transmission HONDA FIT 2007 1.G Owner's Guide

If you see steam and/or spray
coming f rom under the hood, turn
of f the engine. Wait until you see
no more signs of steam or spray,
then open the hood.
The high temperature indicator
should be of f under most conditions.
If the engine coolant temperature
gets higher than normal, the
indicator will blink. If it stays on, you
should determine the reason (hot
day, driving up a steep hill, etc.).
If the vehicle overheats, you should
take immediate action. The only
indication may be the high
temperature indicator blinking or
remaining on. Or you may see steam
or spray coming f rom under the
hood.
Saf ely pull to the side of the road.
Put the transmission in neutral
(M/T) or Park (A/T), and set the
parking brake. Turn of f all
accessories, and turn on the
hazard warning indicators.If you do not see steam or spray,
leave the engine running, and
check the high temperature
indicator. If the high heat is due to
overloading, the engine should
start to cool down almost
immediately. If it does, wait until
the high temperature indicator
goes of f , then continue driving.
If the high temperature indicator
stays on, turn of f the engine.
1.
2. 3.
4.
If theEngineOverheats
216
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.
Driving with the high temperature
indicator on can cause serious damage
to your engine.

If your vehicle has an automatic
transmission, the malfunction
indicator lamp may also come on
with the ‘‘D’’ indicator.
If
you have recently refueled your
vehicle, the indicator coming on
could be due to a loose or missing
fu el fill cap. You will also see a
‘‘CHECK FUEL CAP’’ message on
the information display. Tighten the
cap until it clicks at least once.
Tightening the cap will not turn the
indicator off immediatel y; it can take
several days of normal driving. If
the indicator comes on repeatedly,
even though it may go off as you
continue driving, have your vehicle
checked by a dealer as soon as
possible.
If
this indicator comes on
while driving, it means one
of the engine’s emissions control
systems may have a problem. Even
though you may feel no difference in
your vehicle’s performance, it can
reduce your fuel economy and cause
increased emissions. Continued
operation may cause serious damag e.
Your vehicle has certain ‘‘readiness
codes’’ that are part of the on-board
diagnostics for the emissions
systems. In some states, part of the
emissions testing is to make sure these
codes are set. If they are not
set, the test cannot be completed.
If the battery in your vehicle has
been disconnected or gone dead,
these codes are erased. It can take
several days of driving under various
conditions to set the codes again.
To check if they are set, turn the
ignition switch to the ON (II)
position, without starting the engine.
The malfunction indicator lamp will
come on for 20 seconds. If it then
goes of f , the readiness codes are set.
If it blinks f ive times, the readiness
codes are not set. If possible, do not
take your vehicle for a state
emissions test until the readiness
codes are set. Ref er to for more
inf ormation (see page ). 240
Malf unction Indicator L amp
Readiness Codes State
Emissions T esting
T aking Care of t he Unexpect ed
219
If you keep driving with the
malf unction indicator lamp on, you can
damage your vehicle’s emissions
controls and engine. Those repairs may
not be covered by your vehicle’s
warranties.

µµ
If your vehicle needs to be towed,
call a prof essional towing service or
organization. Never tow your vehicle
with just a rope or chain. It is very
dangerous.
The operator
loads your vehicle on the back of a
truck. Therearetwowaystotowyour
vehicle: If , due to damage, your vehicle must
be towed with the f ront wheels on
the ground, do this:
Release the parking brake.
Shif t the transmission to neutral.
The tow
truck uses two pivoting arms that go
under the tires (f ront) and lif t them
of f the ground. The other two tires
remain on the ground. Turn of f the engine. ShifttoD,thentoN.
Start the engine.
Release the parking brake. Leave the ignition switch in the
ACCESSORY (I) position so the
steering wheel does not lock.
Leave the ignition switch in the
ACCESSORY (I) position so the
steering wheel does not lock.With the f ront wheels on the ground,
do not tow the vehicle more than 50
miles (80 km), and keep the speed
below35mph(55km/h).
Manual transmission:
Automatic transmission:
Flat -bed Equipment
Wheel-lif t Equipment
T his is the best way to
transport your vehicle.
T his is an
acceptable way to tow your
vehicle.
Emergency Towing
226
Improper towing preparation will
damage the transmission. Follow the
above procedure exactly. If you cannot
shif t the transmission or start the
engine (automatic transmission), your
vehicle must be transported with the
f ront wheels of f the ground.

The transmission number is on a
label on top of the transmission. The engine number is stamped into
the f ront of the engine block.
Identif ication Numbers
Technical Inf ormation
231
ENGINE NUMBER
TRANSMISSION NUMBER

ÎÎ
Î
Î
Î
Specif ications
232
Dimensions
Weights
Engine
Capacities
Capacities
157.4 in (3,999 mm)
1.40 US gal (5.3
)
1.43 US gal (5.4
)
Length
Width
Height
Wheelbase
Track
66.2 in (1,682 mm)
60.0 in (1,524 mm)
96.5 in (2,450 mm)
57.3 in (1,456 mm)
57.1 in (1,451 mm)
Gross vehicle weight rating See the certification label attached to the driver’s doorjamb.
Type
BorexStroke
Displacement
Compression ratio
Spark plugs Water cooled 4-stroke SOHC
VTEC 4-cylinder gasoline engine 2.87 x 3.52 in (73.0 x 89.4 mm) 91.3 cu-in (1,497 cm
)
10.4 : 1
Fuel tank
Engine oil 10.8 US gal (41
)
3.8 US qt (3.6
)
3.6 US qt (3.4)
4.4 US qt (4.2) Engine
coolant
Automatic
transmission
fluid
Manual
transmission
fluid
Windshield
washer
reservoir
1.6 US qt (1.5
)
1.7 US qt (1.6)
Excluding the oil remaining in the engine
Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity:
0.11 US gal (0.4
)
IZFR6K-13
SKJ20DR-M13 0.98 US gal (3.7
)
1.00 US gal (3.8
)
2.5 US qt (2.4
)
6.3 US qt (6.0)
2.6 US qt (2.5
)
4.8 US qt (4.5)
Approx.
Front
Rear
Change
Without filter
Total 1:
2:
(NGK)
(DENSO) Change
Total
Change
Total
Change
Total
Change
Total
U.S. Vehicles
Canada
Vehicles
Automatic Transmission
Manual Transmission
1 2
2
Including filter

The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Honda replacement parts or their
equivalent f or repairs. Using lower
qualitypartsmayincreasethe
emissions f rom your vehicle.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more informa-
tion.
The exhaust emissions controls
include f our systems: PGM-FI,
ignition timing control, exhaust gas
recirculation, and three way catalytic
converter. These f our systems work
together to control the engine’s
combustion and minimize the
amount of HC, CO, and NOx that
come out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.
The PGM-FI system uses sequential
multiport f uel injection. It has three
subsystems: air intake, engine
control, and f uel control. The
powertrain control module (PCM) in
automatic transmission vehicles or
the engine control module (ECM) in
manual transmission vehicles uses
various sensors to determine how
much air is going into the engine. It then controls how much f uel to inject
under all operating conditions.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The exhaust gas recirculation (EGR)
system takes some of the exhaust
gas and routes it back into the intake
manif old. Adding exhaust gas to the
air/f uel mixture reduces the amount
of NOx produced when the f uel is
burned.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor.
2
2
Exhaust Emissions Controls Replacement Parts
Emissions Cont rols
PGM-FI SystemIgnit ion T iming Cont rol Syst em
Exhaust Gas Recirculat ion (EGR)Syst em
Three Way Catalytic Converter
238

If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle retested within the
next two or three days, you can
condition the vehicle f or retesting by
doing the f ollowing.Make sure the gas tank is nearly,
but not completely, f ull (around
3/4). Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D (A/T) or 5th (M/T). Do not usethecruisecontrol.Whentraffic
allows, drive f or 90 seconds
without moving the accelerator
pedal. (Vehicle speed may vary
slightly; this is okay.) If you cannot
do this f or a continuous 90
seconds because of traf f ic
conditions, drive f or at least 30
seconds, then repeat it two more
times (for a total of 90 seconds).
Then drive in city/suburban
traffic for at least 10 minutes.
When traffic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
Keep the vehicle in Park
(automatic transmission) or
neutral (manual transmission).
Increase the engine speed to 2,000
rpm,andholditthereuntilthe
temperature gauge rises to at least
1/4of thescale(about3minutes). Make sure the vehicle has been
parked with the engine of f f or 6
hours or more.
Make sure the ambient
temperature is between 40° and
95°F.
If the testing f acility determines the
readiness codes are still not set, see
your dealer.Stop the vehicle, turn of f the
ignition switch, and leave it of f f or
30 minutes.
T esting of Readiness Codes
State Emissions T esting
240

CONT INUED
....................................
Accessories . 138
ACCESSORY (Ignition Key .......................................
Position) .77
...............
Accessory Power Socket . 98
....................
Additives, Engine Oil . 177
.......
Adjusting the Steering Wheel . 74
...........................
Advanced Airbags .27
...............................
Airbag (SRS) . 9, 22
..............
Air Conditioning System . 100
.........................................
Usage .101
.......................
Air Pressure, Tires .198
.......................
Alcohol in Gasoline .132
......................................
Antif reeze .180
Anti-lock Brakes (ABS) ...............................
Indicator . 62, 162
...................................
Operation .162
..............
Anti-thef t, Audio System . 124
.
Anti-thef t Steering Column Lock . 77
................................
Audio System .105
...
Automatic Seat Belt Tensioners . 20
.............
Automatic Speed Control . 127
..............
Automatic Transmission . 151
..........................
Capacity, Fluid .232
...............
Checking Fluid Level . 183..........................
Paddle Shif ters .156
.......................................
Shif ting .151
Shif t Lever Position ...............................
Indicators .151
................
Shif t Lever Positions . 152
....................
Shif t Lock Release . 155
............................
Capacities Chart .232
.............
Carbon Monoxide Hazard . 53
..............................................
Cargo .140
Battery
Charging System ...........................
Indicator . 60, 218
............................
Jump Starting .214
..............................
Maintenance .203
............................
Specif ications .233
..............................
Bef ore Driving .131
....................................
Belts,Seat .8 , 18
...........................
Beverage Holders . 97
..................................
Booster Seats . 50
Brakes ...........
Anti-lock System (ABS) . 162
.............
Break-in, New Linings . 132
....................
Bulb Replacement .190
...........................................
Fluid .185
.........................................
Parking . 95
.................
System Indicator . 60, 220 ..........................
System Design .161
........................
Wear Indicators .161
.............................
Braking System .161
.................
Break-in, New Vehicle . 132
..
Brightness Control, Instruments . 73
..................
Brights, Headlights . 71,72
Bulb Replacement ..........................
Back-up Lights .190
..............................
Brake Lights .190
Front Parking Lights/ ...
Front Side Marker Lights . 188
.................................
Fog Lights .189
.................................
Headlights .186
.........
High-mount Brake Light . 191
............................
Specif ications .233
....................................
Taillights .190
.............
Turn Signal Lights . 188,190
..............................
Bulbs, Halogen .186
Index
A
B
C
INDEX
I

Î
....................
Cargo, How to Carry . 140
..............
CAUTION, Explanation of . ii
.........................................
CD Care .122
.....................
CD Error Messages .121
.......................................
CD Player .112
........................
Certif ication Label .230
.................................
Chains, Tires .202
....................
Changing a Flat Tire .207
.................................
Changing Oil .178
........................................
How to .178
......................................
When to .167
...
Charging System Indicator . 60, 218
..............
Check Fuel Cap Indicator . 67
............
Checklist, Bef ore Driving . 147
.....................................
Child Saf ety .34
..............................
Booster Seats .50
.............................
Child Seats . 34, 41
.....
Important Saf ety Reminders . 34
..........................................
Inf ants .39
............................
Large Children .49
.........................................
LATCH .43
......................
Risks with Airbags .35
.............................
Small Children .40
.........................................
Tethers .47
...........................
Warning Labels .36
.........
Where Should a Child Sit? . 35.................................
Child Seats . 34, 41
.........................................
LATCH .43
..........
Tether Anchorage Points . 47
..................
Childproof Door Locks . 79
................
Cleaning the Seat Belts . 192
....................
Cleaning the Wheels .197
..............................................
Clock .125
...................................
Clutch Fluid .185
........................
CO in the Exhaust .237
............
Cold Weather, Starting in . 148
...............
Consumer Inf ormation . 242
.............
Controls, Instruments and . 57
Coolant ........................................
Adding .180
....................................
Checking .136
.........................
Proper Solution .180
...............
Temperature Indicator . 63
Crankcase Emissions Control ........................................
System .237
................
Cruise Control Indicator . 64
............
Cruise Control Operation . 127
.....................................
Cup Holders .97
.............
Customer Service Of f ice . 242................
DANGER, Explanation of . ii
...................................
Dashboard . 3, 58
................
Daytime Running Lights . 72
Daytime Running Lights .......................................
Indicator .64
.................................
Dead Battery .214
............
Def ects, Reporting Saf ety . 244
................
Def ogger, Rear Window . 73
..............
Def rosting the Windows . 103
.........................
Detachable Anchor .92
....................................
Dimensions .232
.........
Dimming the Headlights . 71, 72
Dipstick ..........
Automatic Transmission . 183
..................................
Engine Oil .135
..........................
Directional Signals .71
........
Disc Brake Wear Indicators . 161
.......................................
Disc Care .122
.......
Disc Player Error Messages . 121
.....................
Disposal of Used Oil .179
Doors ..............
Childproof Door Locks . 79
..............
Locking and Unlocking . 78
......................
Power Door Locks .78
Index
D
II

Î
CONT INUED
........
DOT Tire Quality Grading . 234
Downshif ting, Manual .............................
Transmission .149
...........
Driver and Passenger Safety . 5
...........................................
Driving .145
....................................
Economy .137
........................
Driving Guidelines .146
Driving with the Paddle .......................................
Shif ters .156
..................
Dust and Pollen Filter . 194
..............................
Economy, Fuel .137
..................................
Emergencies .205
.............
Battery, Jump Starting . 214
...........
Brake System Indicator . 220
................
Changing a Flat Tire . 207
.....
Charging System Indicator . 218
..................
Checking the Fuses . 221
.........
Hazard Warning Flashers . 73
............................
Jump Starting .214
.....
Low Oil Pressure Indicator . 218
...
Malf unction Indicator Lamp . 219
..................
Overheated Engine . 216
.......................................
Towing .226 ...........................
Emergency Brake .95
......................
Emergency Flashers .73
......................
Emergency Towing .226
.......................
Emissions Controls .237
.............
Emissions Testing, State . 240
Engine ............
Adding Engine Coolant . 180
Coolant Temperature ...................................
Indicator .63
.........................
If It Won’t Start .212
Malf unction Indicator ......................................
Lamp .219
...................................
Oil Lif e .167
........
Oil Pressure Indicator . 60, 218
..............
Oil, What Kind to Use . 177
...............................
Overheating .216
............................
Specif ications .232
....................
Speed Limiter . 150, 154
.......................................
Starting .148
......................
Ethanol in Gasoline .132
.
Evaporative Emissions Controls . 237
...............................
Exhaust Fumes .53
Expectant Mothers, Use of Seat ........................................
Belts by .16 ...................................
Fan, Interior .101
...........................................
Features .99
....................
Filling the Fuel Tank . 133
Filters .........................
Dust and Pollen .194
...............................................
Oil .178
.............
Flashers, Hazard Warning . 73
...................
Flat Tire, Changing a . 207
Fluids ..........
Automatic Transmission . 183
..........................................
Brake .185
.........................................
Clutch .185
..............
Manual Transmission . 184
..................
Windshield Washer . 182
.........
Folding the Rear Seat Down . 90
...............
Folding the Rear Seat Up . 89
..........................
Four-way Flashers .73
..............................
Front Airbags . 9, 25
Front Seat ......................................
Adjusting .85
.....................................
Airbags . 9, 25
Index
E F
INDEX
III