engine HONDA ODYSSEY 2001 RA6-RA9 / 2.G Manual Online

A defective three way catalytic
converter contributes to air pollution,
and can impair your engine’s per-
f ormance. Follow these guidelines to
protect your vehicle’s three way
catalytic converter.Keep the engine tuned-up.
Have your vehicle diagnosed and
repaired if it is misf iring, back-
f iring, stalling, or otherwise not
running properly.
Always use unleaded gasoline.
Even a small amount of leaded
gasoline can contaminate the
catalyst metals, making the three
way catalytic converter inef f ective.
The three way catalytic converter
contains precious metals that serve
as catalysts, promoting chemical
reactions to convert the exhaust
gasses without af f ecting the metals.
The catalytic converter is ref erred to
as a three-way catalyst, since it acts
on HC, CO, and NOx. A replacement
unit must be an original Honda part
or its equivalent.
The three way catalytic converter
must operate at a high temperature
for the chemical reactions to take
place. It can set on f ire any com-
bustible materials that come near it.
Parkyourvehicleawayfromhigh
grass, dry leaves, or other f lamma-
bles.
Three Way Catalytic Converter
T echnical Inf ormation
342
TTHHRREEEEWWAAYYCCAATTAALLYYTTIICCCCOONNVVEERRTTEERR

CONT INUED
If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle re-tested within the
next two or three days, you can
condition the vehicle for re-testing
by doing the f ollowing.
Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the vehicle has been
parked with the engine of f f or 8
hours or more.
Make sure the ambient
temperature is between 20° and
95°F. Without touching the accelerator
pedal, start the engine and let it
idle f or 20 seconds.
Keep the vehicle in Park
(automatic transmission). Increase
the engine speed to 2,000 rpm and
hold it there until the temperature
gauge rises to at least 1/4 of the
scale (approximately 3 minutes).
T echnical Inf ormation
St at e Emissions T est ing
T esting of Readiness Codes
343

µµ
µ
( % ) $
%."#)
This manual complements the Service Manual by
providing in-depth troubleshooting inf ormation f or each
electrical circuit in your vehicle.
This manual describes the procedures involved in the
replacement of damaged body parts.
This manual covers maintenance and recommended
procedures f or repair to engine and chassis components.
It is written f or the Journeyman mechanic, but is simple
enough f or most mechanically-inclined owners to under-
stand.
Authorized Manuals
Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
352 NOTE: Dealers and Companies please provide dealer or company name,
and also the name of the person to whose attention the shipment should
be sent. For purchases outside U.S.A. please write to the address shown
below for a quotation.
P.O. BOX 07280·DETROIT, MICHIGAN 48207·1-800-782-4356
Customer Name
Attention
Apartment Number
State & Zip Code
City
Daytime Telephone Number
Check or money order enclosed payable to Helm Inc U.S. funds only.
Do not send cash
Master
Card VISA Check here if your billing address is different
from the shipping address shown above.
Account Number Expiration: Mo. Yr.
CUSTOMER SIGNATURE DATE
Street Address No P.O. Box Number
()
These Publications cannot be returned for credit without receiving advance authorization within 14
days of delivery. On returns, a restocking fee may be applied against the original order.

CONT INUED
...
Accessories and Modif ications . 203
................................
Accessories . 203
...
Additional Safety Precaution . 204
............................
Modif ications . 204
ACCESSORY (Ignition Key .......................................
Position) . 83
............
Accessory Power Sockets . 130
....................
Additives, Engine Oil . 251
...............................
Airbag (SRS) . 9, 53
.....................
Air Cleaner Element . 262
.................
Air Conditioning Filter . 272
......
Air Conditioning System . 136, 144
..............................
Maintenance . 271
.....................
Rear A/C Control . 158
.................................
Usage . 136, 144
...............
Air Outlets (Vents) . 138, 144
.......................
Air Pressure, Tires . 273
.......................
Alcohol in Gasoline . 338
.......
Aluminum Wheels, Cleaning . 295
......................................
Antif reeze . 253
Anti-lock Brakes (ABS)
...............................
Indicator . 63, 220
...................................
Operation . 219
..............
Anti-thef t, Audio System . 192 .
Anti-thef t Steering Column Lock . 82
..........................
Appearance Care . 293
........................................
Armrests . 109
...............
Audio Controls, Remote . 191
........................
Audio System . 161, 173
...
Automatic Seat Belt Tensioners . 54
...
Automatic Lighting Off Feature . 71
...............
Automatic Speed Control . 77
..............
Automatic Transmission . 212
..........................
Capacity,Fluid .334
...............
Checking Fluid Level . 259
.......................................
Shif ting . 213
.
Shif t Lever Position Indicator . 212
................
Shif t Lever Positions . 213
....................
Shif t Lock Release . 216
Battery Charging System ...........................
Indicator . 62, 319
............................
Jump Starting . 313
..............................
Maintenance . 267
............................
Specif ications . 335
..............................
Bef ore Driving . 195
....................................
Belts,Seat .8,49 ...........................
Beverage Holder . 124
...................................
Body Repair . 300
Brakes
...........
Anti-lock System (ABS) . 219
.............
Break-in, New Linings . 196
....................
Bulb Replacement . 284
...........................................
Fluid . 260
.......................................
Parking . 122
.................
System Indicator . 62, 322
........................
Wear Indicators . 218
.............................
Braking System . 218
.................
Break-in, New Vehicle . 196
..
Brightness Control, Instruments . 71
........................
Brights, Headlights . 70
Bulb Replacement
..........................
Back-up Lights . 285
..............................
Brake Lights . 284
......................
Cargo Area Light . 288
................
Front Parking Lights . 283
........
Front Side Marker Lights . 283
.................................
Headlights . 282
.........
High-mount Brake Light . 286
..............
Individual Map Lights . 288
...................
License Plate Light . 287
Index
A
B I

Î
Bulb Replacement
.........................
Rear Bulbs . 284, 285
............................
Specif ications . 335
....................
Turn Signal Lights . 283
..............................
Bulbs, Halogen . 282
..................................
Cancel Button . 79
............................
Capacities Chart . 334
.............
Carbon Monoxide Hazard . 57
..........................
Cargo Area Light . 133
......................................
Cargo Net . 208
.............................
Carrying Cargo . 205
Cassette Player
............................................
Care . 190
...........................
Operation . 166, 187
..............
CAUTION, Explanation of . ii
..........................
CD Changer . 169, 183
..............................
CD Player . 169, 181
...............................
Center Pocket . 128
..................................
Center Table . 123
........................
Certif ication Label . 332
............................................
Chains . 279
Changing Oil
........................................
How to . 251 ......................................
When to . 240
....................
Changing a Flat Tire . 303
............
Changing Engine Coolant . 255
...
Charging System Indicator . 62, 319
............
Checklist, Bef ore Driving . 210
..................
Childproof Door Locks . 89
.....................................
Child Saf ety . 22
.........................................
Child Seat . 28
..........
Tether Anchorage Points . 45
....................
Cleaner Element, Air . 262
Cleaning
....................
Aluminum Wheels . 295
...................................
Carpeting . 296
......................................
Exterior . 294
.........................................
Fabric . 297
.......................................
Interior . 296
...................................
Seat Belts . 297
...........................................
Vinyl . 297
....................................
Windows . 298
...............
Climate Control System . 144
.........................
Clock, Setting the . 123
......................................
Coat Hook . 129
.....................
Code, Audio System . 192
........................
CO in the Exhaust . 340
...................................
Coin Holder . 128
............
Cold Weather, Starting in . 211 ..............................
Compact Spare . 302
...............
Consumer Inf ormation . 346
.............
Controls, Instruments and . 59
Coolant
........................................
Adding . 253
....................................
Checking . 201
.........................
Proper Solution . 253
...................................
Replacing . 255
...................
Temperature Gauge . 67
....................
Corrosion Protection . 299
Crankcase Emissions Control
........................................
System . 340
..............
Cruise Control Operation . 77
..........
Customer Relations Of f ice . 346
................
DANGER, Explanation of . ii
...................................
Dashboard . 2, 60
................
Daytime Running Lights . 71
............
Def ects, Reporting Saf ety . 350
................
Def ogger, Rear Window . 75
......
Def rosting the Windows . 141, 151
....................................
Dimensions . 334
...............
Dimming the Headlights . 70
Index
C
D
II

CONT INUED
Dipstick..........
Automatic Transmission . 259
..................................
Engine Oil . 200
..........................
Directional Signals . 72
........
Disc Brake Wear Indicators . 218
.....................
Disposal of Used Oil . 252
Doors
..............
Locking and Unlocking . 83
....................
Lockout Prevention . 84
.................
Manual Sliding Doors . 92
..............................
Monitor Light . 64
......................
Power Door Locks . 83
...................
Power Sliding Doors . 94
..........
DOT Tire Quality Grading . 336
.....................................
Drive Belts . 272
...........
Driver and Passenger Safety . 5
...........................................
Driving . 209
....................................
Economy . 202
.........................
In Bad Weather . 224
................
In Foreign Countries . 339 ............................
Fabric, Cleaning . 297
..........................
Fan, Interior . 136, 148
Features, Comfort and
..............................
Convenience . 135
....................
Filling the Fuel Tank . 197
Filters
...............................................
Air . 262
.......................
Air Conditioning . 272
...............................................
Oil . 251
.............
Flashers, Hazard Warning . 75
...................
Flat Tire, Changing a . 303
.......................................
Floor Mat . 296
Fluids
..........
Automatic Transmission . 259
..........................................
Brake . 260
..........................
Power Steering . 261
..............................
Economy, Fuel . 202
............
Emergencies on the Road . 301
.............
Battery, Jump Starting . 313 Emergencies on the Road
...........
Brake System Indicator . 322
................
Changing a Flat Tire . 303
.....
Charging System Indicator . 319
..................
Checking the Fuses . 323
.....
Low Oil Pressure Indicator . 318
...
Malf unction Indicator Lamp . 320
..................
Overheated Engine . 315
.........................
Emergency Brake . 122
......................
Emergency Flashers . 75
......................
Emergency Towing . 329
.......................
Emissions Controls . 340
.............
Emissions Testing, State . 343Engine
....
Coolant Temperature Gauge . 67
.................................
Drive Belts . 272
Malf unction Indicator
................................
Lamp . 62, 320
........
Oil Pressure Indicator . 62, 318
..............
Oil, What Kind to Use . 249
...............................
Overheating . 315
............................
Specif ications . 335
.......................................
Starting . 211
......................
Ethanol in Gasoline . 338
.
Evaporative Emissions Controls . 340
...............................
Exhaust Fumes . 57 Exhaust Gas Recirculation
........................................
System . 341
Expectant Mothers, Use of Seat ........................................
Belts by . 20
..................
Exterior,Cleaningthe .294
Index
E F
III

Fluids..................
Windshield Washer . 258
FM Stereo Radio
...........................
Reception . 162, 174
.................
Folding the Third Seat . 115
.....
Foreign Countries, Driving in . 339
..........................
Four-way Flashers . 75
.................................................
Fuel . 196
......................
Fill Door and Cap . 197
...........................................
Gauge . 67
................
Octane Requirement . 196
...............................
Oxygenated . 338
........................
Reserve Indicator . 65
........................
Tank, Filling the . 197
.....................
Fuses, Checking the . 324
...............
Gas Mileage, Improving . 202
..........................................
Gasohol . 338
.........................................
Gasoline . 196
...............
Fuel Reserve Indicator . 65
...........................................
Gauge . 67
................
Octane Requirement . 196
........................
Tank, Filling the . 197
................
Gas Station Procedures . 197 Gauges
...
Engine Coolant Temperature . 67
...............................................
Fuel . 67
...............................
Speedometer . 66
.................................
Tachometer . 66
GAWR (Gross Axle Weight
.......................................
Rating) . 228
GCWR (Gross Combined Weight .......................................
Rating) . 228
............
Gearshif t Lever Positions . 213
..............................
Glass Cleaning . 298
........................................
Glove Box . 91
GVWR (Gross Vehicle Weight
.......................................
Rating) . 228
.............
Halogen Headlight Bulbs . 282
..............
Hazard Warning Flashers . 75
........................................
Headlights . 70
........................................
Aiming . 282
..............
Automatic Lighting Off . 71
............
Daytime Running Lights . 71
..................
High Beam Indicator . 65
.........................
Reminder Chime . 70
........
Replacing Halogen Bulbs . 282 ...................................
Turning on . 70
............................
Head Restraints . 110
...............................
Heated Mirror . 122
.....................
Heating and Cooling . 136
.............
High Altitude, Starting at . 211
.................
High-Low Beam Switch . 70
HomeLink Universal
.................................
Transmitter . 99
....................................
Hood Latch . 264
.......................
Hood, Opening the . 198
..................................................
Horn . 69
.................................
Hydroplaning . 225
...
Identif ication Number, Vehicle . 332
Ignition
..............................................
Keys . 80
...........................................
Switch . 82
............
Timing Control System . 341
........................
Immobilizer System . 81
.........
Important Safety Precautions . 6
.........
Indicators, Instrument Panel . 61
..................
Individual Map Lights . 133
...............................
Inf ant Restraint . 32
Index
G H I
IV

..............................
Paint Touch-up . 295
..............
Panel Brightness Control . 71
........................
Park Gear Position . 213
...........................................
Parking . 217
...............................
Parking Brake . 122 .................................
Parking Lights . 70
..
Parking Over Things that Burn . 217
.............................
PGM-FI System . 341
..................
Polishing and Waxing . 295
Power Sliding Doors
.................................
Indicator . 64, 98
.....................................
Operation . 94
.......................................
Switches . 94
............
Pre-Drive Saf ety Checklist . 11
.........
Pregnancy, Using Seat Belts . 20
............................
Protecting Adults . 12
...
Additional Safety Precautions . 20
.....
Advice f or Pregnant Women . 20
........................
Protecting Children . 22
.......................
Protecting Inf ants . 32
.......
Protecting Larger Children . 41
.........
Protecting Small Children . 37
Using Child Seats with
.....................................
Tethers . 45
.....................
Lower Anchorages . 47
...
Octane Requirement, Gasoline . 196
.........................................
Odometer . 66
...............................
Odometer, Trip . 67
Oil
........................
Change, How to . 251
......................
Change, When to . 240
......................
Checking Engine . 200
..............
Pressure Indicator . 62, 318
Selecting Proper Viscosity
......................................
Chart . 250
...........
ON (Ignition Key Position) . 83
..
Operation in Foreign Countries . 339
............................
Outside Mirrors . 121
....................
Overheating, Engine . 315
.......
Owner Maintenance Checks . 247
.........................
Oxygenated Fuels . 338
...................
Radiator Overheating . 315
.............
Radio/CD Sound System . 173
...........................
Readiness Codes . 321 ...............................
Rear A/C Unit . 158
.......................
Rear Compartment . 128
Rear Lights, Bulb
......................
Replacement . 284, 285
..........................
Rear View Mirror . 121
.................
Rear Window Def ogger . 75
...............................
Rear Windows . 120
.
Rear Window Wiper and Washer . 74
.....
Reclining the Seat Backs . 106, 109
.........
Reclining the Second Seats . 106
..............
Reclining the Third Seat . 106
.............................
Reminder Lights . 61
................
Remote Audio Controls . 191
.......................
Remote Transmitter . 85
Removing the Second
...........................................
Seats . 114
Replacement Inf ormation .................
Air Cleaner Element . 262
.......................................
Coolant . 255
................
Engine Oil and Filter . 251
..........................................
Fuses . 323
................................
Light Bulbs . 282
....................................
Schedule . 238
................................
Spark Plugs . 264
................................
Timing Belt . 273
...........................................
Tires . 277
Index
P
O
R
VI

ÎÎ
CONT INUED
.............................
Wiper Blades . 269
Replacing Seat Belts Af ter a ............................................
Crash . 51
...
Reserve Tank, Engine Coolant . 201
..................
Reverse Gear Position . 214
................................
Rotation, Tire . 276
..................................
Saf ety Belts . 8, 49
.........
Safety Defects, Reporting . 350
.................................
Saf ety Features . 7
..........................................
Air bags . 9
..................................
Door Locks . 10
..........................
Head Restraints . 10
.......................................
Seat Belts . 8
.....................
Seats & Seat-Backs . 10
.............
Saf ety Labels, Location of . 58
...............................
Saf ety Messages . ii
.....................................
Seat Belts . 8, 49
...............
Additional Information . 49
Automatic Seat Belt
...............................
Tensioners . 54
.....................................
Cleaning . 297
......................
Lap/Shoulder Belt . 49
................................
Maintenance . 51 Reminder Light and
................................
Beeper . 49, 61
...................
System Components . 49
...............
Use During Pregnancy . 20
...
Wearing a Lap/Shoulder Belt . 15
...............................................
Seats . 104
..............................
Adjustments . 105
.............
Folding the Third Seat . 115
........................
Head Restraints . 110
.......
Manual Height Ajustment . 107
....................
Passenger Seating . 104
.......
Reclining the Second Seat . 106
..........
Reclining the Third Seat . 106
....
Removing the Second Seats . 114
.....................
Third Seat Access . 111
............................
Security System . 193
...............................
Serial Number . 332
...........................
Service Intervals . 240
...........................
Service Manual . 351
.........
Service Station Procedures . 197
..........................
Setting the Clock . 123
.....
Shif t Lever Position Indicator . 212
........................
Shif t Lock Release . 215
Side Marker Lights, Bulb
..............................
Replacement . 283
...............................
Signaling Turns . 72 ...................................
Sliding Doors . 92
.....................................
Snow Tires . 279
...................
Solvent-type Cleaners . 294
........................
Sound System . 161, 173
Spare Tire
......................................
Inf lating . 302
............................
Specif ications . 335
....................................
Spark Plugs . 264
....................
Specif ications Charts . 334
..................................
Speed Control . 77
...................................
Speedometer . 66
..........
SRS, Additional Inf ormation . 52
...
Additional Safety Precautions . 56
How the Automatic Seat Belt
....................
Tensioners Work . 54
..
How the SRS Indicator Works . 54
...........
How Your Airbags Work . 52
........................
SRS Components . 52
..................................
SRS Service . 55
.............................
SRS Indicator . 54, 62
....
START (Ignition Key Position) . 83
Index
S
VII

.....................................
Tachometer . 66
............................................
Tailgate . 89
.................................
Opening the . 89
...................
Open Monitor Light . 64 ......
Taillights, Changing Bulbs in . 285
.
Taking Care of the Unexpected . 301
...........................
Tape Player . 166, 187
Technical Descriptions
.....
Emissions Control Systems . 340
.....................
Oxygenated Fuels . 338
Three Way Catalytic
...............................
Converter . 342
.......................
Temperature Gauge . 67
...................
Tensioners, Seat Belts . 54
..............
Tether Anchorage Points . 45
............................
Thef t Protection . 192
..
Three Way Catalytic Converter . 342
..........................
Time, Setting the . 123
....................................
Timing Belt . 273
....................................
Tire Chains . 279
.........
Tire, How to Change a Flat . 303
...............................................
Tires . 273
..............................
Air Pressure . 273
...................................
Balancing . 276
.........................
Checking Wear . 275
..........................
Compact Spare . 302
......
DOT Tire Quality Grading . 336
......................................
Inf lation . 273
..................................
Inspection . 275
...................................
Replacing . 277 ......................................
Rotating . 276
...........................................
Snow . 279
............................
Specif ications . 335
................................
Tire Chains . 279
Towing .....................................
A Trailer . 226
................
Emergency Wrecker . 329
..
Traction Control System (TCS) . 221
Transmission
...............
Checking Fluid Level . 259
...........................
Fluid Selection . 259
..............
Identif ication Number . 333
.............
Shif ting the Automatic . 213
.....................................
Treadwear . 336
.......................................
Trip Meter . 67
....................................
Turn Signals . 72
...................
Tools, Tire Changing . 303
.....................
Underside, Cleaning . 299
Unexpected, Taking Care
..........................................
of the . 301
....
Unif orm Tire Quality Grading . 336
........................
Unleaded Gasoline . 196
.....................
Upholstery Cleaning . 296
.......................
Starting the Engine . 211
In Cold Weather at High
..................................
Altitude . 211
................
With a Dead Battery . 313
..............
State Emissions Testing . 343
........
Steam Coming f rom Engine . 315
Steering Wheel
..................................
Adjustment . 76
.............
Anti-theft Column Lock . 82
...........
Stereo Sound System . 161, 173
....................
Storing Your Vehicle . 291
...................................
Storage Box . 129
........................
Sunglasses Holder . 126
........................................
Sun Visor . 127
Supplemental Restraint System
......................................
Servicing . 55
.........................
SRS Indicator . 54, 62
...................
System Components . 52
..................................
Synthetic Oil . 250
Index
T U
VIII