Sport eco HYUNDAI I20 2023 Owners Manual
[x] Cancel search | Manufacturer: HYUNDAI, Model Year: 2023, Model line: I20, Model: HYUNDAI I20 2023Pages: 649, PDF Size: 12.35 MB
Page 2 of 649
Your HYUNDAI should not be modified in any way. Such modifications may
adversely affect the performance, safety or durability of your HYUNDAI
and may, in addition, violate conditions of the limited warranties covering
the vehicle. Certain modifications may also be in violation of regulations
established by the Department of Transportation and other government
agencies in your country.
CAUTION: MODIFICATIONS TO YOUR HYUNDAI
Your vehicle is equipped with electronic fuel injection and other electronic
components. It is possible for an improperly installed/adjusted two-way radio
or mobile telephone to adversely affect electronic systems. For this reason,
we recommend that you carefully follow the radio manufacturer’s instructions
or consult your HYUNDAI dealer for precautionary measures or special
instructions if you choose to install one of these devices.
The vehicle is equipped with a device of the system Pan-european eCall
which calls emergency services. Any self-or unauthorised interference in the
system Pan-european eCall, in vehicle systems and its components, installing
of equipment which is not recommended by vehicle manufacturer and/or in
authorised HYUNDAI dealerships can cause incorrect operation (of the device
of) the system Pan-european eCall, making erroneous calls, causing failure
of the device (in cars) in case of traffic accident or other accidents, when you
need emergency care.
This may be dangerous and threaten your life!
7 : 2
Page 66 of 649
3-29
03
Seat belt use and injured people
A seat belt should be used when an
injured person is being transported.
Consult a physician for specific
recommendations.
One person per belt
Two people (including children) should
never attempt to use a single seat belt.
This could increase the severity of injuries
in case of an accident.
Do not lie down
Sitting in a reclined position when the
vehicle is in motion can be dangerous.
Even when buckled up, the protections
of your restraint system (seat belts
and/or air bags) is greatly reduced by
reclining your seatback.
Seat belts must be snug against your
hips and chest to work properly. During
an accident, you could be twined with
the seat belt, causing neck or other
injuries.
The more the seatback is reclined,
the greater chance the passenger’s
hips will slide under the lap belt or the
passenger’s neck will strike the shoulder
belt.
WARNING
[ NEVER ride with a reclined seatback
when the vehicle is moving.
[ Riding with a reclined seatback
increases your chance of serious
or fatal injuries in the event of a
collision or sudden stop.
[ Driver and passengers should always
sit well back in their seats, properly
belted, and with the seatbacks
upright.
Care of seat belts
Seat belt systems should never be
disassembled or modified. In addition,
care should be taken to assure that
seat belts and belt hardware are not
damaged by seat hinges, doors or other
abuse.
Periodic inspection
All seat belts should be inspected
periodically for wear or damage of any
kind. Any damaged parts should be
replaced as soon as possible.
Keep belts clean and dry
Seat belts should be kept clean and
dry. If belts become dirty, they can be
cleaned by using a mild soap solution
and warm water. Bleach, dye, strong
detergents or abrasives should not be
used because they may damage and
weaken the fabric.
When to replace seat belts
The entire seat belt assembly or
assemblies should be replaced if the
vehicle has been involved in an accident.
This should be done even if no damage
is visible. We recommend that you
consult a HYUNDAI authorised repairer.
Page 112 of 649
4-17
04
ECS SPORT Indicator
Light (if equipped) ( 6 &
6 3 2 5 7
7 K L V L Q G L F D W R U O L J K W L O O X P L Q D W H V
[ When ESC SPORT is activated.
For more details, refer to “Electronic
Stability Control” in chapter 6.
AUTO STOP indicator
light (if equipped)
7 K L V L Q G L F D W R U O L J K W L O O X P L Q D W H V
This indicator light illuminates:
When the engine enters the Idle Stop
mode of ISG (Idle Stop and Go) system.
7 K L V L Q G L F D W R U O L J K W E O L Q N V
When the engine automatically starts,
the AUTO STOP indicator on the cluster
will blink for 5 seconds.
For more details, refer to "ISG (Idle Stop
and Go) system" section in chapter 6.
i Information
: K H Q W K H H Q J L Q H D X W R P D W L F D O O \ V W D U W V E \
W K H , 6 * V \ V W H P V R P H Z D U Q L Q J O L J K W V $ % 6
( 6 & ( 6 & 2 ) ) ( 3 6 R U 3 D U N L Q J E U D N H
Z D U Q L Q J O L J K W P D \ W X U Q R Q I R U D I H Z
V H F R Q G V
7 K L V K D S S H Q V E H F D X V H R I O R Z E D W W H U \
Y R O W D J H , W G R H V Q R W P H D Q W K H V \ V W H P K D V
P D O I X Q F W L R Q H G
Immobiliser indicator
light (without smart key)
(if equipped)
7 K L V L Q G L F D W R U O L J K W L O O X P L Q D W H V
[ When the vehicle detects the
immobiliser in the key with the ignition
switch in the ON position.
- At this time, you can start the engine.
- The indicator light goes off after
starting the engine.
7 K L V L Q G L F D W R U O L J K W E O L Q N V
[ When there is a malfunction with the
immobiliser system.
In this case, we recommend that
you have the vehicle inspected by a
HYUNDAI authorised repairer.
Page 115 of 649
4-20
Instrument cluster
Cruise Indicator Light
(if equipped)
7 K L V L Q G L F D W R U O L J K W L O O X P L Q D W H V
[ When Cruise Control is enabled.
For more details, refer to "Cruise
Control (CC)" in chapter 7.
SPORT Mode Indicator
Light (if equipped)
7 K L V L Q G L F D W R U O L J K W L O O X P L Q D W H V
[ When you select "SPORT" mode as
drive mode.
For more details, refer to "Drive Mode
Integrated Control System" in chapter
6.
SMART Mode Indicator
Light (if equipped)
6 0 $ 5 7
7 K L V L Q G L F D W R U O L J K W L O O X P L Q D W H V
[ When you select ''SMART" mode as
drive mode.
For more details, refer to "Drive Mode
Integrated Control System'' in chapter
6.
ECO Mode Indicator
Light (If equipped)
7 K L V L Q G L F D W R U O L J K W L O O X P L Q D W H V
[ When you select "ECO" mode as drive
mode.
For more details, refer to "Drive Mode
Integrated Control System" in chapter
6.
CUSTOM Mode Indicator
Light (If equipped) & 8 6 7 2 0
7 K L V L Q G L F D W R U O L J K W L O O X P L Q D W H V
[ When you select "CUSTOM" mode as
drive mode.
For more details, refer to "Drive Mode
Integrated Control System" in chapter
6.
Page 330 of 649
6-57
06
SPORT+ mode
6 3 2 5 7
SPORT+ mode manages the
driving dynamics by
automatically adjusting the
steering effort, the en-gine
and transmission control
logic for enhanced driver
performance.
[ When SPORT+ mode is selected by
using the DRIVE MODE switch, the
SPORT+ indicator will illuminate.
[ Whenever the engine is restarted,
the Drive Mode will revert back to
NORMAL mode. If SPORT+ mode is
desired, re-select SPORT+ mode from
the DRIVE MODE switch.
[ When SPORT+ mode is activated:
- The engine rpm will tend to remain
raised over a certain length of time
even after releasing the ac-celerator
- Upshifts are delayed when
accelerating
i Information
, Q 6 3 2 5 7 P R G H W K H I X H O H F R Q R P \ P D \
G H F U H D V H
SMART mode
6 0 $ 5 7
SMART mode selects the
proper driving mode among
ECO, COMFORT, and SPORT
by judging the driver’s
driving habits (i.e. Economic
or Aggressive (Sportive))
from the brake pedal
pressing or the steering
wheel operation.
[ Toggle the DRIVE MODE button to
select SMART mode. When SMART
mode is selected, the indicator
illuminates on the instrument cluster.
[ SMART mode automatically controls
the vehicle driving, such as gear
shifting patterns and engine torque,
in accordance with the driver’s driving
habits.
i Information
Page 435 of 649
07
7-89
OBC3070022
To turn off Smart Cruise Control
Press the Driving Assist button to turn
Smart Cruise Control system off.
Information
If your vehicle is equipped with Manual
Speed Limit Assist, press and hold the
Driving Assist button to turn off Smart
Cruise Control. However, Manual Speed
Limit Assist will turn on.
Based on DRIVE MODE
Smart Cruise Control will change
acceleration based on the drive mode
selected from Drive Mode Integrated
Control system. Refer to the following
chart.
Drive mode Smart Cruise Comtrol
COMFORT Normal
ECO Slow
SPORT Fast
Information
For more details on drive mode, refer to
“Drive Mode Integrated Control System”
V H F W L R Q L Q F K D S W H U
„Type A
OTM070141L
„Type B
ONX4E070090
Warning volume
With the engine on, select ‘Driver
D V V L V W D Q F H
Page 565 of 649
9-6
Maintenance
You should exercise the utmost care
to prevent damage to your vehicle and
injury to yourself whenever performing
any maintenance or inspection
procedures.
We recommend you have your vehicle
maintained and repaired by a HYUNDAI
authorised repairer. A HYUNDAI
authorised repairer meets HYUNDAI’s
high service quality standards and
receives technical support from
HYUNDAI in order to provide you with a
high level of service satisfaction.
Owner’s responsibility
Maintenance service and record
retention are the owner’s responsibility.
You should retain documents that show
proper maintenance has been performed
on your vehicle in accordance with
the scheduled maintenance service
charts shown on the following pages.
You need this information to establish
your compliance with the servicing
and maintenance requirements of your
vehicle warranties.
Detailed warranty information is
provided in your Service Passport.
Repairs and adjustments required as
a result of improper maintenance or a
lack of required maintenance are not
covered.
Owner maintenance
precautions
Inadequate, incomplete or insufficient
servicing may result in operational
problems with your vehicle that could
lead to vehicle damage, an accident, or
personal injury. This chapter provides
instructions only for the maintenance
items that are easy to perform.
Your vehicle should not be modified
in any way. Such modifications may
adversely affect the performance, safety
or durability of your vehicle and may, in
addition, violate conditions of the limited
warranties covering the vehicle.
NOTICE
Improper owner maintenance during
the warranty period may affect
warranty coverage. For details, read
the separate Service Passport provided
with the vehicle. If you’re unsure
about any servicing or maintenance
procedure, we recommend that the
system be serviced by a HYUNDAI
authorised repairer.
MAINTENANCE SERVICES
Page 600 of 649
9-41
09
7 H P S H U D W X U H $ % &
The temperature grades are A (the
highest), B and C representing the tyre’s
resistance to the generation of heat
and its ability to dissipate heat when
tested under controlled conditions on a
specified indoor laboratory test wheel.
Sustained high temperature can cause
the material of the tyre to degenerate
and reduce tyre life, and excessive
temperature can lead to sudden tyre
failure. Grades B and A represent higher
levels of performance on the laboratory
test wheel than the minimum required
by law.
WARNING
The temperature grade for this tyre is
established for a tyre that is properly
inflated and not overloaded. Excessive
speed, under-inflation, over-inflation,
or excessive loading, either separately
or in combination, can cause heat
build-up and possible sudden tyre
failure. This may cause loss of vehicle
control resulting in an accident.
Low aspect ratio tyres
Low aspect ratio tyres, the aspect ratio
is lower than 50, are provided for sporty
looks.
Because low aspect ratio tyres are
optimized for handling and braking, their
sidewall is a little stiffer than a standard
tyre. Also, low aspect ratio tyres tend to
be wider so that they consequently have
a greater contact patch with the road
surface. In some instances, they may
generate more road noise compared
with standard tyres.
CAUTION
% H F D X V H W K H V L G H Z D O O R I D O R Z D V S H F W
ratio tyre is shorter than a standard
tyre, the rim of the wheel and the
tyre itself are more easily more easily
susceptible to damage. Use caution
when driving and follow the guidelines
below to help minimise damage to the
wheel and tyre:
[ : K H Q G U L Y L Q J R Q D U R X J K U R D G R U
driving off a road, be careful not to
damage the tyres and wheels. After
driving, inspect the tyres and wheels.
[ : K H Q S D V V L Q J R Y H U D S R W K R O H V S H H G
bump, manhole, or kerb stone,
drive the vehicle slowly so as not to
damage the tyres and wheels.
[ , I W K H W \ U H L V V X E M H F W H G W R D V H Y H U H
impact, we recommend you have
the tyre and wheel inspected by a
HYUNDAI authorised repairer.
[ , Q V S H F W W K H W \ U H F R Q G L W L R Q D Q G
pressure every 3,000 km (1,800 miles)
to prevent tyre damage.
[ , W L V Q R W H D V \ W R U H F R J Q L V H W \ U H
G D P D J H Z L W K \ R X U R Z Q H \ H V % X W
if there is the slightest hint of tyre
damage, have the tyre checked or
replaced because the tyre damage
may cause air leakage from the tyre.
[ , I W K H W \ U H L V G D P D J H G E \ G U L Y L Q J
on a rough road, off road, pothole,
manhole, or kerb stone, it will not be
covered by the warranty.
Page 647 of 649
9-88
Maintenance
The emission control system of your
vehicle is covered by a written limited
warranty. Please see the warranty
information contained in the Service
Passport in your vehicle.
Your vehicle is equipped with an
emission control system to meet all
emission regulations.
There are three emission control systems
which are as follows.
(1) Crankcase emission control system
(2) Evaporative emission control system
(3) Exhaust emission control system
In order to ensure the proper function
of the emission control systems, it is
recommended that you have your car
inspected and maintained by a HYUNDAI
authorised repairer in accordance
with the maintenance schedule in this
manual.
NOTICE
For the Inspection and Maintenance
Test (with Electronic Stability Control
(ESC) system)
[ 7 R S U H Y H Q W W K H Y H K L F O H I U R P P L V I L U L Q J
during dynamometer testing, turn
the Electronic Stability Control
(ESC) system off by pressing the ESC
switch.
[ $ I W H U G \ Q D P R P H W H U W H V W L Q J L V
completed, turn the ESC system back
on by pressing the ESC switch again.
1. Crankcase emission control
system
The positive crankcase ventilation
system is employed to prevent air
pollution caused by blow-by gases
being emitted from the crankcase. This
system supplies fresh filtered air to the
crankcase through the air intake hose.
Inside the crankcase, the fresh air mixes
with blow-by gases, which then pass
through the PCV valve into the induction
system.
2. Evaporative emission control
system
The Evaporative Emission Control
System is designed to prevent fuel
vapours from escaping into the
atmosphere.
Canister
Fuel vapours generated inside the fuel
tank are absorbed and stored in the
onboard canister. When the engine is
running, the fuel vapours absorbed in
the canister are drawn into the surge
tank through the purge control solenoid
valve.
Purge Control Solenoid Valve
(PCSV)
The purge control solenoid valve
is controlled by the Engine Control
Module (ECM); when the engine coolant
temperature is low during idling, the
PCSV closes so that evaporated fuel
is not taken into the engine. After
the engine warms up during ordinary
driving, the PCSV opens to introduce
evaporated fuel to the engine.
( 0 , 6 6 , 2 1 & 2 1 7 5 2 / 6 < 6 7 ( 0