clutch HONDA CIVIC HATCHBACK 2004 7.G Owners Manual

You can increase the set cruising
speed in any of these ways:Press and hold the RESUME/
accel button. When you reach the
desired cruising speed, release the
button. You can decrease the set cruising
speed in any of these ways:
Press and hold the SET/decel
button. Release the button when
you reach the desired speed.
To slow down in very small
amounts, tap the SET/decel
button. Each time you do this,
your vehicle will slow down about
1 mph (1.6 km/h).
Push on the accelerator pedal.
Accelerate to the desired cruising
speed, and press the SET/decel
button.
To increase your speed in very
small amounts, tap the RESUME/
accel button. Each time you do
this, your vehicle will speed up
about 1 mph (1.6 km/h).
Thecruisecontrolmaynotholdthe
set speed when you are going up and
down hills. If your speed increases
going down a hill, use the brakes to
slow down. This will cancel the
cruise control. To resume the set
speed, press the RESUME/accel
button. The CRUISE CONTROL
indicator on the instrument panel will
come back on.
Tap the brake or clutch pedal
lightly with your f oot. The
CRUISE CONTROL indicator on
the instrument panel will go out.
When the vehicle slows to the
desired speed, press the SET/
decel button.
Cruise Control
Comf ort and Convenience Feat ures
Changing t he Set Speed
106
 — —y
  y
() y 
 y

Even with the cruise control turned
on, you can still use the accelerator
pedal to speed up f or passing. Af ter
completing the pass, take your foot
of f the accelerator pedal. The vehicle
will return to the set cruising speed.
Resting your f oot on the brake or
clutch pedal will cause the cruise
control to cancel.Pressing the Cruise Control Master
Switch turns the system completely
of f and erases the previous cruising
speed.
Youcancancelthecruisecontrolin
any of these ways:
Tap the brake or clutch pedal.
Push the CANCEL button on the
steering wheel.
Press the Cruise Control Master
Switch. When you push the CANCEL
button, or tap the brake or clutch
pedal, the system remembers the
previously-set cruising speed. To
return to that speed, accelerate to
above25mph(40km/h)andthen
press and release the RESUME/
accel button. The CRUISE
CONTROL indicator comes on.
The vehicle will accelerate to the
same cruising speed as bef ore.
Cruise Control
Comf ort and Convenience Feat ures
Cancelling t he Cruise Cont rol
107
 — —y
  y
() y 

 y

Apply the parking brake.
In cold weather, turn of f all
electrical accessories to reduce
the drain on the battery.
Push the clutch pedal down all the
way.
Without touching the accelerator
pedal, turn the ignition key to the
START (III) position. Do not hold
the key in START for more than
15 seconds at a time. If the engine
does not start right away, pause
f or at least 10 seconds bef ore
trying again.If the engine fails to start, press
the accelerator pedal all the way
downandholdittherewhile
starting to clear flooding. If the
engine still does not start, return
to step 5.
If the engine does not start within
15 seconds, or starts but stalls
right away, repeat step 4 with the
accelerator pedal pressed halfway
down. If the engine starts, release
pressure on the accelerator pedal
so the engine does not race.
1. 2. 3. 4. 5.
6.
Starting the Engine
Driving
123
NOTICE:
The engine is harder to start
in cold weather. Also, the thinner air
f ound at altitudes above 8,000 f eet
(2,400 meters) adds to this problem.
 — —y
 
y
() y 
y

The manual transmission is syn-
chronizedinallforwardgearsfor
smooth operation. It has a lockout so
you cannot shift directly from Fifth
to Reverse. When shif ting up or
down,makesureyoupushtheclutch
pedal down all the way, shift to the
next gear, and let the pedal up
gradually. When you are not shif ting,
do not rest your f oot on the clutch
pedal. This can cause your clutch to
wear out faster.Come to a full stop before you shift
into Reverse. You can damage the
transmission by trying to shift into
Reverse with the vehicle moving.
Push down the clutch pedal, and
pause f or a f ew seconds bef ore
shif ting into Reverse, or shif t into
one of the f orward gears f or a
moment. This stops the gears so
they won’t ‘‘grind.’’
When slowing down, you can get
extra braking f rom the engine by
shifting to a lower gear. This extra
braking can help you maintain a safe
speed and prevent your brakes f rom
overheating while going down a
steep hill. Bef ore downshif ting,
make sure the vehicle speed is low
enough that you will not activate the
engine speed limiter in the lower
gear. Make sure the engine speed
will not go into the tachometer’s red
zone in the lower gear bef ore
downshif ting.
5-speed Manual T ransmission
Driving
124 Rapid slowing or speeding-up
can cause loss of control on
slippery surfaces. If you crash,
you can be injured.
Use extra care when driving on
slippery surfaces.
 — —y
 y
() y 
y

This section explains why it is
important to keep your vehicle well
maintained and how to f ollow basic
maintenance saf ety precautions.
This section also includes
Maintenance Schedules f or normal
driving and severe driving conditions,
a Maintenance Record, and instruc-
tions f or simple maintenance tasks
you may want to take care of
yourself .
If you have the skills and tools to per-
f orm more complex maintenance
tasks on your Honda, you may want
to purchase the Service Manual. See
page f or inf ormation on how to
obtain a copy, or see your Honda
dealer.......................
Maintenance Saf ety . 130
.................
Maintenance Schedule . 131
....................
Maintenance Record . 135
..............................
Fluid Locations . 137
........................
Adding Engine Oil . 138
.........
Changing the Oil and Filter . 139
..............................
Engine Coolant . 141
....................
Windshield Washers . 142
.......................
Transmission Fluid . 143
....................................
Brake Fluid . 144
...................................
Clutch Fluid . 144
....................................
Hood Latch . 145
.............................................
Lights . 145
................
Cleaning the Seat Belts . 153
.....................................
Floor Mats . 153
.................................
Wiper Blades . 154
...............................................
Tires . 157
...................
Checking the Battery . 162
.............................
Vehicle Storage . 163
203
Maintenance
Maint enance
129
 — —y
  y
() y 
y

Fluid Locations
Maint enance137
ENGINE OIL
DIPSTICK
(Orange handle)
WASHER FLUID
(Blue cap)
ENGINE
COOLANT
RESERVOIR RADIATOR CAP BRAKE FLUID
(Gray cap)
CLUTCH FLUID
(Gray cap)
ENGINE OIL
FILL CAP
 — —y
   y
() y 
 y

The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If it is not, add
brake f luid to bring it up to that level.
Use the same fluid specified for the
brake system.
Low f luid level can indicate a leak in
the clutch system. Have this system
inspected as soon as possible.
Brake f luid marked DOT 5 is not
compatible with your vehicle’s
braking system and can cause
extensive damage.
Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement. Using any non-Honda
brake fluid can cause corrosion and
decrease the lif e of the system. Have
the brake system f lushed and ref illed
with Honda Heavy Duty Brake Fluid
DOT 3 as soon as possible.
Replace it according to the time
recommendation in the maintenance
schedule.
Check the brake f luid level in the
reservoirs monthly.
The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If the level is at or
below the MIN mark, your brake
system needs attention. Have the
brake system inspected f or leaks or
worn brake pads.Clutch System
Brake System
Maint enance
Brake Fluid, Clutch Fluid
144 MAX
MIN
MAX
MIN
 — —y
 
y
() y 
y

You hear nothing, or almost
nothing. The engine’s starter
motor does not operate at all, or
operates very slowly.
You can hear the starter motor
operating normally, or the starter
motor sounds like it is spinning
f aster than normal, but the engine
does not start up and run.When you turn the ignition switch to
START (III), you do not hear the
normal noise of the engine trying to
start. You may hear a clicking sound
or series of clicks, or nothing at all.
Turn the ignition switch to START
(III). If the headlights do not dim,
check the condition of the f uses. If
thefusesareOK,thereis
probably something wrong with
the electrical circuit f or the
ignition switch or starter motor.
You will need a qualif ied
technician to determine the
problem (see
on page ).
If the headlights dim noticeably or
go out when you try to start the
engine, either the battery is dis-
charged or the connections are
corroded. Check the condition of
the battery and terminal connec-
tions (see page ). You can
then try jump starting the vehicle
f rom a booster battery (see page
).
Turn the ignition switch to ON (II).
Turn on the headlights, and check
their brightness. If the headlights
are very dim or don’t light at all,
the battery is discharged. See
on page .
Check the transmission interlock.
The clutch pedal must be pushed
all the way to the f loor or the
starter will not operate.
Check these things:
Diagnosing why the engine won’t
start f alls into two areas, depending
on what you hear when you turn the
key to START (III):
173185
162
173
Nothing Happens or the Starter
Motor Operates Very Slowly
Emergency T owing
Jump Starting T aking Care of t he Unexpect ed
If theEngineWon’tStart
171
 — —y


y
() y 
y

CONT INUED
BatteryCharging System ...........................
Indicator . 52, 177
............................
Jump Starting . 173 ..............................
Maintenance . 162
............................
Specif ications . 191
..............................
Bef ore Driving . 109
....................................
Belts,Seat .8,19
...........................
Beverage Holders . 83
..................................
Booster Seats . 44
Brakes
.............
Break-in, New Linings . 110
...........................................
Fluid . 144
.............
Light, Burned-out . 149, 150
.........................................
Parking . 80
.................
System Indicator . 53, 179
........................
Wear Indicators . 127
.............................
Braking System . 127
.................
Break-in, New Vehicle . 110
..
Brightness Control, Instruments . 62
........................
Brights, Headlights . 61
...
Accessories and Modif ications . 115
....................................
Accessories . 115
.
Additional Safety Precautions . 116
...........
Modif ying Your Vehicle . 116
ACCESSORY (Ignition Key
.......................................
Position) . 66
...............
Accessory Power Socket . 83
Adding
................................
Brake Fluid . 144
...............................
Clutch Fluid . 144
..........................
Engine Coolant . 141
..................................
Engine Oil . 138
...................
Transmission Fluid . 143
........
Windshield Washer Fluid . 142
Additional Inf ormation About .......................
Your Seat Belts . 19
......................
Lap/Shoulder Belt . 19
...............
Seat Belt Maintenance . 21
..
Seat Belt System Components . 19
Additional Inf ormation About
...........................
Your Airbags . 22
...
Additional Safety Precautions . 28
How the Side Airbag Of f
......................
Indicator Works . 27 How Your Front Airbags
.........................................
Work . 22
......
Airbag System Components . 22
....................
Additives, Engine Oil . 139
Adjustments
..........................
Head Restraints . 72
.........................................
Mirrors . 79
.............................................
Seats . 71
...........................
Steering Wheel . 63
.............................
Airbag (SRS) . 10, 22
................
Air Conditioning System . 86
............................................
Usage . 86
.........................
Air Outlets (Vents) . 88
.......................
Air Pressure, Tires . 157
.........................
Normal Driving . 157
......................................
Antif reeze . 141
Anti-thef t Steering Column
..............................................
Lock . 66
..................................
Audio System . 90
Index
A
B I
 — —y


y
() y  y

Bulb Replacement..........................
Back-up Lights . 149
..................................
Stop Light . 149
................
Front Parking Lights . 148
........
Front Side Marker Lights . 147
.................................
Headlights . 145
.........
High-mount Brake Light . 150
.................
License Plate Lights . 152
..................
Side Marker Lights . 147
...........
Side Turn Signal Lights . 151
............................
Specif ications . 191
....................
Turn Signal Lights . 146
..............................
Bulbs, Halogen . 145
.........
Cables, Jump Starting With . 173
............................
Capacities Chart . 190
.............
Carbon Monoxide Hazard . 47
...........................
Cargo Area Cover . 75
........................
Cargo, . 117
Cassette Player
............................................
Care . 102
...................................
Operation . 101
..............
CAUTION, Explanation of . ii
...........................................
CD Care . 97 .....................................
CD Changer . 96
.........
CD Changer Error Message . 99
.........................
CD Error Message . 98
.........................................
CD Player . 96
........................
Certif ication Label . 188
...................................
Chains, tires . 161
Change Oil
........................................
How to . 139
......................................
When to . 133
....................
Changing a Flat Tire . 167
...
Charging System Indicator . 52, 177
Checking
.....................
Battery Condition . 162
................................
Brake Fluid . 144
...............................
Clutch Fluid . 144
..........................
Engine Coolant . 114
..................................
Engine Oil . 113
..........................................
Fuses . 181
...................
Transmission Fluid . 143
............
Checklist, Bef ore Driving . 122
.....................................
Child Saf ety . 29
..............................
Booster Seats . 44
...................................
Child Seats . 36
.....
Important Saf ety Reminders . 31
..........................................
Inf ants . 34
............................
Large Children . 43 .........................................
LATCH . 38
......................
Risks with Airbags . 30
.............................
Small Children . 35
.........................................
Tethers . 39
.........
Where Should a Child Sit? . 30
..............................................
Clock . 104
.........................
Clock, Setting the . 104
...................................
Clutch Fluid . 144
........................
CO in the Exhaust . 194
............
Cold Weather, Starting in . 123
.......................
Compact Spare . 166
...................
Console Compartment . 83
.............
Controls, Instruments and . 49
Coolant
........................................
Adding . 141
....................................
Checking . 114
.........................
Proper Solution . 141
...................
Temperature Gauge . 57
Crankcase Emissions Control ........................................
System . 194
...............................
Cruise Control . 105
........
Cruise Control Indicator . 54, 105
.....................................
Cup Holders . 83
how to carry tire
Index
C
II
 — —y


y
() y  y