transmission HYUNDAI VELOSTER 2019 Repair Manual

7-19
7
Maintenance
Air Cleaner Filter
A genuine HYUNDAI air cleaner filter
is recommended when the filter is
replaced.
Spark Plugs
Make sure to install new spark plugs
of the correct heat range.
Cooling System
Check cooling system components,
such as radiator, coolant reservoir,
hoses and connections for leakage
and damage. Replace any damaged
parts.
Engine Coolant
The coolant should be changed at
the intervals specified in the mainte-
nance schedule.
Automatic Transmission Fluid
(if equipped)
Automatic transmission fluid should
not be checked under normal usage
conditions. But in severe conditions,
the fluid should be changed at an
authorized HYUNDAI dealer in
accordance to the scheduled mainte-
nance at the beginning of this chap-
ter.
Automatic transmission fluid
color is red when new.
As the vehicle is driven, the auto-
matic transmission fluid will begin
to look darker. This is a normal
condition and you should not
judge the need to replace the fluid
based upon the changed color.
Dual Clutch Transmission
Fluid (if equipped)
Inspect the dual clutch transmission
fluid according to the maintenance
schedule.
Manual Transmission Fluid
(if equipped)
Inspect the manual transmission
fluid according to the maintenance
schedule.
NOTICE
The use of a non-specified fluid
could result in transmission
malfunction and failure. Use
only the specified automatic
transmission fluid (refer to
"Recommended Lubricants and
Capacities" in chapter 8).
CAUTION

7-46
Maintenance
Temperature - A, B & C
The temperature grades are A (the
highest), B and C representing the
tire’s resistance to the generation of
heat and its ability to dissipate heat
when tested under controlled condi-
tions on a specified indoor laboratory
test wheel.
Sustained high temperature can
cause the material of the tire to
degenerate and reduce tire life, and
excessive temperature can lead to
sudden tire failure. Grade C
responds to a level of performance
which all passenger car tires must
meet under the Federal Motor
Vehicle Safety Standard No. 109.
Grades B and A represent higher
levels of performance on the labora-
tory test wheel than the minimum
required by law.
Tire Terminology and
Definitions
Air Pressure
The amount of air inside the tire
pressing outward on the tire. Air
pressure is expressed in pounds per
square inch (psi) or kilopascal (kPa).
Accessory Weight
This means the combined weight of
optional accessories. Some exam-
ples of optional accessories are
automatic transmission, power
seats, and air conditioning.
Aspect Ratio
The relationship of a tire's height to
its width.
Belt
A rubber coated layer of cords that is
located between the plies and the
tread. Cords may be made from steel
or other reinforcing materials.
The temperature grade for this
tire is established for a tire that
is properly inflated and not
overloaded. Excessive speed,
under-inflation, over-inflation,
or excessive loading, either
separately or in combination,
can cause heat build-up and
possible sudden tire failure.
This may cause loss of vehicle
control resulting in an accident.
WARNING

7-65
7
Maintenance
Fuse NameFuse RatingProtected Component
ABS310AABS Control Module, ESC Module, Multipurpose Check Connector
TCU215ATransmission Range Switch(A/T), TCM (With DCT)
SENSOR310AE/R Junction Block (F/PUMP Relay)
ECU415AECM/PCM
HORN15AHorn Relay
Engine compartment fuse panel
[G4FJ] : 1.6 T-GDI
[G4NH] : 2.0 MPI

8-6
Specifications, Consumer information and Reporting safety defects
V
VO
O L
LU
U M
M E
E
A
A N
N D
D
W
W E
EI
IG
G H
H T
T
A
A I
IR
R
C
C O
O N
ND
DI
IT
T I
IO
O N
NI
IN
N G
G
S
S Y
Y S
ST
T E
EM
M
Contact an authorized HYUNDAI dealer for more details.
Item
Gasoline Engine
1.6 T-GDI2.0 MPI
M/TDCTM/TA/T
Gross vehicle weight
lbs. (kg)3,814 (1,730)3,858 (1,750)3,748 (1,700)3,748 (1,700)
Luggage volume (SAE)cu. ft. (l)Behind 1st row : 44.5 (1,261)Behind 2nd row : 19.9 (565)
ItemsWeight of VolumeClassification
Refrigerant oz. (g) 15.87 (450) ± 0.88 (25) R-1234yf
Compressor lubricantoz. (cc) 4.23 (120) ± 0.35 (10)PA G
M/T : Manual transmission
A/T : Automatic transmission
DCT : Dual clutch transmission

8-7
88
Specifications, Consumer information and Reporting safety defects
To help achieve proper engine and powertrain performance and durability, use only lubricants of the proper quality.
The correct lubricants also help promote engine efficiency that results in improved fuel economy.
R RE
EC
CO
O M
M M
ME
EN
N D
DE
ED
D
L
L U
U B
BR
RI
IC
C A
A N
N T
TS
S
A
A N
N D
D
C
C A
A P
PA
A C
CI
IT
T I
IE
E S
S
LubricantVolume Classification
Engine oil *
1*2(drain and refill)
RecommendsGamma 1.6 T-GDI4.76 US qt. (4.5 l)
ACEA A5/B5 *4
Nu 2.0 MPI4.23 US qt. (4.0 l)API SM *3& ILSAC GF-4 (or above)
ACEA A5/B5 *4
Manual transmission fluid
Gamma 1.6 T-GDI1.8~1.9 US qt. (1.7 ~ 1.8 l) HK SYN MTF 70W (SK)
SPIRAX S6 GHME 70W MTF (H.K.SHELL)
GS MTF HD 70W (GS CALTEX)
(API GL-4, SAE 70W TGO-9)
Nu 2.0 MPI
Automatic transmission fluidNu 2.0 MPI7.08 US qt. (6.7
l)
MICHANG ATF SP-IV,
SK ATF SP-IV,
NOCA ATF SP-IV,
HYUNDAI genuine ATF SP-IV or other
brands meeting the above specification
approved by HYUNDAI Motor Co.
Dual clutch transmission fluidGamma 1.6 T-GDI2.01~2.11 US qt.
(1.9~2.0 l)
HK SYN DCTF 70W (SK)
SPIRAX S6 GHME 70W DCTF
(H.K.SHELL)
GS DCTF HD 70W (GS CALTEX)
(API GL-4, SAE 70W)

I-2
Air bag warning labels ....................................................2-63
Air bags ........................................................................\
...2-41Driver's air bag ...........................................................2-43
Passenger's front air bag.............................................2-43
Side air bags ...............................................................2-44
Curtain air bags ..........................................................2-45
How does the air bags system operate? .....................2-46
SRS components and functions..................................2-47
SRS warning light ......................................................2-47
What to expect after an air bag inflates .....................2-51
Occupant Classification System (OCS) .....................2-52
Air bag collision sensors ............................................2-58
Why didn't my air bag go off in a collision ...............2-57
Air bag inflation conditions .......................................2-59
Air bag non-inflation conditions ................................2-60
SRS Care ....................................................................2-62\
Additional safety precautions .....................................2-63
Air bag warning labels ...............................................2-63
Air cleaner filter replacement .........................................7-29
Air conditioning system specification ..............................8-6
Antenna ........................................................................\
.....4-2
Anti-lock Brake System (ABS) ......................................5-43
Appearance care..............................................................7-78 Exterior care ...............................................................7-78
Interior care ................................................................7-83 Audio/Video/Navigation system .......................................4-4
Auto defogging system .................................................3-115
Auto light position ..........................................................3-80
Auto LOCK - Enable on shift.........................................3-17
Auto LOCK - Enable on speed.......................................3-17
Auto UNLOCK - Enable on shift ...................................3-17
Auto UNLOCK -Air bag deployment ............................3-17
Automatic climate control system ................................3-104
Automatic heating and air conditioning ...................3-104
Manual heating and air conditioning .......................3-106
Mode selection .........................................................3-106
Instrument panel vents .............................................3-107
Temperature control .................................................3-108
Air intake control .....................................................3-108
Fan speed control .....................................................3-109
Air conditioning .......................................................3-109
OFF mode.................................................................3-109
System maintenance .................................................3-111
Air conditioning refrigerant label.............................3-112
Automatic transmission ..................................................5-22 Transmission ranges ...................................................5-23
Paddle shifter ..............................................................5-25
Shift lock system ........................................................5-25
Good driving practices ...............................................5-27
Automatic ventilation....................................................3-118
AUX, USB and iPod
®port ...............................................4-2
Index
A

I-4
ChainsTire chains ................................................................5-123
Check tire inflation pressure ...........................................7-39
Child restraint system (CRS) ..........................................2-30 Selecting a child restraint system (CRS) ...................2-31
Rearward-facing child restraint system......................2-32
Forward-facing child restraint system........................2-33
Booster seats...............................................................2-33
Installing a child restraint system (CRS) ...................2-33
Lower anchors and tether for Children (LATCH System) ....................................................2-34
Lower anchors ............................................................2-34
Tether anchors ............................................................3-37
Lap/shoulder belt ........................................................3-38
Child-protector rear door lock ........................................3-17
Climate control air filter replacement.............................7-30
Clock ........................................................................\
.....3-126
Clothes hanger ..............................................................3-127
Clutch fluid .....................................................................7-2\
7
Compact spare tire replacement .....................................7-42
Crankcase emission control system ................................7-86
Cruise control..................................................................5-99
Cup holder.....................................................................3-1\
21
Curtain air bags ...............................................................2-45 Daytime running light (DRL) .........................................3-87
Defroster
Rear window defroster .............................................3-117
Dimensions .......................................................................8\
-2
Door locks .......................................................................3\
-13 Central door lock/unlock switch ................................3-15
Child-protector rear door lock....................................3-17
Auto door lock/unlock features ..................................3-17
Drive mode integrated control system ............................5-51 DRIVE MODE ...........................................................5-51
SPORT MODE ...........................................................5-53
Driver Attention Warning (DAW) system ......................5-95
Driver's air bag................................................................2-43
Driving at night .............................................................5-121
Driving in flooded areas ...............................................5-122
Driving in the rain.........................................................5-121
Dual clutch transmission.................................................5-29 Dual clutch transmission operation ............................5-29
Transmission temperature gauge ................................5-31
DCT warning messages..............................................5-32
Transmission ranges ...................................................5-34
Paddle shifter ..............................................................5-36
Shift lock system ........................................................5-37
Good driving practices ...............................................5-38
Index
D

I-7
Instrument cluster ...........................................................3-39Instrument panel illumination ....................................3-40
Gauges and meters .....................................................3-41
Transmission shift indicator .......................................3-44
Warning and indicator lights ......................................3-45
LCD display messages ...............................................3-66
LCD display control ...................................................3-73
Shift indicator pop-up ................................................3-45
LCD display modes ....................................................3-63
User settings mode .....................................................3-66
Assist mode ................................................................3-65
Trip computer mode ...................................................3-64
Instrument panel fuse replacement .................................7-53
Instrument panel overview ...............................................1-5
Interior care .....................................................................7-8\
3
Interior features Cup holder ................................................................3-121
Sunvisor ....................................................................3-12\
2
Power outlet..............................................................3-122
USB charger .............................................................3-123
Wireless cellular phone charging system .................3-124
Clock ........................................................................\
3-126
Clothes hanger ..........................................................3-127
Floor mat anchor(s) ..................................................3-127
Cargo area cover.......................................................3-128 Interior lights Front lamps ..............................................3-87
Rear lamps ..................................................................3-88
Luggage compartment lamp .......................................3-89
Vanity mirror lamp .....................................................3-89
Interior overview...............................................................1-4
Jump starting .....................................................................6-4\
Key ignition switch ...........................................................5-6
Label Vehicle certification label ...........................................8-10
Tire specification and pressure label ..........................8-11
Refrigerant label .........................................................8-11
Lane change signals ........................................................3-85
Lane Keeping Assist (LKA) system ...............................5-87
I
Index
J
K
L

I-9
Main fuse ........................................................................\
7-55
MaintenanceMaintenance services ...................................................7-4
Owner maintenance ......................................................7-5
Scheduled maintenance services ..................................7-7
Normal maintenance schedule ...........................7-8, 7-13
Maintenance under severe usage conditions.....7-11, 7-16
Explanation of scheduled maintenance items ............7-18
Tire maintenance ........................................................7-42
Maintenance services ........................................................7-4
Manual climate control system .......................................3-96 Mode selection ...........................................................3-97
Instrument panel vents ...............................................3-99
Temperature control ...................................................3-99
Air intake control .......................................................3-99
Fan speed control .....................................................3-100
Air conditioning .......................................................3-100
System maintenance .................................................3-102
Air conditioning refrigerant label.............................3-103
Manual transmission .......................................................5-18 Manual transmission operation ..................................5-18
Good driving practices ...............................................5-20
Master warning mode .....................................................3-65 Mirrors ........................................................................\
....3-21
Inside rearview mirror ................................................3-21
Blue Link®center .......................................................3-22
Side view mirrors .......................................................3-22
Adjusting the side view mirrors .................................3-23
Folding/Unfolding the side view mirror ....................3-24
Multi fuse ........................................................................\
7-55
Multimedia system............................................................4-2 AUX, USB and iPod
®port ..........................................4-2
Antenna ........................................................................\
4-2
Steering wheel audio controls ......................................4-3
Audio/Video/Navigation system ..................................4-4
Bluetooth
®Wireless Technology hands-free................4-4
Occupant Classification System (OCS)..........................2-52
Odometer........................................................................\
.3-43
Oil (Engine) ....................................................................7-21\
Outside temperature gauge .............................................3-43
Owner maintenance ..........................................................7-5
I
Index
M
O

I-12
Tachometer ......................................................................3-\
41
Theft-alarm system .........................................................3-18
Tilt steering/Telescope steering ......................................3-20
Tire chains .....................................................................5-1\
23
Tire Mobility Kit (TMK) ................................................6-20
Tire pressure monitoring system (TPMS) ........................6-8
Tire rotation ....................................................................7-39\
Tire specification and pressure label ..............................8-11
Tires and wheels .............................................................7-37Tire care ..............................................................7-37, 8-4
Recommended cold tire inflation pressures ...............7-38
Check tire inflation pressure ......................................7-39
Tire rotation ................................................................7-39
Wheel alignment and tire balance ..............................7-40
Tire replacement .........................................................7-41
Compact spare tire replacement .................................7-41
Wheel replacement .....................................................7-42
Tire maintenance ........................................................7-42
Tire traction ................................................................7-42
Tire sidewall labeling .................................................7-42
Tire terminology and definitions ................................7-46
All Season Tires .........................................................7-49
Summer Tires .............................................................7-49
Snow Tires ..................................................................7-50
Radial-Ply Tires ..........................................................7-50
Low Aspect Ratio Tires ..............................................7-50 Towing ........................................................................\
....6-27
Trailer towing................................................................5-132
Trip computer..................................................................3-73
Average fuel economy................................................3-73
Instant fuel economy ..................................................3-73
Accumulated Info display ..........................................3-73
Driving Info display ...................................................3-75
Digital speedometer....................................................3-76
Smart shift ..................................................................3-76
Transmission temperature ..........................................3-76
Turn signals.....................................................................3-8\
5
USB charger ..................................................................3-123
User settings mode..........................................................3-66
Vanity mirror lamp..........................................................3-89
Vehicle break-in process ...................................................F-9
Vehicle certification label ...............................................8-10
Vehicle identification number (VIN) ..............................8-10
Vehicle load limit ..........................................................5-127 Tire loading information label..................................5-128
Vehicle modification .........................................................F-9
Vehicle Stability Management (VSM)............................5-47
Vehicle weight and luggage volume .................................8-6
Index
T
U
V