engine JAGUAR S TYPE 2005 1.G Electrical Manual
[x] Cancel search | Manufacturer: JAGUAR, Model Year: 2005, Model line: S TYPE, Model: JAGUAR S TYPE 2005 1.GPages: 200, PDF Size: 5.93 MB
Page 23 of 200
DATE OF ISSUE: May 200419
Control Module LocationJaguar S-TYPE 2005
VOICE ACTIVATIONMODULE
CELLULAR PHONE
CONTROL MODULE
VEHICLE INFORMATION
CONTROL MODULE
PARKING AIDMODULE
RESTRAINT CONTROL MODULE
STEERING COLUMN LOCK
MODULE
HEADLAMP LEVELING CONTROL
MODULE SPEED CONTROL MODULE
DYNAMIC STABILITY CONTROL
MODULE
DRIVER SEAT MODULE
DRIVER SEAT HEATER CONTROL
MODULE DRIVER DOOR MODULE
ENGINE CONTROL MODULE
FRONT ELECTRONIC MODULE
AIR CONDITIONING CONTROL MODULE (REMOTE)
PASSENGER SEAT WEIGHT SENSING CONTROL MODULE
OCCUPANCY SENSING CONTROL MODULE
AIR CONDITIONING CONTROL MODULE (COMBINED WITH CONTROL PANEL) PASSENGER SEAT HEATER
CONTROL MODULE
rhd_cm_loc_200045
NOTE:THE TRANSMISSION CONTROL MODULE IS CONTAINED WITHIN THE TRANSMISSION. SPEED CONTROL SENSOR
INSTRUMENT CLUSTER
POWER AMPLIFIER (TOP); NAVIGATION CONTROL MODULE (MIDDLE);
CD AUTOCHANGER (BOTTOM)
ELECTRONIC PARKING
BRAKE MODULEREAR ELECTRONIC MODULE
TRAILER TOWING MODULE ADAPTIVE DAMPING
CONTROL MODULEAUDIO UNIT
RHD
Page 24 of 200
20DATE OF ISSUE: May 2004
Ground Point LocationJaguar S-TYPE 2005
CA52
PI40 (RHD)FH95
FH22
FH77
CA30
CA141
CA158 JB1CA156 CA116 CA154
FC38
CA50
ST2
PI40 (LHD)
PI51 (ENGINE BLOCK GROUND)
FH42
CA21
FH4 (diesel RHD)
FH4 (diesel LHD)
gp_loc_200045
Page 25 of 200
DATE OF ISSUE: May 200421
Control Module Pin IdentificationJaguar S-TYPE 2005
ENGINE CONTROL MODULE
PI1 / BLACK
V6V8 N/A
V8 SC
PI1
ecm_200045
Page 36 of 200
32DATE OF ISSUE: May 2004
Diesel Engine Sensors and ActuatorsJaguar S-TYPE 2005
C30
C34 C69
C31
C25 C28C77 C35
C87
C88 FH14
FH15 C29
sensors_200045
Page 37 of 200
DATE OF ISSUE: May 200433
Diesel Engine Sensors and ActuatorsJaguar S-TYPE 2005
p age refe re nce for TOCactu_200045
C70C48
GP1
C39
C36C44
GP2
C47
C45
C71 C41 C43C42C40
C46
C49
Page 38 of 200
DATE OF ISSUE: May 2004
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds,
control modules and control module pins.
Fig. 01.1
COMPONENTS
Component Connector(s) Connector Description Location
BATTERY — — LUGGAGE COMPARTMENT
FPDB MEGAFUSE — — LUGGAGE COMPARTMENT
FRONT POWER DISTRIBUTION FUSE BOX — — ENGINE COMPARTMENT, RH SIDE
IGNITION SWITCH FC18 7-WAY / BLACK STEERING COLUMN COWLING
REAR POWER DISTRIBUTION FUSE BOX — — LUGGAGE COMPARTMENT
REAR POWER DISTRIBUTION FUSE BOX MEGAFUSE — — LUGGAGE COMPARTMENT
STARTER MEGAFUSE — — LUGGAGE COMPARTMENT
TRANSIT ISOLATION RELAY CA16 2-WAY / WHITE LUGGAGE COMPARTMENT, BATTERY + POST
HARNESS IN-LINE CONNECTORS
Connector Connector Description / Location Location
FC39 10-WAY / GREY / CABIN HARNESS TO FASCIA HARNESS BEHIND INSTRUMENT PANEL, RH SIDE
GROUNDS
Ground Location
JB1 LUGGAGE COMPARTMENT, BATTERY GROUND
Page 40 of 200
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds,
control modules and control module pins.DATE OF ISSUE: May 2004
Fig. 01.2
COMPONENTS
Component Connector(s) Connector Description LocationFRONT POWER DISTRIBUTION FUSE BOX — — ENGINE COMPARTMENT, RH SIDE
REAR POWER DISTRIBUTION FUSE BOX — — LUGGAGE COMPARTMENTHARNESS IN-LINE CONNECTORS
Connector Connector Description / Location LocationDM22 4-WAY / GREY / CABIN HARNESS TO DRIVER SEAT HARNESS UNDER DRIVER SEAT
DM23 20-WAY / BLACK / CABIN HARNESS TO DRIVER SEAT HARNESS UNDER DRIVER SEAT
DT8 14-WAY / GREY / CABIN HARNESS TO DRIVER DOOR TRIM HARNESS DRIVER DOOR
FC39 10-WAY / GREY / CABIN HARNESS TO FASCIA HARNESS BEHIND INSTRUMENT PANEL, RH SIDE
FH1 20-WAY / BLACK / CABIN HARNESS TO FRONT HARNESS RH ‘A’ POST, LOWER
PI41 42-WAY / BLACK / ENGINE HARNESS TO VEHICLE HARNESSES ENGINE COMPARTMENT, BULKHEAD, PASSENGER SIDE
PN23 4-WAY / GREY / CABIN HARNESS TO PASSENGER SEAT HARNESS UNDER PASSENGER SEAT
PN24 20-WAY / BLACK / CABIN HARNESS TO PASSENGER SEAT HARNESS UNDER PASSENGER SEAT
PT1 14-WAY / GREY / CABIN HARNESS TO PASSENGER DOOR TRIM HARNESS PASSENGER DOOR
Page 46 of 200
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds,
control modules and control module pins.DATE OF ISSUE: May 2004
Fig. 01.5
COMPONENTS
Component Connector(s) Connector Description LocationFRONT POWER DISTRIBUTION FUSE BOX — — ENGINE COMPARTMENT, RH SIDE
IGNITION SWITCH FC18 7-WAY / BLACK STEERING COLUMN COWLING
INERTIA SWITCH CA4 3-WAY / GREY LH ‘A’ POST
PARKING BRAKE MODULE CA241 4-WAY / BLACK LUGGAGE COMPARTMENT, RH REAR CA242 12-WAY / BLACK
PRIMARY JUNCTION FUSE BOX CA2 26-WAY / BLACK RH ‘A’ POST CA56 8-WAY / BLACK
FC37 26-WAY / BLACK
FH7 6-WAY / BLACK
FH53 10-WAY / BLACK
REAR POWER DISTRIBUTION FUSE BOX — — LUGGAGE COMPARTMENTHARNESS IN-LINE CONNECTORS
Connector Connector Description / Location LocationDM23 20-WAY / BLACK / CABIN HARNESS TO DRIVER SEAT HARNESS UNDER DRIVER SEAT
FC10 14-WAY / GREEN / FASCIA HARNESS TO FRONT HARNESS BEHIND INSTRUMENT PANEL, RH SIDE
FC39 10-WAY / GREY / CABIN HARNESS TO FASCIA HARNESS BEHIND INSTRUMENT PANEL, RH SIDE
FH1 20-WAY / BLACK / CABIN HARNESS TO FRONT HARNESS RH ‘A’ POST, LOWER
GB1 16-WAY / GREY / ENGINE HARNESS TO TRANSMISSION HARNESS ADJACENT TO TRANSMISSION BELL HOUSING
PI41 42-WAY / BLACK / ENGINE HARNESS TO VEHICLE HARNESSES ENGINE COMPARTMENT, BULKHEAD, PASSENGER SIDE
PN24 20-WAY / BLACK / CABIN HARNESS TO PASSENGER SEAT HARNESS UNDER PASSENGER SEAT
RF34 16-WAY / GREEN / CABIN HARNESS TO DOOR HARNESS ‘D’ POST, UNDER PARCEL SHELF
Page 50 of 200
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds,
control modules and control module pins.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit conn
ections made and all
components connected and fitted. The following abbreviations are used to represent values for Control Module Pin-Out data
I Input
O Output
B+ Battery Voltage PG Power Ground
SS Sensor / Signal Supply V
SG Sensor / Signal GroundC CAN Network
S SCP Network
D2 D2B Network D Serial and Encoded Data
V Voltage (DC)
PWM Pulse Width Modulated
CAUTION: The information on this data page is furnished to ai d the user in understanding circuit operation. THIS INFORMATION SH OULD BE USED FOR
REFERENCE ONLY.DATE OF ISSUE: May 2004
Fig. 01.7
FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. COMPONENTS
Component Connector(s) Connector Description LocationEMS CONTROL RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R4
ENGINE CONTROL MODULE PI1 134-WAY / BLACK FRONT BULKHEAD, P ASSENGER SIDE
FRONT POWER DISTRIBUTION FUSE BOX — — ENGINE COMPARTMENT, RH SIDE
HO2S RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R2
IGNITION COIL RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R3HARNESS IN-LINE CONNECTORS
Connector Connector Description / Location LocationCP1 10-WAY / BLACK / INTERCOOLER PUMP LINK LEAD ENGINE COMPARTMENT, RH FRONT, ADJACENT TO RADIATOR
FH1 20-WAY / BLACK / CABIN HARNESS TO FRONT HARNESS RH ‘A’ POST, LOWER
IL10 12-WAY / BLACK / ENGINE HARNESS TO FUEL INJECTOR LINK REAR OF ENGINE
IS5 6-WAY / BLACK / ENGINE HARNESS TO FUEL INJECTOR LINK ENGINE, LH REAR
IS6 6-WAY / BLACK / ENGINE HARNESS TO FUEL INJECTOR LINK ENGINE, RH REAR
PI41 42-WAY / BLACK / ENGINE HARNESS TO VEHICLE HARNESSES ENGINE COMPARTMENT, BULKHEAD, PASSENGER SIDEGROUNDS
Ground LocationFH42 ENGINE COMPARTMENT, BEHIND RH HEADLAMP
Engine Control Module Pin Description and CharacteristicO PI1–40 EMS CONTROL RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND
Page 51 of 200
Engine Management System Switched Power Distribution: Gasoline
Jaguar S-TYPE 2005
Engine Management System Switched Power Distribution: Gasoline
Fig. 01.7
13 4 114
46 80
76 77 92
ll
15 45ll ll SS
81 118EE
Fig .01.1
Fig .01 .2 F
ig .01.3
Fig .01 .4
Fig . 01.5 F
ig . 01.6 F
ig .01 .7
Input
OutputI
O
B
P+Battery VoltagePower Ground Sensor/Signal Supply V
Sensor/Signal Ground Serial and Encoded Data
CAN
+
SCPC
S DD
–
D2B Network2
f01_7_200045
3
1 5
4
2
R3
PI41-33 IL10-6 ILS1 (V6)
PIS23 (V8)
NR
R2
ENGINE CONTROL MODULE
BW YR YR
GR GR
WG
GR NR NR NR NR NR
NR NR
(N/A)
GR YR
YR
YB
YB WG WG
WR WR
WG RW RW
WG
(V6)
(V8)
WG WG
GU
GUGU
GU
GU
GU
GU
GU
GU
GU
GU
WG
WG
WG
NR
NR
NR
NR
NR
NR
NR
NR
NR
NR
NR
NR
NR
NR
NR
RWWG
WG
WG
WR
WR
GU
GU
GU
NG
NG
NG
(S/C)
GU GU
NR
YR YR
YR
GU YR YR YR YR
YR (SC) (SC)
YB B B
B
YU
PI1-40
PI41-41 FH32-46
FH32-52 FHS60
FH32-49
FH32-50
FH32-14 F17 15AFH32-23 PI41-35
PIS2
ISS1
ISS2
PIS15
PI41-5
FH1-4 PI41-11
PIS1
FH1-4
PI41-5
FHS4 FHS4
FH32-17 F20 30AFH32-26
FH32-47 F35 30A FH32-41
FH32-48 F36 15AFH32-42
FH42
PI41-30
CP1-10 PI41-9PI41-1 PIS24
PIS17PIS14
IS5-1
IS6-1
FH32-16 F19 10AFH32-25
FHS5
FH32-43
FH32-44
F37 15A
F38 10A
F9 50A FH32-9
FH32-51 FHS61
FHS59
FH67
O
47 46
50
49
33II
DIODE 4
DIODE 3
FROM INERTIA SWITCH
FRONT POWER DISTRIBUTION FUSE BOXIGNITION COIL
RELAY
HO2S RELAY
2 5 4
3
1
EMS CONTROL RELAY
45
2
3
1 I
I
I
03.1
03.303.5
03.1 03.303.5
48
111E
03.2
03.403.6
91E
NOTE
: IL10-6 – V6 only.
03.1
03.1
03.1
03.1
03.1
03.6
03.3 03.5
03.3 03.5
03.3 03.5
03.3 03.5
03.3 03.5
03.6
03.2
03.4
03.5
03.1
03.3
03.5
03.1
03.4 03.3
03.5
03.1
03.3
03.5
03.1
03.3
03.5
03.1
03.3
03.5
03.1
03.6 03.3
03.6
03.2
03.4
03.2
03.4
03.2 03.4
03.2 03.4
03.2 03.4
03.2 03.4
03.2 03.4
03.4
03.6
03.6
03.6
03.6
03.6
03.6
03.6
03.6
81E82E83E84E85E86E87E88E89E90E92E93E94E95E96E97E98E99E100E101E102E103E104E105E106E107E108E109E110E112E113E114E115E116E117E118E
R4
VARIANT: Gasoline Vehicles
VIN RANGE: All
DATE OF ISSUE: May 2004