maintenance schedule HONDA PILOT 2005 1.G Owner's Manual

µµ
To thoroughly f lush the
transmission, the technician
should drain and ref ill it with
Honda ATF-Z1 (Automatic
Transmission Fluid), then drive
the vehicle f or a short distance.
Do this three times. Then drain
and ref ill the transmission a f inal
time.
Insert the dipstick all the way back
into the transmission.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
If you are not sure how to add f luid,
contact your dealer. Put a new washer on the f iller bolt,
then reinstall the f iller bolt and
tighten it securely. Tightening
torque:
The dif f erential should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
The timing belt should be replaced
at the intervals shown in the
maintenance schedule. Replace the
belt at 60,000 miles (100,000 km) if
you regularly drive your vehicle in
one or more of these conditions:
In very high temperatures
(over 110°F, 43°C).
In very low temperatures
(under 20°F, 29°C).
Frequently tow a trailer.
Check the f luid level with the
dif f erential at normal operating
temperature and the vehicle sitting
on level ground. Remove the
dif f erential f luid f iller bolt and
washer, and caref ully f eel inside the
bolt hole with your f inger. The f luid
level should be up to the edge of the
bolt hole. If it is not, slowly add
VTM-4 Dif f erential Fluid until it
starts to run out of the hole.
6.
Timing Belt
Dif f erential Oil
A utomatic T ransmission Fluid, Dif f erential Oil, T iming Belt
Maint enance
205
FILLER BOLT
CORRECT LEVEL
33 lbf·ft (45 N·m , 4.6 kgf·m)

The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If the level is at or
below the MIN mark, your brake
system needs attention. Have the
brake system inspected f or leaks or
worn brake pads.
Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement.
Using any non-Honda brake f luid can
cause corrosion and decrease the lif e
of the system. Have the brake
system f lushed and ref illed with
Honda Heavy Duty Brake Fluid
DOT 3 as soon as possible.
Brake f luid marked DOT 5 is not
compatible with your vehicle’s
braking system and can cause
extensive damage.
Check the brake f luid level in the
reservoirs monthly. Replace brake
fluidaccordingtothetime
recommendation in the maintenance
schedule.
Brake Fluid
206
MAX
MIN

Fill the f uel tank.
Change the engine oil and f ilter.Block the rear wheels.
If the vehicle is to be stored f or a
longer period, it should be
supported on jackstands so the
tires are of f the ground.
Wash and dry the exterior
completely.
Cleantheinterior.Makesurethe
carpeting, floor mats, etc., are
completely dry.
If you need to park your vehicle f or
an extended period (more than one
month), there are several things you
should do to prepare it f or storage.
Proper preparation helps prevent
deterioration and makes it easier to
get your vehicle back on the road. If
possible, store your vehicle indoors. Leave one window open slightly (if
the vehicle is being stored
indoors).Cover the vehicle with a
‘‘breathable’’ cover, one made
f rom a porous material such as
cotton. Non-porous materials, such
as plastic sheeting, trap moisture,
which can damage the paint.
Support the f ront wiper blade
arms with a f olded towel or rag so
they do not touch the windshield. Disconnect the battery.
Leave the parking brake off. Put
the transmission in Park. To minimize sticking, apply a
silicone spray lubricant to all door
and tailgate seals. Also, apply a
vehiclebodywaxtothepainted
surfaces that mate with the door
and tailgate seals.If possible periodically run the
engine until it reaches normal
operating temperature (the
cooling f ans cycle twice).
Pref erably, do this once a month.
If you store your vehicle f or 12
months or longer, have your dealer
perf orm the inspections called f or in
the 24 months/30,000 miles
(48,000 km) maintenance schedule
(Normal Conditions) as soon as you
take it out of storage (see page ).
The replacements called f or in the
maintenance schedule are not
needed unless the vehicle has
actually reached that time or mileage. 192
Vehicle Storage
222

ÎÎIn Canada, Honda vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured.
Your vehicle has a positive
crankcase ventilation system. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The positive crankcase ventilation valve routes
them from the crankcase back to the
intake manif old. They are then
drawn into the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The onboard ref ueling vapor
recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
The burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx) and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons. Con-
trolling the production of NOx, CO,
and HC is important to the environ-
ment. Under certain conditions of
sunlight and climate, NOx and HC
react to f orm photochemical ‘‘smog.’’
Carbon monoxide does not contri-
bute to smog creation, but it is a
poisonous gas.
The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page
.
164
Crankcase Emissions Control
System Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
The Clean Air Act
Emissions Cont rols
T echnical Inf ormation
251

.....................................
Heater, Seat .82
.....................
Heating and Cooling .100
.............
High Altitude, Starting at . 159
.................
High-Low Beam Switch . 71
..............
High-mount Brake Light . 211
HomeLink Universal ................................
Transceiver .140
.......................
Hood, Opening the .148
...
Identif ication Number, Vehicle . 244
Ignition ..............................................
Keys .75
...........................................
Switch .77
............
Timing Control System . 252
........................
Immobilizer System .75
...
Important Handling Inf ormation . iii
.........
Important Safety Precautions . 8
.........
Indicators, Instrument Panel . 57
...............................
Inf ant Restraint .39
......................................
Inf ant Seats .39
...................
Inf lation, Proper Tire . 216
...................................
Inside Mirror .88
.............................
Inspection, Tire .217 Installing a Child Seat
...........................................
LACH .43
..........
Tether Anchorage Points . 47
........................
Instrument Panel .5 ,57
........
Instrument Panel Brightness . 72
........................................
Introduction .i
..................................................
Keys .75
.................
Jacking up the Vehicle . 226
.......................................
Jack, Tire .225
................................
Jump Starting .230
.......................
Label, Certif ication .244
.................
Lane Change, Signaling . 71
........................
Lap/Shoulder Belts .20
...........
LATCH Anchorage System . 43
.........................................
Lights .71, 97
....................
Bulb Replacement .208
.......................................
Indicator .57 .........................................
Parking .71
..................................
Turn Signal .71
....................................
Load Limits .154
......
LOCK (Ignition Key Position) . 77
Locks .......
Anti-thef t Steering Column . 77
............................
Fuel Fill Door .147
....................................
Glove Box .96
....................
Lockout Prevention . 78
.................................
Power Door .78
........................
Low Coolant Level .149
.........................
Low Fuel Indicator .63
...
Low Oil Pressure Indicator . 58,234
.................................
Lower Anchor .43
...
Lubricant Specif ications Chart . 246
.........................................
Luggage .153
..................................
Maintenance .187
Owner’s Maintenance ...................................
Checks .191
.................................
Record .195-197
......................
Required Indicator .65
..........................................
Saf ety .188
.............................
Schedule .192-194
Index
I J
K
LM
IV

.................
Remote Control (RES) . 131
.......................
Remote Transmitter .79
Replacement Inf ormation ................
Engine Oil and Filter . 200
.................................
Floor Mats .213
..........................................
Fuses .239
................................
Light Bulbs .208
.............................
Schedule .192-194
................................
Timing Belt .205
...........................................
Tires .218
.............................
Wiper Blades .214
Replacing Seat Belts Af ter a ............................................
Crash .21
...
Reserve Tank, Engine Coolant . 149
...............................
Restraint, Child .34
..................
Reverse Gear Position . 161
......................................
Roof Rack .153
................................
Rotation, Tire .214
......................................
Saf ety Belts .10
............
Safety Defects, Reporting . 260
.................................
Saf ety Features .9
.........................................
Airbags .11
.....................................
Seat Belts .10 .............
Saf ety Labels, Location of . 54
...............................
Saf ety Messages .ii
.........................................
Seat Belts .10
...............
Additional Information . 20
Automatic Seat Belt ...............................
Tensioners .22
.....................................
Cleaning .213
......................
Lap/Shoulder Belt .20
................................
Maintenance .21
Reminder Light and ................................
Beeper .20, 58
...................
System Components . 23
...............
Use During Pregnancy . 18
...
Wearing a Lap/Shoulder Belt . 15
....................................
Seat Heaters .82
.................................................
Seats .83
............
Folding the Second Seat . 85
...............
Folding the Third Seat . 86
..........................
Head Restraints .87
.........
Reclining the Second Seat . 85
............
Reclining the Third Seat . 86
.......................
Third Seat Access .85
...................
Seats, Adjusting the . 83-86
............................
Security System .137
...............................
Serial Number .244
...........................
Service Intervals .189 .............................
Service Manual .261
.........
Service Station Procedures . 147
..........................
Setting the Clock .124
Shif ting the Automatic .............................
Transmission .160
.....
Shif t Lever Position Indicator . 160
........................
Shif t Lock Release .163
Side Marker Lights, Bulb .........................
Replacement in .212
..............................
Side Airbags .11, 28
....................
Cutof f Indicator .30, 58
...............................
Signaling Turns .71
.....................................
Snow Tires .219
................................
Sound System .106
Spare Tire ......................................
Inf lating .224
............................
Specif ications .247
....................
Specif ications Charts . 246
................................
Speed Control .138
..........
SRS, Additional Inf ormation . 23
...
Additional Safety Precautions . 33
.............................
Airbag Service .32
How the Side Airbag Of f ......................
Indicator Works .30
..
How the SRS Indicator Works . 30
Index
S
VI