battery HONDA INSIGHT 2002 1.G Owner's Manual

This indicator should come on when
the ignition switch is ON (II), and go
out af ter the engine starts. If it
comes on brightly when the engine
is running, it indicates that the
charging system has stopped
charging the battery.By eliminating as much of the
electrical load as possible, you can
drive several miles (kilometers)
before the battery is too discharged
to keep the engine running. Drive to
a service station or garage where
you can get technical assistance.
Immediately turn of f all electrical
accessories: A/C, rear def ogger, etc.
Try not to use other electrically-
operated controls such as the radio.
Keep the engine running and take
extra care not to stall it. Starting the
engine will discharge the battery
rapidly.
Charging System Indicator
T aking Care of t he Unexpect ed227
C CH
H A
AR
RGGI INNG G S
SYYSSTTE
EM
M I
INND DI
ICCA A T
TO
OR R

Your car has certain ‘‘readiness
codes’’ that are part of the on-board
diagnostics f or the emissions
systems. In some states, part of the
emissions testing is to make sure
these codes are set. If they are not
set, the test cannot be completed.
If your car’s battery has been
disconnected or gone dead, these
codes are erased. It takes several
days of driving under various
conditions to set the codes again.If possible, do not take your car f or a
state emissions test until the
readiness codes are set. To check if
they are set, turn the ignition ON (II),
but do not start the engine. The
Malf unction Indicator Lamp will
come on f or 20 seconds. If it then
goes of f , the readiness codes are set.
If it blinks 5 times, the readiness
codes are not set. Ref er to the
warranty manual f or more
inf ormation.
Malf unction Indicator L amp
T aking Care of t he Unexpect ed
Readiness Codes
229

µµ
No. Amps. Circuits ProtectedNo. Amps. Circuits Protected
1
2
3
4
5
6
7
8
9
10 50 A
80 A
30 A
10 A
15 A
10 A
15 A
15 A
15 A IG1 Main
Battery
ABS Motor
Hazard
IMA
Horn Stop
Fuel Pump
Lef t Headlight
Not used
Right Headlight 11
12
13
14
15
16
17
18
19
2030 A
40 A
30 A
20 A
40 A
30 A
40 A
7.5 A 20 A Cooling Fan
Heater Motor
Rear Defroster
ABS F/S
Power Steering
Back Up, ACC
Power Window
IMA ECU
Condenser Fan
Spare Fuse
Fuses
T aking Care of t he Unexpect ed235
UNDER-HOOD FUSE BOX

If you decide to tow your car with all
f our wheels on the ground, make
sure you use a properly-designed and
attached tow bar. Prepare the car for
towing as described above, and leave
the ignition switch in Accessory (I)
so the steering wheel does not lock.
Make sure the radio and any items
plugged into the accessory power
socket are turned of f so they do not
rundownthebattery.
Emergency T owing
T aking Care of t he Unexpect ed238
Trying to lif t or tow your car by the
bumpers will cause serious damage.
The bumpers are not designed to
support the car’s weight.
The steering system can be damaged if
the steering wheel is locked. Leave the
ignition switch in Accessory (I), and
make sure the steering wheel turns
f reely bef ore you begin towing.

µµµ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Î
Î
Specif ications
T echnical Inf ormation243
Air Conditioning Alignment
Tires
Battery
Fuses Lights HFC-134a (R-134a)
17.6 19.4 oz (500 550 g) SP-10
12 V 60/55 W (HB2) 0.00 in (0.0 mm)
0.12 in (3.0 mm)
0°1°
2°
P165/65R14 78S
T115/70D14 88M
Refrigerant type
Charge quantity
Lubricant type
Toe-in
Camber
Caster
Size
Pressure
12 V 21 W
12 V 5 W
12 V 12 V
21/5 W
21 W
12 V 18 W
12 V
12 V 5W
5W
12 V
12 V
5W
3.4 W
12V 27Ah/5HR
Capacity
Interior
Under-hood 30 Ah/5 HR
12 V
See page 234or the fuse label
attached to the inside of the fuse
box door under the dashboard.
See page 235or the fuse box
cover.
Headlights (HI/LO)
Front turn signal lights
Front parking lights
Side marker lights
Rear turn signal lights
Stop/Taillights
Back-up lights
Trunk light
License plate light
Interior light
Front
Rear
Front
Rear
Front
Front/Rear
Spare
Front
Rear
Spare
38 psi (260 kPa)
35 psi (240 kPa)
60 psi (420 kPa)
U.S. model M/T
CVT

CONT INUED
If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle re-tested within the
next two or three days, you can
condition the vehicle for re-testing
by doing the f ollowing.
Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the ambient
temperature is between 20° and
95°F. Make sure the vehicle has been
parked with the engine of f f or 8
hours or more. Without touching the accelerator
pedal, start the engine and let it
idle f or 20 seconds.
Keep the vehicle in Park
(automatic transmission) or
Neutral (manual transmission).
Increase the engine speed to 2,000
rpm and hold it there until the
temperature gauge rises to at least
1/4of thescale(approximately3
minutes).
St at e Emissions T est ing
T esting of Readiness Codes
T echnical Inf ormation251

µ
µ
µ µ
µ
µ
µ
µ
µ
Your new Honda is covered by these
warranties:
provides prorated
coverage f or a replacement battery
purchased f rom a Honda dealer.
a seat
belt that f ails to f unction properly is
covered f or the usef ul lif e of the
vehicle.
covers all genuine
Honda replacement parts against
defects in materials and workman-
ship. Genuine Honda Accessories are
covered under this warranty. Time
and mileage limits depend on the
type of accessory and other f actors.
Please read your warranty manual
f or details. all exterior body panels are
covered f or rust-through f rom the
inside f or the specif ied time period
with no mileage limit.
covers
your new vehicle, except f or the
battery, emissions control systems
and accessories, against def ects in
materials and workmanship. provides
coverageforaslongasthepur-
chaser of the muf f ler owns the car.
these two
warranties cover your vehicle’s emis-
sions control systems. Time, mileage,
and coverage are conditional. Please
read the warranty manual for exact
inf ormation.
this warranty gives up
to 100 percent credit toward a
replacement battery. Restrictions and exclusions apply to
all these warranties. Please read the
2002 Honda Warranty Inf ormation
booklet that came with your car f or
precise inf ormation on warranty
coverages. Your Honda’s original
tires are covered by their
manuf acturer. Tire warranty inf or-
mation is in a separate booklet.
Please ref er to the 2002 Warranty
Manual that came with your car.
Replacement Bat t ery L imit ed
Warranty
Seat Belt Limited Warranty
Replacement Part s L imit edWarranty
Accessory Limited Warranty
Rust Perf orat ion L imit ed Warrant y
New Car Limited Warranty
Replacement Muf f ler L if et imeLimited Warranty
Emissions Cont rol Syst ems Def ect s Warrant y and EmissionsPerf ormance Warranty
Original Equipment Bat t ery L imit edWarrantyU.S. Owners
Canadian Owners
Warranty Coverages
Warrant y and Cust omer Relat ions255

CONT INUED
...
Accessories and Modif ications . 126
................................
Accessories .126
...
Additional Safety Precaution . 127
............................
Modif ications .127
ACCESSORY (Ignition Key .......................................
Position) .70
...............
Accessory Power Socket . 81
....................
Additives, Engine Oil . 166
...............................
Airbag (SRS) .9, 47
................
Air Conditioning System . 90
..............................
Maintenance .188
............................................
Usage .90
.........................
Air Outlets (Vents) .90
.......................
Air Pressure, Tires .190
.........................
Normal Driving .191
.......................
Alcohol in Gasoline .246
......................................
Antif reeze .169
Anti-thef t Steering Column ..............................................
Lock .69
..........................
Appearance Care .205
..................................
Audio System .98
........................
Auto Idle Stop .135, 143
..............
Automatic Transmission . 138
..........................
Capacity, Fluid .242 ...............
Checking Fluid Level . 176
.......................................
Shif ting .138
.
Shif t Lever Position Indicator . 138
................
Shif t Lever Positions . 138
....................
Shif t Lock Release . 142
Battery Charging System ...........................
Indicator .56, 227
............................
Jump Starting .223
..............................
Maintenance .183
............................
Specif ications .243
..............................
Bef ore Driving .117
..........................................
Belts, Seat .8
.............................
Beverage Holder .80
.................................
Body Repairs .211
Brakes .............
Break-in, New Linings . 118
...........................................
Fluid .179
....................
Bulb Replacement .201
.........................................
Parking .79
.................
System Indicator . 46,230
........................
Wear Indicators .146
.............................
Braking System .147 ........................
Break-in, New Car .118
..
Brightness Control, Instruments . 62
........................
Brights, Headlights .61
Bulb Replacement ..........................
Back-up Lights .201
...............................
Brake Light .201
................
Front Parking Lights . 199
........
Front Side Marker Lights . 199
.................................
Headlights .198
.............................
Interior Light .203
.................
License Plate Lights . 202
............................
Specif ications .243
....................
Turn Signal Lights . 199
..............................
Bulbs, Halogen .198
............................
Capacities Chart .242
.............
Carbon Monoxide Hazard . 40
.............................
Carrying Cargo .128
Cassette Player ............................................
Care .115
...................................
Operation .104
..............
CAUTION, Explanation of . ii
Index
A
B
C
I

Î.......................................
CD Player .108
........................
Certif ication Label .240
............................................
Chains .195
....................
Charge/Assist Gauge .57
Changing Oil ........................................
How to .167
......................................
When to .156
....................
Changing a Flat Tire .215
............
Changing Engine Coolant . 171
............
Charging System Indicator . 56
............
Checklist, Bef ore Driving . 117
.....................................
Child Saf ety .19
Child Seats ..........
Tether Anchorage Points . 33
....................
Cleaner Element, Air . 181
Cleaning ......................................
Exterior .206
.......................................
Interior .209
...................................
Seat Belts .209
...........................................
Vinyl .209
....................................
Windows .210
.........................
Clock, Setting the .103
...................................
Clutch Fluid .179
........................
CO in the Exhaust .248
............
Cold Weather, Starting in . 133
..............................
Compact Spare .214 ...............
Consumer Inf ormation . 254
.............
Controls, Instruments and . 60
Coolant ........................................
Adding .169
....................................
Checking .123
.........................
Proper Solution .173
...................................
Replacing .171
...................
Temperature Gauge . 58
....................
Corrosion Protection .210
Crankcase Emissions Control ........................................
System .248
.....................
Current Fuel Mileage .55
..........
Customer Relations Of f ice . 254
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 44
................
Daytime Running Lights . 62
............
Defects, Reporting Safety . 258
..........................
Def og and Def rost .84
................
Def ogger, Rear Window . 65
................
Defrosting the Windows . 84
....................................
Dimensions .242
...............
Dimming the Headlights . 61Dipstick
..................................
Engine Oil .122
..........................
Directional Signals .63
........
Disc Brake Wear Indicators . 146
.....................
Disposal of Used Oil .168
..................
Display Change Button . 50
Doors ..............
Locking and Unlocking . 71
..........
DOT Tire Quality Grading . 244
Downshif ting, 5-speed Manual .............................
Transmission .134
.....................................
Drive Belts .189
...........
Driver and Passenger Safety . 5
...........................................
Driving .131
....................................
Economy .124
.........................
In Bad Weather .149
................
In Foreign Countries . 247
..................
DustandPollenFilter . 189
..............................
Economy, Fuel .124
............
Emergencies on the Road . 213
.............
Battery, Jump Starting . 222
...........
Brake System Indicator . 230
................
Changing a Flat Tire . 215
Index
D
E
II

Î
Î...................
Radiator Overheating . 225
......
Radio/Cassette Sound System . 98
..
Rear Lights, Bulb Replacement . 201
............................
Rear View Mirror .79
.................
Rear Window Def ogger . 65
....................
Rear Window Washer .65
.......................
Rear Window Wiper .65
...............
Reclining the Seat Backs . 76
Replacement Inf ormation .................
Air Cleaner Element . 181
..........................
Engine Coolant .171
................
Engine Oil and Filter . 167
..........................................
Fuses .231
................................
Light Bulbs .198
....................................
Schedule .154
...................................
Drive Belt .189
...........................................
Tires .193
.............................
Wiper Blades .185
Replacing Seat Belts Af ter a ............................................
Crash .35
Reserve Tank, Engine ...............................
Coolant .123, 171
...............................
Restraint, Child .19
................................
Rotation, Tire .193 ..................................
Saf ety Belts .8, 34
.........
Safety Defects, Reporting . 256
.................................
Saf ety Features .7
...........................................
Airbags .9
..................................
Door Locks .10
..........................
Head Restraints .10
.......................................
Seat Belts .8
.....................
Seats & Seat-Backs .10
.............
Saf ety Labels, Location of . 41
...............................
Saf ety Messages . ii
.....................................
Seat Belts .8, 34
...............
Additional Information . 34
.....................................
Cleaning .209
......................
Lap/Shoulder Belt .34
................................
Maintenance .35
Reminder Light and ................................
Beeper .34, 46
...................
System Components . 34
...............
Use During Pregnancy . 17
...
Wearing a Lap/Shoulder Belt . 15
........................
Seats, Adjusting the .76
...............................
Serial Number .240
...........................
Service Intervals .154
...........................
Service Manual .257 .........
Service Station Procedures . 119
..........................
Setting the Clock .103
.....
Shif t Lever Position Indicator . 138
........................
Shif t Lock Release .142
...............................
Signaling Turns .63
.....................................
Snow Tires .195
...................
Solvent-type Cleaners . 207
..................................
Sound System .98
Spare Tire ......................................
Inf lating .214
............................
Specif ications .243
....................
Specif ications Charts . 242
...................................
Speedometer .50
..........
SRS, Additional Inf ormation . 36
...
Additional Safety Precautions . 39
How the SRS Indicator .......................................
Works .38
...........
How Your Airbags Work . 36
........................
SRS Components .36
..................................
SRS Service .39
.............................
SRS Indicator .34 ,46
....
START (Ignition Key Position) . 70
.......................
Starting the Engine .133
In Cold Weather at High ..................................
Altitude .133
................
With a Dead Battery . 222
Index
RS
VI