brake HONDA S2000 2009 2.G Service Manual

If the brake system indicator comes
on while driving, the brake f luid level
is probably low. Press lightly on the
brake pedal to see if it f eels normal.
If it does, check the brake f luid level
thenexttimeyoustopataservice
station (see page ).
If the f luid level is low, take your
vehicle to a dealer, and have the
brake system inspected f or leaks or
worn brake pads.However, if the brake pedal does not
f eel normal, you should take
immediate action. A problem in one
part of the system’s dual circuit
design will still give you braking at
two wheels. You will f eel the brake
pedal go down much f arther bef ore
the vehicle begins to slow down, and
you will have to press harder on the
pedal.
Slow down by shif ting to a lower
gear, and pull to the side of the road
when it is saf e. Because of the long
distance needed to stop, it is
hazardous to drive the vehicle. You
should have it towed and repaired as
soon as possible (see
on page ).
If you must drive the vehicle a short
distance in this condition, drive
slowly and caref ully.
The brake system
indicator normally
comes on when
you turn the ignition switch to the
ON (II) position, and as a reminder
to check the parking brake. It will
stay on if you do not f ully release the
parking brake.
178 228Emergency
Towing
Brake System Indicator
220
Canada
U.S.
2009 S2000

The vehicle’s f uses are contained in
threefuseboxes.The primary under-hood f use box is
onthepassenger’ssidenexttothe
battery. To open it, push the two tabs
as shown.The auxiliary under-hood f use box is
on the driver’s side, near the brake
f luid reservoir. To open it, push the
taboneachside,andremovethelid.
The interior f use box is underneath
the dashboard on the driver’s side.
To open it, turn the knob.
Fuses
222
INTERIOR UNDER-HOOD
(PRIMARY)
UNDER-HOOD
(AUXILIARY)
KNOB
2009 S2000

Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
6th.Donotusethecruisecontrol.
When traffic allows, drive for 90
seconds without moving the
accelerator pedal. (Vehicle speed
may vary slightly; this is okay.) If
you cannot do this f or a
continuous 90 seconds because of
traf f ic conditions, drive f or at least
30 seconds, then repeat it two
more times (for a total of 90
seconds).Then drive in city/suburban
traffic for at least 10 minutes.
When traf f ic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
Make sure the vehicle has been
parked with the engine of f f or 30
minutes.
If the testing f acility determines the
readiness codes are still not set, see
your dealer.
9.
7.
8.
Emissions T esting
246
2009 S2000

CONT INUED
....................................
Accessories .136
ACCESSORY (Ignition Key
.......................................
Position) .64
...............
Accessory Power Socket .90
....................
Additives, Engine Oil .170
...............................
Airbag (SRS) .9,20
........
Air Conditioning System .96,100
...................................
Usage .98,102
.......................
Air Pressure, Tires .190
.......................
Alcohol in Gasoline .128
AM/FM Stereo Radio ...................................
Reception .107
......................................
Antif reeze .173
Anti-lock Brakes (ABS) ...............................
Indicator .45,151
...................................
Operation .150
.
Anti-thef t Steering Column Lock .64
..........................
Anti-thef t System .123
......................................
Audio Panel .91
................................
Audio System .104
...
Automatic Seat Belt Tensioners .18
.............
Automatic Speed Control .124 ............................
Capacities Chart .234
.............
Carbon Monoxide Hazard .41
....................
Cargo, How to Carry .138
.............
CAUTION, Explanation of .iii
.........................................
CD Care .117
...................................
CD Changer .116
.....
CD Changer Error Messages .121
.........
CD Player Error Messages .120
.......................................
CD Player .114
........................
Certif ication Label .232
.................................
Chains, Tires .194
....................
Changing a Flat Tire .201
Changing Oil ........................................
How to .171
......................................
When to .161
...
Charging System Indicator .46,218
........
Back-up Light Replacement .183
Battery
Charging System ...........................
Indicator .46,218
............................
Jump Starting .214
..............................
Maintenance .196
............................
Specif ications .235
..............................
Bef ore Driving .127
....................................
Belts,Seat .8,16
.............................
Beverage Holder .90
..................................
Booster Seats .38
............................................
Brakes .149
...........
Anti-lock System (ABS) .150
.............
Break-in, New Linings .128
...........................................
Fluid .178
.........................................
Parking .88
..........................
System Design .150
.................
System Indicator .46,220
........................
Wear Indicators .150
.............................
Braking System .149
.................
Break-in, New Vehicle .128
..
Brightness Control, Instruments .60
.........................
Bulb Replacement .179
..........................
Back-up Lights .183.................................
Headlights .179
...........
Side Turn Signal Lights .182
............................
Specif ications .235
....................
Turn Signal Lights .181
..............................
Bulbs, Halogen .179
Index
B
A
C
INDEX
I
2009 S2000

ÎÎÎ
............
Checklist, Bef ore Driving .145
.....................................
Child Saf ety .29
..............................
Booster Seats .38
...................................
Child Seats .34
.....
Important Saf ety Reminders .32
..........................
Larger Children .37
.......................
Risk with Airbags .30
.............................
Small Children .33
.......................................
Child Seats .34
.......................
Cleaning Seat Belts .184
.................................................
Clock .56
...................................
Clutch Fluid .178
........................
CO in the Exhaust .242
............
Cold Weather, Starting in .146
......................
Compact Spare Tire .200
...............
Consumer Inf ormation .248
.............
Controls, Instruments and .43
..............................
Convertible Top .72
...............
Convertible Top Cover .74
..
Lowering the Convertible Top .72
................................
Maintenance .77
.....
Raising the Convertible Top .76
............................
Wind Def lector .75
Coolant ........................................
Adding .173
....................................
Checking .132.........................
Proper Solution .173
...................
Temperature Gauge .55
Crankcase Emission Control ........................................
System .242
................
Cruise Control Indicator .47
............
Cruise Control Operation .124
......................................
Cup Holder .90
.........................
Customer Service .248
..............................
Economy, Fuel .133
...............
DANGER, Explanation of .iii
...................................
Dashboard .3,44
..............
Dashboard Lower Pocket .92
................
Daytime Running Lights .59
Daytime Running Lights
.......................................
Indicator .48
.................................
Dead Battery .214
.........
Defects, Reporting Safety .250
................
Def ogger, Rear Window .61
........
Def rosting the Windows .99,103
..........................
Dif f erential Fluid .177
....................................
Dimensions .234
...............
Dimming the Headlights .59
Dipstick
..................................
Engine Oil .131..........................
Directional Signals .59
........
Disc Brake Wear Indicators .150
.....................
Disposal of Used Oil .173
...................
Do Not Tow a Trailer .157
Doors
..............
Locking and Unlocking .65
.......................
Monitor Indicator .47
......................
Power Door Locks .65
........
DOT Tire Quality Grading .236
Downshif ting, Manual
.............................
Transmission .147
...........
Driver and Passenger Safety .5
...........................................
Driving .143
....................................
Economy .133
........................
Driving Guidelines .144
..................
DustandPollenFilter .185
Index
D
E
II
2009 S2000

CONT INUED
............................
Fan, Interior .97,101
...........................................
Features .95
....................
Filling the Fuel Tank .129
Filters
.........................
Dust and Pollen .185
...............................................
Oil .171
.............
Flashers, Hazard Warning .60
...................
Flat Tire, Changing a .201
...................
Flat Tire, Repairing a .206 Fluids
..........................................
Brake .178
.........................................
Clutch .178
..............
Manual Transmission .176
..................
Windshield Washer .175
..........................
Four-way Flashers .60
.................................................
Fuel .128
......................
Fill Door and Cap .129
...........................................
Gauge .54
.....................
Low Fuel Indicator .49
................
Octane Requirement .128
...............................
Oxygenated .128
........................
Tank, Ref ueling .129
...............................
Fuel Economy .133
..............
Fuel Station Procedures .129
.....................
Fuses, Checking the .223
...............
Gas Mileage, Improving .133
..................................
Emergencies .199
.............
Battery, Jump Starting .214
...........
Brake System Indicator .220
................
Changing a Flat Tire .201
.....
Charging System Indicator .218
..................
Checking the Fuses .223
...
Closing the Convertible Top .221
.........
Hazard Warning Flashers .60
............................
Jump Starting .214
.....
Low Oil Pressure Indicator .218
...
Malf unction Indicator Lamp .219
..................
Overheated Engine .215
.......................................
Towing .228
...........................
Emergency Brake .88
......................
Emergency Flashers .60
......................
Emergency Towing .228
............
Emergency Trunk Opener .66
.......................
Emissions Controls .242
.............
Emissions Testing, State .245
Engine
............
Adding Engine Coolant .173
....
Coolant Temperature Gauge .55
.........................
If It Won’t Start .212
Malf unction Indicator ................................
Lamp .47,219
.......................
Oil Lif e Indicator .161 ........
Oil Pressure Indicator .46,218
..............
Oil, What Kind to Use .170
...............................
Overheating .215
............................
Specif ications .234
............................
Speed Limiter .148
...............................
Start Button .146
.......................................
Starting .146
Electronic Stability Control ............................
(ESC) System .152
......................
Ethanol in Gasoline .128
...
Evaporative Emission Controls .242
...............................
Exhaust Fumes .41
Expectant Mothers, Use of Seat ........................................
Belts by .14
Index
F
G
INDEX
III
2009 S2000

.........................................
Gasoline .128
...........................................
Gauge .54
.....................
Low Fuel Indicator .49
................
Octane Requirement .128
........................
Tank, Ref ueling .129
.............................................
Gauges .53
...
Engine Coolant Temperature .55
...............................................
Fuel .54
Gearshif t Lever Positions ..............
Manual Transmission .148
Gross Vehicle Weight Rating .............................
(GVWR) .140,234
.............
Halogen Headlight Bulbs .179
.......................
Hardtop, Removable .78
...................................
Installation .79
.......................................
Removal .83
..........................................
Storing .86
.......................................
Washing .86
............................
Wind Def lector .75
..............
Hazard Warning Flashers .60
Headlights
........................................
Aiming .179
............
Daytime Running Lights .59 ..................
High Beam Indicator .49
...........................
Reminder Tone .59
........
Replacing Halogen Bulbs .179
...................................
Turning on .59
.....................................
Heating .96,100
.
Heating and Cooling System .96,100
............................
High Beam Lever .59
.......................
Hood, Opening the .130
..................................................
Horn .57
...........................
Hydraulic Clutch .178
Identif ication Number, .......................................
Vehicle .232
Ignition ..............................................
Keys .62
...........................................
Switch .64
............
Timing Control System .243
........................
Immobilizer System .63
.........
Important Safety Precautions .6
Indicators
..............
ABS (Anti-Lock Brake) .47
Brake (Parking and Brake
............................
System) .46,220
................
Charging System .46,218 .............................
Cruise Control .47
....................................
Door-open .47
DRL(Daytime Running ......................................
Lights) .48
EPS (Electrical Power ..................................
Steering) .48
...................................
High Beam .49
........
Key (Immobilizer System) .49
......................................
Low Fuel .49
................
Low Oil Pressure .46,218
..............
Low Tire Pressure .51,240
...............
Maintenance Required .50
Malf unction Indicator
................................
Lamp .47,219
..................................
Peak Power .52
.......................................
Seat Belt .46
...............................................
SRS .47
...........................
TPMS System .240
..................................
Trunk-open .47
Turn Signal and Hazard ...................................
Warning .48
VSA
(Vehicle Stability ......................................
Assist) .50
.........
Indicators, Instrument Panel .46
...................
Inf lation, Proper Tire .189
........
Recommended Pressures .190
Index
I
H
IV
2009 S2000

Î
Î
Onboard Ref ueling Vapor
....................................
Recovery .242
.........................
Opening the Trunk .65
..............................
Outside Mirrors .87
....
Outside Temperature Indicator .55
....................
Overheating, Engine .215
....
Owner’s Maintenance Checks .167
.........................
Oxygenated Fuels .128
..............
Panel Brightness Control .60
...........................................
Parking .149
.................................
Parking Brake .88
Parking Brake and Brake System .....................................
Indicator .220
.................................
Parking Lights .59
.....................
Peak Power Indicator .52
.............................
PGM-FI System .243
...................................
Pollen Filter .185
..........................
Power Door Locks .65
..................
Power Socket Location .90
..............................
Power Windows .70
.........
Pregnancy, Using Seat Belts .14
........................
Preparing to Drive .145 .........
Protecting Adults and Teens .10
...
Additional Safety Precautions .15
.....
Advice f or Pregnant Women .14
........................
Protecting Children .29
.....................
General Guidelines .29
.......
Protecting Larger Children .37
.........
Protecting Small Children .33
..................................
Saf ety Belts .8,16
.........
Safety Defects, Reporting .250
...................
Radiator Overheating .215
.............
Radio/CD Sound System .104
.................
Radio Thef t Protection .123
...................
Readiness Codes .219,245
..
Rear Lights, Bulb Replacement .183
............................
Rear View Mirror .87
.................
Rear Window Def ogger .61
................
Reclining the Seat-backs .69
.......
Recommended Shif t Speeds .148
Recovery Vehicle, Emergency
.......................................
Towing .228
........................................
Ref ueling .129
.......................
Reminder Indicators .45
.......................
Remote Transmitter .67
........................
Removable Hardtop .78
...................................
Installation .79.......................................
Removal .83
..........................................
Storing .86
.......................................
Washing .86
............................
Wind Def lector .75
Replacement Inf ormation ..............
Dust and Pollen Filter .185
................
Engine Oil and Filter .171
..........................................
Fuses .222
................................
Light Bulbs .179
....................................
Schedule .168
...........................................
Tires .192
.............................
Wiper Blades .186
Replacing Seat Belts Af ter a ............................................
Crash .18
..........
Reporting Saf ety Def ects .250
Reserve Tank, Engine
...............................
Coolant .132,173
...............................
Restraint, Child .29
...........................
Reverse Lockout .148
................................
Rotation, Tire .192
Index
R
P
S
VI
2009 S2000

Service Inf ormation Summary
Gasoline:
Fuel Tank Capacity:Tire Pressure (measured cold):
SpareTirePressure:
Recommended Engine Oil: Manual Transmission Fluid:
Brake Fluid:
Differential Fluid:
60 psi (420 kPa , 4.2 kgf/cm
)
32 psi (220 kPa , 2.2 kgf/cm
)
32 psi (220 kPa , 2.2 kgf/cm
)
5.1 US qt (4.8
)
Premium unleaded gasoline,
pump octane number of 91 or
higher.
Oil change capacity (including
filter):
Front:
Rear:
Front:
Honda Manual Transmission
Fluid preferred, or an SAE 10W-30
or 10W-40 motor oil as a
temporary replacement (see page
).
Capacity: 1.7 US qt (1.6
)
API premium grade 10W-30
detergent oil (see page ). 13.2 US gal (50
)
Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ).
SAE 90 viscosity hypoid gear oil.
API service classified GL5 or GL6
only(seepage).
Fluid change capacity:0.78 US qt (0.74
)
170
176
178
177
2009 S2000