maintenance HYUNDAI VENUE 2023 Repair Manual

Maintenance8-66
1. Crankcase Emission Control System
The positive crankcase ventilation system
is employed to prevent air pollution
caused by blow-by gases being emitted
from the crankcase. This system supplies
fresh filtered air to the crankcase through
the air intake hose. Inside the crankcase,
the fresh air mixes with blow-by gases,
which then pass through the PCV valve
into the induction system.
2. Evaporative Emission Control System Including Onboard
Refueling Vapor Recovery
(ORVR)
The Evaporative Emission Control System
is designed to prevent fuel vapors from
escaping into the atmosphere. The
ORVR system is designed to allow the
vapors from the fuel tank to be loaded
into a canister while refueling at the gas
station, preventing the escape of fuel
vapors into the atmosphere.
Canister
Fuel vapors generated inside the fuel
tank are absorbed and stored in the
onboard canister. When the engine is
running, the fuel vapors absorbed in the
canister are drawn into the surge tank
through the purge control solenoid valve.
Purge Control Solenoid Valve (PCSV)
The purge control solenoid valve
is controlled by the Engine Control
Module (ECM); when the engine coolant
temperature is low during idling, the
PCSV closes so that evaporated fuel
is not taken into the engine. After the
engine warms-up during ordinary
driving, the PCSV opens to introduce
evaporated fuel to the engine.
3. Exhaust Emission Control System
The Exhaust Emission Control System is
a highly effective system which controls
exhaust emissions while maintaining
good vehicle performance.
When the engine starts or fails to start,
excessive attempts to restart the engine
may cause damage to the emission
system.
Engine Exhaust (carbon Monoxide)
Precautions

[ Carbon monoxide can be present
with other exhaust fumes. If you smell
exhaust fumes of any kind in your
vehicle, drive with all the windows
fully open. Have your vehicle checked
and repaired immediately.
WARNING
Engine exhaust gases contain carbon
monoxide (CO). Though colorless and
odorless, it is dangerous and could be
lethal if inhaled. Follow the instructions
on this page to avoid CO poisoning.
WARNING
CALIFORNIA PROPOSITION 65
WARNING
Engine exhaust and a wide variety of
automobile components and parts,
including components found in the
interior furnishings in a vehicle, contain
or emit chemicals known to the State
of California to cause cancer and
birth defects and reproductive harm.
In addition, certain fluids contained
in vehicles and certain products of
component wear contain or emit
chemicals known to the State of
California to cause cancer and birth
defects or other reproductive harm.

Maintenance8-68
CALIFORNIA PERCHLORATE NOTICE
Perchlorate Material-special handling may apply, See:
https://dtsc.ca.gov/perchlorate.
Notice to California Vehicle Dismantlers:
Perchlorate containing materials, such as air bag inflators, seatbelt pretensioners and
keyless remote entry batteries, must be disposed of according to Title 22 California
Code of Regulations Section 67384.10 (a).

Maintenance8-70
If you believe that your vehicle has a defect which could cause a crash or could cause
injury or death, you should immediately inform the National Highway Traffic Safety
Administration (NHTSA) in addition to notifying HYUNDAI MOTOR AMERICA.
To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888- 327-4236
(TTY: 1-800-424-9153);
go to http://www.safercar.gov;
download the SaferCar mobile application;
or write to: Administrator, NHTSA 1200 New Jersey Ave, SE,
West Building Washington, D.C. 20590.
You can also obtain other information about motor vehicle safety from
http://www.safercar.gov.
If NHTSA receives similar complaints, it may open an investigation, and if it finds that a
safety defect exists in a group of vehicles, it may order a recall and remedy campaign.
However, NHTSA cannot become involved in individual problems between you, your
dealer, or HYUNDAI MOTOR AMERICA.
REPORTING SAFETY DEFECTS

IndexI-2
A
Accessing Your Vehicle ........................................................................\
................. 5-4 Immobilizer System ........................................................................\
................ 5-11
Remote Key ........................................................................\
............................... 5-4
Smart Key........................................................................\
.................................. 5-7
Air Bag - Advanced Supplemental Restraint System .......................................... 3-31
Additional Safety Precautions ........................................................................\
. 3-51
Air Bag Warning Labels ........................................................................\
.......... 3-51
How Does the Air Bag System Operate? ........................................................ 3-36
Occupant Classification System (OCS) .......................................................... 3-40
SRS Care ........................................................................\
................................. 3-50
What to Expect After an Air Bag Inflates ....................................................... 3-39
Where Are the Air Bags?...................................................................\
.............. 3-33
Why Didn’t My Air Bag Go Off in a Collision? ............................................. 3-46
Air Cleaner........................................................................\
................................... 8-21
Filter Replacement ........................................................................\
.................. 8-21
Air Conditioning System ........................................................................\
............. 2-10
Appearance Care ........................................................................\
.......................... 8-59 Exterior Care ........................................................................\
........................... 8-59
Interior Care ........................................................................\
............................ 8-63
Automatic Climate Control System ..................................................................... 5-56
Automatic Temperature Control Mode ........................................................... 5-57
Manual Temperature Control Mode ................................................................ 5-58
System Maintenance ........................................................................\
............... 5-63
System Operation ........................................................................\
.................... 5-62
B
Battery ................................................................\
................................................. 8-25 Battery Recharging ........................................................................\
.................. 8-26
For Best Battery Service ........................................................................\
......... 8-26
Reset Features ........................................................................\
......................... 8-26
Before Driving ........................................................................\
............................... 6-5
Before Entering the Vehicle ........................................................................\
...... 6-5
Before Starting ........................................................................\
.......................... 6-5

IndexI-4
Door Locks ........................................................................\
.................................. 5-12 Automatic Door Lock and Unlock Features ................................................... 5-15
Child-Protector Rear Door Locks ................................................................... 5-15
Operating Door Locks from Inside the Vehicle .............................................. 5-13
Operating Door Locks from Outside the Vehicle ............................................ 5-12
Drive Mode Integrated Control System ............................................................... 6-28
LCD Display Message ........................................................................\
............ 6-30
Driver Attention Warning (DAW) ....................................................................... 6-78
Leading Vehicle Departure Alert ..................................................................... 6-81
Resetting the System ........................................................................\
............... 6-79
System Malfunction ........................................................................\
................ 6-79
System Setting and Activation ........................................................................\
6-78
System Standby ........................................................................\
....................... 6-79
E
Emission Control System ........................................................................\
............ 8-65 Crankcase Emission Control System .............................................................. 8-66
Evaporative Emission Control System Including Onboard Refueling Vapor
Recovery (ORVR) ........................................................................\
................... 8-66
Exhaust Emission Control System .................................................................. 8-66
Engine .................................................................\
................................................... 2-7
Engine Compartment ........................................................................\
..................... 8-3
Engine Compartment ........................................................................\
..................... 2-6
Engine Coolant ........................................................................\
............................ 8-16 Changing Engine Coolant ........................................................................\
....... 8-18
Checking the Engine Coolant Level ............................................................... 8-16
Engine Number ........................................................................\
............................ 2-14
Engine Oil ........................................................................\
.................................... 8-15 Checking the Engine Oil and Filter ................................................................. 8-15
Checking the Engine Oil Level ....................................................................... 8-15
Explanation of Scheduled Maintenance Items .................................................... 8-12 Air Cleaner Filter ........................................................................\
.................... 8-13
Air Conditioning Refrigerant ........................................................................\
.. 8-14
Brake/Clutch Fluid ........................................................................\
.................. 8-14
Brake Discs, Pads, Calipers and Rotors .......................................................... 8-14
Brake Hoses and Lines ........................................................................\
............ 8-13
Cooling System ........................................................................\
....................... 8-13
Drive Belts ........................................................................\
.............................. 8-12

IndexI-8
LCD Display ........................................................................\
................................ 4-22 LCD Display Control ........................................................................\
.............. 4-22
LCD Display Modes ........................................................................\
............... 4-23
Light Bulbs ........................................................................\
.................................. 8-50 Headlamp, Parking Lamp, Daytime Running Light, Turn Signal Lamp,
Cornering Lamp and Side Marker..........................................\
......................... 8-50
High Mounted Stop Lamp Replacement ......................................................... 8-57
Interior Light Bulb Replacement .................................................................... 8-58
License Plate Light Bulb Replacement ........................................................... 8-57
Rear Combination Light Bulb Replacement ................................................... 8-55
Side Repeater Lamp Replacement .................................................................. 8-54
Lighting ...............................................................\
................................................ 5-36
Exterior Lights ........................................................................\
........................ 5-36
Interior Lights........................................................................\
.......................... 5-42
M
Maintenance Services ........................................................................\
.................... 8-4 Owner Maintenance Precautions...........................................\
............................ 8-4
Owner’s Responsibility ........................................................................\
............. 8-4
Manual Climate Control System ........................................................................\
. 5-48
Heating and Air Conditioning ........................................................................\
. 5-49
System Maintenance ........................................................................\
............... 5-54
System Operation ........................................................................\
.................... 5-52
Manual Transmission ........................................................................\
................... 6-12 Good Driving Practices ........................................................................\
........... 6-14
Manual Transmission Operation ..................................................................... 6-12
Mirrors ................................................................\
................................................. 5-19 Inside Rearview Mirror ........................................................................\
........... 5-19
Side View Mirrors ........................................................................\
................... 5-20
O
Owner Maintenance ........................................................................\
....................... 8-5 Owner Maintenance Schedule..............................................\
............................. 8-5
P
Parking Brake ........................................................................\
.............................. 8-20 Checking the Parking Brake..............................................\
.............................. 8-20

I
I-9
R
Rear Cross-Traffic Collision Warning (RCCW) .................................................. 6-40Detecting Sensor ........................................................................\
..................... 6-43
Limitations of the System ........................................................................\
....... 6-44
System Description ........................................................................\
................. 6-40
System Setting and Operation ........................................................................\
. 6-40
Warning and System Control ........................................................................\
.. 6-42
Rear View Monitor System ........................................................................\
......... 5-47
Recommended Lubricants and Capacities ........................................................... 2-11 Recommended SAE Viscosity Number .......................................................... 2-12
Reporting Safety Defects ........................................................................\
............. 8-70
S
Safety Messages........................................................................\
............................. 1-4
Scheduled Maintenance Services ........................................................................\
.. 8-7 Maintenance Under Severe Usage Conditions ................................................ 8-11
Normal Maintenance Schedule ........................................................................\
. 8-8
Normal Maintenance Schedule (CONT) ........................................................... 8-9
Normal Maintenance Schedule (CONT) ......................................................... 8-10
Severe Driving Conditions ........................................................................\
...... 8-11
Seat Belts ........................................................................\
..................................... 3-14 Additional Seat Belt Safety Precautions ......................................................... 3-20
Care of Seat Belts ........................................................................\
.................... 3-22
Seat Belt Restraint System ........................................................................\
...... 3-16
Seat Belt Safety Precautions ........................................................................\
... 3-14
Seat Belt Warning Light ........................................................................\
.......... 3-15
Seats ..................................................................\
..................................................... 3-3 Front Seats ........................................................................\
................................. 3-5
Head Restraints ........................................................................\
......................... 3-9
Rear Seats ........................................................................\
.................................. 3-7
Safety Precautions ........................................................................\
..................... 3-4
Seat Warmers ........................................................................\
........................... 3-12

I
I-11
Tires and Wheels ........................................................................\
......................... 8-27All Season Tires ........................................................................\
...................... 8-37
Check Tire Inflation Pressure ........................................................................\
.. 8-28
Low Aspect Ratio Tires ........................................................................\
........... 8-38
Radial-Ply Tires ........................................................................\
....................... 8-38
Recommended Cold Tire Inflation Pressures .................................................. 8-27
Snow Tires ........................................................................\
............................... 8-37
Summer Tires ........................................................................\
.......................... 8-37
Tire Care ........................................................................\
.................................. 8-27
Tire Maintenance ........................................................................\
..................... 8-31
Tire Replacement ........................................................................\
.................... 8-30
Tire Rotation ........................................................................\
........................... 8-29
Tire Sidewall Labeling ........................................................................\
............ 8-31
Tire Terminology and Definitions ................................................................... 8-35
Tire Traction ........................................................................\
............................ 8-31
Wheel Alignment and Tire Balance ................................................................ 8-29
Wheel Replacement ........................................................................\
................ 8-31
Tire Specification and Pressure Label ................................................................. 2-14
Towing ..................................................................\
............................................... 7-21 Emergency Towing........................................................................\
.................. 7-23
Removable Towing Hook....................................................................\
............ 7-22
Tie-down Hook ........................................................................\
....................... 7-24
Towing Service ........................................................................\
........................ 7-21
Trailer Towing ........................................................................\
............................. 6-95
Trip Computer............................................................\
.......................................... 4-31
V
Vehicle Break-In Process ........................................................................\
............... 1-7
Vehicle Certification Label ........................................................................\
.......... 2-13
Vehicle Data Collection and Event Data Recorders .............................................. 1-8
Vehicle Identification Number (vin) .................................................................... 2-13
Vehicle Load Limit ........................................................................\
...................... 6-91 Tire Loading Information Label ...................................................................... 6-91
Vehicle Modifications ........................................................................\
.................... 1-7
Volume and Weight ........................................................................\
...................... 2-10