steering wheel HONDA PILOT 2004 1.G Owner's Manual

Your Pilot can be towed behind a
motorhome at legal highway speeds
up to 65 mph (100 km/h). Do not
exceed 65 mph (100 km/h) or severe
transmission damage will occur. To
avoid damage to the 4WD system, it
must be towed with all f our wheels
on the ground (f lat towing).
When purchasing a tow bar, make
sure you select a reputable
manuf acturer. Follow the
manufacturer’s attachment
instructions caref ully.
Perf orm the f ollowing procedure
everyday immediately bef ore you
begin towing. Otherwise severe
automatic transmission damage will
occur.Check the transmission f luid level
(see page ).
Start the engine. Press on the brake pedal. Move
the shif t lever through all its
positions.
ShifttoD,thentoN.Letthe
engine run f or three minutes, then
turn it off.
Release the parking brake.
Leave the ignition switch in
ACCESSORY (I) so the steering
wheel does not lock. Make sure
the radio and any items plugged
into the accessory power
sockets are turned of f so you do
not run down the battery.
If you tow more than 8 hours in one
day, you should repeat the above
procedure at least every 8 hours
(when you stop f or f uel, etc.)
176
Do not overf ill. Ext ended T owing
Driving
Towing Your Vehicle Behind a Motorhome
154
NOTICE:
NOTICE:
Improper towing preparation
will damage the transmission. Follow
the above procedure exactly. If you
cannot shif t the transmission or start
the engine, your vehicle must be
transported on a f lat-bed or trailer.
T he steering system can be
damaged if the steering wheel is locked.
Leave the ignition switch in
ACCESSORY (I), and make sure the
steering wheel turns f reely bef ore you
begin towing.

Check the level on the side of the
reservoir when the engine is cold.
The f luid should be between the
UPPER LEVEL and LOWER LEVEL.
If not add power steering f luid to the
UPPER LEVEL mark.A low power steering f luid level can
indicate a leak in the system. Check
the f luid level f requently, and have
the system inspected as soon as
possible.
Always use Honda Power Steering
Fluid. You may use another power
steering f luid as an emergency
replacement, but have the power
steering system f lushed and ref illed
with Honda PSF as soon as possible.
Maint enance
Power Steering Fluid
179
NOTICE:
UPPER LEVEL
LOWER LEVEL
T urning the steering wheel to
f ull lef t or right lock and holding it
there can damage the power steering
pump.

If you are changing the bulb on
the driver’s side, start the engine,
turn the steering wheel all the way
to the right, and turn off the
engine. If you are changing the
bulb on the passenger’s side, turn
the steering wheel to the left.Use a f lat-tipped screwdriver to
remove the f ive holding clips f rom
the inner f ender.
Pull the light assembly out of the
tailgate.
Remove the socket f rom the light
assembly by turning it one-quarter
turn counterclockwise.
Pull the bulb straight out of its
socket. Push a new bulb into the
socket until it bottoms. Reinstall
the assembly.
1. 2.
4.
5. 3.
CONT INUED
Lights
Maint enance
Replacing a Front Side Marker
Light Bulb
183
HOLDING CLIP

´
Wheels:
If you ever replace a wheel, make
sure that the wheel’s specif ications
match those of the original wheels. Replace your tires with radial tires of
the same size, load range, speed
rating and maximum cold tire
pressure rating (as shown on the
tire’s side wall).
Mixing radial and bias-ply tires on
your vehicle can reduce braking
ability, traction, and steering
accuracy. Using tires of a dif f erent
size or construction can cause the
ABS to work inconsistently.
It is best to replace all f our tires at
thesametime.If thatisnotpossible
or necessary, replace the two f ront
tires or two rear tires as a pair.
Replacing just one tire can seriously
af f ect your vehicle’s handling. Tires:Tires marked ‘‘M S’’ or ‘‘All
Season’’ on the sidewall have an all-
weather tread design suitable for
most winter driving conditions.
For the best perf ormance in snowy
or icy conditions, you should install
snow tires or tire chains. They may
be required by local laws under
certain conditions.
If you mount snow tires on your
Honda, make sure they are radial
tires of the same size and load range
as original tires. Mount snow tires on
all f our wheels. The traction
provided by snow tires on dry roads
maybelowerthanyouroriginaltires.
Check with the tire dealer f or
maximum speed recommendations.
See page f or DOT tire quality
grading inf ormation, and page
f or tire size explanation.
199 198
Wheel and T ire Specif ications
Replacing T ires
Winter Driving
Snow T ires
Maint enance
Tires
191
16x61/2JJ
P235/70R16 104S Installing improper tires on your
vehicle can affect handling and
stability. This can cause a crash
in which you can be seriously
hurt or killed.
Always use the size and type of
tires recommended in this
owner’s manual.

µµ ÎÎ
Î
Î
Î Î
Î
Î
Specif ications
T echnical Inf ormation218
Dimensions
Weights
Air Conditionig Capacities
1.74 US gal (6.6
)
2.25 US gal (8.5)
5.1 US qt (4.8
)
4.5 US qt (4.3
)
5.8 US qt (5.5
)
3.2 US qt (3.0)
8.2 US qt (7.8)
0.16 US gal (0.6
) 19.3 US gal (73
)
2.79 US qt (2.64
)
188.0 in (4,775 mm)
76.3 in (1,938 mm)
70.6 in (1,793 mm)
4.8 US qt (4.5
)
66.3 in (1,685 mm)
66.5 in (1,690 mm)
9,700 lbs (4,400 kg)
HFC-134a (R-134a)
24.7 26.5 oz (700 750 g) ND-OIL8
106.3 in (2,700 mm)
Excluding the oil remaining in the engine. Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity:
The GCWR must be reduced 2 percent for every 1,000 feet (305
meters) of elevation. Equipped with transmission fluid cooler and power steering
fluid cooler.
Length
Width
Height
Wheelbase
Track
See the tire information label atta-
ched to the driver’s doorjamb.
Gross vehicle weight rating
Gross combined weight
rating (GCWR)
Refrigerant type
Charge quantity
Lubricant type Fuel tank
Engine
coolant
Engine oil
Automatic
transmission
fluid
Rear
differential
fluid
Windshield
washer
reservoir
Approx.
Front
Rear
1:
2:Change
Total
Change
Including
filter
Without
filter
Total
Change
Total
Change
1:
2:
2 1
2
1

....
START (Ignition Key Position) . 64
.......................
Starting the Engine .137
In Cold Weather at High ..................................
Altitude .137
................
With a Dead Battery . 202
..............
State Emissions Testing . 226
........
Steam Coming f rom Engine . 204
Steering Wheel ..................................
Adjustment .61
.............
Anti-theft Column Lock . 64
...............................
Buttons .101, 116
.....................
Stereo Sound System .88
....................
Storing Your Vehicle .194
..........................
Sunglasses Holder .78
..........................................
Sun Visor .79
Supplemental Restraint System ......................................
Servicing .24
.........................
SRS Indicator .23 ,48
...................
System Components . 19
..................................
Synthetic Oil .172
......
Taillights, Changing Bulbs in . 182
.
Taking Care of the Unexpected . 195
......................................
Tape Player .98 Technical Descriptions
......
DOT Tire Quality Grading . 220
.....
Emissions Control Systems . 223
..........
State Emissions Testing . 226
Three Way Catalytic ...............................
Converter .225
.......................
Temperature Gauge .55
..........
Temperature, Inside Sensor . 87
....................
Temperature, Outside . 55
...................
Tensioners, Seat Belts . 18
........
Testing of Readiness Codes . 226
..............
Tether Anchorage Points . 37
............................
Thef t Protection .102
..
Three Way Catalytic Converter . 225
..........................
Time, Setting the .103
..................
Tilt the Steering Wheel . 61
....................................
Timing Belt .177
....................................
Tire Chains .192
.........
Tire, How to Change a Flat . 197
...............................................
Tires .188
..............................
Air Pressure .188
...................................
Balancing .190
.........................
Checking Wear .189
..........................
Compact Spare .196
......
DOT Tire Quality Grading . 220
......................................
Inf lation .188 ..................................
Inspection .189
..............................
Maintenance .190
...................................
Replacing .191
......................................
Rotating .190
...........................................
Snow .191
............................
Specif ications .219
................................
Tire Chains .192
..........................
Winter Driving .191
...................
Tools, Tire Changing . 197
Towing .....................................
A Trailer .147
................
Emergency Wrecker . 208
....
Equipment and Accessories . 151
.......................
Traction Devices .192
Your Vehicle Behind a ............................
Motorhome .154
.............................
Weight Limit .150
.............................
Trailer Loading .147
......................
Trailer Towing Tips .152
Transmission ...............
Checking Fluid Level . 176
...........................
Fluid Selection .176
..............
Identif ication Number . 216
.............
Shif ting the Automatic . 138
.....................................
Treadwear .220
.......................................
Trip Meter .54
Index
T
VIII

ÎÎ
....................................
Turn Signals .58
.............
WARNING, Explanation of . ii
.........
Warning Labels, Location of . 43
..................
Warranty Coverages .231 Washer, Windshield
........
Checking the Fluid Level . 175
............................
Level Indicator .51
.....................................
Operation .57
Wheels ...............
Adjusting the Steering . 61
............
Alignment and Balance . 190
..........................
Compact Spare .196
......................................
Wrench .199
Windows ..................
Operating the Power . 73
...........................
Rear, Def ogger .60
Windshield ...............................
Def roster .83, 85
.......................................
Washers .57
Wipers, Windshield .......................
Changing Blades .186
.....................................
Operation .57
Rear Window Wiper and .....................................
Washer .57
....................................
Worn Tires .189
.....
Wrecker, Emergency Towing . 208
Unexpected, Taking Care
..........................................
of the .195
....
Unif orm Tire Quality Grading . 220
........................
Unleaded Gasoline .124
.......
Used Oil, How to Dispose of . 173
.................
Vehicle Capacity Load . 132
......................
Vehicle Dimensions .218
....
Vehicle Identif ication Number . 216
.............................
Vehicle Storage .194
.................................................
VIN .216
..................................
Viscosity, Oil .171
..................................
VTM-4 Lock .142
: U.S. and Canada only
Index
U
V
W
IX