coolant level HONDA INSIGHT 2001 1.G User Guide

If the coolant level in the reserve
tank is at or below the MIN line, add
coolant to bring it up to the MAX line.
Inspect the cooling system f or leaks.
This coolant should always be a
mixtureof 50percentantifreezeand
50 percent water. Never add straight
antif reeze or plain water.If the reserve tank is completely
empty, you should also check the
coolant level in the radiator.
Always use Honda All Season
Antif reeze/Coolant Type 2. This
coolant is pre-mixed with 50 percent
antif reeze and 50 percent water. It
does not require any additional
mixing.
If it is not available, you may use
another major-brand non-silicate
coolant as a temporary replacement.
Make sure it is a high-quality coolant
recommended f or aluminum engines.
However, continued use of any non-
Honda coolant can result in
corrosion, causing the cooling
system to malf unction or f ail. Have
the cooling system f lushed and
ref illed with Honda antif reeze/
coolant as soon as possible.
CONT INUED
A dding Engine Coolant
Cooling Syst em
Maint enance
171
RREESSEERRVVEETTAANNKK
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

Remove the radiator cap by
pushing down and turning
counterclockwise.
Turn the radiator cap counter-
clockwise, without pressing down
on it, until it stops. This relieves
any pressure remaining in the
cooling system.
Make sure the engine and radiator
are cool.
Pour coolant into the reserve tank.
Fill it to half way between the MAX
and MIN marks. Put the cap back
on the reserve tank.
Put the radiator cap back on.
Tighten it f ully.
The coolant level should be up to
the base of the f iller neck. Add
coolant if it is low. Do not add any rust inhibitors or
other additives to your car’s cooling
system. They may not be compatible
with the coolant or engine compo-
nents.
2. 3. 4. 5. 6.
1.
Cooling Syst em
Maint enance
172
RRAADDIIAATTOORRCCAAPPRREESSEERRVVEETTAANNKK

If the temperature gauge stays at
the red mark, turn of f the engine.
Wait until you see no more signs
of steam or spray, then open thehood.
If you don’t f ind an obvious leak,
check the coolant level in the
radiator reserve tank (see page). If the level is below the
MIN mark, add coolant to halfway
between the MIN and MAX marks. If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly.
If there was no coolant in the
reserve tank, you may also have to
add coolant to the radiator. Let the
engine cool down until the pointer reaches the middle of the tempera-
ture gauge, or lower, bef ore check-
ing the radiator.
Using gloves or a large heavy
cloth, turn the radiator cap
counterclockwise, without pushing
down, to the f irst stop. This
releases any remaining pressure in
the cooling system. After the
pressure releases, push down on
the cap and turn it until it comes
off.
Start the engine and set the
temperature control dial to
maximum. Add coolant to the
radiator up to the base of the f iller
neck. If you do not have the
proper coolant mixture available,
you can add plain water.
Remember to have the cooling
system drained and ref illed with
the proper mixture as soon as you
can.
Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (see
on page ). Put the radiator cap back on
tightly. Run the engine and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair. (See
on page .)
4. 5.
6. 7. 8. 9.
12.
11.
10.
239
125 239
Emergency
Towing
Emergency
Towing
If Your Engine Overheats
T aking Care of t he Unexpect ed 227
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

CONT INUED
.....
Charging System Indicator . 229
..................
Checking the Fuses . 233
.....
Low Oil Pressure Indicator . 228
...
Malf unction Indicator Lamp . 230
..................
Overheated Engine . 227
...........................
Emergency Brake . 79
......................
Emergency Flashers . 65
......................
Emergency Towing . 239
.......................
Emissions Controls . 250 Engine
............................................
Belts . 191
....
Coolant Temperature Gauge . 58
Malf unction Indicator
................................
Lamp . 48, 230
..............
Oil, What Kind to Use . 167
...............................
Overheating . 227
............................
Specif ications . 244
.......................................
Starting . 135
..........
Engine Speed Limiter . 139, 143
......................
Ethanol in Gasoline . 248
.
Evaporative Emissions Controls . 250
...............................
Exhaust Fumes . 40
Expectant Mothers, Use of Seat
........................................
Belts by . 17
..................
Exterior, Cleaning the . 208 ............................
Fabric, Cleaning . 211
.....................................
Fan, Interior . 84
Features, Comfort and
................................
Convenience . 83
....................
Filling the Fuel Tank . 121
Filter
.........................
Dust and Pollen . 191
...............................................
Oil . 167
5-speed Manual Transmission ...............
Checking Fluid Level . 180
................................
Shif ting the . 136
.............
Flashers, Hazard Warning . 65
...................
Flat Tire, Changing a . 217
Fluids
Automatic Transmission .....................................
(CVT) . 178
..........................................
Brake . 181
.........................................
Clutch . 181
..............
Manual Transmission . 180
..................
Windshield Washer . 177
FM Stereo Radio ...................................
Reception . 112
.....
Foreign Countries, Driving in . 249
..........................
Four-way Flashers . 65 .................................................
Fuel . 126
......................
Fill Door and Cap . 121
...........................................
Gauge . 58
................
Octane Requirement . 120
...............................
Oxygenated . 248
........................
Reserve Indicator . 58
........................
Tank, Filling the . 121
.....................
Fuses, Checking the . 233
...............
Gas Mileage, Improving . 126
..........................................
Gasohol . 248
.........................................
Gasoline . 120
...............
Fuel Reserve Indicator . 48
...........................................
Gauge . 50
................
Octane Requirement . 120
........................
Tank, Filling the . 121
................
Gas Station Procedures . 121
Index
F
G
III

CONT INUED
.....................................
Load Limit . 131
......
LOCK (Ignition Key Position) . 69
Locks
............................
Fuel Fill Door . 121
............................................
Hatch . 71
........................
Low Coolant Level . 125
.........................
Low Fuel Indicator . 58
...
Lower Gear, Downshif ting to a . 139
...
Lubricant Specif ications Chart . 244
.........................................
Luggage . 130
..................................
Maintenance . 153
...
Owner Maintenance Checks . 165
........................................
Record . 154
......................
Required Indicator . 59
..........................................
Saf ety . 154
....................................
Schedule . 156
.
Malf unction Indicator Lamp . 48, 230
...................
Manual Transmission . 136
........
Manual Transmission Fluid . 180
...............................
Meters, Gauges . 50
...................
Methanol in Gasoline . 248
..........................
Mirrors, Adjusting . 78 ..................
New Vehicle Break-in . 120
..................
NOTICE, Explanation of . ii
...............
Numbers, Identif ication . 242
...
Octane Requirement, Gasoline . 120
.........................................
Odometer . 50
...............................
Odometer, Trip . 51
Oil
........................
Change, How to . 169
......................
Change, When to . 158
......................
Checking Engine . 124
Selecting Proper Viscosity
......................................
Chart . 168
...........
ON (Ignition Key Position) . 70
Onboard Ref ueling Vapor
....................................
Recovery . 250
.........................
Opening the Hatch . 71
..
Operation in Foreign Countries . 249
..............................
Outside Mirrors . 78
....................
Overheating, Engine . 227
.......
Owner Maintenance Checks . 165
.........................
Oxygenated Fuels . 248 ..............................
Paint Touch-up . 210
..............
Panel Brightness Control . 62
...........................................
Parking . 147
.................................
Parking Brake . 79
Parking Brake and Brake
.................
System Indicator . 46, 232
..
Parking Over Things that Burn . 252
.............................
PGM-FI System . 251
..................
Polishing and Waxing . 210
............
Pre-Drive Saf ety Checklist . 11
.........
Pregnancy, Using Seat Belts . 17
............................
Protecting Adults . 12
...
Additional Safety Precautions . 18
.....
Advice f or Pregnant Women . 17
........................
Protecting Children . 19
.......
Protecting Larger Children . 29
.........
Protecting Small Children . 26
Using Child Seats with
.....................................
Tethers . 33
Index
M N O
P
V