warning HYUNDAI VELOSTER 2020 Owners Manual

7-81
7
Maintenance
Bright-metal maintenance
To remove road tar and insects,
use a tar remover, not a scraper or
other sharp object.
To protect the surfaces of bright-
metal parts from corrosion, apply a
coating of wax or chrome preser-
vative and rub to a high luster.
During winter weather or in coastal
areas, cover the bright metal parts
with a heavier coating of wax or
preservative. If necessary, coat the
parts with non-corrosive petroleum
jelly or other protective compound.
Underbody maintenance
Corrosive materials used for ice and
snow removal and dust control may
collect on the underbody. If these
materials are not removed, acceler-
ated rusting can occur on underbody
parts such as the fuel lines, frame,
floor pan and exhaust system, even
though they have been treated with
rust protection.Thoroughly flush the vehicle under-
body and wheel openings with luke-
warm or cold water once a month,
after off-road driving and at the end
of each winter. Pay special attention
to these areas because it is difficult
to see all the mud and dirt. It will do
more harm than good to wet down
the road grime without removing it.
The lower edges of doors, rocker
panels, and frame members have
drain holes that should not be
allowed to clog with dirt; trapped
water in these areas can cause rust-
ing.
Aluminum wheel maintenance
The aluminum wheels are coated
with a clear protective finish.
Do not use abrasive cleaner, pol-
ishing compound, solvent, or
wire brushes on aluminum
wheels.
Clean the wheel when it has
cooled.
Use only a mild soap or neutral
detergent, and rinse thoroughly
with water. Also, clean the
wheels after driving on salted
roads.
Do not wash the wheels with
high-speed car wash brushes.
Do not use any cleaners con-
taining acid or alkaline deter-
gents.
NOTICE
After washing the vehicle, test
the brakes while driving slowly
to see if they have been affected
by water. If braking performance
is impaired, dry the brakes by
applying them lightly while
maintaining a slow forward
speed.
WARNING

7-87
7
Maintenance
Canister
Fuel vapors generated inside the fuel
tank are absorbed and stored in the
onboard canister. When the engine is
running, the fuel vapors absorbed in
the canister are drawn into the surge
tank through the purge control sole-
noid valve.
Purge Control Solenoid Valve
(PCSV)
The purge control solenoid valve is
controlled by the Engine Control
Module (ECM); when the engine
coolant temperature is low during
idling, the PCSV closes so that evap-
orated fuel is not taken into the
engine. After the engine warms-up
during ordinary driving, the PCSV
opens to introduce evaporated fuel to
the engine.
3. Exhaust Emission Control
System
The Exhaust Emission Control
System is a highly effective system
which controls exhaust emissions
while maintaining good vehicle per-
formance.
When the engine starts or fails to
start, excessive attempts to restart
the engine may cause damage to the
emission system.
Engine exhaust (carbon monox-
ide) precautions
Carbon monoxide can be present
with other exhaust fumes. If you
smell exhaust fumes of any kind in
your vehicle, drive with all the win-
dows fully open. Have your vehicle
checked and repaired immediately.
Engine exhaust gases contain
carbon monoxide (CO). Though
colorless and odorless, it is
dangerous and could be lethal if
inhaled. Follow the instructions
on this page to avoid CO poi-
soning.
WARNING

7-88
Maintenance
Do not operate the engine in con-
fined or closed areas (such as
garages) any more than what is
necessary to move the vehicle in or
out of the area.
When the vehicle is stopped in an
open area for more than a short
time with the engine running,
adjust the ventilation system (as
needed) to draw outside air into the
vehicle.
Never sit in a parked or stopped
vehicle for any extended time with
the engine running.
When the engine stalls or fails to
start, excessive attempts to restart
the engine may cause damage to
the emission control system.
Operating precautions for cat-
alytic converters (if equipped)Your vehicle is equipped with a cat-
alytic converter emission control
device.
To prevent damage to the catalytic
converter and to your vehicle, take
the following precautions:
Use only UNLEADED FUEL for
gasoline engines.
Do not operate the vehicle when
there are signs of engine malfunc-
tion, such as misfire or a noticeable
loss of performance.
Do not misuse or abuse the
engine. Examples of misuse are
coasting with the engine off and
descending steep grades in gear
with the engine off.
Do not operate the engine at high
idle speed for extended periods (5
minutes or more). The exhaust system and cat-
alytic converter are very hot
during and immediately after
the engine has been running. To
avoid SERIOUS INJURY or
DEATH:
Do not park, idle, or drive the
vehicle over or near flamma-
ble objects, such as grass,
vegetation, paper, leaves, etc.
A hot exhaust system can
ignite flammable items under
your vehicle.
Keep away from the exhaust
system and catalytic convert-
er or you may get burned.
Also, Do not remove the heat
sink around the exhaust sys-
tem, do not seal the bottom of
the vehicle, and do not coat
the vehicle for corrosion con-
trol. It may present a fire risk
under certain conditions.
WARNING

I-2
Accessing Your Vehicle ....................................................3-3
Immobilizer System ...................................................3-12
Remote Key ..................................................................3-3
Smart Key.....................................................................3-7
Air bag - advanced supplemental restraint system .........2-41
Additional Safety Precautions ....................................2-63
Air Bag Warning Labels.............................................2-63
Curtain air bags ..........................................................2-45
Driver's front air bag ..................................................2-43
How Does the Air Bag System Operate? ...................2-46
Occupant Classification System (OCS) .....................2-52
Passenger's front air bag.............................................2-43
Side air bags ...............................................................2-44
SRS Care ....................................................................2-62
What to Expect After an Air Bag Inflates ..................2-51
Where Are the Air Bags? ...........................................2-43
Why Didn't My Air Bag Go Off in a Collision?........2-57
Air Cleaner......................................................................7-29
Filter Replacement .....................................................7-29
Air Conditioning System ..................................................8-6
Antenna .............................................................................4-2
Anti-lock Brake System (ABS) ......................................5-43
Appearance care..............................................................7-78
Exterior Care ..............................................................7-78
Interior Care ...............................................................7-83Audio (Display Audio)/Video/Navigation System
(AVN) ............................................................................4-4
Auto Defogging System (Additional Feature with
Automatic Temperature Control System) ..................3-120
Automatic Climate Control System..............................3-109
Automatic Temperature Control Mode ....................3-110
Manual Temperature Control Mode .........................3-111
System Maintenance.................................................3-116
System Operation .....................................................3-114
Automatic Transmission .................................................5-22
Automatic Transmission Operation............................5-22
Good Driving Practices ..............................................5-27
Automatic Ventilation ...................................................3-123
AUX, USB and iPod
®Port ...............................................4-2
Basic Troubleshooting Guide .........................................6-18
Battery .............................................................................7-34
Battery Recharging .....................................................7-35
For Best Battery Service ............................................7-35
Reset Features ............................................................7-36
Before driving ...................................................................5-4
Before Entering the Vehicle .........................................5-4
Before Starting .............................................................5-4
Index
A
B

I-3
Blind-Spot Collision Warning (BCW) System ...............5-56
BCW (Blind-Spot Collision Warning) .......................5-57
Blind Spot Collision Warning - Sensor Location ......5-61
Limitations of the System ..........................................5-62
RCCW (Rear Cross-Traffic Collision Warning) ........5-59
Bluetooth
®Wireless Technology Hands-Free ..................4-4
Brake/Clutch Fluid..........................................................7-27
Checking the brake/clutch Fluid Level ......................7-27
Braking System ...............................................................5-40
Anti-lock Brake System (ABS)..................................5-43
Disc Brakes Wear Indicator........................................5-41
Electronic Stability Control (ESC).............................5-45
Good Braking Practices..............................................5-49
Hill-Start Assist Control (HAC) .................................5-48
Parking Brake .............................................................5-41
Power Brakes..............................................................5-40
Vehicle Stability Management (VSM) .......................5-47
Bulb Wattage .....................................................................8-3Cargo Area Cover .........................................................3-133
Center Console Storage ................................................3-124
Child restraint system (CRS) ..........................................2-30
Children Always in the Rear ......................................2-30
Installing a Child Restraint System (CRS) ................2-33
Selecting a Child Restraint System (CRS).................2-31
Climate Control Additional Features ............................3-123
Automatic Ventilation...............................................3-123
Sunroof Inside Air Recirculation .............................3-123
Climate Control Air Filter...............................................7-30
Filter Inspection..........................................................7-30
Clock .............................................................................3-131
Clothes Hanger .............................................................3-132
Cruise Control ...............................................................5-100
Cruise Control operation ..........................................5-100
Cup Holder....................................................................3-126
I
Index
C

I-4
Daytime Running Light ..................................................7-68
Dimensions .......................................................................8-2
Disc Brakes Wear Indicator ............................................5-41
Door Locks .....................................................................3-15
Automatic Door Lock and Unlock Features ..............3-19
Child-Protector Rear Door Locks ..............................3-19
Operating Door Locks from Inside the Vehicle .........3-16
Operating Door Locks from Outside the Vehicle ......3-15
Drive Mode Integrated Control System .........................5-51
DRIVE MODE (with Automatic Transmission/
Dual Clutch Transmission) .....................................5-51
SPORT MODE (with Manual Transmission) ............5-55
Driver Assist System.......................................................3-96
Parking Distance Warning (Reverse) system .............3-97
Parking Distance Warning (Reverse) system
Precautions ............................................................3-100
Rear view monitor ......................................................3-96
Driver Attention Warning (DAW) System......................5-96
Resetting the System ..................................................5-97
System Malfunction ...................................................5-98
System Setting and Activation ...................................5-96
System Standby ..........................................................5-98
Dual Clutch Transmission...............................................5-29
Dual Clutch Transmission Operation .........................5-29
Good Driving Practices ..............................................5-38
LCD display for transmission temperature and
warning message .....................................................5-31Electric Power Steering (EPS) ........................................3-21
Electronic Stability Control (ESC) .................................5-45
Emission Control System ...............................................7-86
Crankcase Emission Control System .........................7-86
Evaporative Emission Control System Including
Onboard Refueling Vapor Recovery (ORVR) ........7-86
Exhaust Emission Control System .............................7-87
Engine ...............................................................................8-2
Engine Compartment.................................................1-6, 7-3
Engine Coolant ...............................................................7-23
Changing Engine Coolant ..........................................7-26
Checking the Engine Coolant Level ..........................7-23
Engine Number ...............................................................8-11
Engine Oil .......................................................................7-21
Checking the Engine Oil and Filter ...........................7-22
Checking the Engine Oil Level ..................................7-21
Engine Start/Stop Button ..................................................5-9
Explanation of Scheduled Maintenance Items ...............7-18
Exterior Care ...................................................................7-78
Exterior Features .............................................................3-35
Fuel Filler Door ..........................................................3-38
Hood ...........................................................................3-35
Tailgate .......................................................................3-36
Index
DE

I-5
Exterior Lights ................................................................3-81
AUTO light position...................................................3-81
Battery saver function ................................................3-87
Daytime running light (DRL) ....................................3-88
Headlamp delay function ...........................................3-87
Headlamp position......................................................3-82
High Beam Assist (HBA) ...........................................3-83
High beam operation ..................................................3-82
Lane change signals ...................................................3-86
Parking lamp position ................................................3-82
Turn signals ................................................................3-86
Exterior Overview.............................................................1-2
Floor Mat Anchor(s) .....................................................3-132
Forward Collision-Avoidance Assist (FCA) System
(Camera) ......................................................................5-64
FCA Sensor ................................................................5-68
FCA Warning Message and System Control..............5-66
Limitations of the System ..........................................5-71
System Malfunction ...................................................5-69
System Setting and Activation ...................................5-64
Forward Collision-Avoidance Assist (FCA) System
(Fusion Sensor) ............................................................5-76
FCA Sensor ................................................................5-80
FCA Warning Message and System Control..............5-78
Limitations of the System ..........................................5-83
System Malfunction ...................................................5-81
System Setting and Activation ...................................5-76Front Seats ........................................................................2-5
Driver seat folding lever...............................................2-8
Forward and rearward adjustment................................2-6
Lumbar support ............................................................2-7
Seat cushion height ......................................................2-7
Seatback angle ..............................................................2-6
Fuel Filler Door ..............................................................3-38
Fuses ...............................................................................7-52
Engine Compartment Panel Fuse Replacement .........7-54
Fuse/Relay Panel Description ....................................7-56
Instrument Panel Fuse Replacement ..........................7-53
Gauges and Meters .........................................................3-43
Glove Box .....................................................................3-124
Hazard Warning Flasher ...................................................6-2
Head Restraints ...............................................................2-10
Front seat head restraints ............................................2-11
Rear seat head restraints .............................................2-13
Head Up Display (HUD) ................................................3-78
Headlamp ........................................................................7-68
Heated Steering Wheel ...................................................3-23
High Mounted Stop Lamp Replacement ........................7-76
Hill-Start Assist Control (HAC) .....................................5-48
Hood................................................................................3-35
Horn ................................................................................3-22
I
Index
F
G
H

I-6
If the Engine Overheats ....................................................6-6
If the Engine will not Start ...............................................6-3
If the Engine Doesn't Turn Over or
Turns Over Slowly ....................................................6-3
If the Engine Turns Over Normally but
Doesn't Start ..............................................................6-3
If you Have a Flat Tire (With Compact Spare Tire).........6-8
Changing Tires .............................................................6-9
Jack and Tools ..............................................................6-8
Ignition switch ..................................................................5-6
Engine Start/Stop Button ..............................................5-9
Key Ignition Switch .....................................................5-6
Immobilizer System ........................................................3-12
Important safety precautions.............................................2-2
Air Bag Hazards ...........................................................2-2
Always Wear Your Seat Belt ........................................2-2
Control Your Speed ......................................................2-2
Driver Distraction.........................................................2-2
Keep Your Vehicle in Safe Condition ..........................2-2
Restrain All Children....................................................2-2
In Case of an Emergency While Driving .........................6-2
If the Engine Stalls at a Crossroad or Crossing ...........6-2
If the Engine Stalls While Driving...............................6-2
If you Have a Flat Tire While Driving.........................6-3
Inside Rearview Mirror...................................................3-23Instrument Cluster...........................................................3-41
Gauges and Meters .....................................................3-43
Instrument Cluster Control .........................................3-42
LCD Display Messages ..............................................3-58
Transmission shift indicator .......................................3-46
Warning and Indicator Lights.....................................3-47
Instrument Cluster Control .............................................3-42
Instrument Panel Overview ..............................................1-5
Interior Care ....................................................................7-83
Interior Features ............................................................3-126
Cargo Area Cover .....................................................3-134
Clock ........................................................................3-131
Clothes Hanger .........................................................3-132
Cup Holder ...............................................................3-126
Floor Mat Anchor(s) .................................................3-132
Luggage net (Hook) .................................................3-133
Power Outlet.............................................................3-127
Sunvisor ....................................................................3-127
USB charger .............................................................3-128
Wireless Cellular Phone Charging System ..............3-129
Interior Light Bulb Replacement ....................................7-77
Interior Lights .................................................................3-88
Front Door Lamp........................................................3-89
Front Map Lamp ........................................................3-89
Front room lamp .........................................................3-89
Interior lamp AUTO cut .............................................3-88
Luggage compartment lamp .......................................3-90
Rear Room Lamp .......................................................3-89
Vanity mirror lamp .....................................................3-90
Interior Overview..............................................................1-4
Index
I

I-7
Jump Starting ....................................................................6-4
Key Ignition Switch ..........................................................5-6
Lane Keeping Assist (LKA) System ..............................5-88
Limitations of the System ..........................................5-94
LKA system Function Change ...................................5-95
LKA System Operation ..............................................5-89
Warning Light and Message.......................................5-93
LCD Display ...................................................................3-63
LCD Display Control .................................................3-63
LCD Display Modes ..................................................3-64
LCD Display Control......................................................3-63
LCD Display Messages ..................................................3-58
LCD Display Modes .......................................................3-64
License Plate Light Bulb Replacement ..........................7-76Light Bulbs .....................................................................7-67
Headlamp, Position lamp, Daytime Running Light,
Turn signal lamp and Side marker ..........................7-68
High Mounted Stop Lamp Replacement....................7-76
Interior Light Bulb Replacement ...............................7-77
License Plate Light Bulb Replacement ......................7-76
Rear Combination Light Bulb Replacement ..............7-73
Side Repeater Lamp Replacement .............................7-72
Lighting ...........................................................................3-81
Exterior Lights............................................................3-81
Interior Lights.............................................................3-88
Welcome System ........................................................3-90
Maintenance Services .......................................................7-4
Owner Maintenance Precautions..................................7-4
Owner's Responsibility.................................................7-4
Manual Climate Control System ..................................3-101
Heating and Air Conditioning ..................................3-102
System Maintenance ................................................3-107
System Operation .....................................................3-105
Manual Transmission ......................................................5-18
Good Driving Practices ..............................................5-20
Manual Transmission Operation ................................5-18
Mirrors ............................................................................3-23
Inside Rearview Mirror ..............................................3-23
Side View Mirrors ......................................................3-25
I
Index
J
K
L
M

I-8
Multimedia System ...........................................................4-2
Antenna ........................................................................4-2
Audio (Display Audio)/Video/Navigation System
(AVN) ........................................................................4-4
AUX, USB and iPod
®Port ..........................................4-2
Bluetooth®Wireless Technology Hands-Free ..............4-4
Steering Wheel Audio Controls....................................4-3
Owner Maintenance ..........................................................7-5
Owner Maintenance Schedule......................................7-6
Parking Brake ........................................................5-41, 7-28
Checking the Parking Brake ......................................7-28
Parking Distance Warning (Reverse) system .................3-97
Position lamp ..................................................................7-68
Power Brakes ..................................................................5-40
Power Outlet .................................................................3-127
Power Windows ..............................................................3-28Rear Combination Light Bulb Replacement ..................7-73
Rear Seats .........................................................................2-8
Folding the rear seat .....................................................2-8
Rear view monitor ..........................................................3-96
Rear Window Defroster ................................................3-122
Rear Window Wiper and Washer....................................3-95
Recommended Lubricants and Capacities ........................8-7
Recommended SAE viscosity number .........................8-9
Remote Key ......................................................................3-3
Scheduled Maintenance Services .....................................7-7
Maintenance Under Severe Usage Conditions
(Gamma 1.6 Turbo-GDI) ........................................7-16
Maintenance Under Severe Usage Conditions
(Nu 2.0 MPI) ...........................................................7-11
Normal Maintenance Schedule
(Gamma 1.6 Turbo-GDI) ........................................7-13
Normal Maintenance Schedule (Nu 2.0 MPI) .............7-8
Seat belts .........................................................................2-17
Additional Seat Belt Safety Precautions ....................2-26
Care of Seat Belts .......................................................2-29
Seat Belt Restraint System .........................................2-20
Seat Belt Safety Precautions ......................................2-17
Seat Belt Warning Light .............................................2-18
Index
O
PS
R