ignition HONDA CIVIC HATCHBACK 2004 7.G Owner's Guide

If the indicator remains on, or the
f uel cap was not loose or missing,
have your vehicle checked by the
dealer as soon as possible.
Your vehicle has certain ‘‘readiness
codes’’ that are part of the on-board
diagnostics f or the emissions
systems. In some states, part of the
emissions testing is to make sure
these codes are set. If they are not
set, the test cannot be completed.If your vehicle battery has been
disconnected or gone dead, these
codes are erased. It takes at least
three days of driving under various
conditions to set the codes again.
To check if they are set, turn the
ignition to ON (II), without starting
the engine. The Malf unction
Indicator Lamp will come on f or 20
seconds.If itthengoesoff,the
readiness codes are set. If it blinks 5
times, the readiness codes are not
set. If possible, do not take your
vehicle f or a state emissions test
until the readiness codes are set.
Refer to State Emissions Testing for
more inf ormation (see page ).
If the indicator comes on
while driving, it means one
of the engine’s emissions
control systems may have a problem.
Even though you may f eel no
dif f erence in your vehicle’s
perf ormance, it can reduce your f uel
economy and cause increased
emissions. Continued operation may
cause serious damage.
If you have recently ref ueled your
vehicle, the indicator coming on
could be a loose or missing f uel f ill
cap. Tighten the cap until it clicks at
least three times. Tightening the cap
will not turn the indicator of f
immediately; it takes at least three
days of normal driving. 197
Readiness Code
Malf unction Indicator L amp
T aking Care of t he Unexpect ed
178 NOTICE:
If you keep driving with the
Malf unction Indicator Lamp on, you
can damage your vehicle’s emission
controls and the engine. Those repairs
may not be covered by your vehicle’s
warranties.
——y

y
()y

y

However, if the brake pedal does not
f eel normal, you should take
immediate action. A problem in one
part of the system’s dual circuit
design will still give you braking at
two wheels. You will f eel the brake
pedal go down much f arther bef ore
the vehicle begins to slow down, and
you will have to press harder on the
pedal.
Slow down by shif ting to a lower
gear, and pull to the side of the road
when it is saf e. Because of the long
distance needed to stop, it is
hazardous to drive the vehicle. You
should have it towed and repaired as
soon as possible (seeon page ).
If you must drive the vehicle a short
distance in this condition, drive
slowly and caref ully.
If the brake system indicator comes
on while driving, the brake f luid level
is probably low. Press lightly on the
brake pedal to see if it f eels normal.
If it does, check the brake f luid level
thenexttimeyoustopataservice
station (see page ).
If the f luid level is low, take your
vehicle to a dealer and have the
brake system inspected f or leaks or
worn brake pads. The brake system indicator
normally comes on when
you turn the ignition switch
to ON (II), and as a
reminder to check the
parking brake. It will stay
on if you do not f ully
release the parking brake.
144 185Emergency
Towing
Brake System Indicator
T aking Care of t he Unexpect ed 179
Canada
U.S.
——y

y
()y
y

Turn the ignition switch to LOCK
(0). Make sure the headlights and
all other accessories are of f .
Remove the cover f rom the f use
box.
Check each of the large f uses in
the under-hood f use box by
looking through the top at the wire
inside. Remove the screws with a
phillips-head screwdriver.
The vehicle’s f uses are located in
two fuse boxes. The interior fuse
box is located underneath the
steering column. To open it, turn the
knobsasshown.
If something electrical in your
vehicle stops working, check f or a
blown f use f irst. Determine f rom the
chart on pages and ,or the
diagram on the f use box lid, which
f uses control that device. Check
those fuses first, but check all the
f uses bef ore deciding that a blown
f use is the cause. Replace any blown
f uses, and check if the device works.
The under-hood f use box is located
in the back of the engine
compartment on the lef t side. To
open it, push the tabs as shown. 1. 2. 3.
183 184
Checking and Replacing Fuses
Fuses
T aking Care of t he Unexpect ed
181
UNDER-HOOD
INTERIOR
FUSE
BLOWN
——y

y
()y
y

Î
Î No. Amps. Circuits Protected
1 23456789
1011121314151617181920 20A15A
7.5A
20A10A15A15A20A10A40A30A40A40A40A20A20A20A60A80A40A50A Condenser Fan
Small Light
Interior Light
Cooling Fan
Hazard
FI ECU
Horn, Stop
ABS (F/S)
Back Up
ABS Motor
Rear Defroster
Heater Motor
Power Window
Option
Lef t Headlight
Door Lock
Right Headlight
Main Fuse EPS
Main Fuse Battery
Main Fuse Ignition
On Canadian model
Fuse Locations
T aking Care of t he Unexpect ed 183
UNDER-HOOD FUSE BOX
——y

y
()y
y

µµ µ µ µ
Î
Î
Î Î
Î
No. Amps. Circuits Protected No. Amps. Circuits Protected
123456789
10 15A20A
(10A) 10A
7.5A
(20A) 7.5A
10A
7.5A Ignition Coil
LAF Heater
Daytime Running Lights
Alternator
Not Used
Power Window Relay
Moonroof
ACC Radio
Rear Wiper
Meter 111213141516171819202122 23 2425
7.5A
(7.5A) 10A10A
(20A) 15A15A
7.5A 30A 20A20A ABS
Daytime Running Lights
SRS
Power Mirror
Not Used
Heated Seat
Fuel Pump
Accessory Power Socket
Turn Signal Lights
Front Wiper
Not Used
Front Passenger’s Power
Window
Driver’s Power Window
Not Used
Not Used
2: Not Used
1: On Canadian model
1 1
2
Fuse Locations
T aking Care of t he Unexpect ed
184
INTERIOR FUSE BOX
——y

y
()y
y

The exhaust emissions controls
include three systems: PGM-FI,
Ignition Timing Control, and Three
Way Catalytic Converter. These
three systems work together to
control the engine’s combustion and
minimize the amount of HC, CO, and
NOx that comes out the tailpipe. The
exhaust emissions control systems
are separate from the crankcase and
evaporative emissions control
systems.The PGM-FI System uses sequential
multiport f uel injection.
It has three subsystems: Air Intake,
Engine Control, and Fuel Control.
The Engine Control Module (ECM)
uses various sensors to determine
how much air is going into the
engine. It then controls how much
f uel to inject under all operating con-
ditions.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), dinitrogen
(N ), and water vapor.The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Honda replacement parts or their
equivalent f or repairs. Using lower
quality parts may increase the
emissions f rom your vehicle.
The emissions control systems are
covered by warranties separate f rom
the rest of your vehicle. Read your
warranty manual f or more inf orma-
tion.
2
2
Emissions Cont rols
T echnical Inf ormation
Exhaust Emissions Controls
Replacement Parts
PGM-FI Syst em
Three Way Catalytic Converter
Ignit ion T iming Cont rol Syst em
195
——y

y
()y
y

CONT INUED
BatteryCharging System ...........................
Indicator . 52, 177
............................
Jump Starting . 173 ..............................
Maintenance . 162
............................
Specif ications . 191
..............................
Bef ore Driving . 109
....................................
Belts,Seat .8,19
...........................
Beverage Holders . 83
..................................
Booster Seats . 44
Brakes
.............
Break-in, New Linings . 110
...........................................
Fluid . 144
.............
Light, Burned-out . 149, 150
.........................................
Parking . 80
.................
System Indicator . 53, 179
........................
Wear Indicators . 127
.............................
Braking System . 127
.................
Break-in, New Vehicle . 110
..
Brightness Control, Instruments . 62
........................
Brights, Headlights . 61
...
Accessories and Modif ications . 115
....................................
Accessories . 115
.
Additional Safety Precautions . 116
...........
Modif ying Your Vehicle . 116
ACCESSORY (Ignition Key
.......................................
Position) . 66
...............
Accessory Power Socket . 83
Adding
................................
Brake Fluid . 144
...............................
Clutch Fluid . 144
..........................
Engine Coolant . 141
..................................
Engine Oil . 138
...................
Transmission Fluid . 143
........
Windshield Washer Fluid . 142
Additional Inf ormation About .......................
Your Seat Belts . 19
......................
Lap/Shoulder Belt . 19
...............
Seat Belt Maintenance . 21
..
Seat Belt System Components . 19
Additional Inf ormation About
...........................
Your Airbags . 22
...
Additional Safety Precautions . 28
How the Side Airbag Of f
......................
Indicator Works . 27 How Your Front Airbags
.........................................
Work . 22
......
Airbag System Components . 22
....................
Additives, Engine Oil . 139
Adjustments
..........................
Head Restraints . 72
.........................................
Mirrors . 79
.............................................
Seats . 71
...........................
Steering Wheel . 63
.............................
Airbag (SRS) . 10, 22
................
Air Conditioning System . 86
............................................
Usage . 86
.........................
Air Outlets (Vents) . 88
.......................
Air Pressure, Tires . 157
.........................
Normal Driving . 157
......................................
Antif reeze . 141
Anti-thef t Steering Column
..............................................
Lock . 66
..................................
Audio System . 90
Index
A
B I
——y


y
()yy

.............
Halogen Headlight Bulbs . 145
Hatch
.................................
Opening the . 68
.................
Hazard Warning Button . 62
Headlights
............
Daytime Running Lights . 61
..................
High Beam Indicator . 53
...........
High Beams, Turning on . 61
............
Low Beams, Turning on . 61 ........................
Reminder Beeper . 61
........
Replacing Halogen Bulbs . 145
...................................
Turning on . 61
..............................
Head Restraints . 72
.......................
Heating and Cooling . 86
.............
High Altitude, Starting at . 123
.................
High-Low Beam Switch . 61
....................................
Hood Latch . 145
.......................
Hood, Opening the . 112
.................................
Closing the . 113
..............................................
Horn .3,59
.......
Hot Coolant, Warning about . 141
...........................
Hydraulic Clutch . 144
...
Identif ication Number, Vehicle . 188
If Your Vehicle Has to be
........................................
Towed . 185
Ignition ..............................................
Keys . 64
...........................................
Switch . 66
............
Timing Control System . 195
.........
Important Safety Precautions . 6
Indicator Lights, Instrument
.............................................
Panel . 51
Fluids
..........................................
Brake . 144
.........................................
Clutch . 144
..............
Manual Transmission . 143
..................
Windshield Washer . 142
FM Stereo Radio .....................................
Reception . 93
...........................
Folding Rear Seat . 74
..........................
Four-way Flashers . 62
Front End, Towing by
................
Emergency Wrecker . 185
Front Seat ......................................
Adjusting . 71
.........................................
Airbags . 22
.................................................
Fuel . 110
......................
Fill Door and Cap . 111
...........................................
Gauge . 57
................
Octane Requirement . 110
....................
Recommendations . 110
........................
Reserve Indicator . 54
........................
Tank, Filling the . 111
.....................
Fuses, Checking the . 181
...............
Gas Mileage, Improving . 114 .........................................
Gasoline . 110
...............
Fuel Reserve Indicator . 54
...........................................
Gauge . 57
................
Octane Requirement . 110
........................
Tank, Filling the . 111
................
Gas Station Procedures . 111
Gauges
Engine Coolant ...........................
Temperature . 58
...............................................
Fuel . 57
Gearshif t Lever Positions 5-speed Manual .........................
Transmission . 124
........................................
Glove Box . 83
Index
G H
I
IV
——y


y
()y

y

CONT INUED
.................
Jacking up the Vehicle . 168
.......................................
Jack, Tire . 167
................................
Jump Starting . 173
..................................................
Keys . 64
Indicators
..............
ABS (Anti-Lock Brake) . 54
Brake (Parking and Brake
............................
System) . 53, 179
.................................
Brake Lamp . 53
................
Charging System . 52, 177
.............................
Cruise Control . 54
DRL (Daytime Running
......................................
Lights) . 61
...................................
High Beam . 61
........
Key (Immobilizer System) . 55
......................................
Low Fuel . 54
................
Low Oil Pressure . 52, 177
...........................
Side Airbag Of f . 52
.........................................
SRS . 26, 52
Turn Signal and Hazard
.............................
Warning . 61, 62
..............................
Washer Level . 54
...............................
Inf ant Restraint . 34
...................
Inf lation, Proper Tire . 157
.........................
Normal Driving . 158
...................................
Inside Mirror . 79
.............................
Inspection, Tire . 159
............................
Instrument Panel . 51
........
Instrument Panel Brightness . 62
.................................
Interior Lights . 81 ........................................
Introduction . i
.......................
Label, Certif ication . 188
.................
Lane Change, Signaling . 61
..........................
Lap/Shoulder Belt . 19
..
Leaking of Exhaust into Vehicle . 47
Lights
....................
Bulb Replacement . 145
.......................................
Indicator . 51
.........................................
Parking . 80
..................................
Turn Signal . 61
.....................................
Load Limit . 118
......
LOCK (Ignition Key Position) . 66 Locks
.......
Anti-thef t Steering Column . 65
............................
Fuel Fill Door . 111
............................................
Hatch . 68
........................
Low Coolant Level . 114
.........................
Low Fuel Indicator . 54
...
Lower Gear, Downshif ting to a . 125
...
Low Oil Pressure Indicator . 52, 177
...
Lubricant Specif ications Chart . 190
...........
Luggage, Storing (Cargo) . 117
..................................
Maintenance . 129
...
Owner Maintenance Checks . 132
................................
Record . 135, 136
..........................................
Saf ety . 130
....................................
Schedule . 133
.
Malf unction Indicator Lamp . 53, 178
...................
Manual Transmission . 124
........
Manual Transmission Fluid . 143
...............................
Meters, Gauges . 57
..........................
Mirrors, Adjusting . 79
...............
Modif ying Your Vehicle . 116
.........................................
Moonroof . 78
Index
J K L M
V
——y

y
()y
y

..................
New Vehicle Break-in . 110
.....................
Normal Shif t Speeds . 125
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 188
...
Octane Requirement, Gasoline . 110
.........................................
Odometer . 57
...............................
Odometer, Trip . 57
Oil
........................
Change, How to . 139
......................
Change, When to . 133
......................
Checking Engine . 113
..............
Pressure Indicator . 52, 177
...........
ON (Ignition Key Position) . 66
Onboard Ref ueling Vapor
....................................
Recovery . 194
.........................
Opening the Hatch . 68
........................
Opening the Hood . 112
..............................
Outside Mirrors . 79
....................
Overheating, Engine . 174
.......
Owner Maintenance Checks . 132 ..............
Panel Brightness Control . 62
...........................................
Parking . 126
.................................
Parking Brake . 80
Parking Brake and Brake
.................
System Indicator . 53, 179
.................................
Parking Lights . 61
..
Parking Over Things that Burn . 196
.............................
PGM-FI System . 195
..........................
Power Door Locks . 67
.................
Power Socket Locations . 83
..............................
Power Windows . 76
.........
Pregnancy, Using Seat Belts . 17
............................
Protecting Adults . 11
...
Additional Safety Precautions . 18
.....
Advice f or Pregnant Women . 17
........................
Protecting Children . 29
.......................
Protecting Inf ants . 34
.......
Protecting Larger Children . 43
.........
Protecting Small Children . 35
Using Child Seats with
.....................................
Tethers . 39 ...................
Radiator Overheating . 174
......
Radio/Cassette Sound System . 90
..........................
Rear End Towing . 185
..
Rear Lights, Bulb Replacement . 149
............................
Rear Seat Access . 72
..........................
Rear Seat, Folding . 73
............................
Rear View Mirror . 79
.................
Rear Window Def ogger . 62
....................
Rear Window Washer . 60
.......................
Rear Window Wiper . 60
...............
Reclining the Seat Backs . 71
.......
Recommended Shif t Speeds . 125
.............................
Reminder Lights . 51
Replacement Inf ormation
................
Engine Oil and Filter . 139
..........................................
Fuses . 181
................................
Light Bulbs . 145
....................................
Schedule . 131
...........................................
Tires . 160
.............................
Wiper Blades . 154
Replacing Seat Belts Af ter a ............................................
Crash . 21
Reserve Tank, Engine
...............................
Coolant . 114, 141
Index
PR
O
N
VI
——y

y
()y
y