battery HONDA PILOT 2004 1.G Owner's Manual

µ
Connect the second jumper cable
to the negative ( ) terminal on
the booster battery. Connect the
other end to the grounding strap
as shown. Do not connect this
jumper cable to any other part of
the engine.
If the booster battery is in another
vehicle, have an assistant start
that vehicle and run it at a fast idle. Start your vehicle. If the starter
motor still operates slowly, check
that the jumper cables have good
metal-to-metal contact.
Once your vehicle is running,
disconnect the negative cable f rom
your vehicle, then f rom the
booster battery. Disconnect the
positive cable f rom your vehicle,
and then from the booster battery.
Keep the ends of the jumper cables
away from each other and any metal
on the vehicle until everything is
disconnected. Otherwise, you may
cause an electrical short.
4.
5. 6.
7.
T aking Care of t he Unexpect ed
Jump Starting
203

Let the vehicle sit f or a minute.
Open the hood, and check the oil
level (see page ). An engine
very low on oil can lose pressure
during cornering and other driving
maneuvers.
If necessary, add oil to bring the
level back to the full mark on the
dipstick (see page ).
Start the engine, and watch the oil
pressure light. If it does not go out
within ten seconds, turn off the
engine. There is a mechanical
problem that needs to be repaired
bef ore you can continue driving.
(Seeon page
).
This light should never
come on when the engine is
running. If it starts f lashing or stays
on, the oil pressure has dropped very
low or lost pressure. Serious engine
damage is possible and you should
take immediate action. Saf ely pull of f the road, and shut
of f the engine. Turn on the hazard
warning lights.
If the charging system
indicator comes on brightly
when the engine is running, the
battery is not being charged.
Immediately turn of f all electrical
accessories. Try not to use other
electrically operated controls such as
the power windows. Keep the engine
running; starting the engine will
discharge the battery rapidly.
Go to a service station or garage
where you can get technical
assistance.
1.
2.
3.
4.
171
127
208
L ow Oil Pressure Indicator
Emergency T owingCharging System Indicator
T aking Care of t he Unexpect ed
L ow Oil Pressure L ight, Charging System Indicator
206
NOTICE:
Running the engine with low
oil pressure can cause serious
mechanical damage almost immediately.
Turn of f the engine as soon as you can
saf ely get the vehicle stopped.

If the indicator comes on
while driving, it means one
of the engine’s emission control
systems may have a problem. Even
though you may f eel no dif f erence in
your vehicle’s perf ormance,
continued operation may cause
serious damage.
If you have recently ref ueled your
vehicle, the cause of this indicator
coming on could be a loose or
missing f uel f ill cap. Check the cap
or replace it. Tightening the cap will
not make the indicator turn of f
immediately; it takes at least three
days of normal driving.
If the indicator remains on or the
f uel cap was not loose or missing,
have the vehicle checked by the
dealer as soon as possible. If the malf unction indicator lamp
comes on along with the ‘‘D’’
indicator, there is a problem in the
automatic transmission control
system.
Your vehicle has certain ‘‘readiness
codes’’ that are part of the on-board
diagnostics f or the emissions
systems. In some states, part of the
emissions testing is to make sure
these codes are set. If they are not
set, the test cannot be completed.If your vehicle battery has been
disconnected or gone dead, these
codes are erased. It takes at least
three days of driving under various
conditions to set the codes again.
To check if they are set, turn the
ignition to ON (II), without starting
the engine. The Malf unction
Indicator Lamp will come on f or 20
seconds. If it then goes of f , the
readiness codes are set. If it blinks 5
times, the readiness codes are not
set. If possible, do not take your
vehicle f or a state emissions test
until the readiness codes are set.
Refer to State Emissions Testing for
more information (see page ).
226
Malf unction Indicator L amp
Readiness Code
Malf unction Indicator
T aking Care of t he Unexpect ed207
NOTICE:If you keep driving with the
Malf unction Indicator Lamp on, you
can damage your vehicle’s emission
controls and the engine. Those repairs
may not be covered by your vehicle’s
warranties.

The vehicle’s f uses are located in
f our f use boxes. The interior f use
boxes are located under the
dashboard on the driver’s and
passenger’s side.To open the passenger’s side, pull
the right edge of the cover.
The primary under-hood f use box is
locatedonthepassenger’sside.The
secondary f use box is next to the
battery.
Fuses
T aking Care of t he Unexpect ed209
UNDER-
HOOD
FUSE
BOXES
PASSENGER’ S SIDE INTERIOR
DRIVER’ S SIDE INTERIOR

µ
No. Amps. Circuits Protected
No. Amps. Circuits ProtectedNo. Amps. Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12
13 20 A
30 A
20 A
15 A
15 A
20 A
20 A
20 A
40 A
40 A
30 A
40 A Spare Fuse
Spare Fuse
Right Headlight
ACG S
Hazard
Not used
Stop
Lef t Headlight
Radio
Power Window Motor
Power Seat
Rear Defroster
Back Up, ACC
1
2
3
4 40 A
20 A
20 A
20 A ABS Motor
ABS F/S
Rear ACC Socket
4WD 14
15
16
17
18
19
20
21
22
23
24
30 A
40 A
30 A
7.5 A 10 A
15 A
120 A 30 A
7.5 A 50 A
20 A Rear A/C
Heater Motor
Cooling Fan
Spare Fuse
Spare Fuse
Spare Fuse
Battery
Condenser Fan
MG Clutch
IGI Main
Trailer (accessory)
Fuse Locations
T aking Care of t he Unexpect ed212
PRIMARY UNDER-HOOD FUSE BOX
SECONDARY UNDER-HOOD FUSE BOX

µ µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Specif ications
T echnical Inf ormation219
Lights
Battery
Fuses
Engine
Alignment
Tires
60 W/55 W
12 V
60 psi (420 kPa , 4.2 kgf/cm
)
32 psi (220 kPa , 2.2 kgf/cm)
T155/90D16 110M P235/70R16 104S 1°88’
0°50’ 0°50’
0.00 in (0.0 mm)
0.00 in (0.0 mm) 10.0 : 1
211.8 cu-in (3,471 cm
)
3.50 x 3.66 in (89.0 x 93.0 mm)
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V 12 V
12 V
12 V
5W
27 W/8 W
5W
21 W/5 W
21 W/5 W
21 CP (18 W)
5W
18 W
6.2 W
5W
1.1 W
3.8 W
12 V 65 AH/20 HR 14 V 12 V 12.4 W 1.4 W
Headlights
Front side marker lights
Front turn signal lights/
Parking lights
Rear side marker lights
Rear turn signal/hazard lights
Stop/Taillights
Backup lights
License plate lights
High-mount brake light
Individual map lights
Tailgate light
Vanity mirror light
Door (Courtesy) light
Grabrail lights
Console lights
Capacity Interior
Under-hood
Type
BorexStroke
Displacement
Compression ratio
Spark plugs
Water cooled 4-stroke SOHC,
V6 gasoline engine
Toe-in
Camber
Caster
Size
Pressure See page
213or the fuse label
attached to the dashboard.
See page 213or the fuse label
attached to the inside of the fuse
box door under the dashboard.
See page 212or the fuse box
cover.
PZFR5F-11
PKJ16CR-L11
Front/Rear
Spare
Front/Rear
Spare Front
Rear
Front
Rear
Front
Driver’s side
Passenger’s side
(1157 NA)
(168)
(7443)
(7443) (921)
(168)
(921)
(204)
(HB2)
(168)
Front
Rear
Front
Rear
Front NGK:
DENSO:

If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle re-tested within the
next two or three days, you can
condition the vehicle for re-testing
by doing the f ollowing.Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the vehicle has been
parked with the engine of f f or 8
hours or more.
Make sure the ambient
temperature is between 20° and
95°F.
Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
Keep the vehicle in Park. Increase
the engine speed to 2,000 rpm and
hold it there until the temperature
gauge rises to at least 1/4 of the
scale (approximately 3 minutes).
Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D. Do not use the cruise control.
When traffic allows, drive for 90
seconds without moving the
accelerator pedal. (Vehicle speed
may vary slightly; this is okay.) If
you cannot do this f or a
continuous 90 seconds because of
traf f ic conditions, drive f or at least
30 seconds, then repeat it two
more times (for a total of 90
seconds).
T esting of Readiness Codes
St at e Emissions T est ing
T echnical Inf ormation226

µ
µ
µ µ
µ µµ
µ
µ
Your new Honda is covered by these
warranties:
covers your new vehicle, except f or
the battery, emissions control
systems, and accessories, against
def ects in materials and
workmanship.
these two
warranties cover your vehicle’s emis-
sions control systems. Time, mileage,
and coverage are conditional. Please
read the warranty manual for exact
inf ormation.
this warranty gives up
to 100 percent credit toward a
replacement battery. a seat
belt that f ails to f unction properly is
coveredfortheusefullifeof the
vehicle.
all exterior body panels are
covered f or rust-through f rom the
inside f or the specif ied time period
with no mileage limit.
Honda Accessories are covered
under this warranty. Time and
mileage limits depend on the type of
accessory and other f actors. Please
read your warranty manual f or
details. provides prorated
coverage f or a replacement battery
purchased f rom a Honda dealer.
provides
coverageforaslongasthepur-
chaser of the muf f ler owns the
vehicle.
Restrictions and exclusions apply to
all these warranties. Please read the
2004 Honda Warranty Inf ormation
booklet that came with your vehicle
f or precise inf ormation on warranty
coverages. Your Honda’s original
tires are covered by their
manuf acturer. Tire warranty inf or-
mation is in a separate booklet.
Please ref er to the 2004 Warranty
Manual that came with your vehicle.
covers all genuine
Honda replacement parts against
def ects in materials and
workmanship.
U.S. Owners
Canadian OwnersNew Vehicle L imit ed Warrant yEmissions Cont rol Syst ems Def ect sWarrant y and EmissionsPerf ormance Warranty
Original Equipment Bat t ery L imit edWarranty Seat Belt Limited Warranty
Rust Perf orat ion L imit ed Warrant y
Accessory Limited Warranty Replacement Bat t ery L imit ed
Warranty
Replacement Muf f ler L if et imeLimited Warranty
Replacement Part s L imit ed Warranty
T echnical Inf ormation
Warranty Coverages
231

CONT INUED
BatteryCharging System ...........................
Indicator .48, 206
............................
Jump Starting .202
..............................
Maintenance .193
............................
Specif ications .219
..............................
Bef ore Driving .123
....................................
Belts,Seat .8,16
...........................
Beverage Holders .77
..................................
Booster Seats .39 Brakes
...........
Anti-lock System (ABS) . 145
.............
Break-in, New Linings . 124
...........................................
Fluid .178
....................
Bulb Replacement .182
.........................................
Parking .75
.................
System Indicator . 49,208
........................
Wear Indicators .145
.............................
Braking System .144
.................
Break-in, New Vehicle . 124
..
Brightness Control, Instruments . 59
........................
Brights, Headlights .58
Bulb Replacement ..............................
Brake Lights .182
................
Front Parking Lights . 181
........
Front Side Marker Lights . 183
.................................
Headlights .180
........
High-mount Brake Lights . 182
.................................
Rear Bulbs .182
............................
Specif ications .219
.............
Turn Signal Light . 181,182
..............................
Bulbs, Halogen .180
...
Accessories and Modif ications . 129
ACCESSORY (Ignition Key .......................................
Position) .64
..............
Accessory Power Sockets . 77
....................
Additives, Engine Oil . 172
...............................
Airbag (SRS) .9, 19
.....
Airbags, Additional Infomation . 19
...
Additional Safety Precautions . 24
.............................
Airbag Service .24
How the Side Airbag Of f ......................
Indicator Works .23
..
How the SRS Indicator Works . 23
How Your Front Airbags .........................................
Work .20
...
How Your Side Airbags Work . 22
........................
SRS Components .19
................
Air Conditioning System . 82
.......................
Rear A/C Control .87
.......................
Air Pressure, Tires .188
......................................
Antif reeze .174
Anti-lock Brakes (ABS) ....................
Indicator Light .49, 146
...................................
Operation .145
..............
Anti-thef t, Audio System . 102 .
Anti-thef t Steering Column Lock . 64
..................................
Audio System .88
...
Automatic Seat Belt Tensioners . 18
...
Automatic Lighting Off Feature . 58
.............
Automatic Speed Control . 116
..............
Automatic Transmission . 138
..........................
Capacity, Fluid .218
...............
Checking Fluid Level . 176
.......................................
Shif ting .138
.
Shif t Lever Position Indicator . 138
................
Shif t Lever Positions . 139
....................
Shif t Lock Release . 141
Index
A
B
I

Î
................................
Cancel Button .117
............................
Capacities Chart .218
.............
Carbon Monoxide Hazard . 42
........................
Cargo, .131
Cassette Player ..............................................
Care .95
.....................................
Operation .98
..............
CAUTION, Explanation of . ii
...........................................
CD Care .95
.....................................
CD Changer .94
.........
CD Changer Error Message . 97
.........................................
CD Player .93
.............
CD Player Error Message . 96
........................
Certif ication Label .216
...................................
Chains, .192
....................
Changing a Flat Tire .197
Change Oil ........................................
How to .172
.............................
When to .164, 165
...
Charging System Indicator . 48,206
............
Checklist, Bef ore Driving . 136
..................
Childproof Door Locks . 65
.....................................
Child Saf ety .25
..............................
Booster Seats .39 ...................................
Child Seats .30
.....
Important Saf ety Reminders . 25
..........................................
Inf ants .29
..........................
Larger Children .38
.........................................
LATCH .33
......................
Risks with Airbags .26
.............................
Small Children .30
.........................................
Tethers .37
.........
Where Should a Child Sit? . 26
Child Seats .........................................
LATCH .33
...........................
Lower Anchors .33
..........
Tether Anchorage Points . 37
.................
Climate Control System . 86
.........................
Clock, Setting the .103
..............................................
Clock .103
.....................
Code, Audio System .102
........................
CO in the Exhaust .223
............
Cold Weather, Starting in . 137
.......................
Compact Spare .196
...................
Console Compartment . 77
...............
Consumer Inf ormation . 230
.............
Controls, Instruments and . 45
Coolant ........................................
Adding .174
....................................
Checking .127 .........................
Proper Solution .174
...................
Temperature Gauge . 55
Crankcase Emissions Control ........................................
System .223
................
Cruise Control Indicator . 51
............
Cruise Control Operation . 116
.....................................
Cup Holders .77
....
Customer Service Inf ormation . 230
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 46
................
Daytime Running Lights . 59
Daytime Running Lights .......................................
Indicator .51
.................................
Dead Battery .202
............
Def ects, Reporting Saf ety . 232
................
Def ogger, Rear Window . 60
..........
Def rosting the Windows . 83,85
....................................
Dimensions .218
...............
Dimming the Headlights . 58
Dipstick ..........
Automatic Transmission . 176
..................................
Engine Oil .127
..........................
Directional Signals .58
how to carry
tires tire
Index
C
D
II