ignition HONDA INSIGHT 2005 1.G Owner's Guide

If the headlights dim noticeably or
go out when you try to start the
engine, either the battery is
discharged or the connections are
corroded. Check the condition of the
battery and terminal connections
(see page ). You can then try
jump starting the vehicle from a
booster battery (see page ).In this case, the starter motor’s
speed sounds normal, or even f aster
than normal, when you turn the
ignition switch to START (III), but
the engine does not run.
Are you using the proper starting
procedure? Ref er to on page . If youfindnothingwrong,youwill
need a qualif ied technician to f ind
the problem. See
on page .
Do you have f uel? Check the f uel
gauge; the low f uel indicator may
not be working.
There may be an electrical
problem, such as no power to the
f uel pump. Check all the f uses
(see page ).
162
175 109
185 183
If theEngineWon’tStart
T he Starter Operates Normally
Starting the
Engine Emergency
Towing
174

Your vehicle has certain ‘‘readiness
codes’’ that are part of the on-board
diagnostics f or the emissions
systems. In some states, part of the
emissions testing is to make sure
these codes are set. If they are not
set, the test cannot be completed.
If your 12 volt vehicle’s battery has
been disconnected or gone dead,
these codes are erased. It takes at
least three days of driving under
various conditions to set the codes
again.To check if they are set, turn the
ignition to ON (II), without starting
the engine. The malf unction
indicator lamp will come on f or 20
seconds.If itthengoesoff,the
readiness codes are set. If it blinks
f ive times, the readiness codes are
not set. If possible, do not take your
vehicle f or a state emissions test
until the readiness codes are set.
Refer to
f or more inf ormation (see page ).
202
Malf unction Indicator L amp
Readiness Codes
State Emissions T esting
T aking Care of t he Unexpect ed
181

The brake system
indicator normally
comesonwhenyou
turn the ignition switch to ON (II)
and as a reminder to check the
parking brake. It will stay lit if you do
not f ully release the parking brake.
If the brake system indicator comes
on while driving, the brake f luid level
is probably low. Press lightly on the
brake pedal to see if it f eels normal.
If it does, check the brake f luid level
thenexttimeyoustopataservice
station (see page ).
If the f luid level is low, take your
vehicle to a dealer, and have the
brake system inspected f or leaks or
worn brake pads. However, if the brake pedal does not
f eel normal, you should take
immediate action. A problem in one
part of the system’s dual circuit
design will still give you braking at
two wheels. You will f eel the brake
pedal go down much f arther bef ore
the vehicle begins to slow down, and
you will have to press harder on the
pedal.
Slow down by shif ting to a lower
gear, and pull to the side of the road
when it is saf e. Because of the long
distance needed to stop, it is
hazardous to drive the vehicle. You
should have it towed and repaired as
soon as possible (see
on page ). If you must drive the vehicle a short
distance in this condition, drive
slowly and caref ully.
145 183
Brake System Indicator
Emergency
Towing
182
U.S. Canada

The under-hood f use box is in the
engine compartment. To open it,
pushthetabsasshown.If something electrical in your
vehicle stops working, the first thing
youshouldcheckforisablownfuse.
Determine f rom the chart on pages
and , or the diagram on the
fuse box lid, which fuse or fuses
control that device. Check those
f uses f irst, but check all the f uses
bef ore deciding that a blown f use is
the cause. Replace any blown fuses,
andcheckif thedeviceworks.
Turn the ignition switch to LOCK
(0). Make sure the headlights and
all other accessories are of f .
Remove the cover f rom the f use
box.
The interior f use is underneath the
dashboard on the driver’s side.
Remove the storage pocket by
swinging the lid down, pushing up,
and pulling it straight out of its
hinges. 1.
2.188 189
CONT INUED
Checking and Replacing Fuses
Fuses
T aking Care of t he Unexpect ed
185
INTERIOR
TABUNDER-HOOD

Thediagramsinthissectiongive
you the dimensions and capacities of
your vehicle, and the locations of the
identif ication numbers. It also
includes inf ormation you should
know about your vehicle’s tires and
emissions control systems.................
Identif ication Numbers . 192
................................
Specif ications .194
DOT Tire Quality Grading ......................
(U.S. Vehicles) .196
Unif orm Tire Quality ..................................
Grading .196
.................................
Treadwear .196
......................................
Traction .196
.............................
Temperature .197
.................................
Tire Labeling .198 .......................
Emissions Controls .199
.....................
The Clean Air Act .199
Crankcase Emissions Control ....................................
System .199
Evaporative Emissions Control ....................................
System .199
Onboard Ref ueling Vapor ................................
Recovery .199
...
Exhaust Emissions Controls . 200
....................
PGM-FI System .200
Ignition Timing Control ................................
System .200
Three Way Catalytic ...........................
Converter .200
....................
Replacement Parts . 200
..
Three Way Catalytic Converter . 201
..............
State Emissions Testing . 202
....
Testing of Readiness Codes . 202
T echnical Inf ormat ion
T echnical Inf ormation
191

The exhaust emissions controls
include three systems: PGM-FI,
ignition timing control, and three
way catalytic converter. These three
systems work together to control the
engine’s combustion and minimize
the amount of HC, CO, and NOx that
comes out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.The PGM-FI system uses sequential
multiport f uel injection. It has three
subsystems: air intake, engine
control, and f uel control. The
powertrain control module (PCM) in
automatic transmission vehicles or
the engine control module (ECM) in
manual transmission vehicles uses
various sensors to determine how
much air is going into the engine. It
then controls how much f uel to inject
under all operating conditions.The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Honda replacement parts or their
equivalent f or repairs. Using lower
quality parts may increase the
emissions f rom your vehicle.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more inf orma-
tion.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor. This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
2
2
Emissions Cont rols
Exhaust Emissions Controls Replacement PartsPGM-FI Syst em
Three Way Catalytic Converter
Ignit ion T iming Cont rol Syst em
200

CONT INUED
BatteryCharging System ...........................
Indicator .44, 180
............................
Jump Starting .175
..............................
Maintenance .162
............................
Specif ications .195
................................
Bef ore Driving .93
..................................
Belts, Seat .10, 18
.............................
Beverage Holder .71
..................................
Booster Seats .35 Brakes
...........
Anti-lock System (ABS) . 122
................
Break-in, New Linings . 94
....................
Bulb Replacement .149
...........................................
Fluid .144
.........................................
Parking .69
.................
System Indicator . 45,182
........................
Wear Indicators .121
.............................
Braking System .121
...................
Break-in, New Vehicle . 94
..
Brightness Control, Instruments . 57
........................
Brights, Headlights .56
Bulb Replacement ..........................
Back-up Lights .149
..............................
Brake Lights .149
................
Front Parking Lights . 147
........
Front Side Marker Lights . 148
.................................
Headlights .146
............................
Specif ications .195
....................
Turn Signal Lights . 148
..............................
Bulbs, Halogen .146
....................................
Accessories .101
ACCESSORY (Ignition Key .......................................
Position) .61
...............
Accessory Power Socket . 71
....................
Additives, Engine Oil . 136
.............................
Airbag (SRS) .11, 21
...
Airbags, Additional Information . 21
...
Additional Safety Precautions . 24
.............................
Airbag Service .23
..
How the SRS Indicator Works . 23
How Your Front Airbags .........................................
Work .21
........................
SRS Components .21
................
Air Conditioning System . 74
.....................................
Usage .75, 78
.......................
Air Pressure, Tires .156
.........................
Normal Driving .157
.........................
Alcohol in Gasoline .94
......................................
Antif reeze .139
Anti-lock Brakes (ABS) ...............................
Indicator .45, 122
....................................
Operation .122
................
Anti-theft, Audio System . 90Anti-thef t Steering Column
..............................................
Lock .61
..................................
Audio System .80
........................
Auto Idle Stop .111, 118
...
Automatic Seat Belt Tensioners . 19
..............
Automatic Transmission . 113
..........................
Capacity,Fluid .194
...............
Checking Fluid Level . 142
.......................................
Shif ting .114
Shif t Lever Position ...............................
Indicators .113
................
Shif t Lever Positions . 114
....................
Shif t Lock Release . 117
Index
A
B
INDEX
I

.................
Gas Mileage, Improving . 99
...........................................
Gasoline .94
...............
Fuel Reserve Indicator . 46
...........................................
Gauge .49
..................
Octane Requirement . 94
..........................
Tank, Filling the .95
..................
Gas Station Procedures . 95
Gauges ...
Engine Coolant Temperature . 49
...............................................
Fuel .49
Gearshif t Lever Positions Automatic Transmission .....................................
(CVT) .113
..............
Manual Transmission . 110
........................................
Glove Box .71 ...
Identif ication Number, Vehicle . 192
Ignition ..............................................
Keys .59
...........................................
Switch .61
............
Timing Control System . 200
....................
IMA System Indicator . 44
.........
Important Safety Precautions . 8
.........................................
Indicators .44
.......
ABS (Anti-lock Brake) . 45,122 Brake (Parking and Brake
............................
System) .45, 182
................
Charging System . 44,180
DRL (Daytime Running ......................................
Lights) .46
...................................
High Beam .46
...............................................
IMA .44
........
Key (Immobilizer System) . 46
......................................
Low Fuel .46
................
Low Oil Pressure . 44,179
.........................................
SRS .23, 44
Turn Signal and Hazard ...................................
Warning .45
......................................
Inf ant Seats .26
...................
Inf lation, Proper Tire . 156
.........................
Normal Driving .157
...................................
Inside Mirror .68
.............................
Inspection, Tire .158
............................
Instrument Panel .43
........
Instrument Panel Brightness . 57
.................................
Interior Lights .72
........................................
Introduction . i
.............
Halogen Headlight Bulbs . 146
Hatch .................................
Opening the .63
.............
Open Monitor Indicator . 46
.................
Hazard Warning Button . 57Headlights
........................................
Aiming .146
.....
Daytime Running Lights . 46,56
..................
High Beam Indicator . 46
...........................
Reminder Tone .56
........
Replacing Halogen Bulbs . 146
...................................
Turning on .56
.............................................
Heating .76
.............
High Altitude, Starting at . 109
.................
High-Low Beam Switch . 56
.........................
Hood, Opening the .96
..................................................
Horn .54
...........................
Hydraulic Clutch .145
Index
H I
G
IV

CONT INUED
.................
Jacking up the Vehicle . 169
.......................................
Jack, Tire .167
................................
Jump Starting .175
..................................................
Keys .59
.......................
Label, Certif ication .192
.................
Lane Change, Signaling . 56
....................
Lap/Shoulder Belt .14, 18
....................
Lif etime Fuel Mileage . 51
Lights ....................
Bulb Replacement .146
.....................................
Indicators .44
.........................................
Parking .56
..................................
Turn Signal .56
.....................................
Load Limit .104
......
LOCK (Ignition Key Position) . 61
Locks .......
Anti-thef t Steering Column . 61
..............................
Fuel Fill Door .95 ............................................
Hatch .62
.................................
Power Door .62
..........................
Low Coolant Level .98
.........................
Low Fuel Indicator .46
...
Lower Gear, Downshif ting to a . 110
...
Low Oil Pressure Indicator . 44,179
...
Lubricant Specif ications Chart . 194
...........
Luggage, Storing (Cargo) . 103
..................................
Maintenance .125
Owner’s Maintenance ...................................
Checks .128
........................................
Record .131
......................
Required Indicator .47
..........................................
Saf ety .126
....................................
Schedule .127
.
Malf unction Indicator Lamp . 45,180
...................
Manual Transmission . 110
...............
Checking Fluid Level . 143
................................
Shif ting the .110
........
Manual Transmission Fluid . 143
.........................
Meters, Gauges .43, 48
..........................
Mirrors, Adjusting .68
...............
Modif ying Your Vehicle . 102...................
Neutral Gear Position . 114
....................
New Vehicle Break-in .94
..................
NOTICE, Explanation of . ii
...............
Numbers, Identif ication . 192
.....
Octane Requirement, Gasoline . 94
.........................................
Odometer .49
...............................
Odometer, Trip .50
Oil ........................
Change, How to .136
......................
Change, When to .129
........................
Checking Engine .97
..............
Pressure Indicator . 44,179
Selecting Proper Viscosity ......................................
Chart .136
...........
ON (Ignition Key Position) . 61
Onboard Ref ueling Vapor ....................................
Recovery .199
.........................
Opening the Hatch .63
..............................
Outside Mirrors .68
Index
M N
O
J
K
L
INDEX
V

Î
CONT INUED
...................................
Seat Belts .10, 18
...............
Additional Information . 18
Automatic Seat Belt ...............................
Tensioners .19
.....................................
Cleaning .151
......................
Lap/Shoulder Belt .18
................................
Maintenance .19
Reminder Indicator and ................................
Beeper .18, 44
...................
System Components . 18
...............
Use During Pregnancy . 16
...
Wearing a Lap/Shoulder Belt . 14
........................
Seats, Adjusting the .66
...............................
Serial Number .192
...........................
Service Intervals .129
...........................
Service Manual .207
...........
Service Station Procedures . 95
............................
Setting the Clock .91
...
Shif t Lever Position Indicators . 113
........................
Shif t Lock Release .117
Side Marker Lights, Bulb ......................
Replacement .148, 149
...............................
Signaling Turns .56
.....................................
Snow Tires .161
..................................
Sound System .80 Spare Tire
......................................
Inf lating .166
............................
Specif ications .195
....................
Specif ications Charts . 194
.........................................
Spotlights .72
..........
SRS, Additional Inf ormation . 21
...
Additional Safety Precautions . 24
.............................
Airbag Service .23
How the SRS Indicator .......................................
Works .23
How Your Front Airbags .........................................
Work .21
........................
SRS Components .21
.............................
SRS Indicator .23 ,44
....
START (Ignition Key Position) . 61
.......................
Starting the Engine .109
In Cold Weather at High ..................................
Altitude .109
................
With a Dead Battery . 175
..............
State Emissions Testing . 202
........
Steam Coming f rom Engine . 177
Steering Wheel .............
Anti-theft Column Lock . 61
.....................
Stereo Sound System .80
....................
Storing Your Vehicle .163 Supplemental Restraint
................................
System .11, 21
......................................
Servicing .23
.........................
SRS Indicator .23, 44
...................
System Components . 21
..................................
Synthetic Oil .136
......
Taillights, Changing Bulbs in . 149
Taking Care of the ...............................
Unexpected .165
Technical Descriptions ......
DOT Tire Quality Grading . 196
.....
Emissions Control Systems . 199
..........
State Emissions Testing . 202
Three Way Catalytic ...............................
Converter .201
.......................
Temperature Gauge .49
..........
Temperature, Inside Sensor . 79
..............
Tether Anchorage Points . 33
..............................
Thef t Protection .90
..
Three Way Catalytic Converter . 201
............................
Time, Setting the .91
Index
T
INDEX
VII