service HONDA S2000 2005 2.G Owner's Manual

If the brake system indicator comes
on while driving, the brake f luid level
is probably low. Press lightly on the
brake pedal to see if it f eels normal.
If it does, check the brake f luid level
thenexttimeyoustopataservice
station (see page ).
If the f luid level is low, take your
vehicle to a dealer, and have the
brake system inspected f or leaks or
worn brake pads.However, if the brake pedal does not
f eel normal, you should take
immediate action. A problem in one
part of the system’s dual circuit
design will still give you braking at
two wheels. You will f eel the brake
pedal go down much f arther bef ore
the vehicle begins to slow down, and
you will have to press harder on the
pedal.
Slow down by shif ting to a lower
gear, and pull to the side of the road
when it is saf e. Because of the long
distance needed to stop, it is
hazardous to drive the vehicle. You
should have it towed and repaired as
soon as possible (see
on page ).
If you must drive the vehicle a short
distance in this condition, drive
slowly and caref ully.
The brake system
indicator normally
comes on when
you turn the ignition switch to ON
(II), and as a reminder to check the
parking brake. It will stay on if you
do not f ully release the parking
brake.
139 179Emergency
Towing
Brake System Indicator
172
Canada
U.S.

If your vehicle needs to be towed,
call a prof essional towing service or
organization. Never tow your vehicle
with just a rope or chain. It is very
dangerous.The operator will load
your vehicle on the back of a truck.
Any other method of towing will
damage the drive system. When you
contact the towing agency, inf orm
them a f lat-bed is required. If your vehicle gets stuck in sand,
mud, or snow, call a towing service
to pull it out (see the previous
column).
For very short distances, such as
f reeing the vehicle, you can use the
detachable towing hook that mounts
on the anchors in the front and rear
bumpers.To use the towing hook:
Remove the cover f rom the
bumper.
Using the wheel nut wrench,
fasten the extension into the bolt
hole in the anchor. Remove the towing hook, hook
extension, and wheel nut wrench
f rom the tool box.
1.
2.
3.
CONT INUED
Emergency Towing, If Your Vehicle Gets Stuck
Emergency T owing
The only way you can saf ely tow
your vehicle is with f lat-bed
equipment.
If Your Vehicle Gets Stuck
T aking Care of t he Unexpect ed
179

µ
Quality grades can be f ound where
applicable on the tire sidewall
between the tread shoulder and the
maximum section width. For
example:
All passenger car tires must conf orm
to Federal Saf ety Requirements in
addition to these grades. The treadwear grade is a compara-
tive rating based on the wear rate of
the tire when tested under controlled
conditions on a specif ied government
test course. For example, a tire
graded 150 would wear one and one-
half (1 1/2) times as well on the
government course as a tire graded
100. The relative perf ormance of
tires depends upon the actual condi-
tions of their use, however, and may
depart signif icantly f rom the norm
due to variations in driving habits,
service practices, and dif f erences in
road characteristics and climate.
The traction grades, f rom highest to
lowest, are AA, A, B, and C. Those
grades represent the tire’s ability to
stop on wet pavement as measured
under controlled conditions on
specif ied government test surf aces
of asphalt and concrete. A tire
marked C may have poor traction
perf ormance.
Warning: The traction grade
assignedtothistireisbasedon
straight-ahead braking traction tests,
and does not include acceleration,
cornering, hydroplaning, or peak
traction characteristics.
The tires on your vehicle meet all
U.S. Federal Saf ety Requirements.
All tires are also graded f or
treadwear, traction, and temperature
perf ormance according to
Department of Transportation
(DOT) standards. The f ollowing
explains these gradings.
DOT T ire Quality Grading (U.S. Vehicles)
Unif orm T ire Quality Grading
T readwear 200
Traction AA
Temperature A Treadwear
Traction AA, A, B, C
186

Customer Service................................
Inf ormation .194
....................
Warranty Coverages .195
Reporting Saf ety Def ects ..........................
(U.S. Vehicles) .196
.....................
Authorized Manuals .197
Warranty and Customer Relations
Warrant y and Cust omer Relat ions
193

Honda dealership personnel are
trained prof essionals. They should
be able to answer all your questions.
If you encounter a problem that your
dealership does not solve to your
satisf action, please discuss it with
the dealership’s management. The
service manager or general manager
can help. Almost all problems are
solved in this way.
If you are dissatisf ied with the
decision made by the dealership’s
management, contact your Honda
Customer Service Office.
U.S. Owners:Canadian Owners:
In Puerto Rico and the U.S. Virgin
Islands:
When you call or write, please give
us this inf ormation:
Vehicle Identif ication Number
(see page )
Name and address of the dealer
who services your vehicle
Date of purchase
Mileage on your vehicle
Your name, address, and tele-
phone number
A detailed description of the
problem
Name of the dealer who sold the
vehicle to you 182
Cust omer Service Inf ormat ion
194
CUSTOMER RELATIONS
RELATIONS AVEC LA CLIENTÉLE
American Honda Motor Co., Inc.
Automobile Customer Service
Mail Stop 500-2N-7A
1919 Torrance Boulevard
Torrance, California 90501-2746
Tel: (800) 999-1009 Honda Canada Inc.
715 Milner Avenue
Toronto, ON
M1B 2K8
Tel: 1-888-9-HONDA-9
Fax: Toll-free 1-877-939-0909
Toronto (416) 287-4776
Vortex Motor Corp.
Bella International
P.O. Box 190816
San Juan, PR 00919-0816
Tel: (787) 250-4327

µ
Î
Î Î
Î




$
#
Valid only f or sales within the United States. Canadian
owners should contact their authorized Honda dealer.
T he publications shown below can be purchased f rom Helm
Incorporated. You can order in any of three ways:
Detach and mail the order f orm on the right half of this page
Call Helm Inc. at 1-800-782-4356
Go online at
If you are interested in other years or models, contact Helm Inc.
at 1-800-782-4356.
(credit card orders only)
Authorized Manuals
Purchasing Factory Authorized Manuals (U.S. only)
Authorized Manuals
197
ORDER TOLL FREE: 1-800-782-4356
OR
(NOTE: For Credit Card Holder Orders Only)
MINIMUM CREDIT CARD PURCHASE $10.00
From Description
2000-2005 Honda S2000 Service Manual
2000-2005 Honda S2000
Electrical Troubleshooting Manual 2000-2005 Honda S2000Body Repair Manual2005 Honda S2000 Owner’s Manual
2005 Honda S2000
Honda Service History 2005 Honda S2000Quick Start Guide
Order Form for Previous Years-
Indicate Year and Model Desired Price
Each
$70.00
$50.00
$44.00
$34.00
$12.00
$12.00
FREE
Publication
Form Number 61S2A05
61S2A05EL 61S2A30
31S2A650
31S2AM00 31S2AQ20 HON-R
PUBLICATION NUMBER VEHICLE MODEL
Name Year Qty
Price
Each Total
Price
GRAND TOTAL HANDLING CHARGE Mich. Purchases
Add 6% Sales Tax TOTAL MATERIAL
$6.95
Monday-Friday 8:00 A.M. 6:00 P.M. EST
By completing this form you can order the materials desired. You can
pay by check or money order, or charge to your credit card. Mail to
Helm Incorporated at the address shown on the back of the order form.
Prices are subject to change without
notice and without incurring obligation.
Orders are mailed within 10 days. Please
allow adequate time for delivery.
Prices are subject to change without notice and without incurring obligation.
www. helminc. com

µµ
µ
(


%
)
$
%

.
"

#
) This manual covers maintenance and recommended
procedures f or repair to engine and chassis components.
It is written f or the journeyman mechanic, but is simple
enough f or most mechanically-inclined owners to under-
stand.
This manual complements the service manual by
providing in-depth troubleshooting inf ormation f or each
electrical circuit in your vehicle.
This manual describes the procedures involved in the
replacement of damaged body parts.
Authorized Manuals
Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
198
NOTE: Dealers and Companies please provide dealer or company name,
and also the name of the person to whose attention the shipment should
be sent. For purchases outside U.S.A. please write to the address shown
below for a quotation.
P.O. BOX 07280·DETROIT, MICHIGAN 48207·1-800-782-4356
Customer Name Attention
Apartment Number
State & Zip Code
City
Daytime Telephone Number
Check or money order enclosed payable to Helm Inc U.S. funds only.
Do not send cash
Master
Card VISA
Check here if your billing address is different
from the shipping address shown above.
Account Number Expiration: Mo. Yr.
CUSTOMER SIGNATURE DATE
Street Address No P.O. Box Number
()
These Publications cannot be returned for credit without receiving advance authorization within 14
days of delivery. On returns, a restocking fee may be applied against the original order.

Î
................
DANGER, Explanation of . ii
...................................
Dashboard .3, 38
................
Daytime Running Lights . 48
Daytime Running Lights .......................................
Indicator .42
.................................
Dead Battery .166
............
Defects, Reporting Safety . 196
................
Def ogger, Rear Window . 50
................
Defrosting the Windows . 77
..........................
Dif f erential Fluid .138
....................................
Dimensions .184
...............
Dimming the Headlights . 48
Dipstick ..................................
Engine Oil .103
..........................
Directional Signals .48
........
Disc Brake Wear Indicators . 118
.....................
Disposal of Used Oil .134 ...................
Do Not Tow a Trailer . 119
Doors ..............
Locking and Unlocking . 54
.......................
Monitor Indicator .41
......................
Power Door Locks .54
..........
DOT Tire Quality Grading . 186
Downshif ting, Manual .............................
Transmission .115
...........
Driver and Passenger Safety . 5
...........................................
Driving .111
....................................
Economy .104
........................
Driving Guidelines .112
..............................
Economy, Fuel .104
..................................
Emergencies .157
.............
Battery, Jump Starting . 166
...........
Brake System Indicator . 172
................
Changing a Flat Tire . 159
.....
Charging System Indicator . 170
..................
Checking the Fuses . 174
...
Closing the Convertible Top . 173
.........
Hazard Warning Flashers . 49
............................
Jump Starting .166
.....
Low Oil Pressure Indicator . 170
.....................................
Child Saf ety .23
..............................
Booster Seats .32
...................................
Child Seats .28
.....
Important Saf ety Reminders . 26
..........................
Larger Children .31
.......................
Risk with Airbags .24
.............................
Small Children .27
.......................................
Child Seats .28
.......................
Cleaning Seat Belts .145
.................................................
Clock .45
...................................
Clutch Fluid .139
........................
CO in the Exhaust .189
............
Cold Weather, Starting in . 114
......................
Compact Spare Tire .158
...............
Consumer Inf ormation . 194
.............
Controls, Instruments and . 37
..............................
Convertible Top .61
...............
Convertible Top Cover . 63
..
Lowering the Convertible Top . 61
................................
Maintenance .65
.....
Raising the Convertible Top . 64
Coolant ........................................
Adding .134
....................................
Checking .104
.........................
Proper Solution .134
...................
Temperature Gauge . 45Crankcase Emission Control
........................................
System .189
................
Cruise Control Indicator . 41
..............
Cruise Control Operation . 95
......................................
Cup Holder .69
.............
Customer Service Of f ice . 194
Index
D
E
II

ÎÎ Î
.........
Pregnancy, Using Seat Belts . 14
........................
Preparing to Drive .113
.........
Protecting Adults and Teens . 10
...
Additional Safety Precautions . 15
.....
Advice f or Pregnant Women . 14
........................
Protecting Children .23
.....................
General Guidelines .23
.......
Protecting Larger Children . 31
.........
Protecting Small Children . 27
...................
Radiator Overheating . 167
...............
Radio/CD Sound System . 78
...................
Radio Thef t Protection . 94
...................
Readiness Codes . 171,192
..
Rear Lights, Bulb Replacement . 144
............................
Rear View Mirror .66
.................
Rear Window Def ogger . 50
................
Reclining the Seat-backs . 58
.......
Recommended Shif t Speeds . 116
Recovery Vehicle, Emergency .......................................
Towing .179
........................................
Ref ueling .101
.................
Reminder Indicators . 39,40
.......................
Remote Transmitter .56 Replacement Inf ormation
..............
Dust and Pollen Filter . 146
................
Engine Oil and Filter . 132
..........................................
Fuses .174
................................
Light Bulbs .140
....................................
Schedule .123
...........................................
Tires .152
.............................
Wiper Blades .147
Replacing Seat Belts Af ter a ............................................
Crash .17
..........
Reporting Saf ety Def ects . 196
Reserve Tank, Engine ...............................
Coolant .104, 134
...............................
Restraint, Child .23
...........................
Reverse Lockout .116
................................
Rotation, Tire .151
..................................
Saf ety Belts .8, 16
.........
Safety Defects, Reporting . 196
.................................
Saf ety Features .7
...........................................
Airbags .9
.......................................
Seat Belts .8
.............
Saf ety Labels, Location of . 36
...............................
Saf ety Messages .ii ..................................
Satellite Radio .83
.....................................
Seat Belts .8, 16
...............
Additional Information . 16
.....
Advice f or Pregnant Women . 14
Automatic Seat Belt ...............................
Tensioners .17
.....................................
Cleaning .145
......................
Lap/Shoulder Belt .16
................................
Maintenance .17
Reminder Indicator and ................................
Beeper .16, 40
...................
System Components . 16
...............
Use During Pregnancy . 14
........................
Seats, Adjusting the .58
...............................
Serial Number .182
...........................
Service Intervals .125
...........................
Service Manual .197
.........
Service Station Procedures . 101
............................
Setting the Clock .45
Shif ting .............
Manual Transmission . 115
Side Turn Signal, Bulb .............................
Replacement .143
...............................
Signaling Turns .48
.....................................
Snow Tires .153
..................................
Sound System .78
Index
S
R
VI

Î
CONT INUED
Spare Tire......................................
Inf lating .150
............................
Specif ications .185
....................................
Spark Plugs .184
................................
Specif ications .184
..................................
Speed Control .95
................................
Speed Limiter .116
..........
SRS, Additional Inf ormation . 19
...
Additional Safety Precautions . 22
.............................
Airbag Service .21
......
Airbag System Components . 19
How the SRS Indicator .......................................
Works .21
How Your Front Airbags .........................................
Work .19
.............................
SRS Indicator .21 ,41
...................................
Start Button .114
.......................
Starting the Engine .114
In Cold Weather at High ..................................
Altitude .114
................
With a Dead Battery . 166
..............
State Emissions Testing . 192
........
Steam Coming f rom Engine . 167
Steering Wheel .............
Anti-theft Column Lock . 53
.....................
Stereo Sound System .78 ....................
Storing Your Vehicle .155
................................
Stuck Vehicle .179
Supplemental Restraint System ..................................
Servicing .21
.........................
SRS Indicator .21 ,41
...................
System Components . 19
..................................
Synthetic Oil .132
..........
Taillights, Changing Bulbs . 144
.
Taking Care of the Unexpected . 157
Technical Descriptions ....
DOT Tire Quality Grading . 186
.....
Emissions Control Systems . 189
Three Way Catalytic ...............................
Converter .191
.......................
Temperature Gauge .45
...................
Tensioners, Seat Belts . 17
..................
Thef t Protection, Radio . 94
..
Three Way Catalytic Converter . 191
............................
Time, Setting the .45
....................................
Tire Chains .153
.........
Tire, How to Change a Flat . 159
.................................
Tire Labeling .188 ...............................................
Tires .148
..............................
Air Pressure .150
...................................
Balancing .151
........................................
Chains .153
.........................
Checking Wear .150
.................
Compact Spare Tire . 158
......
DOT Tire Quality Grading . 186
......................................
Inf lation .149
..................................
Inspection .150
...................................
Replacing .152
......................................
Rotating .151
...........................................
Snow .153
............................
Specif ications .185
...........................................
Wear .151
...................
Tools, Tire Changing . 159
Towing ......................
A Trailer, Do Not .119
................
Emergency Wrecker . 179
..................
Trailer, Do Not Tow a . 119
Transmission Checking Fluid Level, Manual .........................
Transmission .137
...........................
Fluid Selection .137
..............
Identif ication Number . 183
Index
T
INDEX
VII