radiator cap JEEP COMMANDER 2006 1.G Owners Manual
[x] Cancel search | Manufacturer: JEEP, Model Year: 2006, Model line: COMMANDER, Model: JEEP COMMANDER 2006 1.GPages: 440, PDF Size: 1.78 MB
Page 365 of 440
Cooling System
WARNING!
You or others can be badly burned by hot antifreeze/
coolant or steam from your radiator. If you see or
hear steam coming from under the hood, don’t open
the hood until the radiator has had time to cool.
Never try to open a cooling system pressure cap
when the radiator or coolant bottle is hot.
Engine Coolant Checks
Check antifreeze/coolant protection every 12 months
(before the onset of freezing weather, where applicable).
If antifreeze/coolant is dirty or rusty in appearance, the
system should be drained, flushed and refilled with fresh
antifreeze/coolant. Check the front of the A/C condenserfor any accumulation of bugs, leaves, etc. If dirty, clean by
gently spraying water from a garden hose vertically
down the face of the condenser.
Check the engine cooling system hoses for brittle rubber,
cracking, tears, cuts, and tightness of the connection at
the coolant recovery bottle and radiator. Inspect the
entire system for leaks.
With the engine at normal operating temperature (but
not running), check the cooling system pressure cap for
proper vacuum sealing by draining a small amount of
coolant from the radiator drain cock. If the cap is sealing
properly, the antifreeze/coolant will begin to drain from
the coolant recovery bottle. DO NOT REMOVE THE
COOLANT PRESSURE CAP WHEN THE COOLING
SYSTEM IS HOT.
MAINTAINING YOUR VEHICLE 365
7
Page 367 of 440
Adding Engine Coolant
Your vehicle has been built with an improved antifreeze/
coolant that allows extended maintenance intervals. This
antifreeze/coolant can be used up to 5 Years or 100,000
miles before replacement. To prevent reducing this ex-
tended maintenance period, it is important that you use
the same antifreeze/coolant throughout the life of your
vehicle. Please review these recommendations for using
Hybrid Organic Additive Technology (HOAT)
antifreeze/coolant.
When adding antifreeze/coolant, a minimum solution of
50% recommended MoparAntifreeze/ Coolant 5 Year/
100,000 Mile Formula HOAT (Hybrid Organic Additive
Technology), or equivalent, in water should be used. Use
higher concentrations (not to exceed 70%) if temperatures
below -34°F (-37°C) are anticipated.Use only high purity water such as distilled or deionized
water when mixing the water/antifreeze (coolant) solu-
tion. The use of lower quality water will reduce the
amount of corrosion protection in the engine cooling
system.
Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE:Mixing antifreeze/coolant types will decrease
the life of the antifreeze/coolant and will require more
frequent antifreeze/coolant changes.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of
antifreeze/coolant, and to insure that antifreeze/coolant
will return to the radiator from the coolant recovery tank.
MAINTAINING YOUR VEHICLE 367
7
Page 368 of 440
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
The warning words DO NOT OPEN HOT on the
cooling system pressure cap are a safety precaution.
Never add antifreeze/coolant when the engine is
overheated. Do not loosen or remove the cap to cool
an overheated engine. Heat causes pressure to build
up in the cooling system. To prevent scalding or
injury, do not remove the pressure cap while the
system is hot or under pressure.
Disposal of Used Engine Coolant
Used ethylene glycol-based antifreeze/coolant is a regu-
lated substance requiring proper disposal. Check with
your local authorities to determine the disposal rules for
your community. To prevent ingestion by animals andchildren, do not store ethylene glycol-based antifreeze/
coolant in open containers or allow it to remain in
puddles on the ground. If ingested by a child, contact a
physician immediately. Clean up any ground spills im-
mediately.
Engine Coolant Level
The coolant bottle provides a quick visual method for
determining that the antifreeze/coolant level is adequate.
With the engine idling, and warm to normal operating
temperature, the level of the antifreeze/coolant in the
bottle should be between the ranges indicated on the
bottle.
The radiator normally remains completely full, so there is
not need to remove the radiator cap unless checking for
antifreeze/coolant freeze point or replacing antifreeze/
coolant. Advise your service attendant of this. As long as
the engine operating temperature is satisfactory, the
coolant bottle need only be checked once a month.
368 MAINTAINING YOUR VEHICLE
Page 421 of 440
Autostick............................. 258
Auxiliary Electrical Outlet (Power Outlet)...... 162
Auxiliary Power Outlet................... 162
Battery............................... 359
Emergency Starting..................... 338
Keyless Transmitter Replacement (RKE)....... 24
Saving Feature (Protection)............... 122
Belts,Drive ............................ 355
Belts, Seat.............................. 33
Body Mechanism Lubrication............... 363
B-Pillar Location........................ 285
Brake Assist System...................... 133
Brake Control System, Electronic............. 131
Brake System........................... 370
Anti-Lock (ABS)....................132,271
Hoses.............................. 371
Master Cylinder....................... 371
Parking............................. 269Warning Light........................ 178
Brake/Transmission Interlock............... 257
Break-In Recommendations, New Vehicle........ 68
Bulb Replacement....................... 387
Capacities, Fluid........................ 388
Caps, Filler
Fuel................................ 309
Radiator (Coolant Pressure)............... 367
Car Washes............................ 377
Carbon Monoxide Warning............ 69,153,308
Cargo Area Features...................... 166
Cargo Compartment...................... 166
Luggage Carrier....................... 169
Cargo Load Floor........................ 166
Catalytic Converter...................... 356
Caution, Exhaust Gas..................... 153
CD (Compact Disc) Player...............200,214
Cellular Phone.......................... 82
INDEX 421
10
Page 422 of 440
Chains, Tire............................ 303
Changing A Flat Tire..................... 332
Chart, Tire Sizing........................ 282
Checks, Safety......................... 70,71
Child Restraint.................... 58,59,64,66
Child Restraint Tether Anchors............. 63,64
Child Safety Locks........................ 19
Climate Control......................... 232
Clock ...........................202,216,223
Command View Skylights.................. 161
Compact Disc (CD) Maintenance............. 231
Compass.............................. 193
Compass Variance....................... 198
Computer, Trip/Travel.................... 193
Console, Overhead....................... 152
Contract, Service........................ 414
Converter, Catalytic...................... 356
Cooling System......................... 365
Adding Coolant (Antifreeze).............. 367Coolant Capacity...................... 388
Coolant Level......................... 368
Disposal of Used Coolant................ 368
Drain, Flush, and Refill.................. 366
Inspection........................... 365
Points to Remember.................... 369
Pressure Cap......................... 367
Radiator Cap......................... 367
Selection of Coolant (Antifreeze).........366,388
Courtesy Lights......................... 121
Crankcase Emission Control System.......... 358
Cruise Control (Speed Control).............. 148
CruiseLight ........................... 184
CupHolder ............................ 164
Customer Assistance..................... 412
Data Recorder, Event...................... 56
Daytime Running Lights................... 125
Dealer Service.......................... 351
422 INDEX