light HONDA INSIGHT 2003 1.G Manual PDF

If something electrical in your
vehicle stops working, the first thing
youshouldcheckforisablownfuse.
Determine f rom the chart on pagesand , or the diagram on the
fuse box lid, which fuse or fuses
control that device. Check those
f uses f irst, but check all the f uses
bef ore deciding that a blown f use is
the cause. Replace any blown f uses,
and check if the device works.
Turn the ignition switch to the
LOCK (0) position. Make sure the
headlights and all other
accessories are of f . Remove the cover f rom the under-
hood f use box located on the
battery (see page ).
Check each of the large f uses in
the under-hood f use box on the 12
volt battery by looking through
thetopatthewireinside.
Replacement of these f uses should
be done by your dealer.Check the smaller f uses in the
under-hood f use boxes and all the
fuses in the interior fuse box by
pulling out each one with the f use
puller provided in the interior f use
box.
1.
2.4.
3.
372 373
368
CONT INUED
Checking and Replacing Fuses
Fuses
T aking Care of t he Unexpect ed
369
BLOWNFUSE PULLER

µ
µ
µ
µ
µ
Î
Î
No. No. Amps.
Amps. Circuits Protected
Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22 23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
10 A
10 A
10 A
30 A
20 A
10 A
30 A
7.5 A 10 A
20 A
10 A
15 A
15 A
30 A
15 A
15 A
10 A
7.5 A
7.5 A
15 A
(7.5 A) 20 A
10 A
10 A
10 A
7.5 A
7.5 A
7.5 A 10 A
20 A
7.5 A
7.5 A 10 A
20 A
20 A
20 A
15 A
15 A
7.5 A Hazard
Stop/Horn
Not Used
LAF
Door Lock Main
Headlight Main
Small Light
Radiator Fan Motor
IGPS
Right Headlight Low Beam
IG Coil
Left Headlight Low Beam
Door Lock Motor 2 (Lock)
Door Lock Motor 1 (Lock)
ABS/VSA FSR
Selectable Door Lock
IGP
Not Used
Not Used
IMA 1
MG Clutch
STS
Back Up
TPMS
Driver’s Power Window
Not Used
Back Up Light
SRS
T ransmission SOL
OPDS
Not Used
A/C
ABS/VSA
IMA
ACC Socket
Accessory
Daytime Running Light
Rear Wiper
Front Passenger’s Power
Window
Rear Passenger’s Side
Power Window
Rear Driver’s Side Power
Window
Fuel Pump
Washer
Meter
: U.S. models
Fuse Locations
372
INTERIOR FUSE BOX

µ
µ
µ
Î
Î
Î
ÎÎ
Î
ÎÎ
No. Circuits Protected
No.
Amps.
Amps.
No. Amps. Circuits Protected
Circuits Protected
1
2
Ignition Coil (EX)
Ignition Coil (IN)
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
15 A
15 A
7.5 A
30 A
10 A
15 A
15 A
10 A
15 A
10 A
10 A
30 A
30 A
30 A
30 A
40 A
50 A 1
2
3100 A
60 A
20 A Battery, Main, ACG
EPS
Horn, Stop, Hazard
Hatch Lock
Not Used
Condenser Fan Motor
Left Headlight High Beam
Door Lock Motor 2 (Unlock)
Door Lock Motor 1 (Unlock)
Right Headlight High Beam
DBW
IMA 2
Not Used
Heated Mirror
Front Wiper
Blower Motor
ABS/VSA Motor
Rear Defogger
Rear Defogger
Not Used
IG Main
1:
2:
3: Insight model and U.S. LX model
Canadian models
EX models
2, 3
1
2, 3
Fuse Locations
T aking Care of t he Unexpect ed
373
UNDER-HOOD FUSE BOXES On the battery Next to the battery

µµ¶
µ¶ ¶
¶¶
¶¶ µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Î
Î
Î
Î
ÎÎ Î Î
Î
Î
Specif ications
T echnical Inf ormation
381
Air Conditioning
Tires Alignment Fuses 12 Volt Battery
Lights HFC-134a (R-134a)
15.8 17.6 oz (450 500 g) SP-10
12 V 60 W
Refrigerant type
Charge quantity
Lubricant oil type
12 V 55 W
Size
Pressure Toe-in
Camber
Caster Interior
Under-hood
60 psi (420 kPa , 4.2 kgf/cm
)
33 psi (230 kPa , 2.3 kgf/cm)
P185/60R15 84T 3°30’ 0.5°
1.5° 1°
0° 1°
Capacity
12 V
12 V 35 AH/20 HR
28 AH/5 HR
12 V 21 W
T135/80D15 99M
12 V 5 W
12 V 3.4 W 12 V 12 V
12 V
12 V
12 V
12 V
5W
8W
8W
5W
2CP
16 W
12 V 21 W
Replacement of a light bulb should be done by your dealer. 5W
12 V
0.10 0.10 in (2.5 2.5 mm)00.12in(03mm)
Headlights
Front turn signal lights
Front parking lights
Front side marker lights
Side turn signal lights
(door mirror)
Rear turn signal lights
Stop/taillights
Back-up lights
Rear side marker lights
License plate lights
Spot lights
Ceiling light
Cargo area light
High-mount brake light
Glove box light See page
372or the fuse label
attached to the inside of the fuse
box door under the steering
column.
See page 373or the fuse box
cover.
Front
Rear
Front
Rear
Front
High
Low
Front/Rear
Spare
Front/Rear
Spare
(HB3)
(H11)
(Amber)
LED type
LED type
LED type (Amber)
in
1:
2:
3 : LX model EX models
1
1, 3 1 2
2
2

Î
ÎThe burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx), and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons. Con-
trolling the production of NOx, CO,
and HC is important to the environ-
ment. Under certain conditions of
sunlight and climate, NOx and HC
react to f orm photochemical ‘‘smog.’’
Carbon monoxide does not contri-
bute to smog creation, but it is a
poisonous gas. The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
In Canada, Honda vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured.
Your vehicle has a positive
crankcase ventilation system. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The positive
crankcase ventilation valve routes
them from the crankcase back to the intake manif old. They are then
drawn into the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The onboard ref ueling vapor
recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
The Clean Air Act
Crankcase Emissions Control
System
Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
Emissions Cont rols
T echnical Inf ormation
387

Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D. Do not use the cruise control.
When traffic allows, drive for 90
seconds without moving the
accelerator pedal. (Vehicle speed
may vary slightly; this is okay.) If
you cannot do this f or a
continuous 90 seconds because of
traf f ic conditions, drive f or at least
30 seconds, then repeat it two
more times (for a total of 90
seconds).Then drive in city/suburban
traffic for at least 10 minutes.
When traf f ic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
Make sure the vehicle has been
parked with the engine of f f or 30
minutes.
If the testing f acility determines the
readiness codes are still not set, see
your dealer.
7.
8.
9.
Emissions T est ing
T echnical Inf ormation
391

Index
.............................
Braking System .285
.................
Break-in, New Vehicle . 244
Brightness Control, ...............................
Instruments .124
Bulb Replacement ..........................
Back-up Lights .327
..............................
Brake Lights .330
........
Front Side Marker Lights . 326
.........
Front Turn Signal Lights . 325
.................................
Headlights .321
..........................
Parking Lights .324
..........
Rear Turn Signal Lights . 327
............................
Specif ications .381
..............................
Bulbs, Halogen .321 ...............
DANGER, Explanation of . iv
...................................
Dashboard .3, 60
..............
Daytime Running Lights . 123
............
Def ects, Reporting Saf ety . 396
..............
Def ogger, Rear Window . 126
......
Def rosting the Windows . 165,166
....................................
Dimensions .380
.............
Dimming the Headlights . 120
Dipstick ..........
Automatic Transmission . 318
..................................
Engine Oil .249
........................
Directional Signals .120
Disc Brake Pad Wear ...................................
Indicators .286
............................
Disc Player .173, 188
.....................
Disposal of Used Oil .314
..........................
Cargo Area Light .160
............................
Capacities Chart .380
.............
Carbon Monoxide Hazard . 56
.............................
Carrying Cargo .256
.............
CAUTION, Explanation of . iv
..................................
Ceiling Light .159
..............................
Center Pockets .157
...................................
Center Tray .156
........................
Certif ication Label .378 ............................................
Chains .342
....................
Changing a Flat Tire .349
Changing Oil ........................................
How to .312
......................................
When to .299
...
Charging System Indicator . 63,364
............
Checklist, Bef ore Driving . 262
.....................................
Child Saf ety .38
Child Seats .............
LATCH Anchor System . 47
.............................
Lower Anchor .47
............................
Tether Anchor .51
................
Childproof Door Locks . 134
.............................
Climate Control .162
.........................
Clock, Setting the .220
........................
CO in the Exhaust .387
............
Cold Weather, Starting in . 263
..............................
Compact Spare .348
.................
Console Compartment . 155
.............
Controls, Instruments and . 59
Coolant ........................................
Adding .315
....................................
Checking .250
.........................
Proper Solution .315
...............
Temperature Indicator . 67Crankcase Emissions Control
........................................
System .387
............
Cruise Control Operation . 222
.........................
Customer Service .394
C D
II

.................................................
Fuel .244
......................
Fill Door and Cap .245
...........................................
Gauge .73
................
Octane Requirement . 244
...............................
Oxygenated .244
........................
Reserve Indicator .70
........................
Tank, Filling the .245
.....................
Fuses, Checking the .369
...............
Gas Mileage, Improving . 251
.........................................
Gasoline .244
...............
Fuel Reserve Indicator . 70
...........................................
Gauge .73
................
Octane Requirement . 244
........................
Tank, Filling the .245
................
Gas Station Procedures . 245
Gauges .............................
Charge/Assist .74
...............................................
Fuel .73
............
Gearshif t Lever Positions . 271
..........
Automatic Transmission . 271
......................................
Glove Box .156 .............
Halogen Headlight Bulbs . 321
...........................
HandsFreeLink
. 225
..............................................
Hatch .139
......................................
Opening .139
............................
Open Indicator .68
............
Hazard Warning Flashers . 125
Headlights ........................................
Aiming .321
.........
Daytime Running Lights . 123
..................
High Beam Indicator . 69
......................
Reminder Beeper .121
........
Replacing Halogen Bulbs . 321
.................................
Turning on .121
............................
Head Restraints .142
.............................
Heated Mirrors .148
.............
High Altitude, Starting at . 263
...............
High-Low Beam Switch . 120
...............
Hill Start Assist System . 295
.......................
Hood, Opening the .248
....................................................
Horn .4
...
Identif ication Number, Vehicle . 378Ignition
............................................
Keys .129
.........................................
Switch .131
............
Timing Control System . 388
IMA System Power Flow ........................................
Monitor .84
......................
Immobilizer System .130
.........
Important Safety Precautions . 6
.........
Indicators, Instrument Panel . 62
...
Indicators, Messages (MID) . 62,89
...............
ABS (Anti-lock Brake) . 64
..............................
Auto Idle Stop .66
Brake (Parking and Brake ............................
System) .63, 366
.............................
Cruise Control .69
.................................
Cruise Main .69
................
Door/Hatch Open . 12,68
DRL (Daytime Running ....................................
Lights) .123
.
EPS (Electric Power Steering) . 68
................................
ECON Mode .71
...................................
High Beam .69
....
High Temperature (Coolant) . 67
......................
IMA Battery Level .85
.................................
IMA System .66
........
Key (Immobilizer System) . 63
Index
I H
G
IV

CONT INUED
................................................
Keys .129
.................
Jacking up the Vehicle . 351
.......................................
Jack, Tire .350
................................
Jump Starting .358
Indicators, Messages (MID)
.....................................
Lights On .69
......................................
Low Fuel .70
................
Low Oil Pressure . 62,363
.....
Low Temperature (Coolant) . 67
Low Tire Pressure/ ...............................
TPMS .66, 289
...
Malf unction Indicator Lamp . 365
..........................
Security System .70
...........................
Side Airbag Of f .65
.................................
Seat Belt .21, 62
.........................................
SRS .34, 64
.........................
System Message .70
...........................
TPMS .66, 289, 290
Turn Signal and Hazard ...................................
Warning .69
12 Volt Battery Charging ..............................
System .63, 364
........................................
VSA Off .65
.................................
VSA System .65
...............................
Inf ant Restraint .43
Inf ant Seats ......
LATCH Anchorage System . 47
...........................
Lower Anchors .47
...........................
Tether Anchors .51 .....
Inf lation, Recommended Tire . 338
...................................
Pressures .339
........................
Inf ormation Display .72
.................................
Inside Mirror .147
.............................
Inspection, Tire .339
............................
Instrument Panel .61
......
Instrument Panel Brightness . 124
...............................
Interior Lights .159
........................................
Introduction .i
...............................................
iPod
. 195
.......................
Label, Certif ication .378
...............
Lane Change, Signaling . 121
..................
Lap/Shoulder Belts . 17,22 ...........
LATCH Anchorage System . 47
Lights ....................
Bulb Replacement .321
.......................................
Indicator .69
.......................................
Parking .120
..........................
Turn Signal .69, 120
....................................
Load Limits .257
....
LOCK (Ignition Key Position) . 131
Locks .....
Anti-thef t Steering Column . 131
............................
Fuel Fill Door .245
..........................................
Hatch .139
...............................
Power Door .133
........................
Low Coolant Level .250
.........................
Low Fuel Indicator .70
................................
Lower Anchors .47
...
Low Oil Pressure Indicator . 62,363
...
Lubricant Specif ications Chart . 380
Index
J
K
L
INDEX
V

..................................
Maintenance .297
......
Main Items and Sub Items . 304
........................................
Minder .299
Owner’s Maintenance ...................................
Checks .307
..........................................
Saf ety .298
.
Malf unction Indicator Lamp . 62,365
.........................
Meters, Gauges .61, 72
...................
Methanol in Gasoline . 244
...........................................
Mirrors .147
....................................
Adjusting .147
........................................
Heated .148
...................
Neutral Gear Position . 273
..................
New Vehicle Break-in . 244
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 378..............................
Paddle Shif ters .276
............
Panel Brightness Control . 124
........................
Park Gear Position .273
...........................................
Parking .284
...............................
Parking Brake .151
Parking Brake and Brake .................
System Indicator . 63,366
...............................
Parking Lights .120
..
Parking Over Things that Burn . 284.............................
PGM-FI System .388
..................
Playing the Radio . 169,181
........................
Playing a Disc .173, 188
............................
PlayinganiPod
. 195
Playing a USB Flash Memory ........................................
Device .202
...................................
Pollen Filter .332
.........
Pregnancy, Using Seat Belts . 19
.........
Protecting Adults and Teens . 12
...
Additional Safety Precautions . 20
.....
Advice f or Pregnant Women . 19
........................
Protecting Children .38
.......................
Protecting Inf ants .43
.......
Protecting Larger Children . 52
.........
Protecting Small Children . 44
...
Octane Requirement, Gasoline . 244
.........................................
Odometer .79 Oil
........................
Change, How to .312
......................
Change, When to .299
......................
Checking Engine .249
..............
Pressure Indicator . 62,363
.......
Selecting Proper Viscosity . 311
.........
ON (Ignition Key Position) . 132
Onboard Ref ueling Vapor ....................................
Recovery .387
............................
Outside Mirrors .147
....
Outside Temperature Indicator . 80
....................
Overheating, Engine .360
....
Owner’s Maintenance Checks . 307
.........................
Oxygenated Fuels .244
...................
Radiator Overheating . 360
..........
Radio/Disc/Sound System . 168
.................
Radio Thef t Protection . 219
...................
Readiness Codes . 365,390
Rear Lights, Bulb ..............................
Replacement .327
..........................
Rear View Mirror .147
...............
Rear Window Def ogger . 126
Index
O P
R
M
N
VI