light HONDA PILOT 2008 1.G Repair Manual

If something electrical in your
vehicle stops working, the first thing
youshouldcheckforisablownfuse.
Determine f rom the chart on pagesand , or the diagram on the
f use box lid, which f use or f uses
control that device. Check those
f uses f irst, but check all the f uses
bef ore deciding that a blown f use is
the cause. Replace any blown f uses,
and check if the device works.
Turn the ignition switch to the
LOCK (0) position. Make sure the
headlights and all other
accessories are of f .
Remove the cover f rom the f use
box.
To open the passenger’s side f use
box, pull the right edge of the cover.
The primary under-hood f use box is
on the passenger’s side. To open it,
pushthetabsasshown.
1.
2.289290
Fuses
Checking and Replacing Fuses
286
PASSENGER’ S SIDE INTERIOR
UNDER-
HOOD
FUSE
BOX
\f—\f—\fy

\fy
(+\fy\f
y
2008 Pilot

If you cannot drive the vehicle
without f ixing the problem, and you
do not have a spare fuse, take a fuse
of the same rating or a lower rating
f rom one of the other circuits. Make
sureyoucandowithoutthatcircuit
temporarily (such as the accessory
power socket or radio).
If you replace the blown f use with a
spare f use that has a lower rating, it
might blow out again. This does not
indicate anything wrong. Replace the
f use with one of the correct rating as
soon as you can.If the replacement fuse of the
same rating blows in a short time,
there is probably a serious
electrical problem with your
vehicle. Leave the blown fuse in
that circuit, and have your vehicle
checked by a qualif ied technician.
If a trailer light is burned out, check
if these f uses are blown when you
replace the light bulbs:
If thosefusesareOK,butthetrailer
lights still do not work, there are two
blown 7.5 amp f uses in the trailer
hitch wiring. To access the 7.5 amp
f uses:
Open the tailgate and remove the
cargo f loor lid.
Pull out the bottom of the tailgate
rubber seal.
Remove rear trim panel by pulling
up on the inside edge of the rear
trim panel, and unhooking the f our
clips and tabs.
Af ter replacing f uses, and reinstall
the rear trim panel in the reverse
order of removal.
Primary under-hood f use box
fuses5,7,and24
Interior driver’s side f use box: 10
Interior passenger’s side f use box:
10
If the radio f use is removed, the
audio system will disable itself . The
nexttimeyouturnontheradioyou
will see ‘‘ENTER CODE’’ in the
f requency display. Use the preset
buttons to enter the digit code (see
page ).
If the driver’s power window f use is
removed, the AUTO function of the
driver’s window may be disabled.
You should reset the AUTO f eature,
(see page ).
6.
1.
2.
3.
4.
95
141
Except f or LX models
Trailer Fuses
Fuses
288
Replacing a f use with one that has a
higher rating greatly increases the
chances of damaging the electrical
system. If you do not have a
replacement f use with the proper rating
f or the circuit, install one with a lower
rating.
\f—\f—\fy


y
(+\fy\fy
2008 Pilot

µµ
No. Amps. No. Circuits Protected
No. Circuits ProtectedAmps.
Amps.
Circuits Protected
Circuits Protected
No. Amps.
CONT INUED
1
2
3
4
5
6
7
8
9
10
11
12
13 20 A
30 A
20 A
15 A
15 A
20 A
20 A
20 A
40 A
40 A
30 A
40 A 14
15
16
17
18
19
20
21
22
23
24
Rear A/C
Heater Motor
Cooling Fan
Spare Fuse
Spare Fuse
Spare Fuse
Battery
Condenser Fan
MG Clutch
IGI Main
Trailer (accessory)
7
8
9
10
11 ET CS
IG Coil
LAF
TPMS
(FR FOG)
30 A
40 A
30 A
7.5 A 10 A
15 A
120 A 30 A
7.5 A 50 A
15 A
15 A
15 A
7.5 A
(20 A)
Spare Fuse
Spare Fuse
Right Headlight
ACG S
Hazard
Not used
Stop, Horn
Left Headlight
Radio
Power Window Motor
Power Seat
Rear Defroster
Back Up, ACC
AC INVERTER
VSA F/S Relay
VSA Motor
VTM-4
ACM
Rear Accessory Socket
1
2
3
4
5
6 20 A
40 A
30 A
20 A
10 A
15 A
Fuse Locations
T aking Care of t he Unexpect ed
289
PRIMARY UNDER-HOOD FUSE BOX
SECONDARY UNDER-HOOD FUSE BOX
\f—\f—\fy


y
(+\fy\fy
2008 Pilot

µ
µ
Î
ÎÎ Î
No. No. Amps.Amps. Circuits Protected Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12
13 1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16 20 A
20 A
20 A
20 A
10 A
20 A
20 A
15 A
15 A
10 A
20 A
7.5 A
7.5 A 20 A
20 A
15 A
10 A
7.5 A
7.5 A 10 A
15 A
7.5 A
7.5 A 10 A
7.5 A
7.5 A 30 A Fuel Pump
SRS
Heater Control, A/C Clutch
Relay, Cooling Fan Relay
Power Mirror, ABS
Daytime Running Light
ECU(PCM),CruiseControl
OPDS, Rear Wiper
ACC Relay
Back-up Lights, Instrument
Lights
Turn Signals
VTM-4
Front Wiper
Not used Driver’s Power Window
Driver’s Power Seat Reclining
Heated Seat
Driver’s Power Seat Sliding
Not used
Daytime Running Light
Driver’s side Rear Power
Window
Front Passenger’s Power
Window
Front Accessory Socket
Small Light
Interior Light
Power Door Lock
Back Up
Moonroof
Moonroof
Passenger’s Side Rear Power
Window
Canadian models
:
Canadian models
Fuse Locations
290
Driver’s Side
INTERIOR FUSE BOX
Passenger’s Side
Front Front
:
\f—\f—\fy

y
(+\fy\fy
2008 Pilot

µ
µ
µ
µ µµ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Î
Î
Î
Î
Specif ications
Technical Inf ormation
295
Lights
Fuses Engine
Air Conditioning
Alignment
Tires
Headlights
Front side marker lights
Front position lights
Front turn signal lights
Side turn signal lights
Front fog lights
Rear side marker lights
Rear turn signal/hazard lights
Stop/Taillights
Backup lights
License plate lights
High-mount brake light
Front map lights
Rear map lights
Cargo area light
Vanity mirror light
Door (Courtesy) light
21 W/5 W
5W
12 V
12 V
3CP
21 CP (18 W)
8W
4CP
5W
5W
21 W
3CP
55 W
3CP
12 V
12 V 1.1 W
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V 21 W/5 W 5W
12 V
12 V
12 V
12 V
12 V
Interior
Under-hood Type
BorexStroke
Displacement
Compression ratio
Spark plugs
SKJ16DR-M11IZFR5K-1110.0 : 1
211.8 cu-in (3,471 cm
)
3.50 x 3.66 in (89.0 x 93.0 mm) Water cooled 4-stroke SOHC,
i-VTEC V6 gasoline engine (2WD) Water cooled 4-stroke SOHC,
VTEC V6 gasoline engine (4WD)
12 V
12 V
55 W
60 W
Refrigerant type
Charge quantity
Lubricant type
Toe-in
Camber
Caster
Size
Pressure 60 psi (420 kPa , 4.2 kgf/cm
)
32 psi (220 kPa , 2.2 kgf/cm)
T155/90D16 110M P235/70R16 104S
1°98’ 1°88’
0°50’
0°50’
0°76’
0°66’ 0.00 in (0.0 mm)
0.00 in (0.0 mm)
3.8 W
21 CP (18 W) HFC-134a (R-134a)
24.7 26.5 oz (700 750 g) ND-OIL8
See page290or the fuse label
attached to the dashboard.
See page290or the fuse label
attached to the inside of the fuse
box door under the dashboard.
See page289or the fuse box
cover. Front/Rear
Spare
Front/Rear
Spare
Front
Rear
Front
Rear
Front
Driver’s side
Passenger’s side NGK:
DENSO:
(2WD)
(2WD)
(2WD)(4WD)
(4WD)
(4WD)
High
Low
(AMBER)
(H11)(HB3)
(H11)
1 : EX-L and EX-SE models
2 : LX, LX-VP, and EX models
1 2
\f—\f—\fy

\fy
(+\fy\f\f\fy
2008 Pilot

Î
ÎThe burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx), and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons. Con-
trolling the production of NOx, CO,
and HC is important to the environ-
ment. Under certain conditions of
sunlight and climate, NOx and HC
react to f orm photochemical ‘‘smog.’’
Carbon monoxide does not contri-
bute to smog creation, but it is a
poisonous gas. The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
In Canada, Honda vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured.
Your vehicle has a positive
crankcase ventilation system. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The positive
crankcase ventilation valve routes
them from the crankcase back to the intake manif old. They are then
drawn into the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The onboard ref ueling vapor
recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
The Clean Air Act
Crankcase Emissions Control
System
Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
Emissions Cont rols
302
\f—\f—\fy

y
(+\fy\f\fy
2008 Pilot

If you take your vehicle f or an
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle retested within the
next two or three days, you can
condition the vehicle f or retesting by
doing the f ollowing.Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
Keep the vehicle in Park. Increase
the engine speed to 2,000 rpm, and
hold it there until the temperature
gauge rises to at least 1/4 of the
scale (about 3 minutes).
Make sure the vehicle has been
parked with the engine of f f or 6
hours or more.
Make sure the ambient
temperature is between 40° and
95°F. Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
f or at least 20 minutes. Drive on
the highway in D. Do not use the
cruise control. When traf f ic allows,
drive f or 90 seconds without
moving the accelerator pedal.
(Vehicle speed may vary slightly;
this is okay.) If you cannot do this
f or a continuous 90 seconds
because of traf f ic conditions, drive
f or at least 30 seconds, then repeat
it two more times (f or a total of 90
seconds).
Without touching the accelerator
pedal, let the engine idle f or 20
seconds.
1.
2.
3.
4. 5.
6.
7.
CONT INUED
T esting of Readiness Codes
Emissions T esting
Technical Inf ormation
305
\f—\f—\fy

\fy
(+\fy\f
\fy
2008 Pilot

CONT INUED
...
Accessories and Modif ications .196
ACCESSORY (Ignition Key
.......................................
Position) .81
............
Accessory Power Sockets .101
...........................
AC Power Outlet .102
....................
Additives, Engine Oil .245
...............
AdvancedAirbagSystem .30
.............................
Airbag (SRS) .11,25
..........
Airbag System Components .25
..............
Air Conditioning System .106
.....................
Rear A/C Control .113
.......................
Air Pressure, Tires .264
......................................
Antif reeze .248
...............
Anti-lock Brakes (ABS) .216
...............................
Indicator .63,217
...................................
Operation .216
..............
Anti-thef t, Audio System .141
.
Anti-thef t Steering Column Lock .81
................................
Audio System .115
...
Automatic Seat Belt Tensioners .23
...
Automatic Lighting Off Feature .76
.............
Automatic Speed Control .177
..............
Automatic Transmission .206
..........................
Capacity, Fluid .294 ...............
Checking Fluid Level .250
.......................................
Shif ting .206
.
Shif t Lever Position Indicator .206
................
Shif t Lever Positions .207
....................
Shif t Lock Release .209
Battery Charging System ...........................
Indicator .62,282
............................
Jump Starting .278
..............................
Maintenance .269
............................
Specif ications .294
..............................
Bef ore Driving .187
..................................
Belts, Seat .10,21
...........................
Beverage Holders .99
..................................
Booster Seats .54
Brakes
...........
Anti-lock System (ABS) .216
.............
Break-in, New Linings .188
....................
Bulb Replacement .258
...........................................
Fluid .252
.........................................
Parking .97
.................
System Indicator .63,284
........................
Wear Indicators .215 .............................
Braking System .215
.................
Break-in, New Vehicle .188
..
Brightness Control, Instruments .76
........................
Brights, Headlights .75
Bulb Replacement
..........................
Back-up Lights .258
.....................
Brake Lights .258,259
................
Front Parking Lights .255
........
Front Side Marker Lights .255
.................................
Headlights .254
........
High-mount Brake Lights .259
.................................
Rear Bulbs .258
............................
Specif ications .295
.............
Turn Signal Light .255,258
..............................
Bulbs, Halogen .254
............................
Capacities Chart .294
.............
Carbon Monoxide Hazard .57
.............................
Carrying Cargo .198
.............
CAUTION, Explanation of .iii
..........................
CD Changer .131,134
.......................................
CD Player .130
Index
A
B
C
INDEX
I
——y

y
(+y
y
2008 Pilot

........................
Certif ication Label .292
............................................
Chains .268
....................
Changing a Flat Tire .273
Change Oil
........................................
How to .246
......................................
When to .237
...
Charging System Indicator .62,282
............
Checklist, Bef ore Driving .204
..................
Childproof Door Locks .83
Child Seats
.........................................
LATCH .47
..........
Tether Anchorage Points .51
...............
Climate Control System .112
.........................
Clock, Setting the .142
.....................
Code, Audio System .141
........................
CO in the Exhaust .302
............
Cold Weather, Starting in .205
......................
Compact Spare Tire .272
...................
Console Compartment .99
.................
Consumer Inf ormation .308
.............
Controls, Instruments and .59
Coolant
........................................
Adding .248
....................................
Checking .192
.........................
Proper Solution .248
...................
Temperature Gauge .71 ...................
Conversation Mirror .100
Crankcase Emissions Control
........................................
System .302
............
Cruise Control Operation .177
....
Customer Service Inf ormation .308
..............................
Economy, Fuel .193
............
Emergencies on the Road .271
.............
Battery, Jump Starting .278
...........
Brake System Indicator .284
................
Changing a Flat Tire .273
.....
Charging System Indicator .282
..................
Checking the Fuses .285
.....
Low Oil Pressure Indicator .282
...
Malf unction Indicator Lamp .283
..................
Overheated Engine .280
...........................
Emergency Brake .97
......................
Emergency Flashers .77
......................
Emergency Towing .285
.......................
Emissions Controls .302
........................
Emissions Testing .305
...............
DANGER, Explanation of .iii
...................................
Dashboard .4,60
................
Daytime Running Lights .76
Daytime Running Lights
.......................................
Indicator .67
.................................
Dead Battery .278
............
Def ects, Reporting Saf ety .310
................
Def ogger, Rear Window .77
......
Def rosting the Windows .108,110
....................................
Dimensions .294
...............
Dimming the Headlights .75
Dipstick
..........
Automatic Transmission .250
..................................
Engine Oil .191
....................
Directional Signals .66,75
........
Disc Brake Wear Indicators .215
.....................
Disposal of Used Oil .247 Doors
..............
Locking and Unlocking .82
..........
DOT Tire Quality Grading .296
...........
Driver and Passenger Safety .7
...........................................
Driving .203
....................................
Economy .193
...................................
DVD Player .144
........
DVD Player Error Message .173
Index
D
E
II
——y

y
(+y
y
2008 Pilot

CONT INUED
...................................
Fan, Interior .106
.........................................
Features .105
....................
Filling the Fuel Tank .189
Filters
...............................................
Oil .246
.............
Flashers, Hazard Warning .77
...................
Flat Tire, Changing a .273 Fluids
..........
Automatic Transmission .250
..........................................
Brake .252
..........................
Power Steering .253
................
Windshield Washers .249
...................
Folding the Third Seat .90
..........................
Four-way Flashers .77
.................................................
Fuel .188
...............................
Cap Message .72
......................
Fill Door and Cap .189
...........................................
Gauge .70
................
Octane Requirement .188
........................
Reserve Indicator .67
........................
Tank, Filling the .189
.....................
Fuses, Checking the .285
...............
Gas Mileage, Improving .194
.........................................
Gasoline .188
...............
Fuel Reserve Indicator .67
...........................................
Gauge .70
................
Octane Requirement .188
........................
Tank, Filling the .189
................
Gas Station Procedures .189 Gauges
...
Engine Coolant Temperature .71
...............................................
Fuel .70
GAWR (Gross Axle Weight .......................................
Rating) .221
GCWR (Gross Combined Weight .......................................
Rating) .221
............
Gearshif t Lever Positions .206
........................................
Glove Box .99
GVWR (Gross Vehicle Weight
.......................................
Rating) .221
.............
Halogen Headlight Bulbs .254
.................
Hazard Warning Button .77
Engine
....
Coolant Temperature Gauge .71
Malf unction Indicator
................................
Lamp .62,283
........
Oil Pressure Indicator .62,282
..............
Oil, What Kind to Use .245
...............................
Overheating .280
............................
Specif ications .295
............................
Speed Limiter .208
.......................................
Starting .205
.
Evaporative Emissions Controls .302
...............................
Exhaust Fumes .57
Exhaust Gas Recirculation
........................................
System .303
Expectant Mothers, Use of Seat ........................................
Belts by .19
Index
F GH
INDEX
III
\f—\f—\fy

y
(+\fy\f\fy
2008 Pilot