maintenance schedule HONDA S2000 2003 1.G Owner's Manual

The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
Check the f luid level with the
transmission at normal operating
temperature and the car sitting on
level ground. Remove the
transmission f iller bolt and caref ully
f eel inside the bolt hole with your
f inger. The f luid level should be up
to the edge of the bolt hole. If it is
not, add Honda Manual Transmis-
sion Fluid (MTF) until it starts to
run out of the hole. Reinstall the
f iller bolt and tighten it securely. If Honda MTF is not available, you
may use an SAE 10W-30 or 10W-40
viscosity motor oil with the API
Certif ication seal that says ‘‘FOR
GASOLINE ENGINES’’ as a
temporary replacement. However,
motor oil does not contain the proper
additives and continued use can
cause stiffer shifting. Replace as
soon as it is convenient.
Maint enance
6-speed Manual T ransmission Fluid
172
CORRECT LEVEL
FILLER BOLT

Put a new washer on the f iller bolt,
then reinstall the f iller bolt. Tighten
it securely. Tightening torque:
The dif f erential should be drained
and ref illed with new f luid according
to the time and distance
recommendations in the
maintenance schedule.
Check the f luid level with the
dif f erential at normal operating
temperature and the vehicle sitting
on level ground. Remove the
dif f erential f luid f iller bolt and
washer and caref ully f eel inside the
bolt hole with your f inger. The f luid
level should be up to the edge of the
bolt hole. If it is not, slowly add f luid
until it starts to run out of the hole. Use an SAE 90 viscosity hypoid gear
oil, API service classif ied GL5 or
GL6 only, in the dif f erential.
Maint enance
Dif f erential Fluid
173
CORRECT LEVEL
FILLER BOLT
33 lbf·ft (45 N·m , 4.6 kgf·m)

The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If the level is at or
below the MIN mark, your brake
system needs attention. Have the
brake system inspected f or leaks or
worn brake pads.
Check the f luid level in the reser-
voirs monthly. There are two reser-
voirs. They are:
Brake f luid reservoir
Clutch f luid reservoir
The brake f luid should be replaced
according to the time recommenda-
tion in the maintenance schedule. Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement. However, the use of
any non-Honda brake fluid can cause
corrosion and decrease the lif e of the
system. Have the brake system
f lushed and ref illed with Honda
Heavy Duty Brake Fluid DOT 3 as
soon as possible.
Brake f luid marked DOT 5 is not
compatible with your car’s braking
system and can cause extensive
damage.Brake System
Brake and Clutch Fluid
Maint enance174
MAX
MIN

To replace it:
Follow the replacement procedure
for removal and reinstallation.
Unsnap the six clamps holding the
air cleaner housing cover.
Remove the air cleaner housing
cover. Disconnect the air intake
duct f rom the air cleaner element.Remove the old air cleaner
element.
Caref ully clean the inside of the
air cleaner housing with a damp
rag.
The air cleaner element should be
replaced according to the time and
distance recommendations in the
maintenance schedule.
1.
2.3.
4.
Replacement
A ir Cleaner Element
Maint enance176
CLAMPS
AIR CLEANER ELEMENT

The spark plugs in your car are a
special platinum-tipped design f or
longer lif e. They only need to be
replaced every 7 years or 105,000
miles (168,000 km), whichever
comes f irst.
Clean the hood latch assembly with a
mild cleaner, then lubricate it with a
multipurpose grease. Lubricate all
the moving parts (as shown),
including the pivot. Follow the time
and distance recommendations in
the Maintenance Schedule. If you
are not sure how to clean and grease
the latch, contact your Honda dealer. Clean off any dirt and oil that have
collected around the ignition coils. Remove the four hexagon socket
head cap bolts holding the ignition
coil cover.
1.
2.
ReplacementSpark Plugs
Hood L atch
Maint enance
Hood L at ch, Spark Plugs
178
PIVOTS

Open the hood. Unclip the
windshield base by pulling it up.Put the pins on the windshield
base into their mating holes on the
support, and push the base down
until the pins snap in. Remove the old f ilter. Put a new
f ilter in the holder and push it in
until it locks.
The dust and pollen f ilter is located
in the engine compartment on the
passenger’s side near the base of the
windshield.
Push the tab on the dust and
pollen f ilter to unlock it f rom the
holder.
This f ilter should be replaced every
30,000 miles (48,000 km) under
normal conditions. It should be
replaced every 15,000 miles (24,000
km) if you drive primarily in urban
areas that have high concentrations
of soot in the air f rom industry and
diesel-powered vehicles. Replace it
more of ten if air f low f rom the
climate control system becomes less
than usual. Have the dust and pollen
f ilter replaced by your Honda dealer. The dust and pollen f ilter removes
pollen and dust f rom the outside air,
The heating and cooling system
brings air into the interior. It should
be replaced according to the time
and distance recommendations in
the maintenance schedule.
1.2.
3.
4.
Maint enance
Replacement
Dust and Pollen Filter
187

Block the rear wheels.
Disconnect the battery.If possible, run the engine f or a
while periodically (pref erably once
amonth).
Support the f ront wiper blade
arms with a f olded towel or rag so
they do not touch the windshield.
To minimize sticking, apply a
silicone spray lubricant to all door
and trunk seals. Also, apply a
vehiclebodywaxtothepainted
surfaces that mate with the door
and trunk seals.
Fill the f uel tank.
Change the engine oil and f ilter
(see page ).
Wash and dry the exterior
completely.
Cleantheinterior.Makesurethe
carpeting, floor mats, etc. are
completely dry.
If you need to park your car f or an
extended period (more than one
month), there are several things you
should do to prepare it f or storage.
Proper preparation helps prevent
deterioration and makes it easier to
get your car back on the road. If
possible, store your car indoors.
If the car is to be stored for a
longer period, it should be
supported on jackstands so the
tires are of f the ground.
Leave one window open slightly (if
the car is being stored indoors).Coverthecarwitha‘‘breathable’’
cover, one made f rom a porous
material such as cotton.
Nonporous materials, such as
plastic sheeting, trap moisture,
which can damage the paint.
If you store your car f or 12 months
or longer, have your Honda dealer
perf orm the inspections called f or in
the 24 months/30,000 miles (48,000
km) maintenance schedule as soon
as you take it out of storage (see
page ). The replacements called
f or in the maintenance schedule are
not needed unless the car has
actually reached that time or mileage.
Raise the convertible top cover.
Leave the parking brake off. Put
the transmission in Reverse. 163
152
Maint enance
St oring Your Car
206

ÎÎ
The burning of gasoline in your car’s
engine produces several byproducts.
Some of these are carbon monoxide
(CO), oxides of nitrogen (NOx) and
hydrocarbons (HC). Gasoline
evaporating from the tank also
produces hydrocarbons. Controlling
the production of NOx, CO, and HC
is important to the environment.
Under certain conditions of sunlight
and climate, NOx and HC react to
f orm photochemical ‘‘smog.’’ Carbon
monoxide does not contribute to
smog creation, but it is a poisonous
gas.
Your car has a Positive Crankcase
Ventilation System. This keeps
gasses that build up in the engine’s
crankcase from going into the
atmosphere. The Positive Crankcase
Ventilation valve routes them fromthe crankcase back to the intake
manif old. They are then drawn into
the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
In Canada, Honda vehicles comply
with the Canadian Motor Vehicle
Saf ety Standards (CMVSS) f or
Emissions valid at the time they are
manuf actured. The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page .
152
The Clean Air Act
Crankcase Emissions Control
System Evaporative Emissions Control
System
Emissions Cont rols
T echnical Inf ormation257

CONT INUED
.........................
Low Fuel Indicator .48
...
Low Oil Pressure Indicator . 46,232
...
Lubricant Specif ications Chart . 250
.........................................
Luggage .128
..................
New Vehicle Break-in . 120
.....................
Normal Shif t Speeds .138
..................
NOTICE, Explanation of . ii
...............
Numbers, Identif ication . 248
..................................
Maintenance .147
...
Owner Maintenance Checks . 159
........................................
Record .157
....................................
Schedule .150
..
Maintenance Required Indicator . 51
.
Malf unction Indicator Lamp . 47,234
...................
Manual Transmission . 137
........
Manual Transmission Fluid . 172
...............................
Meters, Gauges .49
...................
Methanol in Gasoline . 255
..........................
Mirrors, Adjusting .80 ...
Octane Requirement, Gasoline . 120
.........................................
Odometer .50
...............................
Odometer, Trip .51
Oil ........................
Change, How to .163
......................
Change, When to .150
......................
Checking Engine .123
..............
Pressure Indicator . 46,232
Selecting Proper Viscosity ......................................
Chart .162
...........
ON (Ignition Key Position) . 61
.........................
Opening the Trunk .66
..
Operation in Foreign Countries . 256
..............................
Outside Mirrors .80
....................
Overheating, Engine .229
.........................
Oxygenated Fuels .255
..............................
Paint Touch-up .210
..............
Panel Brightness Control . 54
.................................
Parking Brake .81
.................................
Parking Lights .53
.............................
PGM-FI System .258 ..................
Polishing and Waxing . 209
Power ..................................
Door Locks .62
..............
Engine, Specif ications . 250
.........................................
Mirrors .80
......................................
Windows .70
.........
Pregnancy, Using Seat Belts . 17
............................
Protecting Adults .12
...
Additional Safety Precautions . 18
.....
Advice f or Pregnant Women . 17
........................
Protecting Children .18
.......
Protecting Larger Children . 29
.........
Protecting Small Children . 26
...................
Radiator Overheating . 229
.......................
Radio Sound System .94
...................
Readiness Codes . 235,260
..
Rear Lights, Bulb Replacement . 202
............................
Rear View Mirror .80
................
Reclining the Seat-backs . 69
.......
Recommended Shif t Speeds . 138
Index
M
N O
P
R
V

Recovery Vehicle, Emergency.......................................
Towing .245
.............................
Reminder Lights .45
.......................
Remote Transmitter .63
Replacement Inf ormation ................................
Air Cleaner .176
..........................
Engine Coolant .167
................
Engine Oil and Filter . 163
..........................................
Fuses .239
................................
Light Bulbs .198
....................................
Schedule .150
................................
Spark Plugs .178
...........................................
Tires .193
.............................
Wiper Blades .184
Replacing Seat Belts Af ter a ............................................
Crash .34
...............................
Restraint, Child .19
................................
Rotation, Tire .192
........................................
Saf ety Belts .8
............
Safety Defects, Reporting . 266
.............
Saf ety Labels, Location of . 41
...............................
Saf ety Messages .ii ...........................................
Seat Belts .8
...............
Additional Information . 33
.....
Advice f or Pregnant Women . 17
.....................................
Cleaning .212
......................
Lap/Shoulder Belt .33
................................
Maintenance .34
......
Reminder Light and Beeper . 46
...................
System Components . 33
...............
Use During Pregnancy . 17
........................
Seats, Adjusting the .69
...............................
Serial Number .248
...........................
Service Intervals .150
.............................
Service Manual .267
.........
Service Station Procedures . 121
Shif ting The 6-speed Manual .........................
Transmission .137
Side Marker Lights, Bulb .........................
Replacement in .200
...............................
Signaling Turns .55
6-speed Manual Transmission ...............
Checking Fluid Level . 172
................................
Shif ting the .137
.....................................
Snow Tires .195
...................
Solvent-type Cleaners . 208
..................................
Sound System .94 Spare Tire
......................................
Inf lating .218
............................
Specif ications .251
................
Spark Plugs, Replacing . 178
....................
Specif ications Charts . 250
................................
Speed Control .115
...................................
Speedometer .49
..........
SRS, Additional Inf ormation . 36
...
Additional Safety Precautions . 39
How the Automatic Seat Belt ....................
Tensioners Work .34
How the SRS Indicator .......................................
Works .38
...........
How Your Airbags Work . 36
........................
SRS Components .36
..................................
SRS Service .39
..................
SRS Indicator Light . 38,47
.......................
Starting the Engine .135
In Cold Weather at High ..................................
Altitude .136
................
With a Dead Battery . 226
..............
State Emissions Testing . 260
........
Steam Coming f rom Engine . 229
Steering Wheel .............
Anti-theft Column Lock . 60
.....................
Stereo Sound System .94
Index
S
VI