belt JEEP CHEROKEE 2016 KL / 5.G Manual PDF

Engine Air Cleaner Filter Installation
NOTE:Inspect and clean the housing if dirt or debris is
present before replacing the air filter element.
1. Install the air cleaner filter element into the housing assembly with the air cleaner filter inspection surface
facing downward.
2. Install the air cleaner cover onto the housing assembly locating tabs.
3. Install screws to secure the air cleaner cover to the housing assembly and install air hose (if equipped).
Accessory Drive Belt Inspection
WARNING!
•Do not attempt to inspect an accessory drive belt
with vehicle running.
(Continued)
WARNING! (Continued)
•When working near the radiator cooling fan, dis-
connect the fan motor lead. The fan is temperature
controlled and can start at any time regardless of
ignition switch position. You could be injured by
the moving fan blades.
• You can be badly injured working on or around a
motor vehicle. Only do service work for which you
have the knowledge and the proper equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
When inspecting accessory drive belts, small cracks that
run across ribbed surface of belt from rib to rib, are
considered normal. These are not a reason to replace belt.
However, cracks running along a rib (not across) are not
672 MAINTAINING YOUR VEHICLE

normal. Any belt with cracks running along a rib must be
replaced. Also have the belt replaced if it has excessive
wear, frayed cords or severe glazing.
Conditions that would require replacement:
•Rib chunking (one or more ribs has separated from belt
body) •
Rib or belt wear
• Longitudinal belt cracking (cracks between two ribs)
• Belt slips
• “Groove jumping (belt does not maintain correct
position on pulley)
• Belt broken (note: identify and correct problem before
new belt is installed)
• Noise (objectionable squeal, squeak, or rumble is
heard or felt while drive belt is in operation)
Some conditions can be caused by a faulty component
such as a belt pulley. Belt pulleys should be carefully
inspected for damage and proper alignment.
Belt replacement on some models requires the use of
special tools, we recommend having your vehicle ser-
viced at an authorized dealer.
Accessory Belt (Serpentine Belt)
7
MAINTAINING YOUR VEHICLE 673

CAUTION!(Continued)
•If a “fast charger” is used while the battery is in the
vehicle, disconnect both vehicle battery cables be-
fore connecting the charger to the battery. Do not
use a “fast charger” to provide starting voltage.
Air Conditioner Maintenance
For best possible performance, your air conditioner should
be checked and serviced by an authorized dealer at the
start of each warm season. This service should include
cleaning of the condenser fins and a performance test.
Drive belt tension should also be checked at this time.
WARNING!
• Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause the
system to fail, requiring costly repairs. Refer to
Warranty Information Book, located on the DVD,
for further warranty information.
• The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced technician.
7
MAINTAINING YOUR VEHICLE 675

Glass Surfaces
All glass surfaces should be cleaned on a regular basis
with MOPAR Glass Cleaner, or any commercial
household-type glass cleaner. Never use an abrasive type
cleaner. Use caution when cleaning the inside rear win-
dow equipped with electric defrosters or windows
equipped with radio antennas. Do not use scrapers or
other sharp instrument that may scratch the elements.
When cleaning the rear view mirror, spray cleaner on the
towel or cloth that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.1. Clean with a wet soft cloth. A mild soap solution may
be used, but do not use high alcohol content or
abrasive cleaners. If soap is used, wipe clean with a
clean damp cloth.
2. Dry with a soft cloth.
Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the
vehicle to wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
7
MAINTAINING YOUR VEHICLE 705

WARNING!
A frayed or torn belt could rip apart in a collision and
leave you with no protection. Inspect the belt system
periodically, checking for cuts, frays, or loose parts.
Damaged parts must be replaced immediately. Do
not disassemble or modify the system. Seat belt
assemblies must be replaced after a collision if they
have been damaged (i.e., bent retractor, torn web-
bing, etc.).
FUSES
WARNING!
•When replacing a blown fuse, always use an appro-
priate replacement fuse with the same amp rating as
the original fuse. Never replace a fuse with another
(Continued)
WARNING! (Continued)
fuse of higher amp rating. Never replace a blown
fuse with metal wires or any other material. Failure
to use proper fuses may result in serious personal
injury, fire and/or property damage.
•Before replacing a fuse, make sure that the ignition
is off and that all the other services are switched off
and/or disengaged.
• If the replaced fuse blows again, contact an autho-
rized dealer.
• If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, gearbox system) or steering system
blows, contact an authorized dealer.
706 MAINTAINING YOUR VEHICLE

Maintenance Chart
Mileage or time passed (whichever comes first)20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Additional Inspections
Inspect the CV joints. X X X X X X X
Inspect front suspension, boot seals. tie rod ends,
and replace if necessary. XXX X X X X
Inspect the brake linings, parking brake function. X X X X X X X
Inspect front accessory drive belt, tensioner, idler
pulley, and replace if necessary. X
Additional Maintenance
Replace engine air cleaner filter. XX X XX
Replace air conditioning/cabin air filter. X X X X X X X
732 MAINTENANCE SCHEDULES

Alterations/Modifications, Vehicle...............8
Antifreeze (Engine Coolant) ...............691, 725
Disposal ............................. .694
Anti-Lock Brake System (ABS) ................520
Anti-Lock Warning Light ....................345
Appearance Care ........................ .700
Arming System (Security Alarm) ...............19
Assist, Hill Start ......................... .523
Auto Down Power Windows ..................46
Automatic Door Locks ....................36, 37
Automatic Headlights ..................... .166
Automatic High Beams .....................168
Automatic Temperature Control (ATC) . . . .421, 432, 441
Automatic Transaxle ...................... .483
Automatic Transmission .................485, 699
Adding Fluid ...................... .699, 728
Fluid And Filter Changes ..................699
Fluid Change ......................... .699
Fluid Level Check ...................698, 699 Fluid Type
........................ .698, 728
Special Additives ...................... .698
Torque Converter ...................... .494
Auto Unlock, Doors ........................37
Auto Up Power Windows ....................46
Auxiliary Electrical Outlet (Power Outlet) ........296
Auxiliary Power Outlet .....................296
Axle Fluid ............................. .728
Axle Lubrication ......................... .728
Battery ............................ .334, 674
Charging System Light ...................334
Keyless Transmitter Replacement (RKE) ........26
Belts, Seat ...............................116
Blind Spot Monitoring ..................... .137
Body Mechanism Lubrication .................679
B-Pillar Location ......................... .547
Brake Assist System ...................... .522
Brake Control System, Electronic ..............520
10
INDEX 747

Brake Fluid............................ .728
Brakes ................................ .519
Brake System ........................ .519, 696
Fluid Check ....................... .696, 728
Master Cylinder ....................... .696
Warning Light ........................ .329
Brake/Transmission Interlock .................485
Brightness, Interior Lights ...................172
Bulb Replacement ..................... .718, 720
Bulbs, Light ..........................118,718
Camera, Rear ........................... .280
Capacities, Fluid ......................... .725
Caps, Filler Fuel ................................ .584
Oil (Engine) ....................659, 660, 667
Radiator (Coolant Pressure) ................694
Carbon Monoxide Warning ...............115,581
Cargo Area Features ...................... .309Cargo Compartment
...................... .309
Cargo Load Floor ........................ .309
Cargo Tie-Downs ........................ .310
Car Washes ............................ .700
Certification Label ........................ .588
Changing A Flat Tire ...................... .631
Chart, Tire Sizing ........................ .542
Check Engine Light (Malfunction Indicator Light) . .662
Checking Your Vehicle For Safety ..............114
Checks, Safety ............................114
Child Restraint ............................91
Child Restraints Booster Seats ...........................96
Child Restraints .........................91
Child Seat Installation ....................110
How To Stow An Unused ALR Seat Belt .......107
Infants And Child Restraints ................94
Install A LATCH-Compatible Child Restraint . . . .105
748 INDEX

Installing Child Restraints Using The Vehicle Seat
Belt................................ .108
LATCH Positions ........................99
Locating The LATCH Anchorages ............102
Lower Anchors And Tethers For Children .......98
Older Children And Child Restraints ..........94
Seating Positions ........................97
Child Safety Locks .........................37
Clean Air Gasoline ....................... .577
Cleaning Wheels .............................. .702
Climate Control ......................... .421
Automatic ........................... .421
Coin Holder ............................ .307
Cold Weather Operation ....................475
Compact Disc (CD) Maintenance ..............418
Compact Spare Tire ....................... .559
Console ............................... .307
Console, Floor .......................... .307Contract, Service
......................... .739
Coolant Pressure Cap (Radiator Cap) ...........694
Cooling System .......................... .690
Adding Coolant (Antifreeze) ...............692
Coolant Capacity ...................... .725
Coolant Level ......................... .695
Disposal Of Used Coolant .................694
Drain, Flush, And Refill ...................691
Inspection ........................ .690, 695
Points To Remember .....................695
Pressure Cap ......................... .694
Radiator Cap ......................... .694
Selection Of Coolant (Antifreeze) ......691, 725, 726
Corrosion Protection ...................... .700
Cruise Control (Speed Control) ................187
Cruise Light ......................... .357, 358
Cupholders ............................ .305
Customer Assistance ...................... .737
10
INDEX 749

Jump Starting........................... .644
Key Fob Arm The Alarm .........................20
Panic Alarm ............................25
Programming Additional Key Fobs .........19, 26
Programming Additional Transmitters .......19, 26
Key-In Reminder ..........................15
Keyless Enter-N-Go ........................39
Lock The Vehicle’s Doors ..................390
Passive Entry Programming ................390
Unlock Liftgate ........................ .390
Keyless Entry System .......................23
Key, Replacement ..........................18
Keys ...................................12
Key, Sentry (Immobilizer) ....................17
Lane Change And Turn Signals ...............170
Lane Change Assist ....................... .171LaneSense
............................. .218
Lap/Shoulder Belts .........................56
Latches ................................118
Hood ............................... .164
Lead Free Gasoline ....................... .577
Leaks, Fluid .............................118
Life Of Tires ............................ .562
Liftgate .................................48
Liftgate Window Wiper/Washer ...............312
Light Bulbs ..........................118,718
Lights ..............................118,165
AirBag ........................87, 116, 328
Automatic Headlights ....................166
Back-Up ............................. .723
Battery Saver ......................... .174
Brake Assist Warning ....................530
Brake Warning ........................ .329
Bulb Replacement ....................718, 720
Cruise ........................... .357, 358
10
INDEX 755