automatic transmission HONDA ELEMENT 2004 1.G Owner's Manual

The Engine Number is stamped into
the engine block.
The Transmission Number is on a
label on top of the transmission.
Identif ication Numbers
T echnical Inf ormation203
AUTOMATIC TRANSMISSION NUMBER
ENGINE NUMBER MANUAL TRANSMISSION NUMBER
—
—y
y
(+
yy

ÎÎ ÎÎ Î
Specif ications
T echnical Inf ormation204
Dimensions
Weights
Engine
Capacities
169.3 in (4,300 mm)
71.5 in (1,815 mm)
70.4 in (1,788 mm)
101.4 in (2,575 mm)
62.1 in (1,577 mm)
62.3 in (1,582 mm)
1.88 US gal (7.1
)
1.90 US gal (7.2
)
3.3 US qt (3.1
)
7.6 US qt (7.2
)
2.0 US qt (1.9
)
1.43 US gal (5.4
)
3.1 US qt (2.9
)
1.45 US gal (5.5
)
6.9 US qt (6.5
)
5.6 US qt (5.3
)
4.2 US qt (4.0)
4.4 US qt (4.2)
15.9 US gal (60
)
9.7 : 1
144 cu-in (2,354 cm
)
3.43 x 3.90 in (87.0 x 99.0 mm)
0.145 US gal (0.55
)4.8 US qt (4.5
)
2.6 US qt (2.5)
1.3 US qt (1.2
)
1.1 US qt (1.0)
2.4 US qt (2.3
)
2.3 US qt (2.2)
Excluding the oil remaining in the engine.
Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity:
Length
Width
Height
Wheelbase
Track
Gross vehicle weight rating Type
BorexStroke
Displacement
Compression ratio
Spark plugs
Fuel tank
Engine oil
See the certification label attached
to the driver’s doorjamb (front
edge of rear door).
Water cooled 4-stroke DOHC
VTEC 4-cylinder gasoline engine Engine
coolant Automatic
transmission
fluid Manual
transmission
fluid Rear
differential
fluid (4WD)
Windshield
washer
reservoir
IZFR6K-11SKJ20DR-M11
Approx.
FrontRear
Change
Without filter
Total 1: 2:ChangeTotal
Change Total
Change
4WD
2WD
Total
4WD
2WD
ChangeTotal 4WD
2WD
ChangeTotal
U.S. Vehicles
Canada
Vehicles
NGK:
DENSO:
Automatic Transmission
Manual Transmission
1 22
Including filter
—
—y
y
(+
yy

If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle re-tested within the
next two or three days, you can
condition the vehicle for re-testing
by doing the f ollowing.Make sure the gas tank is nearly,
but not completely, f ull (around
3/4). Make sure the vehicle has been
parked with the engine of f f or 8
hours or more.
Make sure the ambient
temperature is between 20° and
95°F.
Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
Keep the vehicle in Park
(automatic transmission) or
Neutral (manual transmission).
Increase the engine speed to 2,000
rpm and hold it there until the
temperature gauge rises to at least
1/4of thescale(approximately3
minutes).
Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D (A/T) or 5th (M/T). Do not use
thecruisecontrol.
When traffic allows, drive for 90
seconds without moving the
accelerator pedal. (Vehicle speed
may vary slightly; this is okay.) If
you cannot do this f or a
continuous 90 seconds because of
traf f ic conditions, drive f or at least
30 seconds, then repeat it two
more times (for a total of 90
seconds).
Then drive in city/suburban
traffic for at least 10 minutes.
When traffic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
If the testing f acility determines the
readiness codes are still not set, see
your Honda dealer.
T esting of Readiness Codes
St at e Emissions T est ing
T echnical Inf ormation212
—
—y

y
(+
y
y

CONT INUED
BatteryCharging System ...........................
Indicator . 54, 192
............................
Jump Starting . 188
..............................
Maintenance . 177
............................
Specif ications . 205
..............................
Bef ore Driving . 109
....................................
Belts,Seat .8,19
...........................
Beverage Holders . 87
...................................
Body Panels . 165
..................................
Booster Seats . 45
Brakes
...........
Anti-lock System (ABS) . 133
.............
Break-in, New Linings . 110
....................
Bulb Replacement . 166 ...........................................
Fluid . 164
.........................................
Parking . 83
.................
System Indicator . 54, 194
........................
Wear Indicators . 133
.............................
Braking System . 132
.................
Break-in, New Vehicle . 110
..
Brightness Control, Instruments . 63
........................
Brights, Headlights . 62
Bulb Replacement
..........................
Back-up Lights . 169
..............................
Brake Lights . 169
................
Front Parking Lights . 167
........
Front Side Marker Lights . 168
.................................
Headlights . 166
............................
Specif ications . 205
....................
Turn Signal Lights . 167
..............................
Bulbs, Halogen . 166
............................
Capacities Chart . 204
.............
Carbon Monoxide Hazard . 48
..............................................
Cargo . 117
........................
Cargo, . 117
...
Accessories and Modif ications . 115
................................
Accessories . 115
............................
Modif ications . 116
ACCESSORY (Ignition Key .......................................
Position) . 69
..............
Accessory Power Sockets . 87
....................
Additives, Engine Oil . 157
.............................
Airbag (SRS) . 10, 22
................
Air Conditioning System . 91
............................................
Usage . 91
.........................
Air Outlets (Vents) . 92
.......................
Air Pressure, Tires . 172
.........................
Normal Driving . 173
......................................
Antif reeze . 160
Anti-lock Brakes (ABS)
...............................
Indicator . 55, 134
...................................
Operation . 133
..............
Anti-thef t, Audio System . 104
.
Anti-thef t Steering Column Lock . 69
......................
Armrests, Front Seat . 74
..................................
Audio System . 94
...
Automatic Seat Belt Tensioners . 20
.............
Automatic Speed Control . 107 ..............
Automatic Transmission . 127
..........................
Capacity, Fluid . 204
...............
Checking Fluid Level . 162
.......................................
Shif ting . 127
.
Shif t Lever Position Indicator . 127
................
Shif t Lever Positions . 127
....................
Shif t Lock Release . 130
......................
Auxiliary Input Jack . 106
how to carry
Index
A
B C
I
—
—y
y
(+
yy

Î
..............
CAUTION, Explanation of . ii
.........................................
CD Care . 101
...................................
CD Changer . 100
.......................
CD Error Message . 102
.......
CD Changer Error Message . 103
.......................................
CD Player . 100
.................................
Ceiling Pocket . 86
........................
Certif ication Label . 202
...................................
Chains, . 176
....................
Changing a Flat Tire . 181
.................................
Changing Oil . 158
........................................
How to . 158
......................................
When to . 149
...
Charging System Indicator . 54, 192
............
Checklist, Bef ore Driving . 123
.....................................
Child Saf ety . 29
...................................
Child Seats . 37
.......
Important Saf ety Reminder . 29
..........................................
Inf ants . 34
............................
Large Children . 44
.........................................
LATCH . 37
...........................
Lower Anchors . 39
......................
Risks with Airbags . 30
.............................
Small Children . 36
.........................................
Tethers . 39
..........
Tether Anchorage Points . 43 ............
Where Should Child Sit? . 30
............
Cleaning the Body Panels . 165
..............................................
Clock . 105
.........................
Clock, Setting the . 105
...................................
Clutch Fluid . 164
........................
CO in the Exhaust . 211
............
Cold Weather, Starting in . 124
..............................
Compact Spare . 180
...............
Consumer Inf ormation . 214
.............
Controls, Instruments and . 51
Coolant
........................................
Adding . 160
....................................
Checking . 113
.........................
Proper Solution . 160
...................
Temperature Gauge . 59
Crankcase Emissions Control ........................................
System . 209
................
Cruise Control Indicator . 56
............
Cruise Control Operation . 107
.............
Customer Service Of f ice . 214
................
DANGER, Explanation of . ii
...................................
Dashboard . 2, 52 Daytime Running Lights
.......................................
Indicator . 56
.................................
Dead Battery . 188
............
Def ects, Reporting Saf ety . 216
..........................
Def og and Def rost . 91
................
Def ogger, Rear Window . 63
................
Def rosting the Windows . 93
....................................
Dimensions . 204
...............
Dimming the Headlights . 62
Dipstick
..........
Automatic Transmission . 162
..................................
Engine Oil . 113
..........................
Directional Signals . 62
........
Disc Brake Wear Indicators . 133
.....................
Disposal of Used Oil . 159
Doors
..............
Locking and Unlocking . 70
......................
Power Door Locks . 70
..........
DOT Tire Quality Grading . 206
Downshif ting, 5-speed Manual
.............................
Transmission . 125
...........................................
Driving . 121
....................................
Economy . 114
........................
Driving Guidelines . 122
..................
Dust and Pollen Filter . 170
tires
Index
D
II
—
—y
y
(+
yy

CONT INUED
..............................
Economy, Fuel . 114
..................................
Emergencies . 179
............................
Jump Starting . 188
...........
Brake System Indicator . 194
................
Changing a Flat Tire . 181
.....
Charging System Indicator . 192
..................
Checking the Fuses . 196
.........
Hazard Warning Flashers . 63
.....
Low Oil Pressure Indicator . 192
...
Malf unction Indicator Lamp . 193
..................
Overheated Engine . 190
.......................................
Towing . 195
...........................
Emergency Brake . 83
......................
Emergency Flashers . 63
.......................
Emissions Controls . 209
.............
Emissions Testing, State . 212 Engine
....
Coolant Temperature Gauge . 59
......
Engine Speed Limiter . 126, 129
.............................. 186
Malf unction Indicator ................................
Lamp . 54, 193
........
Oil Pressure Indicator . 54, 192
..............
Oil, What Kind to Use . 157 ...............................
Overheating . 190
............................
Specif ications . 204
.......................................
Starting . 124
......................
Ethanol in Gasoline . 110
.
Evaporative Emissions Controls . 209
...............................
Exhaust Fumes . 48
Expectant Mothers, Use of Seat
........................................
Belts by . 17
.....................................
Fan, Interior . 90
Features, Comfort and
................................
Convenience . 89
....................
Filling the Fuel Tank . 111
Filters
.........................
Dust and Pollen . 170
...............................................
Oil . 158
5-speed Manual Transmission ...............
Checking Fluid Level . 163
................................
Shif ting the . 125
.............
Flashers, Hazard Warning . 63
...................
Flat Tire, Changing a . 181
Fluids
..........
Automatic Transmission . 162
..........................................
Brake . 164 .........................................
Clutch . 164
..............
Manual Transmission . 163
..........................
Power Steering . 165
..................
Windshield Washer . 161
FM Stereo Radio .....................................
Reception . 97
...........................
Folding Rear Seat . 77
..........................
Four-way Flashers . 63
Front Seat
......................................
Adjusting . 11
.........................................
Airbags . 22
.................................................
Fuel . 110
......................
Fill Door and Cap . 111
...........................................
Gauge . 58
................
Octane Requirement . 110
........................
Reserve Indicator . 56
........................
Tank, Filling the . 111
.....................
Fuses, Checking the . 196
...............
Gas Mileage, Improving . 114
..........................................
Gasohol . 110
If it won’t start
Index
E
F
G
III
—
—y
y
(+
yy

.........................................
Gasoline . 110
...............
Fuel Reserve Indicator . 56
...........................................
Gauge . 58
................
Octane Requirement . 110
........................
Tank, Filling the . 111
................
Gas Station Procedures . 111
Gauges
...
Engine Coolant Temperature . 59
...............................................
Fuel . 58
Gearshif t Lever Positions ..........
Automatic Transmission . 127
5-speed Manual
.........................
Transmission . 126
........................................
Glove Box . 87
.............
Halogen Headlight Bulbs . 166
................................................
Hatch . 71
..............
Hazard Warning Flashers . 63
Headlights
........................................
Aiming . 166
............
Daytime Running Lights . 62
..................
High Beam Indicator . 56
........................
Reminder Beeper . 62
........
Replacing Halogen Bulbs . 166 ...................................
Turning on . 62
..............................
Head Restraints . 75
.......................
Heating and Cooling . 90
.................
High-Low Beam Switch . 62
.......................
Hood, Opening the . 112
..............................................
Horn .3,60
...........................
Hydraulic Clutch . 164
...
Identif ication Number, Vehicle . 202
Ignition
..............................................
Keys . 65
...........................................
Switch . 69
............
Timing Control System . 210
........................
Immobilizer System . 66
.........
Important Safety Precautions . 6
Indicators
..............
ABS (Anti-Lock Brake) . 55
Brake (Parking and Brake
............................
System) . 54, 194
........................
Charging System . 54
.............................
Cruise Control . 56
DRL (Daytime Running
......................................
Lights) . 56
...................................
High Beam . 56 ........
Key (Immobilizer System) . 55
......................................
Low Fuel . 56
........................
Low Oil Pressure . 54
...........................
Side Airbag Of f . 55
...............................................
SRS . 55
Turn Signal and Hazard
...................................
Warning . 56
..............................
Washer Level . 57
.........
Indicators, Instrument Panel . 53
...............................
Inf ant Restraint . 34
......................................
Inf ant Seats . 34
......
LATCH Anchorage System . 39
...........................
Lower Anchors . 39
..........
Tether Anchorage Points . 43
...................
Inf lation, Proper Tire . 172
.........................
Normal Driving . 173
...................................
Inside Mirror . 82
.............................
Inspection, Tire . 174
............................
Instrument Panel . 53
........
Instrument Panel Brightness . 63
........................................
Introduction . i
.................
Jacking up the Vehicle . 183
.......................................
Jack, Tire . 181
Index
H I
J
IV
—
—y
y
(+
yy

Î
.................
Vehicle Capacity Load . 118
......................
Vehicle Dimensions . 204
....
Vehicle Identif ication Number . 202 .............................
Vehicle Storage . 178
........................................
Ventilation . 92
.................................................
VIN . 202
..................................
Viscosity, Oil . 157
Unexpected, Taking Care ..........................................
of the . 179
....
Unif orm Tire Quality Grading . 206
........................
Unleaded Gasoline . 110
.......
Used Oil, How to Dispose of . 159 .............
WARNING, Explanation of . ii
.........
Warning Labels, Location of . 49
..................
Warranty Coverages . 215
Washers, Windshield
........
Checking the Fluid Level . 161
.....................................
Operation . 61
Wheels ...............
Adjusting the Steering . 64
............
Alignment and Balance . 174
......................................
Wrench . 183
Windows ..................
Operating the Power . 81
...........................
Rear, Def ogger . 63
Windshield .......................................
Cleaning . 61
.....................................
Def roster . 91
.....................................
Washers . 161
Wipers, Windshield .......................
Changing Blades . 171
..........................
Time, Setting the . 105
....................................
Tire Chains . 176
.........
Tire, How to Change a Flat . 181
...........................
Tire Inf ormation . 208
...............................................
Tires . 172
..............................
Air Pressure . 173
.........................
Checking Wear . 174
..........................
Compact Spare . 180
......
DOT Tire Quality Grading . 206
......................................
Inf lation . 172
..................................
Inspection . 174
..............................
Maintenance . 174
...................................
Replacing . 175
......................................
Rotating . 175
...........................................
Snow . 176
............................
Specif ications . 205
................................
Tire Chains . 176
...................
Tools, Tire Changing . 181
Towing
.....................................
A Trailer . 135
...............
Behind a Motorhome . 141
................................
Emergency . 195
...
Equipment And Accessories . 137
.............................
Weight Limit . 135
.............................
Trailer Loading . 136
......................
Trailer Towing Tips . 139 Transmission
Checking Fluid Level, ..............................
Automatic . 162
Checking Fluid Level, ...................................
Manual . 163
..................
Fluid Selection . 162, 163
..............
Identif ication Number . 202
.............
Shif ting the Automatic . 127
..................
Shif ting the Manual . 125
.....................................
Treadwear . 206
.......................................
Trip Meter . 58
....................................
Turn Signals . 62
Index
U V W
VIII
—
—y

y
(+
y
y

Service Inf ormat ion Summary
Gasoline:
Fuel Tank Capacity:
Recommended Engine Oil:
Automatic Transmission Fluid:5-speed Manual Transmission Fluid:
Power Steering Fluid:Brake Fluid:
Tire Pressure (measured cold):
Rear Differential Fluid: SpareTirePressure:
15.9 US gal (60
)
2.0 US qt (1.9
)
4.4 US qt (4.2
) 1.1 US qt (1.0
)
Unleaded gasoline, pump octane
number of 86 or higher.
API Premium grade 5W-20
detergent oil (see page ).
Oil change capacity (including
filter):
Honda Manual Transmission
Fluid preferred, or an SAE 10W-30
or 10W-40 motor oil as a
temporary replacement (see page
).
Honda Power Steering Fluid
preferred, or another brand of
power steering fluid as a
temporary replacement. Do not
use ATF (see page ). Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ).
Honda ATF-Z1 (Automatic
Transmission Fluid) preferred, or
aDEXRON
III ATF as a
temporary replacement (see page
). Capacity (including differential):
Honda Dual Pump Fluid. Do not
use ATF.
Capacity:
Front:
Rear:
32 psi (220 kPa , 2.2 kgf/cm
)
34 psi (235 kPa , 2.4 kgf/cm
)
60 psi (420 kPa , 4.2 kgf/cm
)
157
162 163
165 164
—
—y
y
(+
yy