maintenance HYUNDAI VENUE 2022 Repair Manual

Maintenance
8-66
1. Crankcase Emission Control
System
The positive crankcase ventilation system
is employed to prevent air pollution
caused by blow-by gases being emitted
from the crankcase. This system supplies
fresh filtered air to the crankcase through
the air intake hose. Inside the crankcase,
the fresh air mixes with blow-by gases,
which then pass through the PCV valve
into the induction system.
2. Evaporative Emission Control
System Including Onboard
Refueling Vapor Recovery
(ORVR)
The Evaporative Emission Control System
is designed to prevent fuel vapors from
escaping into the atmosphere. The
ORVR system is designed to allow the
vapors from the fuel tank to be loaded
into a canister while refueling at the gas
station, preventing the escape of fuel
vapors into the atmosphere.
Canister
Fuel vapors generated inside the fuel
tank are absorbed and stored in the
onboard canister. When the engine is
running, the fuel vapors absorbed in the
canister are drawn into the surge tank
through the purge control solenoid valve.
Purge Control Solenoid Valve (PCSV)
The purge control solenoid valve
is controlled by the Engine Control
Module (ECM); when the engine coolant
temperature is low during idling, the
PCSV closes so that evaporated fuel
is not taken into the engine. After the
engine warms-up during ordinary
driving, the PCSV opens to introduce
evaporated fuel to the engine.
3. Exhaust Emission Control
System
The Exhaust Emission Control System is
a highly effective system which controls
exhaust emissions while maintaining
good vehicle performance.
When the engine starts or fails to start,
excessive attempts to restart the engine
may cause damage to the emission
system.
Engine exhaust (carbon monoxide)
precautions

[Carbon monoxide can be present
with other exhaust fumes. If you smell
exhaust fumes of any kind in your
vehicle, drive with all the windows
fully open. Have your vehicle checked
and repaired immediately.
WARNING
Engine exhaust gases contain carbon
monoxide (CO). Though colorless and
odorless, it is dangerous and could be
lethal if inhaled. Follow the instructions
on this page to avoid CO poisoning.
WARNING
CALIFORNIA PROPOSITION 65
WARNING
Engine exhaust and a wide variety of
automobile components and parts,
including components found in the
interior furnishings in a vehicle, contain
or emit chemicals known to the State
of California to cause cancer and
birth defects and reproductive harm.
In addition, certain fluids contained
in vehicles and certain products of
component wear contain or emit
chemicals known to the State of
California to cause cancer and birth
defects or other reproductive harm.

Maintenance
8-68
CALIFORNIA PERCHLORATE NOTICE
Perchlorate Material-special handling may apply, See:
www.dtsc.ca.gov/hazardouswaste/perchlorate.
Notice to California Vehicle Dismantlers:
Perchlorate containing materials, such as air bag inflators, seatbelt pretensioners and
keyless remote entry batteries, must be disposed of according to Title 22 California
Code of Regulations Section 67384.10 (a).

Maintenance
8-70
If you believe that your vehicle has a defect which could cause a crash or could cause
injury or death, you should immediately inform the National Highway Traffic Safety
Administration (NHTSA) in addition to notifying HYUNDAI MOTOR AMERICA.
To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888- 327-4236
(TTY: 1-800-424-9153);
go to http://www.safercar.gov;
download the SaferCar mobile application;
or write to: Administrator, NHTSA
1200 New Jersey Ave, SE,
West Building Washington, D.C. 20590.
You can also obtain other information about motor vehicle safety from
http://www.safercar.gov.
If NHTSA receives similar complaints, it may open an investigation, and if it finds that a
safety defect exists in a group of vehicles, it may order a recall and remedy campaign.
However, NHTSA cannot become involved in individual problems between you, your
dealer, or HYUNDAI MOTOR AMERICA.
REPORTING SAFETY DEFECTS

I
I-3
Automatic climate control system ....................................................................... 5-55
Air conditioning .............................................................................................. 5-61
Air conditioning refrigerant label.................................................................... 5-63
Automatic temperature control mode ............................................................. 5-56
Fan speed control ............................................................................................ 5-59
Manual heating and air conditioning............................................................... 5-48
Manual temperature control mode .................................................................. 5-57
Mode selection ................................................................................................ 5-57
OFF mode........................................................................................................ 5-60
System maintenance ........................................................................................ 5-62
System operation ............................................................................................. 5-61
Temperature control ........................................................................................ 5-59
Automatic door lock and unlock features ............................................................ 5-15
Air bag deployment ......................................................................................... 5-15
Auto LOCK - Enable on shift ......................................................................... 5-15
Auto LOCK - Enable on speed ....................................................................... 5-15
Auto UNLOCK - On Shift to P ....................................................................... 5-15
B
Battery ................................................................................................................. 8-25
Battery saver function .......................................................................................... 5-40
Before driving ........................................................................................................ 6-5
Blind-spot Collision Warning (BCW) system ..................................................... 6-31
Bluetooth® Wireless Technology hands-free ...................................................... 5-77
Brake system ........................................................................................................ 6-20
Anti-lock Brake System (ABS) ....................................................................... 6-22
Disc brakes wear indicator .............................................................................. 6-20
Electronic Stability Control (ESC).................................................................. 6-24
Good braking practices ................................................................................... 6-27
Hill-Start Assist Control (HAC) ...................................................................... 6-27
Power brakes ................................................................................................... 6-20
Rear drum brakes ............................................................................................ 6-20
Vehicle Stability Management (VSM) ............................................................ 6-26
Brake/clutch fluid ................................................................................................ 8-19

Index
I-6
Emission control system ...................................................................................... 8-65
Crankcase emission control system ................................................................ 8-66
Evaporative emission control System includinding
onboard refueling vapor recovery (ORVR) ..................................................... 8-66
Exhaust emission control system .................................................................... 8-66
Engine compartment ...................................................................................... 2-6, 8-3
Engine compartment panel fuse replacement ...................................................... 8-41
Engine coolant ..................................................................................................... 8-16
Engine coolant temperature gauge......................................................................... 4-6
Engine number ..................................................................................................... 2-14
Engine oil ............................................................................................................. 8-15
Engine specification............................................................................................... 2-7
Engine start/stop button ......................................................................................... 6-9
Evaporative emission control System includinding
onboard refueling vapor recovery (ORVR) ......................................................... 8-66
Exhaust emission control system ......................................................................... 8-66
Explanation of scheduled maintenance items ...................................................... 8-12
Exterior care......................................................................................................... 8-59
Exterior lights ...................................................................................................... 5-35
AUTO headlamp position ............................................................................... 5-35
Battery saver function ..................................................................................... 5-40
Cornering lamp................................................................................................ 5-35
Daytime running light (DRL).......................................................................... 5-35
Headlamp delay function ................................................................................ 5-40
Headlamp position .......................................................................................... 5-36
High Beam Assist (HBA) ................................................................................ 5-37
High beam operation ....................................................................................... 5-36
Parking lamp position ..................................................................................... 5-36
Turn signals ..................................................................................................... 5-40
Exterior overview .................................................................................................. 2-2
Front view ......................................................................................................... 2-2
Rear view .......................................................................................................... 2-3
F
Flat tire ................................................................................................................. 7-15
Changing tires ................................................................................................. 7-16
Jack and tools .................................................................................................. 7-15
Jack label ......................................................................................................... 7-20
Use of compact spare tires .............................................................................. 7-18

Index
I-10
L
Label
Tire loading information label ......................................................................... 6-91
Tire sidewall labeling ...................................................................................... 8-31
Tire specification and pressure label ............................................................... 2-14
Vehicle certification label ................................................................................ 2-13
Lane Keeping Assist (LKA) ................................................................................ 6-71
LKA system Function Change ........................................................................ 6-71
LCD display (for supervision cluster)
LCD display control ........................................................................................ 4-22
LCD display modes ......................................................................................... 4-23
User settings mode .......................................................................................... 4-25
LCD display control ............................................................................................ 4-22
LCD display messages ......................................................................................... 4-17
LCD display modes ............................................................................................. 4-23
Leading vehicle departure alert ........................................................................... 6-81
Liftgate ................................................................................................................. 5-31
Light bulbs ........................................................................................................... 8-50
Lubricants and capacities ..................................................................................... 2-11
Luggage compartment lamp ................................................................................ 5-43
Luggage net holder .............................................................................................. 5-73
M
Main fuse ............................................................................................................. 8-42
Maintenance
Explanation of scheduled maintenance items ................................................. 8-12
Maintenance services ....................................................................................... 8-4
Owner maintenance ........................................................................................... 8-5
Scheduled maintenance services ....................................................................... 8-7
Tire maintenance ............................................................................................ 8-31
Maintenance services ............................................................................................. 8-4
Manual climate control system ............................................................................ 5-47
Air conditioning .............................................................................................. 5-52
Air conditioning refrigerant label.................................................................... 5-54
Fan speed control ............................................................................................ 5-51
Heating and air conditioning ........................................................................... 5-48
Mode selection ................................................................................................ 5-48

I
I-11
System maintenance ........................................................................................ 5-53
System operation ............................................................................................. 5-51
Temperature control ........................................................................................ 5-50
Manual transmission ............................................................................................ 6-12
Downshifting ................................................................................................... 6-13
Good driving practices .................................................................................... 6-14
Manual transmission operation ....................................................................... 6-12
Using the clutch............................................................................................... 6-13
Mirrors ................................................................................................................. 5-19
Adjusting the side view mirrors ...................................................................... 5-21
Day/night rearview mirror............................................................................... 5-20
Folding the side view mirrors ......................................................................... 5-21
Inside rearview mirror ..................................................................................... 5-19
Side view mirrors ............................................................................................ 5-20
Moonroof, see sunroof ......................................................................................... 5-26
Multi fuse ............................................................................................................. 8-42
O
Odometer ............................................................................................................... 4-7
Outside temperature gauge .................................................................................... 4-7
Owner maintenance ............................................................................................... 8-5
P
Parking brake ............................................................................................. 6-21, 8-20
Passenger’s front air bag ...................................................................................... 3-33
Power brakes ........................................................................................................ 6-20
Power outlet ......................................................................................................... 5-69
Power window lock switch .................................................................................. 5-25
Pre-tensioner seat belt .......................................................................................... 3-18
R
Range ..................................................................................................................... 4-8
Rear Cross–Traffic Collision Warning (RCCW) ................................................. 6-40
Rear drum brakes ................................................................................................. 6-20
Rear seats ............................................................................................................... 3-7
Folding the rear seat .......................................................................................... 3-7

Index
I-12
Rear View Monitor system .................................................................................. 5-46
Rear window defroster ......................................................................................... 5-66
Rear window wiper and washer ........................................................................... 5-45
Recommended cold tire inflation pressures ......................................................... 8-27
Recommended lubricants and capacities ............................................................. 2-11
Recommended SAE viscosity number ............................................................ 2-12
Remote key ............................................................................................................ 5-4
Battery replacement .......................................................................................... 5-6
Removable towing hook ...................................................................................... 7-22
Replacement light bulb ........................................................................................ 8-50
Rocking the vehicle ............................................................................................. 6-85
Roof side rails ...................................................................................................... 5-74
Rotation (Tire) ..................................................................................................... 8-29
S
Scheduled maintenance services............................................................................ 8-7
Seat belt warning light ......................................................................................... 3-15
Seat belts ................................................................................................................ 3-4
Additional seat belt safety precautions ........................................................... 3-20
Care of seat belts ............................................................................................. 3-22
Do not lie down ............................................................................................... 3-22
Keep belts clean and dry ................................................................................. 3-22
One person per belt ......................................................................................... 3-22
Periodic inspection ......................................................................................... 3-22
Pre-tensioner seat belt ..................................................................................... 3-18
Rear center seatbelt ......................................................................................... 3-18
Seat belt restraint system ................................................................................. 3-16
Seat belt safety precautions ............................................................................. 3-14
Seat belt use and children ................................................................................ 3-20
Seat belt use during pregnancy ....................................................................... 3-20
Seat belt warning light ................................................................................... 3-15
Transporting an injured person ....................................................................... 3-22
When to replace seat belts ............................................................................... 3-22
Seat warmers ........................................................................................................ 3-12
Seatback pocket ..................................................................................................... 3-7

Index
I-14
T
Tachometer ............................................................................................................ 4-6
Theft-alarm system .............................................................................................. 5-16
Tire chains............................................................................................................ 6-88
Tire loading information label ............................................................................. 6-91
Tire pressure monitoring system (TPMS) (TYPE A) ............................................ 7-7
Tire pressure monitoring system (TPMS) (TYPE B) .......................................... 7-10
Tire rotation ......................................................................................................... 8-29
Tire specification and pressure label ................................................................... 2-14
Tires and wheels .................................................................................................. 8-27
All season tires ................................................................................................ 8-37
Check Tire Inflation Pressure .......................................................................... 8-28
Compact spare tire replacement ...................................................................... 8-31
Low aspect ratio tires ...................................................................................... 8-38
Radial-ply tires ................................................................................................ 8-38
Recommended cold tire inflation pressures .................................................... 8-27
Snow Tires ....................................................................................................... 6-88
Tire maintenance ............................................................................................. 8-31
Tire replacement .............................................................................................. 8-30
Tire rotation ..................................................................................................... 8-29
Tire sidewall labeling ..................................................................................... 8-31
Tire terminology and definitions ..................................................................... 8-35
Tire traction ..................................................................................................... 8-31
Wheel alignment and tire balance ................................................................... 8-29
Wheel replacement .......................................................................................... 8-31
Towing ................................................................................................................. 7-21
Trailer towing ...................................................................................................... 6-98
Transmission shift indicator................................................................................... 4-8
Trip computer ...................................................................................................... 4-31
U
USB and iPod ...................................................................................................... 5-75
USB charger ......................................................................................................... 5-70
User settings mode ............................................................................................... 4-25