brake JEEP LIBERTY 2006 KJ / 1.G Repair Manual

Miles 108,000 114,000 120,000
(Kilometers) (180 000) (190 000) (200 000)
[Months] [108] [114] [120]
Change the engine oil and engine oil filter. X X X
Rotate the tires. X X X
Inspect the engine air filter element, and replace if necessary. X
Replace the spark plugs. X
Inspect and replace the PCV valve, if necessary. X
Inspect the brake linings. X
Inspect the drive belt and replace as needed. Not required if pre-
viously replaced. XX
Flush and replace the engine coolant/anti-freeze if not done at
102,000 miles (170 000 km). X
Inspect the manual transmission fluid, add as necessary. X
Drain and refill the transfer case fluid. X
Inspection and service should be performed anytime a
malfunction is observed or suspected. Retain all receipts.
This maintenance is recommended by the manufac-
turer to the owner, but it is not required to maintain
emissions warranty.
SCHEDULE “A” — GASOLINE ENGINES 383
8
M A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent, add as required.
Once a Month
•Check the tire pressure and look for unusual wear or
damage.
•Inspect the battery, clean and tighten the terminals as
required.
•Check the fluid levels of engine coolant/anti-freeze
deaeration bottle, brake master cylinder, and transmis-
sion, and add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect brake hoses.
•Check the engine coolant/anti-freeze level, hoses, and
clamps.
•Inspect engine accessory drive belts. Replace as neces-
sary.
•Inspect for the presence of water in the fuel filter/
water separator unit.
Tire Rotation
•Rotate the tires every 6,250 miles (10 000 km).
SCHEDULE “A” — GASOLINE ENGINES 385
8
M A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Miles 6,250 12,500 18,750 25,000 31,250
(Kilometers) (10 000) (20 000) (30 000) (40 000) (50 000)
Change the engine oil and engine oil filter. X X X X X
Inspect the engine air filter element. Replace as
necessary. XXX
Replace the engine air filter element. XX
Inspect the boost pressure solenoid filter. Replace
as necessary. X X XXX
Replace the fuel filter/water separator unit. X
Inspect the brake linings. X X
Drain and refill the front and rear axle fluid. X X
SCHEDULE “B” — DIESEL ENGINES 387
8
M A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Miles 37,500 43,750 50,000 56,250 62,500
(Kilometers) (60 000) (70 000) (80 000) (90 000)
(100 000)
Change the engine oil and engine oil filter. X X X X X
Inspect the engine air filter element. Replace as necessary. XX
Replace the engine air filter element. XXX
Inspect the boost pressure solenoid filter. Replace as necessary. X X X X
Replace the boost pressure solenoid filter, if not previously
replaced. X
Replace the fuel filter/water separator unit. X
Replace the engine accessory drive belt. X
Inspect the brake linings. X X X
Drain and refill the front and rear axle fluid. X X X
Drain and refill the transfer case fluid. X
Inspect the manual transmission fluid, add as necessary. X
Drain and refill the automatic transmission fluid, replace
sump filter, and spin-on cooler return filter (if equipped). X
388 SCHEDULE “B” — DIESEL ENGINES
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Miles 68,750 75,000 81,250 87,500 93,750 100,000
(Kilometers) (110 000) (120 000) (130 000) (140 000) (150 000) (160 000)
Inspect the brake linings. X X
Drain and refill the front and rear axle fluid. X X
Applies only if vehicle is used for frequent trailer
towing, or fleet/commercial service.
† The replacement of such component is requested if
there is superficial wear, bearing clearance, or evident
grease leak. * This maintenance is not required if the belt was
previously replaced.
Inspection and service should be performed anytime a
malfunction is observed or suspected. Retain all receipts.
390 SCHEDULE “B” — DIESEL ENGINES
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Schedule “A” — Diesel Engines
Miles 12,500 25,000 37,500 50,000
(Kilometers) (20 000) (40 000) (60 000) (80 000)
Change the engine oil and engine oil filter. X X X X
Inspect the engine air filter element. Replace as neces-
sary. XX
Replace the engine air filter element. XX
Inspect the boost pressure solenoid filter. Replace as nec-
essary. XXX
Replace the boost pressure solenoid filter, if not previ-
ously replaced. X
Replace the fuel filter/water separator unit. X X
Inspect the brake linings. X X
Inspect the manual transmission fluid, add as necessary. X
Inspect the transfer case fluid. X
SCHEDULE “A” — DIESEL ENGINES 391
8
M A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Miles 62,500 75,000 87,500 100,000
(Kilometers) (100 000) (120 000) (140 000) (160 000)
Change the engine oil and engine oil filter. XXXX
Inspect the engine air filter element. Replace as necessary. XX
Replace the engine air filter element. XX
Inspect the boost pressure solenoid filter. Replace as necessary. X X X
Replace the boost pressure solenoid filter, if not previously replaced. X
Replace the fuel filter/water separator unit. X X
Replace the engine timing belt, and idler pulleys. X
Inspect the engine timing belt tensioner, replace if necessary.† X
Flush and replace the engine coolant/anti-freeze. X
Replace the engine accessory drive belt. X
Inspect the brake linings. X X
Inspect the transmission fluid, add as necessary. X
Inspect the transfer case fluid. X
† The replacement of such component is requested if
there is superficial wear, bearing clearance, or evident
grease leak. Inspection and service should be performed anytime a
malfunction is observed or suspected. Retain all receipts.
392 SCHEDULE “A” — DIESEL ENGINES
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

ABS (Anti-Lock Brake System)............175,245
Adding Washer Fluid ..................... 163
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 326
Air Conditioner Maintenance ............... 327
Air Conditioning, Operating Tips ............ 210
Air Conditioning Refrigerant ............... 328
Air Filter .............................. 326
Air Pressure, Tires ....................... 262
Airbag ................................ 47
Airbag Deployment ....................... 58
Airbag Light ....................... 52,61,179
Airbag Maintenance ....................... 60
Airbag, Window (Side Curtain) ............... 48
Alarm, Panic ............................ 25
Alarm (Security Alarm) .................... 27
Alignment and Balance ................... 267
Alterations/Modifications, Vehicle ............. 8
Antenna, Satellite Radio ................... 204
Antifreeze (Engine Coolant) ................ 362 Anti-Lock Brake System (ABS)
............125,245
Anti-Lock Warning Light .................. 175
Appearance Care ........................ 345
Arming Theft System (Security Alarm) ......... 28
Auto Down Power Windows ................ 33
Automatic Dimming Mirror ................. 80
Automatic Door Locks ..................... 21
Automatic Transmission ................227,340
Adding Fluid ......................... 341
Fluid and Filter Changes ................. 340
Fluid Level Check ...................... 340
Fluid Type ........................... 340
Gear Ranges .......................... 228
Shifting ............................. 227
Special Additives ...................... 341
Torque Converter ...................... 232
Auxiliary Electrical Outlet (Power Outlet) ...... 153
Auxiliary Power Outlet ................... 153
402 INDEX

Bar, Light........................... 1 19,359
Battery ............................... 326
Emergency Starting ..................... 307
Keyless Transmitter Replacement (RKE) ....... 27
Saving Feature (Protection) ............... 118
Belts, Drive ............................ 323
Body Mechanism Lubrication ............... 329
B-Pillar Location ........................ 257
Brake Assist System ...................... 127
Brake Assist Warning Light ................. 182
Brake Control System, Electronic ............. 125
Brake System ........................... 337
Anti-Lock (ABS) ................. 125,175,245
Hoses .............................. 338
Master Cylinder ....................... 338
Parking ............................. 243
Warning Light ........................ 178
Brake/Transmission Interlock ............... 227
Break-In Recommendations, New Vehicle ........ 71 Bulb Replacement
....................... 356
Bulbs, Light ............................ 356
Calibration, Compass ..................... 143
Capacities, Fluid ........................ 362
Caps, Filler Fuel ................................ 281
Radiator (Coolant Pressure) ............... 334
Car Washes ............................ 345
Carbon Monoxide Warning ..............147,279
Cargo Area Cover ....................... 157
Cargo Area Features ...................... 157
Cargo Compartment Light ............................ 1 15,157
Luggage Carrier ....................... 164
Cargo Light ......................... 1 15,157
Cargo Organizer ........................ 160
Cargo Tie-Downs ........................ 158
Catalytic Converter ...................... 324
INDEX 403
10

Temperature Gauge..................... 176
Crankcase Emission Control System .......... 326
Cruise Control (Speed Control) .............. 133
Cruise Light ........................... 177
Cup Holder ............................ 155
Customer Assistance ..................... 394
Cylinder, Retest Requirements ............... 118
Daytime Running Lights ................... 118
Dealer Service .......................... 318
Defroster, Rear Window ................... 163
Diagnostic System, Onboard ................ 316
Diesel Engine Maintenance ................. 384
Diesel Fuel System, Re-Priming .............. 222
Diesel Fuel Water Separator ................ 221
Dimmer Switch, Headlight ................. 117
Dipsticks Oil (Engine) .......................... 319
Power Steering ........................ 328 Disabled Vehicle Towing
................... 310
Disarming, Theft System ................... 28
Disposal Engine Oil ........................... 323
Used Engine Fluids ..................... 323
Door Locks ............................. 18
Door Locks, Automatic .................... 21
Door Opener, Garage ..................... 145
Doors ................................. 18
Drive Belts ............................ 323
Driving ............................... 248
Off-Pavement ......................... 249
Off-Road ............................ 249
Electric Remote Mirrors .................... 81
Electrical Outlet, Auxiliary (Power Outlet) ...... 153
Electrical Power Outlets ................... 153
Electronic Brake Control System ............. 125
Electronic Speed Control (Cruise Control) ...... 133
INDEX 405
10