lock HONDA S2000 2004 2.G Workshop Manual

If you have a f lat tire while driving,
stop in a saf e place to change it.
Drive slowly along the shoulder until
you get to an exit or an area that is
far away from the traffic lanes.Thesizedifferencemayalsocause
damage to the rear dif f erential, so do
not mount the compact spare on the
rear. If either rear tire goes f lat,
remove the f ront tire on that same
side, mount the compact spare tire
on the f ront, then mount the f ront
tire on the rear.
Park the vehicle on f irm, level, and
non-slippery ground. Put the
transmission in Reverse. Apply the
parking brake.
Turn on the hazard warning lights,
and turn the ignition switch to
LOCK (0). Have your passenger
get out of the vehicle while you
change the tire. Open the trunk. Lif t up the tool
box lid, and take the jack, wheel
wrench, and extension out of the
tool box.
Thecompactsparetireissmaller
than a standard tire, which will affect
the vehicle’s handling. Drive
cautiously when this spare is
mounted on your vehicle. 3.
1.
2.
CONT INUED
Changing a Flat T ire
T aking Care of t he Unexpect ed155
NOTICE:
TOOL BOX LID
JACK
The vehicle can easily roll off
the jack, seriously injuring
anyone underneath.
Follow the directions for
changing a tire exactly, and
never get under the vehicle
when it is supported only by the
jack. Use the jack that came with
your vehicle. If you try to raise another
vehicle with this jack or use another
jack to raise your vehicle, the vehicle or
jack can be damaged.

Remove the three clips holding
the spare tire cover by pulling
straight up on the rings. Remove
the spare tire cover.Unscrew the wing bolt, and take
the spare tire out of the spare tire
shelf .
Loosen the f ive wheel nuts 1/2
turn with the wheel wrench.Locate the jacking point nearest
thetireyouneedtochange.Itis
pointed to by an arrow molded into
the underside of the body. Place
the jack under the jacking point.
Turn the end bracket clockwise
until the top of the jack contacts
the jacking point. Make sure the
center of the jacking point tab is
restinginthejacknotch.
4.
5.
6.7.
Changing a Flat T ire
T aking Care of t he Unexpect ed156
SPARETIRECOVER

Diagnosing why the engine won’t
start f alls into two areas, depending
on what you hear when you press
the ENGINE START button.You hear nothing, or almost
nothing. The engine’s starter
motor does not operate at all, or
operates very slowly.
You can hear the starter motor
operating normally, or the starter
motor sounds like it is spinning
f aster than normal, but the engine
does not start up and run. When you press the ENGINE
START button, you do not hear the
normal noise of the engine trying to
start. You may hear a clicking sound
or series of clicks, or nothing at all.
Turn the ignition switch to ON (II).
Turn on the headlights, and check
their brightness. If the headlights
are very dim or don’t light at all,
the battery is discharged. See
on page .
Press the ENGINE START button,
then release it. If the headlights do
not dim, check the condition of the
f uses. If the f uses are OK, there is
probably something wrong with
the electrical circuit f or the
ignition switch or starter motor.
You will need a qualif ied
technician to determine the
problem. (See on page .)
Check these things:
Are you using a properly coded
key? An improperly coded key will
cause the immobilizer system
indicator in the instrument panel
to blink rapidly (see page ). Check the transmission interlock.
The clutch pedal must be pushed
all the way to the f loor or the
starter will not operate. 52 162
176
T aking Care of t he Unexpect ed
Nothing Happens or the Starter
Motor Operates Very Slowly Jump Starting
Emergency
Towing
If theEngineWon’tStart
160

If there was no coolant in the
reserve tank, you may need to add
coolant to the radiator. Let the
engine cool down until the reading
reaches the middle of the
temperature gauge, or lower,
bef ore checking the radiator.Using gloves or large heavy cloth,
turn the radiator cap
counterclockwise, without pushing
down, to the f irst stop. Af ter the
pressure releases, push down on
the cap, and turn it until it comes
off.
Start the engine, and set the
temperature control dial to
maximum. Add coolant to the
radiator up to the base of the f iller
neck. If you do not have the
proper coolant mixture available,
you can add plain water.
Remember to have the cooling
system drained and ref illed with
the proper mixture as soon as you
can.Put the radiator cap back on
tightly. Run the engine, and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair (see
on page ).
If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly.
9. 8.
7. 10.
11.176
T aking Care of t he Unexpect ed
Emergency
Towing
If theEngineOverheats
165
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

Turn the ignition switch to LOCK
(0). Make sure the headlights and
all other accessories are off.
Remove the cover f rom the f use
box.
Check each of the large f uses in
the under-hood f use box by
looking through the top at the wire
inside. Remove the screws with a
Phillips-head screwdriver.Check the smaller f uses in the
under-hood f use boxes and all the
fuses in the interior fuse box by
pulling out each one with the f use
puller provided in the primary
under-hood f use box.
Look f or a burned wire inside the
f use. If it is burned, replace it with
oneof thesparefusesof thesame
rating or lower.
If you cannot drive the vehicle
without f ixing the problem, and you
do not have a spare fuse, take a fuse
of the same rating or a lower rating
f rom one of the other circuits. Make
sureyoucandowithoutthatcircuit
temporarily (such as the accessory
power socket or radio).
If you replace the blown f use with a
spare f use that has a lower rating, it
might blow out again. This does not
indicate anything wrong. Replace the
f use with one of the correct rating as soon as you can.
If the replacement fuse of the
same rating blows in a short time,
there is probably a serious
electrical problem in your vehicle.
Leave the blown fuse in that
circuit, and have your vehicle
checked by a qualif ied mechanic.
If the radio f use is removed, the
audio system will disable itself . The
nexttimeyouturnontheradioyou
will see ‘‘Code’’ in the f requency
display. Use the preset buttons to
enter the f ive-digit code (see page ).
1.
2.
3. 4.
5.
6.
94
Fuses
T aking Care of t he Unexpect ed171
NOTICE:
BLOWN
Replacing a f use with one
that has a higher rating greatly
increases the chances of damaging the
electrical system. If you do not have a
replacement f use with the proper rating
f or the circuit, install one with a lower
rating.

The Transmission Number is on a
label underneath the transmission. The Engine Number is stamped on
the back lef t corner of the engine
block, below the rear valve cover.
Identif ication Numbers
T echnical Inf ormation179
TRANSMISSION NUMBERENGINE NUMBER

CONT INUED
Accessories.................................
Installation .105
...............
Accessory Power Socket . 70
ACCESSORY (Ignition Key .......................................
Position) .53
....................
Additives, Engine Oil . 130
...............................
Airbag (SRS) .9, 18
..............................
Air Conditioning .74
.......................
Air Pressure, Tires .146
.............................
Alarm, Anti-theft .53
......................................
Antif reeze .132
Anti-lock Brakes (ABS) ....................
Indicator Light .41, 118
...................................
Operation .117
.
Anti-thef t Steering Column Lock . 53
............................
Anti-thef t System .94
......................................
Audio Panel .71
..................................
Audio System .78
...............
Automatic Speed Control . 95 ............................
Capacities Chart .180
.............
Carbon Monoxide Hazard . 34
........................
Cargo, .107
..............
CAUTION, Explanation of . ii
...........................................
CD Care .85
........................
CD Error Messages .86
.....................................
CD Changer .84
.......
CD Changer Error Messages . 87
.........................................
CD Player .83
........................
Certif ication Label .178
...................................
Chains, .150
Changing Oil ........................................
How to .130
......................................
When to .121
....................
Changing a Flat Tire .155
...
Charging System Indicator . 40,166
............
Checklist, Bef ore Driving . 112
........
Back-up Light Replacement . 141Battery
Charging System ...........................
Indicator .40, 166
............................
Jump Starting .162
..............................
Maintenance .151
............................
Specif ications .181
................................
Bef ore Driving .99
....................................
Belts,Seat .8,15
.............................
Beverage Holder .70
..................................
Booster Seats .31
............................................
Brakes .116
...........
Anti-lock System (ABS) . 117
.............
Break-in, New Linings . 100
...........................................
Fluid .136
.........................................
Parking .67
.................
System Indicator . 40,168
..............
Wear Indicators, Disc . 117
.............................
Braking System .116
.................
Break-in, New Vehicle . 100
..
Brightness Control, Instruments . 49
........................
Brights, Headlights .48
.........................
Bulb Replacement .137
..........................
Back-up Lights .141
.................................
Headlights .137
...........
Side Turn Signal Lights . 139
............................
Specif ications .181 ............
Turn Signal Lights . 139,141
..............................
Bulbs, Halogen .137
how to carry
tires
Index
B A C
I

..............................
Economy, Fuel .104
............
Emergencies on the Road . 153
.............
Battery, Jump Starting . 162
................
Changing a Flat Tire . 155
.....
Charging System Indicator . 166
..................
Checking the Fuses . 170
.........
Hazard Warning Flashers . 49
.....
Low Oil Pressure Indicator . 166
...
Malf unction Indicator Lamp . 167
..................
Overheated Engine . 163
...........................
Emergency Brake .67
......................
Emergency Flashers .49
............
Emergency Trunk Opener . 55
.......................
Emissions Controls .185
.....................................
Child Saf ety .22
..............................
Booster Seats .31
...................................
Child Seats .26
.....
Important Saf ety Reminders . 25
..........................
Larger Children .30
......................
Risk With Airbags .23
.............................
Small Children .26
.......................................
Child Seats .26
Cleaning .................................
Floor Mats .143
...................................
Seat Belts .143
...................................
Clutch Fluid .136
........................
CO in the Exhaust .185
.........................
Compact .154
.............
Controls, Instruments and . 70
..............................
Convertible Top .61
...............
Convertible Top Cover . 63
..
Lowering the Convertible Top . 61
................................
Maintenance .65
.....
Raising the Convertible Top . 64
Coolant ........................................
Adding .132
....................................
Checking .103
.........................
Proper Solution .132
...................
Temperature Gauge . 45Crankcase Emission Control
........................................
System .185
..............
Cruise Control Operation . 95
................
Cruise Control Indicator . 42
......................................
Cup Holder .70
Customer Relations ................................
Inf ormation .192
................
DANGER, Explanation of . ii
.......................................
Dashboard .38
................
Daytime Running Lights . 48
Daytime Running Lights .......................................
Indicator .42
.................................
Dead Battery .162
............
Def ects, Reporting Saf ety . 194
................
Def rosting the Windows . 77
....................................
Dimensions .180
...............
Dimming the Headlights . 48
Dipstick ..................................
Engine Oil .103
..........................
Directional Signals .48
........
Disc Brake Wear Indicators . 117
.....................
Disposal of Used Oil .132
...................
Do Not Tow a Trailer . 118Doors
..............
Locking and Unlocking . 54
..............................
Monitor Light .41
......................
Power Door Locks .54
..........
DOT Tire Quality Grading . 182
Downshif ting, 6-speed Manual
.............................
Transmission .114
...........................................
Driving .111
....................................
Economy .104
spare tire
Index
D
E
II

....................................
Hood Latch .135
.......................
Hood, Opening the .102
...........................
Hydraulic Clutch .136
................
Jacking Up the Vehicle . 156
.......................................
Jack, Tire .155
................................
Jump Starting .162
..................................................
Keys .51 .........................
Label, Certif ication .78
.................
Lane Change, Signaling . 48
..................
Lap/Shoulder Belts . 12,15
Lights ....................
Bulb Replacement .137
.......................................
Indicator .40
..................................
Turn Signal .48
.....................................
Load Limit .108
...............................
Loading Cargo .107
......
LOCK (Ignition Key Position) . 53
Locks .......
Anti-thef t Steering Column . 53
............................
Fuel Fill Door .101
.................................
Power Door .54
...........................................
Trunk .54
........................
Low Coolant Level .103
...
Lower Gear, Downshif ting to a . 114
.........................
Low Fuel Indicator .42
...
Low Oil Pressure Indicator . 40,166
...
Lubricant Specif ications Chart . 180
...............
Luggage, .107
Identif ication Number,
.......................................
Vehicle .178
Ignition ..............................................
Keys .51
...........................................
Switch .53
............
Timing Control System . 186
Indicator Lights, Instrument .........................................
Panel .40
..............
ABS (Anti-Lock Brake) . 41
Brake (Parking and Brake ....................................
System) .40
........................
Charging System .40
.............................
Cruise Control .42
....................................
Door-open .41
DRL(Daytime Running ......................................
Lights) .42
EPS (Electrical Power ..................................
Steering) .41
...................................
High Beam .42
........
Key (Immobilizer System) . 42......................................
Low Fuel .42
........................
Low Oil Pressure .40
...............
Maintenance Required . 43
.......................................
Seat Belt .40
...............................................
SRS .41
..................................
Trunk-open .41
Turn Signal and Hazard ...................................
Warning .42
...................
Inf lation, Proper Tire . 146
...................................
Inside Mirror .66
.............................
Inspection, Tire .147
............................
Instrument Panel .39
........
Instrument Panel Brightness . 49
.................................
Interior Lights .68
........................................
Introduction .i
storing (cargo)
Index
I
J
KL
IV

CONT INUED
..............
Panel Brightness Control . 49
.................................
Parking Brake .67
.................................
Parking Lights .48
.............................
PGM-FI System .186
Power ..................................
Door Locks .54
..............
Engine, Specif ications . 180
.........................................
Mirrors .66
......................................
Windows .59
..........................
Power Door Locks .54
..................
Power Socket Location . 70..............................
Power Windows .59
.........
Pregnancy, Using Seat Belts . 14
.........
Protecting Adults and Teens . 10
...
Additional Safety Precautions . 15
.....
Advice f or Pregnant Women . 14
........................
Protecting Children .22
.....................
General Guidelines .22
.......
Protecting Larger Children . 30
.........
Protecting Small Children . 26
..................................
Maintenance .119
Owner’s Maintenance ...................................
Checks .122
........................................
Record .125
....................................
Schedule .121
..
Maintenance Required Indicator . 43
.
Malf unction Indicator Lamp . 41,167
...................
Manual Transmission . 114
........
Manual Transmission Fluid . 134
...............................
Meters, Gauges .44
..........................
Mirrors, Adjusting .66
...............
Modif ying Your Vehicle . 106
..................
New Vehicle Break-in . 100
.....................
Normal Shif t Speeds .115
..................
NOTICE, Explanation of . ii
...............
Numbers, Identif ication . 178
...
Octane Requirement, Gasoline . 100
.........................................
Odometer .44 ...............................
Odometer, Trip .44
Oil ........................
Change, How to .130
......................
Change, When to .121
......................
Checking Engine .103
..............
Pressure Indicator . 40,166
Selecting Proper Viscosity ......................................
Chart .130
...........
ON (Ignition Key Position) . 53
.........................
Opening the Trunk .54
..............................
Outside Mirrors .66
....................
Overheating, Engine .163
...................
Radiator Overheating . 163
.......................
Radio Sound System .78
...................
Readiness Codes . 167,188
..
Rear Lights, Bulb Replacement . 141
............................
Rear View Mirror .66
................
Reclining the Seat-backs . 58
.......
Recommended Shif t Speeds . 115
Recovery Vehicle, Emergency .......................................
Towing .176
.............................
Reminder Lights .40
.......................
Remote Transmitter .56
Index
M
N
O P
R
V