warning HYUNDAI IX20 2011 Owners Manual
[x] Cancel search | Manufacturer: HYUNDAI, Model Year: 2011, Model line: IX20, Model: HYUNDAI IX20 2011Pages: 420, PDF Size: 20.53 MB
Page 394 of 420

781
Maintenance
Underbody maintenance
Corrosive materials used for ice and
snow removal and dust control may col-
lect on the underbody. If these materials
are not removed, accelerated rusting can
occur on the underbody parts such as
the fuel lines, frame, floor pan and
exhaust system, even though they have
been treated with rust protection.
Thoroughly flush the vehicle underbody
and wheel openings with lukewarm or
cold water once a month, after off-road
driving and at the end of each winter. Payspecial attention to these areas because
it is difficult to see all the mud and dirt. It
will do more harm than good to wet down
the road grime without removing it. The
lower edges of the doors, rocker panels,
and frame members have drain holes
that should not clog with dirt; trapped
water in these areas can cause rusting.
Aluminum wheel maintenance
The aluminum wheels are coated with a
clear protective finish.
Do not use any abrasive cleaner, pol-ishing compound, solvent, or wire
brushes on aluminum wheels. They
may scratch or damage the finish.
Use only a mild soap or neutral deter- gent, and rinse thoroughly with water.
Also, be sure to clean the wheels after
driving on salted roads. This helps pre-
vent corrosion.
Avoid washing the wheels with high- speed car wash brushes.
Do not use any acid detergent. It may damage and corrode the aluminum
wheels coated with a clear protectivefinish.WARNING
After washing the vehicle, test the
brakes while driving slowly to see if
they have been affected by water. If
braking performance is impaired,
dry the brakes by applying them
lightly while maintaining a slow for-
ward speed.
JC ENG 7.QXP 9/7/2010 12:02 PM Page 81
procarmanuals.com
Page 399 of 420

Maintenance
86
7
Canister
Fuel vapors generated inside the fuel tank are absorbed and stored in the
onboard canister. When the engine is
running, the fuel vapors absorbed in the
canister are drawn into the surge tank
through the purge control solenoid valve.
Purge Control Solenoid Valve (PCSV)
The purge control solenoid valve is con-
trolled by the Engine Control Module
(ECM); when the engine coolant temper-
ature is low during idling, the PCSV clos-
es so that evaporated fuel is not taken
into the engine. After the engine warms
up during ordinary driving, the PCSV
opens to introduce evaporated fuel to the
engine. 3. Exhaust emission control
system
The Exhaust Emission Control System is
a highly effective system which controls
exhaust emissions while maintaining
good vehicle performance.
Vehicle modifications
This vehicle should not be modified.
Modification of your vehicle could affect
its performance, safety or durability and
may even violate governmental safety
and emissions regulations.
In addition, damage or performance
problems resulting from any modification
may not be covered under warranty.
Engine exhaust gas precautions (car- bon monoxide)
Carbon monoxide can be present with other exhaust fumes. Therefore, if you
smell exhaust fumes of any kind inside
your vehicle, have it inspected and
repaired immediately. If you ever sus-
pect exhaust fumes are coming into
your vehicle, drive it only with all the
windows fully open. Have your vehicle
checked and repaired immediately.
WARNING - Exhaust
Engine exhaust gases contain car-
bon monoxide (CO). Though color-
less and odorless, it is dangerousand could be lethal if inhaled.
Follow the instructions on this
page to avoid CO poisoning.
JC ENG 7.QXP 9/7/2010 12:03 PM Page 86
procarmanuals.com
Page 400 of 420

787
Maintenance
Do not operate the engine in confinedor closed areas (such as garages) any
more than what is necessary to move
the vehicle in or out of the area.
When the vehicle is stopped in an open area for more than a short time
with the engine running, adjust the
ventilation system (as needed) to draw
outside air into the vehicle.
Never sit in a parked or stopped vehi- cle for any extended time with the
engine running.
When the engine stalls or fails to start, excessive attempts to restart the
engine may cause damage to theemission control system.Operating precautions for catalytic
converters (if equipped)
Your vehicle is equipped with a catalytic
converter emission control device.
Therefore, the following precautions
must be observed:
Use only UNLEADED FUEL for gaso- line engine.
Do not operate the vehicle when there are signs of engine malfunction, such
as misfire or a noticeable loss of per-
formance. Do not misuse or abuse the engine.
Examples of misuse are coasting withthe ignition off and descending steep
grades in gear with the ignition off.
Do not operate the engine at high idle speed for extended periods (5 minutesor more).
Do not modify or tamper with any part of the engine or emission control sys-
tem. All inspections and adjustments
must be made by an authorized
HYUNDAI dealer.
Avoid driving with a extremely low fuel level. Running out of fuel could cause
the engine to misfire, damaging the
catalytic converter.
Failure to observe these precautionscould result in damage to the catalytic
converter and to your vehicle.
Additionally, such actions could void your
warranties.
WARNING - Fire
A hot exhaust system can ignite
flammable items under your vehi-
cle. Do not park, idle, or drive the
vehicle over or near flammable
objects, such as grass, vegetation,
paper, leaves, etc.
JC ENG 7.QXP 9/7/2010 12:03 PM Page 87
procarmanuals.com
Page 411 of 420

Index
2
I
Air bags ···········································································3-37
Air bag warning label................................................3-59
Air bag warning light ................................................3-40
Curtain air bag ..........................................................3-51
Driver's and passenger's front air bag ......................3-44
Passenger’s front air bag ON/OFF indicator ............3-41
Passenger’s front air bag ON/OFF switch ................3-47
Side impact air bag....................................................3-49
Air cleaner·······································································7-43
Alarm system ··································································4-11
Antenna ·········································································4-111
Anti-lock brake system (ABS) ·······································5-29
Appearance care······························································7-79 Exterior care ······························································7-79
Interior care ·······························································7-84
Armrest ····································································3-5, 3-13
Ashtray ··········································································4-104
Audio system ································································4-111 Antenna ···································································4-111
Aux, USB and iPod ·················································4-107
Audio remote control ·············································4-112
Automatic climate control system ··································4-90 Air conditioning ···············································4-86, 4-96
Automatic heating and air conditioning····················4-91
Manual heating and air conditioning ························4-92 Automatic transaxle ························································5-21
Shift lock system ·······················································5-24
Battery ·············································································7-47
Battery saver function ·····················································4-69
Before driving ···································································5-3
Bottle holders, see cup holders ·····································4-105
Brake/clutch fluid ···························································7-38
Brake system ···································································5-26 Anti-lock brake system (ABS) ··································5-29
Electronic stability program (ESP) ···························5-31
Hill-start assist control (HAC) ··································5-34
Parking brake ····························································5-27
Power brakes ·····························································5-26
Bulb replacement ····························································7-71 Front fog light bulb replacement ······························7-74
Headlight bulb replacement ······································7-72
High mounted stop light replacement ·······················7-77
Interior light bulb replacement··································7-78
License plate light bulb replacement ························7-77
Position light bulb replacement ································7-73
Rear combination light bulb replacement ·················7-75
Rear fog light bulb replacement································7-77Side repeater light bulb replacement·························7-74
Smart cornering light bulb replacement····················7-72
Turn signal light bulb replacement ···························7-73
A
B
JC ENG INDEX.QXP 9/7/2010 12:36 PM Page 2
procarmanuals.com
Page 414 of 420

I5
Index
Front seat adjustment ························································3-4
Fuel filler lid ··································································4-26
Fuel filter(for diesel) ······················································7-42
Fuel gauge ······································································4-43
Fuel requirements ····························································1-3Fuses ··············································································7-60
Fuse/relay panel description ····································7-64
Main fuse ··································································7-63
Memory fuse ·····························································7-62
Multi fuse ·································································7-60
Gauges·············································································4-41 Engine temperature gauge·········································4-42
Fuel gauge ································································4-43
Glassroof, see panorama sunroof····································4-29
Glove box ·····································································4-100
Glove box cooling·························································4-101 Hazard warning flasher ··········································4-68, 6-2
Hazardous driving conditions ········································5-45
Headlight bulb replacement ···········································7-72
Headlight escort function ···············································4-69
Headlight leveling device ··············································4-74
Headrest ··································································3-6, 3-12
Heating and air conditioning ·········································4-82High mounted stop light replacement ····························7-77
Highway driving ····························································5-49
Hill-start assist control (HAC)········································5-34Hood ···············································································4-24Horn ···············································································4-34
How to use this manual ···················································1-2
Immobilizer system ·························································4-3
Indicators and warnings ·················································4-47Indicator symbols on the instrument cluster ····················1-7
Instrument cluster ··························································4-40
Engine temperature gauge ········································4-42
Fuel gauge ································································4-43
Instrument panel illumination ··································4-41
LCD display ······························································4-58Odometer ··································································4-43Speedometer ·····························································4-41
G
H
I
JC ENG INDEX.QXP 9/7/2010 12:36 PM Page 5
procarmanuals.com
Page 415 of 420

Index
6
I
Tachometer ·······························································4-41
Tripmeter ···································································4-44
Trip computer ···························································4-44
Warning and indicators ············································4-47
Instrument panel illumination ········································4-41
Instrument panel overview ··············································2-4
Interior care ····································································7-84
Interior features ····························································4-103 Ashtray ···································································4-104
Cigarette lighter ······················································4-104
Clothes hanger·························································4-107
Cup holder ······························································4-105
Digital clock ···························································4-103
Aux, USB and iPod ················································4-107
Floor mat anchor(s) ················································4-108
Luggage net (holder) ··············································4-108
Luggage board·························································4-109
Outside temperature ················································4-103
Power outlet ···························································4-106
Shopping bag holder ··············································4-107Sunvisor ··································································4-105
Interior light ···································································4-79 Luggage room lamp ··················································4-18
Map lamp ··································································4-79
Room lamp ································································4-79
Vanity mirror lamp····················································4-79
Interior light bulb replacement ······································7-78
Interior overview ·····························································2-2 ISG (Idle Stop and Go) system ······································5-14
ISOFIX system ······························································3-33
Jack and tools ···································································6-9
Jump starting ····································································6-5
Key positions ···································································5-4 Keys ·················································································4-2 Label
Air bag warning label ··············································3-59
Tire sidewall labeling ···············································7-56
Tire specification and pressure label ·························8-8
Vehicle certification label ··········································8-7
Latch system, see ISOFIX system ·································3-33
License plate light bulb replacement ·····························7-77
Light bulbs ·····································································7-71 Front fog light bulb replacement ·····························7-74
Headlight bulb replacement ·····································7-72
High mounted stop light replacement ······················7-77
Interior light bulb replacement ································7-78
License plate light bulb replacement ·······················7-77
L
K
J
JC ENG INDEX.QXP 9/7/2010 12:36 PM Page 6
procarmanuals.com
Page 417 of 420

Index
8
I
Neck restraints, see headrest ··································3-6, 3-12 Odometer ·······································································4-43
Oil (Engine) ···································································7-34
Outside mirror defroster ················································4-80
Outside temperaure ·······················································4-103
Outside rearview mirror ·················································4-36Overheats ·········································································6-8
Owner maintenance ·························································7-5
Panorama sunroof ··························································4-29
Parking brake ·································································5-27
Parking brake inspect ·····················································7-41
Passenger's front air bag ················································3-44
Position light bulb replacement ·····································7-73
Power brakes ··································································5-27
Power outlet ·································································4-106
Power window lock switch ············································4-22
Pre-tensioner seat belt ····················································3-21
Push starting ·····································································6-7 Rear combination light bulb replacement ······················7-75
Rear fog light ··································································4-73
Rear fog light bulb replacement ·····································7-77
Rear seat adjustment ·························································3-9
Rear parking assist system ·············································4-63
Rear window defroster····················································4-80
Rearview camera ···························································4-67
Recommended cold tire inflation pressures ··················7-50
Recommended lubricants and capacities ·························8-4
Recommended SAE viscosity number ······················8-6
Remote keyless entry ·······················································4-5
Road warning ···································································6-2
Rocking the vehicle ·······················································5-46
Room lamp······································································4-79
Scheduled maintenance service ·······································7-7 Normal maintenance schedule ··························7-8, 7-19
Maintenance under severe usage conditions ··7-17, 7-28
Seat····················································································3-2 Armrest ·····························································3-5, 3-13
Folding the rear seat ·················································3-10
Front seat adjustment ··················································3-4
Headrest ····························································3-6, 3-12
Rear seat adjustment ···················································3-9
R
S
O
P
N
JC ENG INDEX.QXP 9/7/2010 12:36 PM Page 8
procarmanuals.com
Page 418 of 420

I9
Index
Seatback pocket ··························································3-9
Seat warmer ································································3-8
Seat belts ········································································3-14 Pre-tensioner seat belt ··············································3-21
Lap/shoulder belt ······················································3-16
3 point rear center belt ·············································3-19
Seat belt warning ···························································3-15
Seat warmer ·····································································3-8
Seatback pocket ·······························································3-9
Shift lock system ···························································5-24
Shopping bag holder ····················································4-107
Side impact air bag ························································3-49
Side repeater light bulb replacement ·····························7-74
Smart cornering light ······················································4-69
Smart key ·········································································4-8
Smooth cornering ···························································5-47
Snow tires ······································································5-50Spare tire Removing and storing the spare tire ························6-10Use of compact spare tire ·········································6-15
Special driving conditions ·············································5-45 Driving at night ························································5-47
Driving in flooded areas ··········································5-48
Driving in the rain ····················································5-48
Hazardous driving conditions ··································5-45
Highway driving ······················································5-49
Rocking the vehicle ··················································5-46
Smooth cornering ·····················································5-47 Speed limit control system ·············································5-41Speedometer ···································································4-41
Starting difficulties, see engine will not start ··················6-4
Starting the engine ··················································5-5, 5-11
Steering wheel ·······························································4-33
Electric power steering ············································4-33Horn ··········································································4-34
Tilt steering ······························································4-33
Storage compartment ···················································4-100 Center console storage ···········································4-100
Cool box ··································································4-101
Glove box ·······························································4-100
Luggage box ····························································4-102
Sunglass holder ······················································4-101
Sunroof, see panorama sunroof ·····································4-29Sunvisor ·······································································4-105 Tachometer ····································································4-41 Tailgate ··········································································4-17 Emergency tailgate safety release ····························4-18
Tether anchor system ·····················································3-32
Theft-alarm system ························································4-11
Tie-down hook ································································6-31
Tilt steering ····································································4-33
Tire chains·······································································5-51
TireMobilityKit ·······························································6-17
T
JC ENG INDEX.QXP 9/7/2010 12:36 PM Page 9
procarmanuals.com
Page 419 of 420

Index
10
I
Tire Pressure Monitoring System (TPMS) ·····················6-22
Tire specification and pressure label ·······························8-8
Tires and wheels ·····················································7-50, 8-3
Checking tire inflation pressure ·······························7-51
Recommended cold tire inflation pressures ·············7-50
Tire care ···································································7-50
Tire maintenance ······················································7-55
Tire replacement ······················································7-54
Tire rotation ······························································7-52
Tire sidewall labeling ···············································7-56
Tire traction ······························································7-55
Wheel alignment and tire balance ····························7-53
Wheel replacement ···················································7-55
Towing ···········································································6-27 Emergency towing ···················································6-29
Removable towing hook ··········································6-28
Trailer towing ·································································5-54Transaxle Automatic transaxle ·················································5-21
Manual transaxle ······················································5-18
Tripmeter ·······································································4-44
Trip computer ································································4-44
Turn signals and lane change signals ·····························4-72
Turn signal light bulb replacement ································7-73 Vanity mirror lamp ·························································4-79
Vehicle break-in process ·················································1-6
Vehicle certification label ················································8-7
Vehicle identification number (VIN) ······························8-7
Vehicle weight ························································5-62, 8-3
Base curb weight ······················································5-62
Cargo weight ····························································5-62
GAW (Gross axle weight) ·······································5-62
GAWR (Gross axle weight rating) ··························5-62
GVW (Gross vehicle weight) ··································5-62
GVWR (Gross vehicle weight rating) ·····················5-62
Washer fluid ···································································7-41
Waste tray, see ashtray ················································4-104
Warnings and indicators ················································4-47
Wheel alignment and tire balance ·································7-53
Wheel replacement ························································7-55Windows ········································································4-19 Auto down window ··················································4-21
Auto up/down window ·············································4-21
Power window lock switch ······································4-22
Windshield defrosting and defogging ···························4-98
Winshield deicer ·····························································4-80V
W
JC ENG INDEX.QXP 9/7/2010 12:36 PM Page 10
procarmanuals.com