repaired as
soon as possible. (See
on page .)
However, if the brake pedal does not
f eel normal, you should take
immediate action. Because of the
brake system’s dual-circuit design, a
problem in one part of the system
will still give you braking at two
wheels. You will f eel the brake pedal
go down much f arther bef ore the car
begins to slow down, and you will
have to press harder on the pedal.
The distance needed to stop will be
much longer.
If it comes on at any other time, it
indicates a problem with the car’s
brake system. In most cases, the
problem is a low f luid level in the
brake f luid reservoir. Press lightly on
the brake pedal to see if it f eels
normal. If it does, check the brake
f luid level the next time you stop at a
service station (see page ). If the
fluid level is low, take the car to your
dealer and have the brake system
inspected f or leaks or worn brake
pads.
The Brake System Indicator
normallycomesonwhenyouturn
the ignition switch ON (II). It is a
reminder to check the parking brake.
It comes on and stays lit if you do not
f ully release the parking brake. 178
245
Brake System Indicator
T aking Care of t he Unexpect ed Emergency
Towing
238 The U.S. indicator shown
BRAKE SYSTEM INDICATOR

If something electrical in your car
stops working, the f irst thing you
should check f or is a blown f use.
Determine f rom the chart on pagesand , or the diagram on the
fuse box lid, which fuse or fuses
control that component. Check those
f uses f irst, but check all the f uses
bef ore deciding that a blown f use is
not the cause. Replace any blown
f uses and check the component’s
operation.
Turn the ignition switch to LOCK
(0). Make sure the headlights and
all other accessories are off.
Remove the cover f rom the f use
box. Check each of the large f uses in
the under-hood f use box by
looking through the top at the wire
inside. Removing these f uses
requires a Phillips-head screw-
driver.
Check the smaller f uses in the
under-hood f use box and all the
fuses in the interior fuse box by
pulling out each f use with the f use
puller provided in the interior f use
box.
3.
1. 2. 4.
243 244
CONT INUED
Checking and Replacing Fuses
Fuses
T aking Care of t he Unexpect ed
241
FUSE
BLOWN FUSE PULLER

Î
Î No. Amps. Circuits Protected
CONT INUED
1 23456789
1011121314151617181920 20A15A
7.5A
20A10A15A15A20A10A40A30A40A40A40A15A20A15A60A80A40A50A Condenser Fan
Small Light
Interior Light
Cooling Fan
Hazard
FI ECU
Horn, Stop
ABS (F/S)
Back Up
ABS Motor
Rear Defroster
Heater Motor
Power Window
Option
Lef t Headlight
Door Lock
Right Headlight
Main Fuse EPS
Main Fuse Battery
Main Fuse Ignition
On Canadian model
Fuses
T aking Care of t he Unexpect ed 243
UNDER-HOOD FUSE BOX

µµ µ µ µ
Î
Î
Î Î
Î
No. No.
Amps. Circuits Protected Amps. Circuits Protected
123456789
10 111213141516171819202122 23 2425
15A20A
(10A) 10A
7.5A
(20A) 7.5A10A
7.5A Ignition Coil
LAF Heater
Daytime Running Lights
Alternator
Not Used
Power Window Relay
Moonroof
ACC Radio
Rear Wiper
Meter 7.5A
(7.5A) 10A10A
(20A) 15A15A
7.5A 30A 20A20A ABS
Daytime Running Lights
SRS
Power Mirror
Not Used
Heated Seat
Fuel Pump
ACC Cigarette Lighter
Turn Signal Lights
Front Wiper
Not Used
Front Passenger’s Power
Window
Driver’s Power Window
Not Used
Not Used
2: Not Used
1: On Canadian model
1 1
2
T aking Care of t he Unexpect ed
Fuses
244
INTERIOR FUSE BOX

µµµ
µ µµµµµµµµµµµµµ µ
Specif ications
T echnical Inf ormation 251
Air Conditioning
Alignment
Tires
Lights
Fuses
Battery HFC-134a (R-134a)
21.2 22.9 oz (500 550 g) SP-10
12 V
12 V 60/55 W (HB2)
21 W 0.00 in (0.0 mm)
0.08 in (2.0 mm)
0°45°
1°33’
195/60R15 88V
T125/70D15 95M
Refrigerant type
Charge quantity
Lubricant type
Toe-in
CamberCaster Size
Pressure 33 psi (230 kPa , 2.3 kgf/cm
)
30 psi (210 kPa , 2.1 kgf/cm)
60 psi (420 kPa , 4.2 kgf/cm)
12 V
12 V
12 V
12 V
21 W
21/5 W
2CP
12 V
12 V 21 W
12 V
12 V
12 V 5W5W5W
3CP5W
2CP 8W
12 V
12 V
Headlights (HI/LO)
Front turn signal
Front parking light
Side turn signal light
Front side marker
Rear turn signal lights
Stop/Taillights
Rear side marker lights
Back-up lights
High-mount brake light
License plate lights
Front ceiling light/Spotlights
Center ceiling light
Cargo area light
Interior
Under-hood
Capacity
45 AH/20 HR
12 V
12 V 5 W
See page 244 or the fuse label
attached to the inside of the fuse
box door under the dashboard.
See page 243 or the fuse box
cover. FrontRear
FrontRear
Front
Front/Rear
Spare
FrontRear
Spare

Î
Î
The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page
.
In Canada, Honda vehicles comply
with the Canadian Motor Vehicle
Saf ety Standards (CMVSS) f or
Emissions valid at the time they are
manuf actured.
The burning of gasoline in your car’s
engine produces several byproducts.
Some of these are carbon monoxide
(CO), oxides of nitrogen (NOx) and
hydrocarbons (HC). Gasoline
evaporating from the tank also
produces hydrocarbons. Controlling
the production of NOx, CO, and HC
is important to the environment.
Under certain conditions of sunlight
and climate, NOx and HC react to
f orm photochemical ‘‘smog.’’ Carbon
monoxide does not contribute to
smog creation, but it is a poisonous
gas.
Your car has a Positive Crankcase
Ventilation System. This keeps
gasses that build up in the engine’s
crankcase from going into the
atmosphere. The Positive Crankcase
Ventilation valve routes them fromthe crankcase back to the intake
manif old. They are then drawn into
the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The Onboard Ref ueling Vapor
Recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
158
The Clean Air Act
Crankcase Emissions Control
System Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
Emissions Cont rols
T echnical Inf ormation
256

Then drive in city/suburban
traffic for at least 10 minutes.
When traf f ic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
If the testing f acility determines the
readiness codes are still not set, see
your Honda dealer.
Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
5th.Donotusethecruisecontrol.
When traffic allows, drive for 90
seconds without moving the
accelerator pedal. (Vehicle speed
may vary slightly; this is okay.) If
you cannot do this f or a
continuous 90 seconds because of
traf f ic conditions, drive f or at least
30 seconds, then repeat it two
more times (for a total of 90
seconds).
St at e Emissions T est ing
T echnical Inf ormation
260

CONT INUED
BatteryCharging System ...........................
Indicator . 58, 235
............................
Jump Starting . 230
..............................
Maintenance . 184
............................
Specif ications . 251
..............................
Bef ore Driving . 127
....................................
Belts,Seat .8,43
...........................
Beverage Holders . 90
.................................
Body Repairs . 220
Brakes
.............
Break-in, New Linings . 128
...........................................
Fluid . 177
.....................
Light, Burned-out . 207
.........................................
Parking . 89
.................
System Indicator . 59, 238
........................
Wear Indicators . 147
.............................
Braking System . 147
........................
Break-in, New Car . 128
..
Brightness Control, Instruments . 67
........................
Brights, Headlights . 66
...
Accessories and Modif ications . 135
................................
Accessories . 135
.
Additional Safety Precautions . 136
............................
Modif ications . 136
ACCESSORY (Ignition Key .......................................
Position) . 73
...............
Accessory Power Socket . 92
Adding
................................
Brake Fluid . 178
...............................
Clutch Fluid . 178
..........................
Engine Coolant . 171
..................................
Engine Oil . 167
....
Manual Transmission Fluid . 177
........
Windshield Washer Fluid . 176
Additional Inf ormation About .......................
Your Seat Belts . 43
......................
Lap/Shoulder Belt . 43
...............
Seat Belt Maintenance . 45
..
Seat Belt System Components . 43
Additional Inf ormation About ...........................
Your Airbags . 46
...
Additional Safety Precautions . 51
How the Passenger Airbag
..........
Cutoff Indicator Works . 49 How Your Front Airbags
.........................................
Work . 46
....................
Airbag Components . 46
....................
Additives, Engine Oil . 168
Adjustments
..........................
Head Restraints . 82
.........................................
Mirrors . 88
.............................................
Seats . 81
...........................
Steering Wheel . 71
...............................
Airbag (SRS) . 9, 46
.....................
Air Cleaner Element . 179
................
Air Conditioning System . 96
..............................
Maintenance . 189
............................................
Usage . 96
.........................
Air Outlets (Vents) . 98
.......................
Air Pressure, Tires . 193
..................
High Speed Driving . 194
.........................
Normal Driving . 194
.......................
Alcohol in Gasoline . 254
......................................
Antif reeze . 171
Anti-thef t Steering Column
..............................................
Lock . 73
..........................
Appearance Care . 213
................................
Audio System . 104
Index
A B
I

Bulb Replacement..........................
Back-up Lights . 206
..................................
Stop Light . 206
......................
Cargo Area Light . 211
................
Front Parking Lights . 205
........
Front Side Marker Lights . 204
.................................
Headlights . 202
.........
High-mount Brake Light . 207
...........................
Interior Lights . 210
.................
License Plate Lights . 209
..................
Side Marker Lights . 204
...........
Side Turn Signal Lights . 208
............................
Specif ications . 251
....................
Turn Signal Lights . 203
..............................
Bulbs, Halogen . 202
.........
Cables, Jump Starting With . 230
............................
Capacities Chart . 250
.............
Carbon Monoxide Hazard . 52
...........................
Cargo Area Cover . 84
.............................
Carrying Cargo . 137
Cassette Player
............................................
Care . 122
...................................
Operation . 119 ..............
CAUTION, Explanation of . ii
...................................
CD Changer . 115
.......................................
CD Player . 113
........................
Certif ication Label . 248
............................................
Chains . 199
Change Oil
........................................
How to . 169
......................................
When to . 158
....................
Changing a Flat Tire . 223
............
Changing Engine Coolant . 173
...
Charging System Indicator . 58, 235
Checking
.....................
Battery Condition . 184
................................
Brake Fluid . 178
...............................
Clutch Fluid . 178
.................................
Drive Belts . 192
..........................
Engine Coolant . 133
..................................
Engine Oil . 132
..........................................
Fuses . 241
....
Manual Transmission Fluid . 177
............
Checklist, Bef ore Driving . 142
.....................................
Child Saf ety . 20
....................
Cleaner Element, Air . 179
Cleaning
....................
Aluminum Wheels . 216
...................................
Carpeting . 216 ......................................
Exterior . 214
.........................................
Fabric . 217
.......................................
Interior . 216
...................................
Seat Belts . 218
...........................................
Vinyl . 217
....................................
Windows . 218
.........................
Clock, Setting the . 109
...................................
Clutch Fluid . 178
........................
CO in the Exhaust . 256
............
Cold Weather, Starting in . 143
..............................
Compact Spare . 222
.............
Controls, Instruments and . 55
Coolant
........................................
Adding . 171
....................................
Checking . 133
.........................
Proper Solution . 171
...................................
Replacing . 173
...................
Temperature Gauge . 64
....................
Corrosion Protection . 219
Crankcase Emissions Control
........................................
System . 256
...............................
Cruise Control . 124
Index
C
II

CONT INUED
................
DANGER, Explanation of . ii
...................................
Dashboard . 2, 56
................
Daytime Running Lights . 67
...........
Dead Battery, What to Do . 230
............
Def ects, Reporting Saf ety . 264
........................
Def og and Def rost . 101
................
Def ogger, Rear Window . 70
..............
Def rosting the Windows . 101
....................................
Dimensions . 250
...............
Dimming the Headlights . 66
Dipstick
..................................
Engine Oil . 132
..........................
Directional Signals . 68
.....
Disabled, Towing Your Car If . 245
........
Disc Brake Wear Indicators . 147
.....................
Disposal of Used Oil . 170
Doors
..............
Locking and Unlocking . 75
..........
DOT Tire Quality Grading . 252
Downshif ting, 5-speed Manual
.............................
Transmission . 144
.....................................
Drive Belts . 192
...........
Driver and Passenger Safety . 5 ...........................................
Driving . 141
....................................
Economy . 134
.........................
In Bad Weather . 151
................
In Foreign Countries . 255
..............................
Economy, Fuel . 134
............
Emergencies on the Road . 221
.............
Battery, Jump Starting . 230
...........
Brake System Indicator . 238
................
Changing a Flat Tire . 223
.....
Charging System Indicator . 235
..................
Checking the Fuses . 241
.....
Low Oil Pressure Indicator . 234
...
Malf unction Indicator Lamp . 236
..................
Overheated Engine . 232
...........................
Emergency Brake . 89
......................
Emergency Flashers . 70
......................
Emergency Towing . 245
.......................
Emissions Controls . 256Engine
............................................
Belts . 192
....
Coolant Temperature Gauge . 64
Malf unction Indicator
................................
Lamp . 59, 236 ........
Oil Pressure Indicator . 58, 234
..............
Oil, What Kind to Use . 167
...............................
Overheating . 232
............................
Specif ications . 250
...................
Engine Speed Limiter . 145
......................
Ethanol in Gasoline . 254
.
Evaporative Emissions Controls . 256
...............................
Exhaust Fumes . 52
Expectant Mothers, Use of Seat
........................................
Belts by . 18
..................
Exterior,Cleaningthe .214
............................
Fabric, Cleaning . 217
.....................................
Fan, Interior . 96
Features, Comfort and
................................
Convenience . 95
....................
Filling the Fuel Tank . 129
Filter
................................
Air Cleaner . 179
...............................................
Oil . 169
Index
E
F
D
III