weight JEEP DJ 1953 Workshop Manual

'Jeep9
UNIVERSAL
SERIES SERVICE
MANUAL
U PULLEY SPEEDS (R.P.M.)
- 8'
(20.3CM.) PULLEY

Governor
Control

Poeltlone
1-1
RATIO

Engine

Speede

Governor

Control

Poeltlone
TR

ANSMISS

HON
Engine

Speede

Governor

Control

Poeltlone
Lew
Inter.
High

1 306

682
857 1000

2
367
662
1028 1200

3
428
774 1200 1400

4
480 884
1372 1600

S
5S1 985 1542
1800
e 612 1105
1714 2000
7 673
1237 1885 2200

8
734 1326
2057 2400

9
796 1436
2228 2600
SPLINE SHAFT HORSEPOWER
The
chart
below shows
the
draw

bar
horsepower
at the
governor
controlled
engine
speeds
and
the
horsepower
at
the
spline shaft with
the vehicle stationary. Also
is

shown
the
horsepower available
at
the spline shaft with
the
vehicle at
the
maximum approved weight

(3500
lbs.) (1590
kg.)
moving
at

the speed shown
and
exerting
a

draw
bar
pull
of
zero pounds through
1200
pounds
(544 kg.)
(maximum
recommended)
in
steps

of 300 pounds
(136
kg.).

Governed Engine
R.P.M. Vehicle
Speed
M.P.H.* Draw
Bar

H.P**
H.P.
AT
P.T.O.
SPLINE SHAFT
Governed Engine
R.P.M. Vehicle
Speed
M.P.H.* Draw
Bar

H.P**
Vehicle
Stationary 3600
Lb

Vehicle
Mov

ng with
Governed
Engine
R.P.M. Vehicle
Speed
M.P.H.* Draw
Bar

H.P**
Vehicle
Stationary
No
Lbs.
Draw
Bar
Pull 300 Lbs.
Draw
Bar
Pull 800 Lbs.
Draw
Bar
Pull 700
Lbs.

Draw
Bar
Pull 1200
Lbs.

Draw
Bar

Pull
1000 2.2
7.18 16.3
13.7 11.9
10.2
8.4 6.6
1200 2.7 8.62 20.3
17.2
15.0 13.0
10.8 8.6
1400 3.1 10.06
24.5 20.8 18.3
15.9 13.3 10.8
1600 3.6
11.49 28.5 24.3 21.5
18.8 15.8 12.9
1800 4.0
12.93 33.0
28.6 25.3
22.2 19.0
15.8
2000 4.5
14.38 33.0 33.0
30.0 26.4 22.9
19.3
2200 4.9
15.80
33.0 33.0 32.5
28.5
24.7 20.7
2400 5.4 17.24
33.0 33.0 33.0 29.8 25.4
21.2
2600
%B
18.68 33.0
33.0 33.0
31.2 26.6
22.0
'Vehicle speed
in
low transmission
and
transfer case ratios.
••Based
on
maximum recommended draw
bar
pull
for
continuous service
—
1200
Lbs. 367

'Jeep'
UNIVERSAL
SERIES SERVICE
MANUAL

ALPHABETICAL INDEX

SUBJECT PAR.
SUBJECT
PAR.

Abbreviations,
List
U-17 Accelerator Linkage E-70
Air
Cleaner B-25, B-26, B-82, C-21, E-69

Air
Delivery Manifold Fl-4, F2-12
Air
Filter, Pump • F2-3, F2-11

Air
Injection Tubes Fl-5, F2-13
Air
Pump Fl-2, F2-10
Alternator Bearings B-76, H-80
Alternator Brushes H-74, H-75
Alternator Charging System •
•
H-63
Alternator
Diodes
H-69, H-85
Alternator Precautions H-64 Alternator Rotor H-76, H-79
Alternator Tests H-67, H-77 Alternator Specifications H-l 52
Alternator Stator H-84
Anti-Backfire
Valve Fl-6, F2-14
Antifreeze
Chart
• G-22 Antifreeze
Solutions
- G-16
Axle Camber O-l
Axle Caster 0-8

Back-Up
Lights H-135

Ballast
Resistor. H-32 Battery C-3, H-2 Bendix Folo-Thru Drive H-105, H-106
Bleeding Brakes P-7
Body T-l Body Lubrication. B-65 Body Name Plates ' A-7

Brake
Adjustment P-14
Brake
Drums. • .P-17

Brake
Hoses
P-8

Brake
Maintenance . P-5
Brake
Master Cylinder B-40, P-2, P-20

Brake
Service P-6
Brake
Wheel Cylinder • P-21

Camber
Adjustment 0-7
Camshaft D-6, D-51, D-52, D-53, D-81, Dl-26, Dl-33, Dl-55, Dl-80

Carburetor
E-10, E-25

Carburetor
Adjustment C-25, E-14, E-40,
Fl-13,
F2-16
Carburetor
Specifications .Fl-38, F2-34, E-79

Caster
Adjustment 0-8

Charging
System Service. .H-34, H-63

Chassis
Lubrication B-7, B-83

Chassis
Torque Specifications U-14

Clutch
1-4, MO
Clutch
Adjustment 1-3
Clutch
Linkage B-44, 1-3

Clutch
Maintenance .. 1-2
Clutch
Release Bearing B-74, 1-25

Coil
C-20, H-19, H-31 Connecting Rod Bearings D-47, D-48, D-49, Dl-49 Connecting Rod
Crank
Pins D-42
Connecting Rods... .D-20, D-50, D-95, Dl-31, Dl-45, Dl-75
Controls B-59, B-62
Cooling System B-28, G-l Cooling System Filling G-2

Core
Hole Expansion Plugs D-72

Crankcase
Ventilating System B-13, C-6, D-110

Crankshaft
D-26, D-38, D-39, Dl-38, Dl-73
Crankshaft
End Play. D-83, Dl-74

Crankshaft
Main Bearing D-43, D-44, Dl-32, Dl-40, Dl-73

Crankshaft
Oil Seal, Front Dl-21, Dl-85
Crankshaft
Oil Seal, Rear D-63, D-85, Dl-72

Cylinder
Block D-32, Dl-34

Cylinder
Bores D-35, Dl-36

Cylinder
Head D-17, D-73, D-98, Dl-24, Dl-63, Dl-82

Cylinder
Head Torque. C-5
Dash Pot Adjustment C-26, E-44
Differential B-51 thru B-53, N-9 Differential Adjustments N-16, N-18
Differential, Powr-Lok N-20
Differential,
Trac-Lok
N-24
Directional Signal Lights. . H-138
Distributor B-14, B-15, C-10, D-13, Dl-9, H-9, H-20 Distributor Check H-l7, H-28
Distributor Point Dwell C-17 Distributor Resistance Test C-16

Drawbar
.R-6, U-16
Dual
Brake System P-l thru P-26

Electrical
Instruments H-l22

Electrical
Specifications .H-l52

Electrical
System H-l Engine .
..D-l,
Dl-1
Engine Code Number A-6
Engine Compression .
.
C-9 Engine Disassembly . • .D-6, Dl-5 Engine Installation D-105, Dl-102
Engine Lubrication System B-4, B-6 Engine Mountings D-3, Dl-3
Engine Oil B-9
Engine Oil Filter B-10, B-ll,
D-lll,
Dl-13, Dl-93
Engine Oil Pan D-l9, D-66, D-97, Dl-29, Dl-51, Dl-77 Engine Oil Pump. . .D-14, D-65, D-93, Dl-19, Dl-50, Dl-87
Engine Overheating. G-l9 Engine Removal D-5, Dl-4.

Exhaust
Emission Control — F4 Fl-1 thru Fl-30
Exhaust
Emission Control — V6 F2-1 thru F2-36
Exhaust
Manifold, Install F-6

Exhaust
Pipe -
•
F-8

Exhaust
System F-2, F-3

Exhaust
System Maintenance F-4

Fan
Belt C-27, Dl-11, Dl-96, G-18
Floating Oil Intake. D-64, Dl-30, Dl-50, Dl-76 Flywheel D-25, D-67, D-87, Dl-28, Dl-52, Dl-78
Flywheel Housing. D-71, D-88, Dl-27, Dl-54, Dl-79
Flywheel Pilot Bushing D-70, 1-8

Frame
R-l

Frame
Alignment. R-2
Frame
Dimensions R-3
Frame
Straightening R-4

Front
Bumper Weight. • U-9
Front
Axle B-50, M-2

Front
Axle Alignment R-5

Front
Axle Installation • M-12
Front
Axle Maintenance M-3

Front
Axle Shaft Removal M-5

Front
Axle U-Joint B-54, B-55, M-7

Front
Axle Steering Knuckle M-&

Front
Wheel Alignment 0-4

Front
Wheel Bearings B-56, B-57, Q-4
Front
Wheel Toe-in 0-5, 0-6

Front
Wheel Turning Angle 0-9
Fuel
Gauge Float Unit F-76

Fuel
Lines - E-77

Fuel
Pump E-45, E-54, E-60, E-67
Fuel
Pump Check C-23

Fuel
Tank
E-72

G

Gauges, Testing H-l24

General
Specifications A-8
Generator B-16, H-34 thru H-40

Glass
Replacement • T-4
Governor. . .
•.
• U-3
Guides, Valve D"61

H

Hazard
Warning Lights H-139
Head Lamp Aiming H-131, H-132 Head Lamp Replacement H-130
Headlight Dimmer Switch H-l
2
7

Heat Control Valve C-7, F-7 Heated Air System • •
•
F2-2
Heater U-10
Horns.....
....H-137 371