Oil HONDA PILOT 2007 1.G Owner's Manual

Putane
ww
as
he r
on
t
he f iller bolt,
then reinstall the f iller bolt and
tighten it securely. Tightening
torque:
The dif f erential should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
GL5 with a viscosity of SAE 90 or
80W-90, and have your dealer
replace the transfer assembly fluid.
Check the f luid level with the
dif f erential at normal operating
temperature and the vehicle sitting
on level ground. Remove the
dif f erential f luid f iller bolt and
washer, and caref ully f eel inside the
bolt hole with your f inger. The f luid
level should be up to the edge of the
bolt hole. If it is not, slowly add
VTM-4 Dif f erential Fluid until it
starts to run out of the hole.
Always use Honda ATF-Z1
(automatic transmission f luid). If
it’s not available, you may use a
DEXRON
III automatic
transmission f luid as a temporary
replacement. However, continued
use can affect the shift quality.
Have the transmission f lushed and
ref illed with Honda ATF-Z1 by
your dealer as soon as it is
convenient.
Insert the dipstick all the way back
into the transmission securely as
shown in the illustration.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule. The transfer assembly should be
drained and refilled with new fluid
when this service is indicated by a
maintenance message on the
information display.
Always use Hypoid gear oil GL4 or
6.
4WD models only
Transfer Assembly Fluid
Dif f erential Oil
A utomatic Transmission Fluid, Dif f erential Oil, Transfer Assembly Fluid
Maint enance
245
FILLER BOLT
CORRECT LEVEL
33 lbf·ft (45 N·m , 4.6 kgf·m)

Open the hood.
Remove the electrical connector
f rom the bulb by squeezing the
connector to unlock the tab, then
slide the connector of f the bulb.
Remove the bulb by turning it
approximately one-quarter turn
counterclockwise.Insert the new bulb into the hole,
and turn it one-quarter turn
clockwise to lock it in place.
Push the electrical connector onto
the new bulb.
Turn on the headlights to test the
new bulb.
Theheadlightswereproperlyaimed
when your vehicle was new. If you
regularly carry heavy items in the
trunk, readjustment may be required.
Adjustment should be done by your
dealer or other qualif ied mechanic.
Your vehicle has halogen headlight
bulbs. When replacing a bulb, handle
it by its base, and protect the glass
f rom contact with your skin or hard
objects. If you touch the glass, clean
it with denatured alcohol and a clean
cloth.
1.
2.
3.4.
5.
6.
Headlight A iming
Replacing a Headlight Bulb
Lights
248
TAB
BULB CONNECTOR
Halogen headlight bulbs get very hot
when lit. Oil, perspiration, or a scratch
on the glass can cause the bulb to
overheat and shatter.

Fill the f uel tank.
Change the engine oil and f ilter.Block the rear wheels.
Wash and dry the exterior
completely.
Cleantheinterior.Makesurethe
carpeting, floor mats, etc., are
completely dry.
If you need to park your vehicle f or
an extended period (more than 1
month), there are several things you
should do to prepare it f or storage.
Proper preparation helps prevent
deterioration and makes it easier to
get your vehicle back on the road. If
possible, store your vehicle indoors. Leave one window open slightly (if
the vehicle is being stored
indoors).Cover the vehicle with a
‘‘breathable’’ cover, one made
f rom a porous material such as
cotton. Non-porous materials, such
as plastic sheeting, trap moisture,
which can damage the paint.
Support the f ront wiper blade
arms with a f olded towel or rag so
they do not touch the windshield. Disconnect the battery.
Leave the parking brake off. Put
the transmission in Park. To minimize sticking, apply a
silicone spray lubricant to all door
and tailgate seals. Also, apply a
vehiclebodywaxtothepainted
surfaces that mate with the door
and tailgate seals.If possible, periodically run the
engine until it reaches f ull
operating temperature (the
cooling f ans cycle on and of f
twice). Pref erably, do this once a
month.
If the vehicle is to be stored f or a
longer period, it should be
supported on jackstands so the
tires are of f the ground.
Vehicle Storage
Maint enance
263

This section covers the more
common problems that motorists
experience with their vehicles. It
gives you inf ormation about how to
safely evaluate the problem and what
to do to correct it. If the problem has
stranded you on the side of the road,
you may be able to get going again.
If not, you will also f ind instructions
on getting your vehicle towed.......................
Compact Spare Tire .266
....................
Changing a Flat Tire .267
.............
If the Engine Won’t Start .271
................................
Jump Starting .272
..............
If the Engine Overheats .274
.........
Low Oil Pressure Indicator .276
..........
Charging System Indicator .276
.......
Malf unction Indicator Lamp .277
...............
Brake System Indicator .278
......................
Emergency Towing .279
..............................................
Fuses .279
..............................
Fuse Locations .283
Taking Care of the Unexpected
T aking Care of t he Unexpect ed
265

If necessary, add oil to bring the
level back to the full mark on the
dipsti ck (see page ).
Safely
pull off the road, and shut
off the engine. Turn on the hazard
warning lights.
Go to a service station or garage
where you can get technical
assistance. Immediately turn off all electri cal
accessories. Try not to use other
electrically operated controls such as
the power windows. Keep the engine
running; starting the engine will
discharge the battery rapidly.
If
the charging system
indicator comes on brightly
when the engine is running, the
battery is not being charged.
This
indicator should never
come on when the engine is
running. If it starts flashing or stays
on, the oil pressure has dropped very
low or lost pressure. Serious engine
damage is possible, and you should
take immediate action. Let
the vehicle sit for a minute.
Op en the hood, and check the oil
level (see page ). An engine
very low on oil can lose pressure
during cornering and other driving
maneuvers.
Start the engine and watch the oil
pressure indicator. If it does not go
out within 10 seconds, turn off the
engine. There is a mechanical
problem that needs to be repaired
bef ore you can continue driving
(see on page
).
1.
2.
3.
4.
189
279 239
L ow Oil Pressure Indicator
Charging System Indicator
Emergency T owing
L ow Oil Pressure Indicator, Charging System Indicator
276
Running the engine with low oil
pressure can cause serious mechanical
damage almost immediately. Turn of f
the engine as soon as you can saf ely get
the vehicle stopped.

µµ
No. Amps.No.Circuits Protected
No. Circuits Protected
Amps.
Amps.
Circuits Protected
Circuits Protected
No. Amps.
1
2
3
4
5
6
7
8
9
10
11
12
13 20 A
30 A
20 A
15 A
15 A
20 A
20 A
20 A
40 A
40 A
30 A
40 A 14
15
16
17
18
19
20
21
22
23
24
Rear A/C
Heater Motor
Cooling Fan
Spare Fuse
Spare Fuse
Spare Fuse
Battery
Condenser Fan
MG Clutch
IGI Main
Trailer (accessory)
7
8
9
10
11 ET CS
IG Coil
LAF
TPMS
(FR FOG)
30 A
40 A
30 A
7.5 A 10 A
15 A
120 A 30 A
7.5 A 50 A
15 A
15 A
15 A
7.5 A
(20 A)
Spare Fuse
Spare Fuse
Right Headlight
ACG S
Hazard
Not used
Stop, Horn
Left Headlight
Radio
Power Window Motor
Power Seat
Rear Defroster
Back Up, ACC
AC INVERTER
VSA F/S Relay
VSA Motor
VTM-4
ACM
Rear Accessory Socket
1
2
3
4
5
6 20 A
40 A
30 A
20 A
10 A
15 A
Fuse Locations
T aking Care of t he Unexpect ed
283
PRIMARY UNDER-HOOD FUSE BOX
SECONDARY UNDER-HOOD FUSE BOX

µµÎ
Î
Î
Î
µ
ÎÎ Î
Î
Specif ications
288
Dimensions
Weights
Air Conditioning
Battery Capacities1.93 US gal (7.3
)
2.43 US gal (9.2)
4.5 US qt (4.3
)
4.2 US qt (4.0
)
5.3 US qt (5.0
)
20.34 US gal (77.0
)
188.0 in (4,775 mm)
76.5 in (1,943 mm)
ND-OIL8
24.7 26.5 oz (700 750 g) HFC-134a (R-134a)
Length
Width
Height
Wheelbase
Track 66.3 in (1,685 mm)
106.3 in (2,700 mm) 70.5 in (1,790 mm)
Gross vehicle weight rating
Gross combined weight
rating (GCWR) See the tire information label atta-
ched to the driver’s doorjamb.
9,700 lbs (4,400 kg)
Equipped with transmission fluid cooler and power steering
fluid cooler.
The GCWR must be reduced 2 percent for every 1,000 feet (305
meters) of elevation.
Refrigerant type
Charge quantity
Lubricant type 77.5 in (1,968 mm)
71.7 in (1,821 mm)
70.1 in (1,780 mm)
71.3 in (1,811 mm)
66.5 in (1,690 mm)
66.5 in (1,690 mm)
66.7 in (1,694 mm)
12 V 20 AH/5 HR
Capacity Excluding the oil remaining in the engine 0.193 US gal (0.73
)
Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity: 2.79 US qt (2.64
)
4.8 US qt (4.5
)
Fuel tank
Engine
coolant
Engine oil
Automatic
transmission
fluid
Rear
differential
fluid (4WD)
Windshield
washer
reservoir
8.3 US qt (7.9
)
3.5 US qt (3.3
)
8.9 US qt (8.4
)
4.0 US qt (3.8
)
Approx.
1:
2:
1:
2: Front
Rear
4WD
2WD
LX
EX
LX
EX
LX
EX
Front
Rear
4WD
2WD Change
Total
Change
Including
filter
Without
filter
Total
Change
Total
Change 4WD
2WD
4WD
2WD
2
1 1
2

CONT INUED
...
Accessories and Modif ications .191
ACCESSORY (Ignition Key
.......................................
Position) .81
............
Accessory Power Sockets .101
...........................
AC Power Outlet .102
....................
Additives, Engine Oil .239
...............
AdvancedAirbagSystem .30
.............................
Airbag (SRS) . 11, 25
..........
Airbag System Components .25
..............
Air Conditioning System .106
.....................
Rear A/C Control .113
.......................
Air Pressure, Tires .258
......................................
Antif reeze .242
...............
Anti-lock Brakes (ABS) .209
...............................
Indicator . 63, 210
...................................
Operation .209
..............
Anti-thef t, Audio System .139
.
Anti-thef t Steering Column Lock .81
................................
Audio System .115
...
Automatic Seat Belt Tensioners .23
...
Automatic Lighting Off Feature .76
.............
Automatic Speed Control .175
..............
Automatic Transmission .200
..........................
Capacity, Fluid .288 ...............
Checking Fluid Level .244
.......................................
Shif ting .200
.
Shif t Lever Position Indicator .200
................
Shif t Lever Positions .201
....................
Shif t Lock Release .203
Battery Charging System ...........................
Indicator . 62, 276
............................
Jump Starting .272
..............................
Maintenance .262
............................
Specif ications .289
..............................
Bef ore Driving .185
..................................
Belts, Seat . 10, 21
...........................
Beverage Holders .99
..................................
Booster Seats .54
Brakes
...........
Anti-lock System (ABS) .209
.............
Break-in, New Linings .186
....................
Bulb Replacement .252
...........................................
Fluid .246
.........................................
Parking .97
.................
System Indicator . 63, 278
........................
Wear Indicators .209 .............................
Braking System .208
.................
Break-in, New Vehicle .186
..
Brightness Control, Instruments .76
........................
Brights, Headlights .75
Bulb Replacement
..........................
Back-up Lights .252
.....................
Brake Lights . 252, 253
................
Front Parking Lights .249
........
Front Side Marker Lights .249
.................................
Headlights .248
........
High-mount Brake Lights . 253
.................................
Rear Bulbs .252
............................
Specif ications .289
.............
Turn Signal Light . 249, 252
..............................
Bulbs, Halogen .248
............................
Capacities Chart .288
.............
Carbon Monoxide Hazard . 57
.............................
Carrying Cargo .193
.............
CAUTION, Explanation of . iii
..........................
CD Changer . 131, 134
.......................................
CD Player .130
Index
A
B
C
INDEX
I

........................
Certif ication Label .286
............................................
Chains .261
....................
Changing a Flat Tire .267
Change Oil
........................................
How to .240
......................................
When to .229
...
Charging System Indicator . 62, 276
............
Checklist, Bef ore Driving .198
..................
Childproof Door Locks .83
Child Seats
.........................................
LATCH .47
..........
Tether Anchorage Points .51
...............
Climate Control System .112
.........................
Clock, Setting the .140
.....................
Code, Audio System .139
........................
CO in the Exhaust .295
............
Cold Weather, Starting in .199
......................
Compact Spare Tire .266
...................
Console Compartment .99
.................
Consumer Inf ormation .302
.............
Controls, Instruments and .59
Coolant
........................................
Adding .242
....................................
Checking .190
.........................
Proper Solution .242
...................
Temperature Gauge .71 ...................
Conversation Mirror .100
Crankcase Emissions Control
........................................
System .295
............
Cruise Control Operation .175
....
Customer Service Inf ormation .302
..............................
Economy, Fuel .190
............
Emergencies on the Road .265
.............
Battery, Jump Starting . 272
...........
Brake System Indicator . 278
................
Changing a Flat Tire . 267
.....
Charging System Indicator . 276
..................
Checking the Fuses . 279
.....
Low Oil Pressure Indicator . 276
...
Malf unction Indicator Lamp . 277
..................
Overheated Engine . 274
...........................
Emergency Brake .97
......................
Emergency Flashers .77
......................
Emergency Towing .279
.......................
Emissions Controls .295
.............
Emissions Testing, State . 298
...............
DANGER, Explanation of . iii
...................................
Dashboard . 4, 60
................
Daytime Running Lights . 76
Daytime Running Lights .......................................
Indicator .67
.................................
Dead Battery .272
............
Def ects, Reporting Saf ety . 304
................
Def ogger, Rear Window . 77
......
Defrosting the Windows . 108, 110
....................................
Dimensions .288
...............
Dimming the Headlights . 75
Dipstick ..........
Automatic Transmission . 244
..................................
Engine Oil .189
....................
Directional Signals . 66,75
........
Disc Brake Wear Indicators . 209
.....................
Disposal of Used Oil .241 Doors
..............
Locking and Unlocking . 82
..........
DOT Tire Quality Grading . 290
...........
Driver and Passenger Safety . 7
...........................................
Driving .197
....................................
Economy .190
...................................
DVD Player .142
........
DVD Player Error Message . 171
Index
D
E
II

CONT INUED
...............
Gas Mileage, Improving .190
.........................................
Gasoline .186
...............
Fuel Reserve Indicator .67
...........................................
Gauge .70
................
Octane Requirement .186
........................
Tank, Filling the .187
................
Gas Station Procedures .187 Gauges
...
Engine Coolant Temperature .71
...............................................
Fuel .70
GAWR (Gross Axle Weight .......................................
Rating) .214
GCWR (Gross Combined Weight .......................................
Rating) .214
............
Gearshif t Lever Positions .200
........................................
Glove Box . 99
GVWR (Gross Vehicle Weight .......................................
Rating) .214
.............
Halogen Headlight Bulbs . 248
.................
Hazard Warning Button . 77
Engine
....
Coolant Temperature Gauge . 71
Malf unction Indicator ................................
Lamp . 62, 277
........Oil
Pressure Indicator . 62, 276
..............Oil, What Kind to Use . 239
...............................
Overheating .274
............................
Specif ications .289
............................
Speed Limiter .202
.......................................
Starting .199
.
Evaporative Emissions Controls . 295
...............................
Exhaust Fumes .57
Exhaust Gas Recirculation ........................................
System .296
Expectant Mothers, Use of Seat ........................................
Belts by .19
...................................
Fan, Interior .106
.........................................
Features .105
....................
Filling the Fuel Tank . 187
Filters ...............................................
Oil .240
.............
Flashers, Hazard Warning . 77
...................
Flat Tire, Changing a . 267Fluids
..........
Automatic Transmission . 244
..........................................
Brake .246
..........................
Power Steering .247
................
Windshield Washers . 243
...................
Folding the Third Seat . 90
..........................
Four-way Flashers .77
.................................................
Fuel .186
...............................
Cap Message .72
......................
Fill Door and Cap .187
...........................................
Gauge .70
................
Octane Requirement . 186
........................
Reserve Indicator .67
........................
Tank, Filling the .187
.....................
Fuses, Checking the .279
Index
F GH
INDEX
III