heated ISUZU AXIOM 2002 Service Repair Manual

0A±12
GENERAL INFORMATION
Abbreviations Charts
List of automotive abbreviations which may be used
in this manual
A Ð Ampere(s)
ABS Ð Antilock Brake System
AC Ð Alternating Current
A/C Ð Air Conditioning
ACCEL Ð Accelerator
ACC Ð Accessory
ACL Ð Air Cleaner
Adj Ð Adjust
A/F Ð Air Fuel Ratio
AIR Ð Secondary Air Injection System
Alt Ð Altitude
AMP Ð Ampere(s)
ANT Ð Antenna
ASM Ð Assembly
A/T Ð Automatic Transmission/Transaxle
ATDC Ð After Top Dead Center
ATF Ð Automatic Transmission Fluid
Auth Ð Authority
Auto Ð Automatic
BARO Ð Barometric Pressure
Bat Ð Battery
B+ Ð Battery Positive Voltage
Bbl Ð Barrel
BHP Ð Brake Horsepower
BPT Ð Backpressure Transducer
BTDC Ð Before Top Dead Center

C Ð Degrees Celsius
CAC Ð Charge Air Cooler
Calif Ð California
cc Ð Cubic Centimeter
CID Ð Cubic Inch Displacement
CKP Ð Crankshaft Position
CL Ð Closed Loop
CLCC Ð Closed Loop Carburetor Control
CMP Ð Camshaft Position
CO Ð Carbon Monoxide
Coax Ð Coaxial
Conn Ð Connector
Conv Ð Converter
Crank Ð Crankshaft
Cu. In. Ð Cubic Inch
CV Ð Constant Velocity
Cyl Ð Cylinder(s)
DI Ð Distributor Ignition
Diff Ð Differential
Dist Ð Distributor
DLC Ð Data Link Connector
DOHC Ð Double Overhead Camshaft
DTC Ð Diagnostic Trouble Code
DTM Ð Diagnostic Test Mode
DTT Ð Diagnostic Test Terminal
DVM Ð Digital Voltmeter (10 meg.)
DVOM Ð Digital Volt Ohmmeter
EBCM Ð Electronic Brake Control Module
ECM Ð Engine Control Module
ECT Ð Engine Coolant Temperature
EEPROM Ð Electronically Erasable Programmable
Read Only Memory
EGR Ð Exhaust Gas Recirculation
EI Ð Electronic Ignition
ETR Ð Electronically Tuned Receiver
EVAP Ð Evaporation EmissionExh Ð Exhaust

F Ð Degrees Fahrenheit
Fed Ð Federal (All States Except Calif.)
FF Ð Front Drive Front Engine
FL Ð Fusible Link
FLW Ð Fusible Link Wire
FP Ð Fuel Pump
FRT Ð Front
ft Ð Foot
FWD Ð Front Wheel Drive
4WD Ð Four Wheel Drive
4 x 4 Ð Four Wheel Drive
4 A/T Ð Four Speed Automatic Transmission/Transaxle
Gal Ð Gallon
GEN Ð Generator
GND Ð Ground
Gov Ð Governor
g Ð Gram
Harn Ð Harness
HC Ð Hydrocarbons
HD Ð Heavy Duty
Hg Ð Hydrargyrum (Mercury)
HiAlt Ð High Altitude
HO2S Ð Heated Oxygen Sensor
HVAC Ð Heater±Vent±Air±Conditioning
IAC Ð Idle Air Control
IAT Ð Intake Air Temperature
IC Ð Integrated Circuit / Ignition Control
ID Ð Identification / Inside Diameter
IGN Ð Ignition
INJ Ð Injection
IP Ð Instrument Panel
IPC Ð Instrument Panel Cluster
Int Ð Intake
ISC Ð Idle Speed Control
J/B Ð Junction Block
kg Ð Kilograms
km Ð Kilometers
km/h Ð Kilometer per Hour
kPa Ð Kilopascals
kV Ð Kilovolts (thousands of volts)
kW Ð Kilowatts
KS Ð Knock Sensor
L Ð Liter
lb ft Ð Foot Pounds
lb in Ð Inch Pounds
LF Ð Left Front
LH Ð Left Hand
LR ÐLeft Rear
LS Ð Left Side
LWB Ð Long Wheel Base
L±4 Ð In±Line Four Cylinder Engine
MAF Ð Mass Air Flow
MAN Ð Manual
MAP Ð Manifold Absolute Pressure
Max Ð Maximum
MC Ð Mixture Control
MFI Ð Multiport Fuel Injection
MIL Ð Malfunction Indicator Lamp
Min Ð Minimum
mm Ð Millimeter
MPG Ð Miles Per Gallon
MPH Ð Miles Per Hour
M/T Ð Manual Transmission/Transaxle
MV Ð Millivolt

6A±14
ENGINE MECHANICAL (6VE1 3.5L)
Abnormal Combustion
ConditionPossible causeCorrection
Trouble in fuel systemFuel pressure control valve defectiveReplace
Fuel filter cloggedReplace
Fuel pump cloggedClean or replace
Fuel tank or fuel pipe cloggedClean or replace
Fuel injector cloggedClean or replace
Fuel pump relay defectiveReplace
Power supply cable for fuel pump
broken or poor connectionsReconnect, correct or replace
Mass Airflow (MAF) Sensor circuit
open or defectiveCorrect or replace
MAF Sensor defectiveReplace
Manifold Absolute Pressure Sensor
circuit open or shortedCorrect or replace
Manifold Absolute Pressure Sensor
defectiveReplace
Engine Coolant Temperature (ECT)
Sensor circuit open or shortedCorrect or replace
ECT Sensor defectiveReplace
Throttle Position Sensor adjustment
incorrectReadjust
Throttle Position Sensor defectiveReplace
Throttle Position Sensor connector
poor connectionsReconnect
Vehicle Speed Sensor cable poor
connections or defectiveCorrect or replace
Vehicle Speed Sensor loosely fixedFix tightly
Vehicle Speed Sensor in wrong
contact or defectiveReplace
Powertrain Control Module cable
poor connections or defectiveCorrect or replace
Trouble in emission control systemHeated Oxygen Sensor circuit openCorrect or replace
Heated Oxygen Sensor defectiveReplace
Signal vacuum hose loosely fitted or
defectiveCorrect or replace
EGR Valve circuit open or shortedCorrect or replace
Exhaust Gas Recirculation Valve
defectiveReplace
ECT Sensor circuit open or shortedCorrect or replace
Canister Purge Valve circuit open or
shortedCorrect or replace
Canister Purge Valve defectiveReplace
ECT Sensor defectiveReplace
Positive Crankcase Ventilation
(PCV) valve and hose cloggedCorrect or replace
Evaporator systemRefer to Section 6E
Trouble in ignition systemÐÐÐÐRefer to ªEngine Lacks Powerº

6A±18
ENGINE MECHANICAL (6VE1 3.5L)
Malfunction Indicator Lamp
The instrument panel ªCHECK ENGINEº Malfunction In-
dicator Lamp (MIL) illuminates by self diagnostic system
when the system checks the starting of engine, or senses
malfunctions.
Condition
Possible causeCorrection
ªCHECK ENGINEº MIL does not
illuminate at the starting of engine
Bulb defectiveReplace
illuminate at the starting of engineMIL circuit openCorrect or replace
Command signal circuit to operate
self diagnostic system shortedCorrect or replace
Powertrain Control Module (PCM)
cable loosely connected,
disconnected or defectiveCorrect or replace
PCM defectiveReplace
ªCHECK ENGINEº MIL illuminates,
and stays onDeterioration of heated oxygen
sensor internal elementReplace
Heated oxygen sensor connector
terminal improper contactReconnect properly
Heated oxygen sensor lead wire
shortedCorrect
Heated oxygen sensor circuit openCorrect or replace
Deterioration of engine coolant
temperature sensor internal elementReplace
Engine coolant temperature sensor
connector terminal improper contactReconnect properly
Engine coolant temperature sensor
lead wire shortedCorrect
Engine coolant temperature sensor
circuit openCorrect or replace
Throttle position sensor open or
shorted circuitsCorrect or replace
Deterioration of crankshaft position
sensorReplace
Crankshaft position sensor circuit
open or shortedCorrect or replace
Vehicle speed sensor circuit openCorrect or replace
Manifold absolute pressure sensor
circuit open or shortedCorrect or replace
Intake air temperature sensor circuit
open or shortedCorrect or replace
Fuel injector circuit open or shortedCorrect or replace
PCM driver transistor defectiveReplace PCM
Malfunctioning of PCM RAM
(Random Access Memory) or ROM
(Read Only Memory)Replace PCM

6B±10
ENGINE COOLING (6VE1 3.5L)
Cap tester: J±24460±01
Adapter: J±33984±A
110RX002
Installation
1. Install rubber cushions on both sides of radiator
bottom.
2. Install radiator assembly with hose, taking care not to
damage the radiator core with a fan blade.
3. Connect reserve tank hose (4).
4. Install lower fan guide (3).
5. Connect radiator inlet hose and outlet hose to the
engine.
6. Connect oil cooler hose (1) to automatic
transmission.
110RX001
7. Connect battery ground cable.
8. Pour engine coolant up to filler neck of radiator, and
up to MAX mark of reserve tank.
110RW012Important operation (in case of 100% engine coolant
change) procedure for filling with engine coolant.
Engine Coolant Filling Up Procedure
1. Make sure that the engine is cool.
WARNING: WHEN THE COOLANT IS HEATED TO A
HIGH TEMPERATURE, BE SURE NOT TO LOOSEN
OR REMOVE THE RADIATOR CAP. OTHERWISE YOU
MIGHT GET SCALDED BY HOT VAPOR OR BOILING
WATER. TO OPEN THE RADIATOR CAP, PUT A
PIECE OF THICK CLOTH ON THE CAP AND LOOSEN
THE CAP SLOWLY TO REDUCE THE PRESSURE
WHEN THE COOLANT HAS BECOME COOLER.
2. Open radiator cap pour coolant up to filler neck.
3. Pour coolant into reservoir tank up to ªMAXº line.
4. Tighten radiator cap and start the engine. After idling
for 2 to 3 minutes, stop the engine and reopen radiator
cap. If the water level is lower, replenish.
5. After replenishing with coolant tighten radiator cap,
warm up the engine at about 2000 rpm. Set heater
adjustment to the highest temperature position, and
let the coolant circulate also into heater water system.
6. Check to see the thermometer, continuously idle for 5
minutes and stop the engine.
7. When the engine has been cooled, check filler neck
for water level and replenish if required. Should
extreme shortage of coolant is found, check the
coolant system and reservoir tank hose for leakage.
8. Pour coolant into the reservoir tank up to ªMAXº line.

6D3±5
STARTING AND CHARGING SYSTEM (6VE1 3.5L)
Starter
Removal
1. Battery ground cable.
2. Disconnect Heated O
2 Sensor connector (1).
3. Remove exhaust front left pipe(2).
150R100011
4. Disconnect starter wiring connector from terminals
ª30º (1) and ª50º (2).
5. Remove starter assembly mounting bolts on inside
and outside(3).
6. Remove starter assembly (4) toward the bottom of
engine.
065RY00050
Legend
(1) Terminal ª30º
(2) Terminal ª50º
(3) Fixing Bolts
(4) Starter Assembly
Installation
1. Install starter assembly(4).
2. Install mounting bolts and tighten bolts to specified
torque(3).
Torque: 40 N´m (30 lb ft)
3. Reconnect the connectors to terminals ª50º (2)
tighten terminals ª30º (1) to specified torque.
Torque: 9 N´m (78 lb in)
065RY00050
Legend
(1) Terminal ª30º
(2) Terminal ª50º
(3) Fixing Bolts
(4) Starter Assembly
4. Install exhaust front left pipe (2) and tighten bolts and
nuts to specified torque.
Stud Nuts
Torque: 67 N´m (49 lb ft)
Bolts
Torque: 43 N´m (32 lb ft)

6D3±6
STARTING AND CHARGING SYSTEM (6VE1 3.5L)
5. Connect two Heated O2 Sensor connector (1).
150R100011
6. Reconnect the battery ground cable.

6E±1
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
AXIOM
ENGINE
6VE1 3.5L ENGINE
DRIVEABILITY AND EMISSIONS
CONTENTS
Specifications 6E±6. . . . . . . . . . . . . . . . . . . . . . . . . . .
Tightening Specifications 6E±6. . . . . . . . . . . . . . .
Diagrams and Schematics 6E±7. . . . . . . . . . . . . . . .
PCM Wiring Diagram (1 of 7) 6E±7. . . . . . . . . . . .
PCM Wiring Diagram (2 of 7) 6E±8. . . . . . . . . . . .
PCM Wiring Diagram (3 of 7) 6E±9. . . . . . . . . . . .
PCM Wiring Diagram (4 of 7) 6E±10. . . . . . . . . . . .
PCM Wiring Diagram (5 of 7) 6E±11. . . . . . . . . . . .
PCM Wiring Diagram (6 of 7) 6E±12. . . . . . . . . . . .
PCM Wiring Diagram (7 of 7) 6E±13. . . . . . . . . . . .
PCM Pinouts 6E±14. . . . . . . . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Blue Connector
± Row ªF1 ~ 20º 6E±14. . . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Blue Connector
± Row ªF20 ~ 40º 6E±15. . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Blue Connector
± Row ªF41 ~ 60º 6E±16. . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Blue Connector
± Row ªF61 ~ 80º 6E±17. . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Red Connector
± Row ªS1 ~ 20º 6E±19. . . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Red Connector
± Row ªS21 ~ 40º 6E±21. . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Red Connector
± Row ªS41 ~ 60º 6E±23. . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Red Connector
± Row ªS61 ~ 80º 6E±25. . . . . . . . . . . . . . . . . . . . .
Component Locators 6E±27. . . . . . . . . . . . . . . . . . .
Undercarriage Component Locator 6E±29. . . . . .
Fuse and Relay Panel (Underhood
Electrical Center) 6E±30. . . . . . . . . . . . . . . . . . . . .
Sensors and Miscellaneous Component
Locators 6E±31. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis 6E±33. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Strategy-Based Diagnostics 6E±33. . . . . . . . . . . . .
DTC Stored 6E±33. . . . . . . . . . . . . . . . . . . . . . . . . . .
No DTC 6E±33. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
No Matching Symptom 6E±33. . . . . . . . . . . . . . . . .
Intermittents 6E±33. . . . . . . . . . . . . . . . . . . . . . . . . .
No Trouble Found 6E±33. . . . . . . . . . . . . . . . . . . . .
Verifying Vehicle Repair 6E±33. . . . . . . . . . . . . . . .
General Service Information 6E±33. . . . . . . . . . . . . .
OBD II Serviceablity Issues 6E±33. . . . . . . . . . . . .
Emissions Control Information Label 6E±34. . . . .
Visual / Physical Engine Compartment
Inspection 6E±34. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Basic Knowledge of Tools Required 6E±35. . . . . .
Serial Data Communications 6E±35. . . . . . . . . . . . . . Class 2 Serial Data Communications 6E±35. . . . .
On-Board Diagnostic (OBD II) 6E±35. . . . . . . . . . . . .
On-Board Diagnostic Tests 6E±35. . . . . . . . . . . . .
Comprehensive Component Monitor
Diagnostic Operation 6E±35. . . . . . . . . . . . . . . . . .
System Status and Drive Cycle for
Satisfying Federal Inspection/Maintenance
(I/M 240) Regulations 6E±36. . . . . . . . . . . . . . . . . .
Common OBD II Terms 6E±36. . . . . . . . . . . . . . . . .
The Diagnostic Executive 6E±36. . . . . . . . . . . . . . .
DTC Types 6E±37. . . . . . . . . . . . . . . . . . . . . . . . . . .
Decimal/Binary/Hexadecimal Conversions 6E±39
Verifying Vehicle Repair 6E±39. . . . . . . . . . . . . . . .
Reading Diagnostic Trouble Codes Using
The Tech 2 Scan Tool 6E±39. . . . . . . . . . . . . . . . .
Tech 2 6E±40. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tech 2 Features 6E±41. . . . . . . . . . . . . . . . . . . . . . .
Getting Started 6E±41. . . . . . . . . . . . . . . . . . . . . . . .
Operating Procedure (For Example) 6E±42. . . . .
DTC Modes 6E±43. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC Information Mode 6E±43. . . . . . . . . . . . . . . . .
Miscellaneous Test 6E±44. . . . . . . . . . . . . . . . . . . .
Lamps Test 6E±44. . . . . . . . . . . . . . . . . . . . . . . . . . .
Relays Test 6E±46. . . . . . . . . . . . . . . . . . . . . . . . . . .
EVAP Test 6E±47. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel System Test 6E±48. . . . . . . . . . . . . . . . . . . . . .
Instruments Test 6E±50. . . . . . . . . . . . . . . . . . . . . . .
EGR Control Test 6E±52. . . . . . . . . . . . . . . . . . . . . .
Variable Intake Manifold Solenoid Test 6E±52. . .
Injector Balance Test 6E±54. . . . . . . . . . . . . . . . . . .
Plotting Snapshot Graph 6E±54. . . . . . . . . . . . . . . . .
Plotting Graph Flow Chart (Plotting graph
after obtaining vehicle information) 6E±55. . . . . .
Flow Chart for Snapshot Replay (Plotting
Graph) 6E±56. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Primary System-Based Diagnostic 6E±57. . . . . . . . .
Primary System-Based Diagnostic 6E±57. . . . . . .
Fuel Control Heated Oxygen Sensor 6E±57. . . . .
HO2S Heater 6E±57. . . . . . . . . . . . . . . . . . . . . . . . .
Catalyst Monitor Heated Oxygen Sensors
and Diagnostic Operation 6E±57. . . . . . . . . . . . . .
Misfire Monitor Diagnostic Operation 6E±58. . . . . . .
Misfire Monitor Diagnostic Operation 6E±58. . . . .
Misfire Counters 6E±58. . . . . . . . . . . . . . . . . . . . . . .

6E±4
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
DTC P1107 MAP Circuit Intermittent Low
Voltage 6E±386. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D T C P 1111 I AT Sensor Circuit Intermittent
High Voltage 6E±388. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1112 IAT Sensor Circuit Intermittent
Low Voltage 6E±391. . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1114 ECT Sensor Circuit Intermittent
Low Voltage 6E±393. . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1115 ECT Sensor Circuit Intermittent
High Voltage 6E±395. . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic Trouble Code(DTC)P1120-TPS 1
Throttle Position Sensor (TPS1) Output
Abnormal 6E±398. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1125 ETC (Electric Throttle Control)
Limit Performance Mode 6E±401. . . . . . . . . . . . . . . . .
DTC P1133 HO2S Insufficient Switching
Bank 1 Sensor 1 6E±404. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1134 HO2S Transition Time Ratio
Bank 1 Sensor 1 6E±408. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1153 HO2S Insufficient Switching
Bank 2 Sensor 1 6E±412. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1154 HO2S Circuit Transition Time
Ratio Bank 2 Sensor 1 6E±416. . . . . . . . . . . . . . . . . .
DTC P1167 Fuel System Rich During Decel
Fuel Cut Off (Bank 1) 6E±420. . . . . . . . . . . . . . . . . . . .
DTC P1169 Fuel System Rich During Decel
Fuel Cut Off (Bank 2) 6E±422. . . . . . . . . . . . . . . . . . . .
DTC P1171 Fuel System Lean During
Acceleration 6E±424. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1220 Throttle Position Senser2
(TPS2) Circuit Fault 6E±427. . . . . . . . . . . . . . . . . . . . .
DTC P1221 TPS1 ± TPS2 Correlation
(Circuit Performance) 6E±430. . . . . . . . . . . . . . . . . . .
DTC P1271 APS 1± 2 Correlation Error 6E±433. . .
DTC P1272 APS 2 ± 3 Correlation Error 6E±436. . .
DTC P1273 APS 1 ± 3 Correlation Error 6E±439. . . .
DTC P1275 APS 1 Output Fault 6E±442. . . . . . . . . . .
DTC P1280 APS 2 Output Fault 6E±444. . . . . . . . . . .
DTC P1285 APS 3 Output Fault 6E±446. . . . . . . . . . .
DTC P1290 ETC Forced Idle Mode 6E±448. . . . . . . .
DTC P1295 ETC Power Management Mode 6E±451
DTC P1299 ETC Forced Engine Shutdown
Mode 6E±455. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1310 ION Sensing Module Diagnosis 6E±459
DTC P1311 ION Sensing Module SEC
Line 1 Circuit Fault 6E±462. . . . . . . . . . . . . . . . . . . . . .
DTC P1312 ION Sensing Module SEC
Line 2 Circuit Fault 6E±465. . . . . . . . . . . . . . . . . . . . . .
DTC P1326 ION Sensing Module Combustion
Quality Input Circuit Fault 6E±468. . . . . . . . . . . . . . . .
DTC P1340 ION Sensing Module Cylinder ID
Fault (Cylinder Synchronization Fail) 6E±471. . . . . .
DTC P1404 EGR Stuck Closed 6E±474. . . . . . . . . . .
DTC P1441 EVAP System Flow During
Non-Purge 6E±477. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1514 TPS - MAF Correlation Error 6E±480. . . DTC P1515 Command - Actual TPS
Correlation Error 6E±484. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1516 Command - Actual TPS
Correlation Error 6E±487. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1523 Actuator Control Return
Performance 6E±490. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1571 Brake Switch No Operation 6E±493. . . .
DTC P1625 PCM Unexpected Reset 6E±495. . . . . . .
DTC P1635 Reference Voltage # 1 Circuit
Fault 6E±496. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1639 Reference Voltage # 2 Circuit
Fault 6E±498. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1640 Driver-1-Output Circuit Fault
(ODM) 6E±500. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1650 Quad Driver Module ªAº Fault 6E±503. .
Symptom Diagnosis 6E±506. . . . . . . . . . . . . . . . . . . . .
Default Matrix Table 6E±535. . . . . . . . . . . . . . . . . . . . .
On Vehicle Service
Crankshaft Position (CKP) Sensor 6E±538. . . . . . . . .
Engine Coolant Temperature (ECT) Sensor 6E±538.
Heated Oxygen Sensor (HO2S) 6E±539. . . . . . . . . . .
Intake Air Temperature (IAT) Sensor 6E±542. . . . . . .
ION Sensing Module 6E±542. . . . . . . . . . . . . . . . . . . . .
Mass Air Flow (MAF) Sensor 6E±543. . . . . . . . . . . . .
Manifold Absolute Pressure (MAP) Sensor 6E±544.
Malfunction Indicator Lamp (MIL) 6E±545. . . . . . . . . .
Reduced Power Lamp 6E±545. . . . . . . . . . . . . . . . . . .
Powertrain Control Module (PCM) 6E±545. . . . . . . . .
Service Precaution 6E±545. . . . . . . . . . . . . . . . . . . .
EEPROM 6E±547. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle Position (TP) Sensor 6E±547. . . . . . . . . . . . .
Vehicle Speed Sensor (VSS) 6E±548. . . . . . . . . . . . .
Air Cleaner/Air Filter 6E±549. . . . . . . . . . . . . . . . . . . . .
Common Chamber 6E±549. . . . . . . . . . . . . . . . . . . . . .
Accelerator Pedal Replacement 6E±550. . . . . . . . . . .
Accelerator Position Sensor Replacement 6E±551. .
Accelerator Position Sensor Adjustment 6E±551. . . .
Fuel Filler Cap 6E±552. . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Filter 6E±552. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Gauge Unit 6E±553. . . . . . . . . . . . . . . . . . . . . . . .
Fuel Injectors 6E±554. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Metering System 6E±555. . . . . . . . . . . . . . . . . . . .
Fuel Pump Assembly 6E±555. . . . . . . . . . . . . . . . . . . .
Fuel Pump Relay 6E±556. . . . . . . . . . . . . . . . . . . . . . . .
Fuel Rail Assembly 6E±557. . . . . . . . . . . . . . . . . . . . . .
Fuel Tank 6E±558. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle Body (TB) 6E±558. . . . . . . . . . . . . . . . . . . . . . .
Electronic Ignition System 6E±560. . . . . . . . . . . . . . . .
Catalytic Converter 6E±561. . . . . . . . . . . . . . . . . . . . . .
Air Conditioning Thermo Relay 6E±561. . . . . . . . . . .
EVAP Canister Hoses 6E±561. . . . . . . . . . . . . . . . . . . .
EVAP Canister 6E±562. . . . . . . . . . . . . . . . . . . . . . . . . .
EVAP Canister Vent Solenoid 6E±562. . . . . . . . . . . . .

6E±6
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
Specifications
Tightening Specifications
ApplicationN´mLb Ft.Lb In.
EGR Bolt2518Ð
Engine Coolant Temperature Sensor3022Ð
Fuel Drain Plug2014Ð
Fuel Pressure Regulator Attaching Screw3Ð26
Fuel Rail Bolts2518Ð
Fuel Tank Undercover Retaining Bolts3627Ð
Heated Oxygen Sensor5540Ð
Lower Intake Manifold to Engine Block Bolts2518Ð
Lower Intake Manifold to Engine Block Nuts2518Ð
Spark Plugs1813Ð
Throttle Body Mounting Bolts10Ð87
Common Chamber to Lower Intake Manifold Bolts2518Ð
VSS Retaining Bolt1612Ð

6E±29
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
Undercarriage Component Locator
014RW142
Undercarriage Component Locator Table
Number
NameLocation
1Fuel Pump Assembly and Vapor Pressure
(Fuel Tank Pressure) SensorInstalled in the top of the fuel tank
2Fuel Gauge UnitInstalled in the top of the fuel tank
3Evaporative (EVAP) CanisterOn the top of the bracket that is located behind
the cross member
4Vent Solenoid (EVAP Canister)On the top of the bracket that is located behind
the cross member
5Fuel FilterLocated along the inside of the right frame rail,
ahead of the fuel tank
6Vehicle Speed Sensor (VSS)Protrudes from the transmission housing, just
ahead of the propeller shaft
7Heated Oxygen Sensor (Bank 1, HO2S 1)Threaded into the exhaust pipe behind the
right-hand catalytic converter
8Heated Oxygen Sensor (Bank 1, HO2S 2)Threaded into the exhaust pipe ahead of the
right-hand catalytic converter
9Heated Oxygen Sensor (Bank 2, HO2S 1)Threaded into the exhaust pipe ahead of the
left-hand catalytic converter
10Heated Oxygen Sensor (Bank 2, HO2S 2)Threaded into the exhaust pipe behind the
left-hand catalytic converter