fluid HONDA CR-V 2002 RD4-RD7 / 2.G User Guide

Put a new washer on the f iller bolt,
then reinstall the f iller bolt and
tighten it securely.
Only use Honda Dual Pump Fluid.
Do not use Automatic Transmission
Fluid (ATF).
The rear dif f erential should be
drained and ref illed with new f luid
accordingtothetimeanddistance
recommendations in the mainte-
nance schedule.
Check the f luid level with the rear
dif f erential at normal operating
temperature and the vehicle sitting
on level ground. Remove the
dif f erential f luid f iller bolt and
washer and caref ully f eel inside the
bolt hole with your f inger. The f luid
level should be up to the edge of the
bolt hole. If it is not, slowly add
Honda Dual Pump Fluid until it
starts to run out of the hole.
Rear Dif f erential Fluid
Maint enance
4WD models only
262
C Co or
rrreec ctt
l
le ev veell W
WA
AS
SHH E
ER
R
F
FI ILLL LEE R
R B
BOOL LTT

The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If the level is at or
below the MIN mark, your brake
system needs attention. Have the
brake system inspected f or leaks or
worn brake pads.
Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement. However, the use of
any non-Honda brake fluid can cause
corrosion and decrease the lif e of the
system. Have the brake system
f lushed and ref illed with Honda
Heavy Duty Brake Fluid DOT 3 as
soon as possible.
Check the f luid level in the reser-
voirs monthly. There are up to two
reservoirs, depending on the model.
They are:
Brake f luid reservoir (all models)
Clutch f luid reservoir
(manual transmission only)
The brake f luid should be replaced
according to the time recommenda-
tion in the maintenance schedule. Brake f luid marked DOT 5 is not
compatible with your vehicle’s
braking system and can cause
extensive damage.Brake System
Brake and Clutch Fluid
Maint enance263
M M
A
AX
X
M
MI
INN

Always use Honda Power Steering
Fluid. If it is not available, you may
use another power steering f luid as
an emergency replacement.
However, continued use can cause
increased wear and poor steering in
cold weather. Have the power
steering system f lushed and ref illed
with Honda PSF as soon as possible.
A low power steering f luid level can
indicate a leak in the system. Check
the f luid level f requently and have
the system inspected as soon as
possible.
Check the level when the engine is
cold. Look at the side of the
reservoir. The f luid should be
between the UPPER LEVEL and
LOWER LEVEL. If it is below the
LOWER LEVEL, add power steering
f luid to the UPPER LEVEL.
The f luid should be between the
MIN and MAX marks on the side of
the reservoir. If it is not, add brake
f luid to bring it up to that level. Use
the same f luid specif ied f or the
brake system.
Low f luid level can indicate a leak in
the clutch system. Have this system
inspected as soon as possible. Power Steering
Clutch System
Maint enance
Brake and Clutch Fluid, Power Steering
264
L LO OW WE ER
R L
LEE V
V E
EL
L
M
M
A
AX
X U
UPPP
PE
ER
R L
LEE V
V E
EL
L
M
M I
INN
T urning the steering wheel to f ull lef t
or right lock and holding it there can
damage the power steering pump.

ÎÎ
ÎÎ
Î
Specif ications
T echnical Inf ormation342
Dimensions
Weights
Engine
Capacities
178.6 in (4,537 mm)
70.2 in (1,782 mm)
66.2 in (1,682 mm)
103.1 in (2,620 mm)
60.4 in (1,533 mm)
60.6 in (1,538 mm)
3.43 x 3.90 in (87.0 x 99.0 mm) 144 cu-in (2,354 cm
)
9.6 : 1
15.3 US gal (58
, 12.8 Imp gal)
4.4 US qt (4.2
, 3.7 Imp qt)
4.2 US qt (4.0, 3.5 Imp qt)
5.6 US qt (5.3, 4.7 Imp qt) 1.43 US gal (5.4
, 1.19 Imp gal)
1.88 US gal (7.1, 1.56 Imp gal)
1.45 US gal (5.5
, 1.21 Imp gal)
1.90 US gal (7.2, 1.58 Imp gal)
3.3 US qt (3.1
, 2.7 Imp qt)
3.1 US qt (2.9, 2.6 Imp qt)
7.6 US qt (7.2
, 6.3 Imp qt)
6.9 US qt (6.5, 5.7 Imp qt)
2.0 US qt (1.9, 1.7 Imp qt)
2.4 US qt (2.3, 2.0 Imp qt)
1.1 US qt (1.0
, 0.9 Imp qt)
1.3 US qt (1.2, 1.1 Imp qt)
Length
Width
Height
Wheelbase
Track
Gross vehicle weight rating See the certification label attached
to the driver’s doorjamb.
Type
BorexStroke
Displacement
Compression ratio
Spark plugs
Fuel tank
Engine oil See spark plug maintenance
section page 268 .Water cooled 4-stroke DOHC
VTEC 4-cylinder gasoline engine
4.8 US qt (4.5
, 4.0 Imp qt)
2.6 US qt (2.5, 2.2 Imp qt)
2.2 US qt (2.1
, 1.8 Imp qt)
Engine
coolant
Automatic
transmission
fluid
Manual
transmission
fluid
Rear
differential
fluid (4WD)
Windshield
washer
reservoir
Excluding the oil remaining in the engine.
Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity:
0.16 US gal (0.6
, 0.13 Imp gal)
Approx.
Front
Rear
Change
Without filter
Total 1:
2:Change
Total
Change
Total
Change
4WD
2WD
Total 4WD
2WD
Change
Total
Change
Total
U.S. Vehicles
Canada
Vehicles 4WD
2WD
Automatic Transmission
Manual Transmission
1 2
2
Including filter

CONT INUED
...
Accessories and Modif ications . 191
................................
Accessories .191
.
Additional Safety Precautions . 192
............................
Modif ications .192
ACCESSORY (Ignition Key .......................................
Position) .87
............
Accessory Power Sockets . 122
....................
Additives, Engine Oil . 248
.............................
Airbag (SRS) .10, 54
.....................
Air Cleaner Element .265
..............
Air Conditioning System . 128
..............................
Maintenance .274
.........................................
Usage .128
.......................
Air Outlets (Vents) .130
.......................
Air Pressure, Tires .278
..................
High Speed Driving . 279
.........................
Normal Driving .279
.......................
Alcohol in Gasoline .346
......................................
Antif reeze .251
Anti-lock Brakes (ABS) ...............................
Indicator .68, 214
...................................
Operation .212
..............
Anti-thef t, Audio System . 178Anti-thef t Steering Column
..............................................
Lock .87
..........................
Appearance Care .297
................................
Audio System .137
...
Automatic Seat Belt Tensioners . 52
.............
Automatic Speed Control . 179
..............
Automatic Transmission . 204
..........................
Capacity,Fluid .342
...............
Checking Fluid Level . 260
.......................................
Shif ting .205
.
Shif t Lever Position Indicator . 204
................
Shif t Lever Positions . 205
....................
Shif t Lock Release . 209
Battery Charging System ...........................
Indicator .66, 326
............................
Jump Starting .320
..............................
Maintenance .269
............................
Specif ications .343
..............................
Bef ore Driving .183
....................................
Belts,Seat .8,50
.........................
Beverage Holders .116
.................................
Body Repairs .305 Brakes
...........
Anti-lock System (ABS) . 212
.............
Break-in, New Linings . 184
....................
Bulb Replacement .290
...........................................
Fluid .263
.........................................
Parking .82
.................
System Indicator . 66,329
........................
Wear Indicators .211
.............................
Braking System .211
.................
Break-in, New Vehicle . 184
..
Brightness Control, Instruments . 77
........................
Brights, Headlights .76
.................................
Built-in Table .117
Bulb Replacement ..........................
Back-up Lights .290
..............................
Brake Lights .290
......................
Cargo Area Light .293
..............................
Ceiling Light .293
................
Front Parking Lights . 289
........
Front Side Marker Lights . 288
.................................
Headlights .287
.........
High-mount Brake Light . 292
...........................
Interior Lights .293
...................
License Plate Light . 291
Index
A
B
I

ÎBulb Replacement.........
Rear Side Marker Lights . 290
............................
Specif ications .343
...................................
Spotlights .293
....................
Turn Signal Lights . 288
..............................
Bulbs, Halogen .287
................
DANGER, Explanation of . ii
.......................................
Dashboard .64
................
Daytime Running Lights . 77
............
Def ects, Reporting Saf ety . 356
........................
Def og and Def rost .134
................
Def ogger, Rear Window . 81
..............
Def rosting the Windows . 134
.......................
Detachable Anchor .108
....................................
Dimensions .342
...............
Dimming the Headlights . 76
............................
Capacities Chart .342
.............
Carbon Monoxide Hazard . 60
..........................
Cargo Area Light .125
.................................
Cargo Hooks .195
.............................
Carrying Cargo .193
Cassette Player ............................................
Care .168
...........................
Operation .151, 164
..............
CAUTION, Explanation of . ii
..........................
CD Changer .149, 169
.......................................
CD Player .146
...............................
Center Pocket .119
..................................
Center Table .115
........................
Certif ication Label .340
............................................
Chains .284
....................
Changing a Flat Tire .308
............
Changing Engine Coolant . 253.................................
Changing Oil .249
........................................
How to .249
......................................
When to .238
...
Charging System Indicator . 66,326
............
Checklist, Bef ore Driving . 199
.....................................
Child Saf ety .24
.......................................
Child Seats .29
......
LATCH Anchorage System . 48
...........................
Lower Anchors .48
............
Tether Anchorage Point . 46
..................
Childproof Door Locks . 93
....................
Cleaner Element, Air . 265
Cleaning ....................
Aluminum Wheels .299
...................................
Carpeting .301
......................................
Exterior .298
.........................................
Fabric .302
.......................................
Interior .301
.......................................
Leather .302
...................................
Seat Belts .302
...........................................
Vinyl .302
....................................
Windows .303
.................
Clock, Setting the . 144,162
...................................
Clutch Fluid .264
........................
CO in the Exhaust .348
............
Cold Weather, Starting in . 201...............
Consumer Inf ormation . 354
.............
Controls, Instruments and . 63
Coolant ........................................
Adding .251
....................................
Checking .189
.........................
Proper Solution .251
...................................
Replacing .253
...................
Temperature Gauge . 74
....................
Corrosion Protection .304
Crankcase Emissions Control ........................................
System .348
............
Cruise Control Operation . 179
..........
Customer Relations Of f ice . 354
Index
C
D
II

CONT INUED
..............................
Economy, Fuel .190
............
Emergencies on the Road . 307
.............
Battery, Jump Starting . 320
...........
Brake System Indicator . 329................
Changing a Flat Tire . 308
.....
Charging System Indicator . 326
..................
Checking the Fuses . 332
.....
Low Oil Pressure Indicator . 325
...
Malf unction Indicator Lamp . 327
...
Manually Closing Moonroof . 330
..................
Overheated Engine . 323
...........................
Emergency Brake .82
......................
Emergency Flashers .81
......................
Emergency Towing .337
.......................
Emissions Controls .348
.............
Emissions Testing, State . 351
Engine ....
Coolant Temperature Gauge . 74
...................................
Drive Belt .277
......
Engine Speed Limiter . 203,208
Malf unction Indicator ................................
Lamp .66, 327
........
Oil Pressure Indicator . 66,325
..............
Oil, What Kind to Use . 247
...............................
Overheating .323
............................
Specif ications .342
.......................................
Starting .200
......................
Ethanol in Gasoline .346
.
Evaporative Emissions Controls . 348
...............................
Exhaust Fumes .60 Expectant Mothers, Use of Seat
........................................
Belts by .21
..................
Exterior,Cleaningthe .298
............................
Fabric, Cleaning .302
...................................
Fan, Interior .128
Features, Comfort and ..............................
Convenience .127
....................
Filling the Fuel Tank . 185
Filters ................................
Air Cleaner .265
.........................
Dust and Pollen .275
...............................................
Oil .249
5-speed Manual Transmission ...............
Checking Fluid Level . 261
................................
Shif ting the .202
.............
Flashers, Hazard Warning . 81
...................
Flat Tire, Changing a . 308
Dipstick
..........
Automatic Transmission . 260
..................................
Engine Oil .188
..........................
Directional Signals .77
........
Disc Brake Wear Indicators . 211
.....................
Disposal of Used Oil .250
Doors ..............
Locking and Unlocking . 88
......................
Power Door Locks .88
..........
DOT Tire Quality Grading . 344
Downshif ting, 5-speed Manual .............................
Transmission .202
.......................................
Drive Belt .277
...........................................
Driving .197
....................................
Economy .190
.........................
In Bad Weather .215
................
In Foreign Countries . 347
........................
Driving Guidelines .198
..................
Dust and Pollen Filter . 275
Index
E F
III

Fluids..........
Automatic Transmission . 260
..........................................
Brake .263
.........................................
Clutch .264
..............
Manual Transmission . 261
..........................
Power Steering .264
.......................
Rear Differential .262
..................
Windshield Washer . 258
FM Stereo Radio ...................................
Reception .161
.........................
Folding Rear Seat .104
.....
Foreign Countries, Driving in . 347
..........................
Four-way Flashers .81
............................
Front Airbags .10, 54
.................................................
Fuel .184
......................
Fill Door and Cap .185
...........................................
Gauge .74
................
Octane Requirement . 184
...............................
Oxygenated .346
........................
Reserve Indicator .69
........................
Tank, Filling the .185
.....................
Fuses, Checking the .331
...............
Gas Mileage, Improving . 190..........................................
Gasohol .346
.........................................
Gasoline .184
...............
Fuel Reserve Indicator . 69
...........................................
Gauge .74
................
Octane Requirement . 184
........................
Tank, Filling the .185
................
Gas Station Procedures . 185
Gauges ...
Engine Coolant Temperature . 74
...............................................
Fuel .74
...............................
Speedometer .72
.................................
Tachometer .72
Gearshif t Lever Positions ..........
Automatic Transmission . 204
5-speed Manual .........................
Transmission .203
..............................
Glass Cleaning .303
........................................
Glove Box .96
.............
Halogen Headlight Bulbs . 287
.....................................
Hatch Glass .94
..............
Hazard Warning Flashers . 81
Headlights ........................................
Aiming .287 ............
Daytime Running Lights . 77
..................
High Beam Indicator . 69
........................
Reminder Beeper .76
........
Replacing Halogen Bulbs . 287
...................................
Turning on .76
..............................
Head Restraints .99
.....................
Heating and Cooling .128
.............
High Altitude, Starting at . 201
.................
High-Low Beam Switch . 76
..............
High-mount Brake Light . 292
....................................
Hood Latch .266
.......................
Hood, Opening the .186
..............................................
Horn .3,75
...........................
Hydraulic Clutch .264
.................................
Hydroplaning .216
...
Identif ication Number, Vehicle . 340
Ignition ..............................................
Keys .84
...........................................
Switch .86
............
Timing Control System . 349
........................
Immobilizer System .85
.........
Important Safety Precautions . 6
.........
Indicators, Instrument Panel . 65
Index
G H
I
IV

CONT INUED
.......................
Label, Certif ication .340
.................
Lane Change, Signaling . 77
..................
Lap/Shoulder Belts . 17,50
...........
LATCH Anchorage System . 48
Lights ....................
Bulb Replacement .287
.......................................
Indicator .65
.........................................
Parking .76
..................................
Turn Signal .77
.....................................
Load Limit .194
......
LOCK (Ignition Key Position) . 87
Locks .......
Anti-thef t Steering Column . 87
............................
Fuel Fill Door .185
....................................
Glove Box .96
.................................
Power Door .88
........................................
Tailgate .93
........................
Low Coolant Level .189
.........................
Low Fuel Indicator .69
...
Low Oil Pressure Indicator . 66,325
................................
Lower Anchors .48
...
Lubricant Specif ications Chart . 342
.........................................
Luggage .193 ..................................
Maintenance .233
...
Owner Maintenance Checks . 245
.................................
Record .243-244
......................
Required Indicator .70
..........................................
Saf ety .234
.............................
Schedule .238-242
.
Malf unction Indicator Lamp . 66,327
...................
Manual Transmission . 202
........
Manual Transmission Fluid . 261
.........................
Meters, Gauges .65, 72
...................
Methanol in Gasoline . 346
........................
Mirrors, Adjusting .114
.......................................
Moonroof .113
......................
Closing Manually .330
...................................
Operation .113
...............................
Inf ant Restraint .34
......................................
Inf ant Seats .34
......
LATCH Anchorage System . 48
...........................
Lower Anchors .48
..........
Tether Anchorage Points . 46
...................
Inf lation, Proper Tire . 278
.................
High Speed Driving . 279
.........................
Normal Driving .279
.................................
Inside Mirror .114
.............................
Inspection, Tire .280
............................
Instrument Panel .65
........
Instrument Panel Brightness . 77
...........................
Interior Cleaning .301
...............................
Interior Lights .124
........................................
Introduction .i
..................................................
Keys .84
..................
Jacking up the vehicle . 312
.......................................
Jack, Tire .309
................................
Jump Starting .320
Index
LM
K J
V

...................
Neutral Gear Position . 206
..................
New Vehicle Break-in . 184
.....................
Normal Shif t Speeds .203
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 340
...................
Radiator Overheating . 323
Radio/Cassette/CD Sound ........................................
System .137
...........................
Readiness Codes .328
.................
Rear Dif f erential Fluid . 262
..
Rear Lights, Bulb Replacement . 290
........................
Rear Seat, Folding .104
..........................
Rear View Mirror .114
.................
Rear Window Def ogger . 81
.
Rear Window Wiper and Washer . 80
...............
Reclining the Seat Backs . 97
.......
Recommended Shif t Speeds . 203
.............................
Reminder Lights .65
.......................
Remote Transmitter .89
...
Octane Requirement, Gasoline . 184
.........................................
Odometer .73
...............................
Odometer, Trip .73
..............
Of f -Highway Guidelines . 226
Oil ........................
Change, How to .249
......................
Change, When to .238
......................
Checking Engine .188
..............
Pressure Indicator . 66,325
Selecting Proper Viscosity ......................................
Chart .248
...........
ON (Ignition Key Position) . 87
Onboard Ref ueling Vapor ....................................
Recovery .348
..
Operation in Foreign Countries . 347
............................
Outside Mirrors .114 ....
Outside Temperature Indicator . 73
.....................................
Over Drive .207
....................
Overheating, Engine .323
.......
Owner Maintenance Checks . 245
.........................
Oxygenated Fuels .346
..............................
Paint Touch-up .300
..............
Panel Brightness Control . 77
........................
Park Gear Position .205
...........................................
Parking .210
.................................
Parking Brake .82
Parking Brake and Brake .................
System Indicator . 66,329
.................................
Parking Lights .76
..
Parking Over Things that Burn . 210
.............................
PGM-FI System .349
..................
Polishing and Waxing . 299
............
Pre-Drive Saf ety Checklist . 12
.........
Pregnancy, Using Seat Belts . 21
............................
Protecting Adults .13
...
Additional Safety Precautions . 22
.....
Advice f or Pregnant Women . 21
........................
Protecting Children .24
.......................
Protecting Inf ants .34 .......
Protecting Larger Children . 42
.........
Protecting Small Children . 38
Using Child Seats with .....................................
Tethers .46
.............................
Using LATCH .48
Index
N
O R
P
VI