Service schedule HONDA CR-V 2002 RD4-RD7 / 2.G User Guide

µ
Î
Ì
ÌÌÎ
Maint enance240
Service at the indicated distance or time whichever comes first. miles x 1,000
km x 1,000
months
Replace every 5,000 miles (8,000 km) or 6 monthsCheck oil and coolant at each fuel stop
10
16
50
8070
112 110
176
At 120,000 miles (192,000 km) or 10 years,
then every 60,000 miles (96,000 km) or 5 years Every 3 years (independent of mileage)
At 60,000 miles (96,000 km) or 3 years, then every 30,000 miles
(48,000 km) or 2 years
20
32
30
4840
64 60
9680
128 100
160120
192
90
144
Every 110,000 miles (176,000 km) or 7 years
Inspect every 110,000 miles (176,000 km), otherwise adjust only if noisy Every 110,000 miles (176,000 km)
Every 15,000 miles (24,000 km) in dusty conditions,
otherwise use normal schedule
Service the following items at the recommended intervals.
See information on maintenance and emissions warranty, last column, page . See dust and pollen filter on page for replacement information under special driving conditions.
Check engine oil and coolant
Replace engine oil
Rotate tires (Check tire inflation and condition at least once per month)
Replace engine oil filter
Inspect front and rear brakes
Lubricate all hinges, locks, and latches
Visually inspect the following items:
Tie rod ends, steering gear box and boots
Suspension components
Driveshaft boots
Check parking brake adjustment
Visually inspect the following items: Brake hoses and lines (including ABS)
All fluid levels and condition of fluidsExhaust system, Fuel lines and connections
Lights and controls, Vehicle underbody
Inspect and adjust drive belts
Replace dust and pollen filter
Replace transmission fluid
Replace rear differential fluid (4WD)
Replace air cleaner element
Replace spark plugs
Inspect valve clearance
Inspect idle speed
Replace engine coolant
Replace brake fluid 24
4872
12 3660
M/T
A/T
:
: 237
275
Maintenance Schedule for Severe Conditions

µµ
Ø
Ø
Ø
Ø
Ø Ø
Ø
Ø
Ø
Ø
Ø
Ø
Ø
Ø
Ø
Ø
Ø
Ø
Ø
Ø
Ø
Ø
Ø
Ì
Ì
Î
CONT INUED
Maint enance241
U.S. Owners
Canadian Owners A, B, C, D, E
A
B
C
D
E
Refer to page to determine which schedule to use.
Use the Maintenance Schedule for Severe Conditions.
Service at the indicated distance or time, whichever comes first. Do the items in
as required for each distance/time.
5,000 mi/8,000 km
10,000 mi/16,000 km/1 yr
15,000 mi/24,000 km
20,000 mi/32,000 km/1 yr
25,000 mi/40,000 km
30,000 mi/48,000 km
30,000 mi/48,000 km/2 yrs
35,000 mi/56,000 km
40,000 mi/64,000 km/2 yrs
45,000 mi/72,000 km
3yrs
50,000 mi/80,000 km/3 yrs
55,000 mi/88,000 km
60,000 mi/96,000 km
60,000 mi/96,000 km/3 yrs
65,000 mi/104,000 km
70,000 mi/112,000 km/4 yrs
75,000 mi/120,000 km
80,000 mi/128,000 km/4 yrs
85,000 mi/136,000 km
90,000 mi/144,000 km
90,000 mi/144,000 km/5 yrs Do items in A.
Do items in A, B.
Do items in A, E.
DoitemsinA,B,C.
Do items in A.
Do item in E.
DoitemsinA,B,D.
Do items in A.
DoitemsinA,B,C.
Do items in A, E.
Replace brake fluid (independent of mileage).
Do items in A, B.
Do items in A.
Do item in E. Replace transmission fluid (M/T).
Replace transmission fluid (A/T).
DoitemsinA,B,C,D.
Do items in A.
Do items in A, B.
Do items in A, E.
DoitemsinA,B,C.
Do items in A.
Do item in E. Replace transmission fluid (A/T).
Replace rear differential fluid (4WD).
DoitemsinA,B,D. Replace engine oil.
Replace engine oil filter.
Inspect front and rear brakes.
Rotate tires (follow pattern on page
281).
Lubricate all hinges, locks, and latches with
multipurpose grease.
Inspect tie rod ends, steering gear box and boots.
Inspect suspension components.
Inspect driveshaft boots.
Check parking brake adjustment.
Inspect brake hoses and lines (including ABS).
Check all fluid levels, condition of fluids, and check
for leaks. Inspect exhaust system.
Inspect fuel lines and connections.
Check all lights.
Inspect the underbody.
Inspect and adjust drive belts.
Replace dust and pollen filter .
Replace air cleaner element every 15,000 mi/
24,000 km (independent of time) under dusty
conditions, otherwise use Normal Conditions
schedule.
236Maintenance Schedule for Severe Conditions (listed by distance/time)

Remove the oil f ilter and let the
remaining oil drain. A special
wrench (available from your
Honda dealer) is required to
remove the f ilter.
Install a new oil f ilter according to
instructions that come with it.
Run the engine until it reaches
normal operating temperature,
then shut it off.
Open the hood and remove the
engine oil f ill cap. Remove the oil
drain bolt and washer f rom the
bottom of the engine. Drain the oil
into an appropriate container.
Always change the oil and f ilter
accordingtothetimeanddistance
(miles/kilometers) recommenda-
tions in the maintenance schedule.
The oil and f ilter collect contami-
nants that can damage your engine if
they are not removed regularly.
Changing the oil and f ilter requires
special tools and access f rom
underneath the vehicle. The vehicle
should be raised on a service station-
type hydraulic lif t f or this service.
Unless you have the knowledge and
proper equipment, you should have
this maintenance done by a skilled
mechanic.
1.
2.
4. 3.
CONT INUED
Changing the Oil and Filter
Engine Oil
Maint enance249
O OIILL D
DR
RAA I
INN B
BOOL LTT W
WA
AS
SHH E
ER
R
O
OIILL F
FIILLT T E
ER
R

Insert the dipstick all the way back
into the transmission securely as
shown in the illustration.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
Check the f luid level with the
transmission at normal operating
temperature and the vehicle sitting
on level ground. Remove the
transmission f iller bolt and caref ully
f eel inside the bolt hole with your
f inger. The f luid level should be up
to the edge of the bolt hole. If it is
not, add Honda Manual
Transmission Fluid (MTF) until it
starts to run out of the hole.The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule. If Honda MTF is not available, you
may use an API service SG, SH or SJ
grade motor oil with a viscosity of
SAE 10W-30 or 10W-40 as a
temporary replacement. An SG
grade is pref erred, but an SH or SJ
grade may be used if SG is not
available. However, motor oil does
not contain the proper additives and
continued use can cause stif f er
shif ting. Replace as soon as it is
convenient. Put a new washer on the f iller bolt,
then reinstall the f iller bolt and
tighten it securely.
6.
5-speed Manual Transmission
T ransmission Fluid
Maint enance261
F FIILLL LEE R
R B
BOOL LTT
C
Co or
rrreec ctt l
leev veell
W
WA
AS
SHH E
ER
R

ÎÎ
CONT INUED
Replacement Inf ormation
.................
Air Cleaner Element . 265
..............
Dust and Pollen Filter . 275
..........................
Engine Coolant .253
................
Engine Oil and Filter . 249
..........................................
Fuses .331
................................
Light Bulbs .287
....................................
Schedule .238
................................
Spark Plugs .267
...........................................
Tires .282
.............................
Wiper Blades .271
Replacing Seat Belts Af ter a ............................................
Crash .53
Reserve Tank, Engine ...............................
Coolant .189, 251
...............................
Restraint, Child .24
..................
Reverse Gear Position . 206
...........................
Reverse Lockout .209
................................
Rotation, Tire .281
..................................
Saf ety Belts .8, 50
.........
Safety Defects, Reporting . 356
...........
Saf ety Checklist, Pre-Drive . 12.................................
Saf ety Features .7
.........................................
Airbags .10
..................................
Door Locks .11
..........................
Head Restraints .11
.......................................
Seat Belts .8
.....................
Seats & Seat-Backs .11
.............
Saf ety Labels, Location of . 61
...............................
Saf ety Messages . ii
.....................................
Seat Belts .8, 50
...............
Additional Information . 50
.....
Advice f or Pregnant Women . 21
Automatic Seat Belt ...............................
Tensioners .52
.....................................
Cleaning .302
...................
Detachable Anchor . 108
................
Lap/Shoulder Belt . 17,50
................................
Maintenance .53
Reminder Light and ................................
Beeper .50, 67
................................
Replacement .53
...................
System Components . 50
...............
Use During Pregnancy . 21
...
Wearing a Lap/Shoulder Belt . 17
..................................
Seat Heaters .109
........................
Seats, Adjusting the .97
...............................
Serial Number .340 ...........................
Service Intervals .238
...........................
Service Manual .357
.........
Service Station Procedures . 185
..................
Setting the Clock . 144,162
.....
Shif t Lever Position Indicator . 204
........................
Shif t Lock Release .209
..............................
Side Airbags .10, 56
....................
Cutof f Indicator .58, 67
Side Marker Lights, Bulb ..............................
Replacement .288
...............................
Signaling Turns .77
.....................................
Snow Tires .283
...................
Solvent-type Cleaners . 298
................................
Sound System .137
......................................
Spare Tire .308
................
Spark Plugs, Replacing . 267
....................
Specif ications Charts . 342
................................
Speed Control .179
...................................
Speedometer .72
.......................................
Spotlights .124
Index
S
VII